Removal of anaerobic soluble microbial products in a biological activated carbon reactor

The soluble microbial products (SMP) in the biological treatment effluent are generally of great amount and are poorly biodegradable. Focusing on the biodegradation of anaerobic SMP, the biological activated carbon (BAC) was introduced into the anaerobic system. The experiments were conducted in two identical lab-scale up-flow anaerobic sludge blanket (UASB) reactors. The high strength organics were degraded in the first UASB reactor (UASB1) and the second UASB (UASB2, i.e., BAC) functioned as a polishing step to remove SMP produced in UASB1. The results showed that 90% of the SMP could be removed before granular activated carbon was saturated. After the saturation, the SMP removal decreased to 60% on the average. Analysis of granular activated carbon adsorption revealed that the main role of SMP removal in BAC reactor was biodegradation. A strain of SMP-degrading bacteria, which was found highly similar to Klebsiella sp., was isolated, enriched and inoculated back to the BAC reactor. When the influent chemical oxygen demand (COD) was 10,000 mg/L and the organic loading rate achieved 10 kg COD/(m 3 ·day), the effluent from the BAC reactor could meet the discharge standard without further treatment. Anaerobic BAC reactor inoculated with the isolated Klebsiella was proved to be an effective, cheap and easy technical treatment approach for the removal of SMP in the treatment of easily-degradable wastewater with COD lower than 10,000 mg/L.     

Biodegradability of terephthalic acid in terylene artificial silk printing and dyeing wastewater

As the characteristic pollutant,terephthalic acid(TA)was in charge of 40%-78% of the total COD of terylene artificial silk printing and dyeing wastewater(TPW-water).The studies on biodegradability of TA were conducted in a serial of activated sludge reactors with TPW-water.TA appeared to be readily biodegradable with removal efficiency over 96.5% under aerobic conditions,hardly biodegradable with removal efficiency below 10% under anoxic conditions and slowly biodegradable with a turnover between 31.4% and 56.0% under anaerobic conditions. TA also accounted for the majority of BOD in TPW-water.The process combined by anoxic,anaerobic and aerobic activated sludge reactor was suitable for TA degradation and TPW-water treatment.Further, the aerobic process was essentially much more effective than the anaerobic or anoxic one to degrade TA in TPW-water.     

Inhibitory effect of high phenol concentration in treating coal gasification wastewater in anaerobic biofilter

In this paper, the inhibition of methanogens by phenol in coal gasification wastewater(CGW)was investigated by both anaerobic toxicity tests and a lab-scale anaerobic biofilter reactor(AF). The anaerobic toxicity tests indicated that keeping the phenol concentration in the influent under 280 mg/L could maintain the methanogenic activity. In the AF treating CGW,the result showed that adding glucose solution as co-substrate could be beneficial for the quick start-up of the reactor. The effluent chemical oxygen demand(COD) and total phenol reached1200 and 100 mg/L, respectively, and the methane production rate was 175 m L CH4/g COD/day.However, if the concentration of phenol was increased, the inhibition of anaerobic micro-organisms was irreversible. The threshold of total phenol for AF operation was 200–250 mg/L. The extracellular polymeric substances(EPS) and particle size distribution of anaerobic granular sludge in the different stages were also examined, and the results indicated that the influence of toxicity in the system was more serious than its effect on flocculation of EPS. Moreover, the proportion of small size anaerobic granular sludge gradually increased from10.2% to 34.6%. The results of high through-put sequencing indicated that the abundance of the Chloroflexi and Planctomycetes was inhibited by the toxicity of the CGW, and some shifts in the microbial community were observed at different stages.     

Importance of storage time in mesophilic anaerobic digestion of food waste

Storage was used as a pretreatment to enhance the methanization performance of mesophilic anaerobic digestion of food waste. Food wastes were separately stored for 0, 1,2, 3, 4, 5, 7, and 12 days, and then fed into a methanogenic reactor for a biochemical methane potential(BMP) test lasting up to 60 days. Relative to the methane production of food waste stored for 0–1 day(285–308 m L/g-added volatile solids(VSadded)), that after2–4 days and after 5–12 days of storage increased to 418–530 and 618–696 m L/g-VSadded,respectively. The efficiency of hydrolysis and acidification of pre-stored food waste in the methanization reactors increased with storage time. The characteristics of stored waste suggest that methane production was not correlated with the total hydrolysis efficiency of organics in pre-stored food waste but was positively correlated with the storage time and acidification level of the waste. From the results, we recommend 5–7 days of storage of food waste in anaerobic digestion treatment plants.     

