改性双氰胺-甲醛絮凝脱色剂的制备与应用

通过在原料中引入尿素,合成出了改性双氰胺-甲醛絮凝脱色剂,并应用到印染废水处理中。采用正交实验方法确定了最佳合成条件,实验结果表明,在反