An innovative approach to minimize excess sludge production in sewage treatment using integrated bioreactors

The present investigation deals with an application of integrated sequential oxic and anoxic bioreactor(SOABR) and fluidized immobilized cell carbon oxidation(FICCO) reactor for the treatment of domestic wastewater with minimum sludge generation. The performance of integrated SOABR-FICCO system was evaluated on treating the domestic wastewater at hydraulic retention time(HRT) of 3 hr and 6 hr for 120 days at organic loading rate(OLR)of 191 ± 31 mg/(L·hr). The influent wastewater was characterized by chemical oxygen demand(COD) 573 ± 93 mg/L; biochemical oxygen demand(BOD5) 197 ± 35 mg/L and total suspended solids(TSS) 450 ± 136 mg/L. The integrated SOABR-FICCO reactors have established a significant removal of COD by 94% ± 1%, BOD5 by 95% ± 0.6% and TSS by 95% ± 4% with treated domestic wastewater characteristics COD 33 ± 5 mg/L; BOD59 ± 0.8 mg/L and TSS 17 ± 9 mg/L under continuous mode of operation for 120 days. The mass of dry sludge generated from SOABR-FICCO system was 22.9 g/m~3. The sludge volume index of sludge formed in the SOABR reactor was 32 mL/g and in FICCO reactor it was 46 mL/g. The sludge formed in SOABR and FICCO reactor was characterized by TGA, DSC and SEM analysis. Overall, the results demonstrated that the integrated SOABR-FICCO reactors substantially removed the pollution parameters from domestic wastewater with minimum sludge production.     

Production and application of anaerobic granular sludge produced by landfill

Sludge granulation is considered to be the most critical parameter governing successful operation of an upflow anaerobic sludge blanket and expanded granular sludge bed(EGSB)reactors.Pre-granulated seeding sludge could greatly reduce the required start- up time.Two lab-scale and a pilot-scale EGSB reactors were operated to treat Shaoxing Wastewater Treatment Plant(SWWTP) containing wastewater from real engineering printing and dyeing with high pH and sulfate concentration.The microbiological structure and the particle size distribution in aerobic excess sludge,sanitary landfill sludge digested for one year,and the granular sludge of EGSB reactor after 400 d of operation were analyzed through scanning electron microscopy (SEM) and sieves.The lab-scale EGSB reactor seeded with anaerobic sludge after digestion for one year in landfill showed obviously better total chemical oxygen demand (TCOD)removal efficiency than one seeded with aerobic excess sludge after cation polyacrylamide flocculation-concentration and dehydration.The TCOD removed was 470.8 mg/L in pilot scale EGSB reactor at short hydraulic retention time of 15 h.SEM of sludge granules showed that the microbiological structure of the sludge from different sources showed some differences.SEM demonstrated that Methanobacterium sp.was present in the granules of pilot-scale EGSB and the granular sludge produced by landfill contained a mixture of anaerobic/anoxic organisms in abundance.The particle size distribution in EGSB demonstrated that using anaerobic granular sludge produced by sanitary landfill as the seeding granular sludge was feasible.     

Treating both wastewater and excess sludge with an innovative process

The innovative process consists of biological unit for wastewater treatment and ozonation unit for excess sludge treatment. An aerobic membrane bioreactor( MBR ) was used to remove organics and nitrogen, and an anaerobic reactor was added to the biological unit for the release of phosphorus contained at aerobic sludge to enhance the removal of phosphorus. For the excess sludge produced in the MBR, which was fed to ozone contact column and reacted with ozone, then the ozonated sludge was returned to the MBR for further biological treatment. Experimental results showed that this process could remove organics, nitrogen and phosphorus efficiently, and the removals for COD, NH3-N, TN and TP were 93.17%, 97.57%, 82.77% and 79.5%, respectively. Batch test indicated that the specific nitrification rate and specific denitrifieation rate of the MBR were 1.03 mg NH3-N/(gMLSS^ h) and 0.56 mg NOx-N/(gMLSS^ h), and denitrification seems to be the rate-limiting step. Under the test conditions, the sludge concentration in the MBR was kept at 5000--6000 rng/L, and the wasted sludge was ozenated at an ozone dosage of 0.10 kgO3/kgSS. During the experimental period of two months, no excess sludge was wasted, and a zero withdrawal of excess sludge was implemented. Through economic analysis, it was found that an additional ozonation operating cost for treatment of both wastewater and excess sludge was only 0. 045 RMB Yuan( USD 0.0054)/m^3 wastewater.     

Correlation of anaerobic ammonium oxidation and denitrification

The feasibility of the nitrous organic wastewater treated was studied in seven anaerobic sequencing batch reactors（ASBRs） （0^#-6^#） which had been run under stable anaerobic ammonium oxidation （Anammox）. By means of monitoring and data analysis of COD, NH4^#-N, NO2^--N, NO3^--N and pH, and of microbial test, the results revealed that the optimal Anammox performance was achieved from 2^# reactor in which COD/NH4^＋ -N was 1.65, Anammox bacteria and denitrification bacteria could coexist, and Anammox reaction and denitrification reaction could occur simultaneously in the reactors. The ratio of NH4^＋-N consumed ： NO2^- -N consumed ： NO3^- -N produced was 1：1.38：0.19 in 0^# reactor which was not added glucose in the wastewater. When different ratio of COD and NH4^＋-N was fed for the reactors, the ratio of NO2^- -N consumed： NH4^＋-N consumed was in the range of 1.51-2.29 and the ratio of NO;-N produced： NH4^＋ -N consumed in the range of 0 -0.05.     

Methanogenic community dynamics in anaerobic co-digestion of fruit and vegetable waste and food waste

A lab-scale continuously-stirred tank reactor (CSTR), used for anaerobic co-digestion of fruit and vegetable waste (FVW) and food waste (FW) at different mixture ratios, was operated for 178 days at the organic loading rate of 3 kg VS (volatile solids)/(m³.day). The dynamics of the Archaeal community and the correlations between environmental variables and methanogenic community structure were analyzed by polymerase chain reactions - denaturing gradient gel electrophoresis (PCR-DGGE) and redundancy analysis (RDA), respectively. PCR-DGGE results demonstrated that the mixture ratio of FVW to FW altered the community composition of Archaea. As the FVW/FW ratio increased, Methanoculleus, Methanosaeta and Methanosarcina became the predominant methanogens in the community. Redundancy analysis results indicated that the shift of the methanogenic community was significantly correlated with the composition of acidogenic products and methane production yield. Different mixture ratios of substrates led to different compositions of intermediate metabolites, which may affect the methanogenic community. These results suggested that the analysis of microbial communities could be used to diagnose anaerobic processes.     

Anoxic gas recirculation system for fouling control in anoxic membrane reactor

Anoxic gas recirculation system was applied to control the membrane fouling in pilot-scale 4-stage anoxic membrane bioreactor(MBR). In the anaerobic-anoxic-anoxic-aerobic flow scheme,hydrophilic polytetrafluoroethylene(PTFE) membrane(0.2 μm, 7.2 m2/module) was submerged in the second anoxic zone. During 8 months operation, the average flux of the membrane was 21.3L/(m2·hr). Chemical cleaning of the membrane was conducted only once with sodium hydroxide and sodium hypochlorite. Dissolved oxygen(DO) concentration in the second anoxic zone was maintained with an average of 0.19 ± 0.05 mg/L. Gas chromatography analysis showed that the headspace gas in the second anoxic reactor was mainly consisted of N2(93.0% ± 2.5%), O2(3.8% ± 0.6%), and CO2(3.0% ± 0.5%), where the saturation DO concentration in liquid phase was 1.57 mg/L. Atmospheric O2 content(20.5% ± 0.8%) was significantly reduced in the anoxic gas. The average pH in the reactor was 7.2 ± 0.4. As a result, the recirculation of the anoxic gas was successfully applied to control the membrane fouling in the anoxic MBR.     

Effect of dissolved oxygen on nitrate removal using polycaprolactone as an organic carbon source and biofilm carrier in fixed-film denitrifying reactors

Nitrate-nitrogen(NO_3~--N) always accumulates in commercial recirculating aquaculture systems(RASs) with aerobic nitrification units. The ability to reduce NO_3~--N consistently and confidently could help RASs to become more sustainable. The rich dissolved oxygen(DO)content and sensitive organisms stocked in RASs increase the difficulty of denitrifying technology. A denitrifying process using biologically degradable polymers as an organic carbon source and biofilm carrier was proposed because of its space-efficient nature and strong ability to remove NO_3~--N from RASs. The effect of dissolved oxygen(DO) levels on heterotrophic denitrification in fixed-film reactors filled with polycaprolactone(PCL) was explored in the current experiment. DO conditions in the influent of the denitrifying reactors were set up as follows: the anoxic treatment group(Group A, average DO concentration of 0.28 ± 0.05 mg/L), the low-oxygen treatment DO group(Group B, average DO concentration of 2.50 ± 0.24 mg/L) and the aerated treatment group(Group C, average DO concentration of 5.63 ± 0.57 mg/L). Feeding with 200 mg/L of NO_3~--N, the NO_3~--N removal rates were 1.53, 1.60 and 1.42 kg/m3PCL/day in Groups A, B and C, respectively. No significant difference in NO_3~--N removal rates was observed among the three treatments. It was concluded that the inhibitory effects of DO concentrations lower than 6 mg/L on heterotrophic denitrification in the fixed-film reactors filled with PCL can be mitigated.     

Oxygen tolerance capacity of upflow anaerobic solid-state (UASS) with anaerobic filter (AF) system

In order to investigate the oxygen tolerance capacity of upflow anaerobic solid-state(UASS)with anaerobic filter(AF) system, the effect of microaeration on thermophilic anaerobic digestion of maize straw was investigated under batch conditions and in the UASS with AF system. Aeration intensities of 0–431 m L O2/gvswere conducted as pretreatment under batch conditions. Aeration pretreatment obviously enhanced anaerobic digestion and an aeration intensity of 431 m L O2/gvsincreased the methane yield by 82.2%. Aeration intensities of 0–355 m L O2/gvswere conducted in the process liquor circulation of the UASS with AF system. Dissolved oxygen(DO) of UASS and AF reactors kept around 1.39 ±0.27 and 0.99 ± 0.38 mg/L, respectively. p H was relatively stable around 7.11 ± 0.04. Volatile fatty acids and soluble chemical oxygen demand concentration in UASS reactor were higher than those in AF reactor. Methane yield of the whole system was almost stable at 85 ± 7 m L/gvs as aeration intensity increased step by step. The UASS with AF system showed good oxygen tolerance capacity.     

厌氧、缺氧、好氧环境下富磷剩余污泥的释磷机制

以采用A/O生物强化除磷工艺水质净化厂排出的富磷剩余污泥为研究对象,利用棕色消化瓶设计3组释磷试验,讨论厌氧、缺氧、好氧环境下富磷剩余污泥消化释磷的机制. 结果表明:富磷剩余污泥在厌氧和缺氧环境下均有明显的释磷现象,平均释磷速率分别为1.614和0.998 mg/(L·d);厌氧和缺氧环境下释磷量与聚β-羟基丁酸(PHB)之间的计量关系比较表明,释磷过程中包含有明显的微生物释磷机制,同时还存在着物理化学方面引起的释磷机制,硝酸盐抑制剩余污泥中磷的释放主要是通过影响其微生物学机制完成的.      

Anaerobic digestion in mesophilic and room temperature conditions: Digestion performance and soil-borne pathogen survival

Tomato plant waste(TPW) was used as the feedstock of a batch anaerobic reactor to evaluate the effect of anaerobic digestion on Ralstonia solanacearum and Phytophthora capsici survival. Batch experiments were carried out for TS(total solid) concentrations of 2%, 4% and 6% respectively, at mesophilic(37 ± 1°C) and room(20–25°C) temperatures. Results showed that higher digestion performance was achieved under mesophilic digestion temperature and lower TS concentration conditions. The biogas production ranged from 71 to 416 L/kg VS(volatile solids). The inactivation of anaerobic digestion tended to increase as digestion performance improved. The maximum log copies reduction of R. solanacearum and P. capsici detected by quantitative PCR(polymerase chain reaction) were 3.80 and 4.08 respectively in reactors with 4% TS concentration at mesophilic temperatures. However, both in mesophilic and room temperature conditions, the lowest reduction of R. solanacearum was found in the reactors with 6% TS concentration, which possessed the highest VFA(volatile fatty acid) concentration. These findings indicated that simple accumulation of VFAs failed to restrain R. solanacearum effectively, although the VFAs were considered poisonous. P. capsici was nearly completely dead under all conditions. Based on the digestion performance and the pathogen survival rate, a model was established to evaluate the digestate biosafety.     

Differences in nitrite-oxidizing communities and kinetics in a brackish environment after enrichment at low and high nitrite concentrations

Nitrite accumulation in shrimp ponds can pose serious adverse effects to shrimp production and the environment.This study aims to develop an effective process for the enrichment of ready-to-use nitrite-oxidizing bacteria(NOB)inocula that would be appropriate for nitrite removal in brackish shrimp ponds.To achieve this objective,the effects of nitrite concentrations on NOB communities and nitrite oxidation kinetics in a brackish environment were investigated.Moving-bed biofilm sequencing batch reactors and continuous moving-bed biofilm reactors were used for the enrichment of NOB at various nitrite concentrations,using sediment from brackish shrimp ponds as seed inoculum.The results from NOB population analysis with quantitative polymerase chain reaction(q PCR)show that only Nitrospira were detected in the sediment from the shrimp ponds.After the enrichment,both Nitrospira and Nitrobacter coexisted in the reactors controlling effluent nitrite at 0.1 and 0.5 mg-NO_2~--N/L.On the other hand,in the reactors controlling effluent nitrite at 3,20,and 100 mg-NO_2~--N/L,Nitrobacter outcompeted Nitrospira in many orders of magnitude.The half saturation coefficients(Ks)for nitrite oxidation of the enrichments at low nitrite concentrations(0.1 and 0.5 mg-NO_2~--N/L)were in the range of 0.71–0.98 mg-NO_2~--N/L.In contrast,the Ksvalues of NOB enriched at high nitrite concentrations(3,20,and 100 mg-NO_2~--N/L)were much higher(8.36–12.20 mg-NO_2~--N/L).The results suggest that the selection of nitrite concentrations for the enrichment of NOB inocula can significantly influence NOB populations and kinetics,which could affect the effectiveness of their applications in brackish shrimp ponds.     

Shifts in microbial community structure and diversity in a MBR combined with worm reactors treating synthetic wastewater

The chemical oxygen demand (COD) and NH₃-N removal, membrane fouling, sludge characteristics and microbial community structure in a membrane bioreactor (MBR) coupled with worm reactors (SSBWR) were evaluated for 210 days. The obtained results were compared to those from a conventional MBR (C-MBR) operated in parallel. The results indicated that the combined MBR (S-MBR) achieved higher COD and NH₃-N removal efficiency, slower increase in membrane fouling, better sludge settleability and higher activities of the related enzymes in the activated sludge. Denaturing gradient gel electrophoresis was used to analyze the microbial community structures in the C-MBR and the S-MBR. The microbial community structure in the S-MBR was more diverse than that in the C-MBR. Additionally, the slow-growing microbes such as Saprospiraceae, Actinomyces, Frankia, Clostridium, Comamonas, Pseudomonas, Dechloromonas and Flavobacterium were enriched in the S-MBR, further accounting for the sludge reduction, membrane fouling alleviation and wastewater treatment.     

Inhibition factors and Kinetic model for ammonium inhibition on the anammox process of the SNAD biofilm

The aim of the present work was to evaluate the anaerobic ammonium oxidation (anammox) activity of simultaneous partial nitrification, anammox and denitrification (SNAD) biofilm with different substrate concentrations and pH values. Kaldnes rings taken from the SNAD biofilm reactor were incubated in batch tests to determine the anammox activity. Haldane model was applied to investigate the ammonium inhibition on anammox process. As for nitrite inhibition, the NH₄⁺-N removal rate of anammox process remained 87.4% of the maximum rate with the NO₂⁻-N concentration of 100 mg/L. Based on the results of Haldane model, no obvious difference in kinetic coefficients was observed under high or low free ammonia (FA) conditions, indicating that ammonium rather than FA was the true inhibitor for anammox process of SNAD biofilm. With the pH value of 7.0, the r_max, Ks and K_I of ammonium were 0.209 kg NO₂⁻-N/kg VSS/day, 9.5 mg/L and 422 mg/L, respectively. The suitable pH ranges for anammox process were 5.0 to 9.0. These results indicate that the SNAD biofilm performs excellent tolerance to adverse conditions.     

反硝化聚磷菌快速富集、培养及其荧光原位杂交技术鉴别

以污水处理厂A2/O厌氧段污泥为种泥,采用膜生物反应器(membrane bio-reactor,MBR)对反硝化聚磷菌(denitrifyingphosphate-removal bacteria,DPB)进行快速富集及培养,并提供一种鉴别方法.试验中以乙酸钠为碳源,并在缺氧段投加一定浓度的硝酸盐,结果表明,在膜组件的高效截留作用下,经过厌氧-好氧和厌氧-缺氧2个阶段的富集培养,35 d内反硝化聚磷菌占全部聚磷菌(phosphate-accumulating organisms)的比例从24%上升到93%.此时系统的脱氮、除磷效率均可保持在90%以上.通过荧光原位杂交技术(fluorescence in situ hybridization,FISH)并结合常规测定手段对活性污泥进行鉴别,确定Pseudomonas sp.和Rhodocyclus sp.为主要的优势菌.     

Achieving partial nitrification by inhibiting the activity of Nitrospira-like bacteria under high-DO conditions in an intermittent aeration reactor

It is generally accepted that a low dissolved oxygen(DO) concentration is more beneficial for achieving partial nitrification than high-DO. In this study, partial nitrification was not established under low-DO conditions in an intermittent aeration reactor for treating domestic wastewater. During the operational period of low-DO conditions(DO: 0.3 ±0.14 mg/L), stable complete nitrification was observed. The abundance of Nitrospira-like bacteria, which were the major nitrite-oxidizing bacteria, increased from 1.03 × 10~6to2.64 × 10~6cells/m L. At the end of the low-DO period, the batch tests showed that high-DO concentration(1.5, 2.0 mg/L) could inhibit nitrite oxidation, and enhance ammonia oxidation. After switching to the high-DO period(1.8 ± 0.32 mg/L), partial nitrification was gradually achieved. Nitrospira decreased from 2.64 × 10~6 to 8.85 × 10~5cells/m L. It was found that suddenly switching to a high-DO condition could inhibit the activity and abundance of Nitrospira-like bacteria, resulting in partial nitrification.     

快速启动厌氧氨氧化工艺

为研究如何获得厌氧氨氧化的快速启动工艺,采用两种不同水力流态反应器:完全混合式膜生物反应器(MBR)和推流式厌氧折流板反应器(ABR),分别接种絮状硝化污泥,考察其厌氧氨氧化快速启动性能.结果表明:两种反应器均能成功启动厌氧氨氧化,MBR启动周期(90 d)比ABR(111 d)缩短20%;稳定运行期内,MBR总氮(NH_4~+-N+NO_2~--N)平均去除负荷[0.098 kg·(m3·d)-1]也明显高于ABR[0.089 kg·(m3·d)-1];此外,两个反应器中污泥形态差异明显,MBR中污泥呈絮状,而ABR第1隔室中以厌氧氨氧化颗粒污泥为主;NH_4~+-N、NO_2~--N和NO_3~--N之间的定量关系分析表明:相较于ABR,MBR能实现完全的生物截留,使得系统内含有更多种类的脱氮功能菌,有利于氮素的去除.MBR在厌氧氨氧化的快速启动方面表现出更明显的优势.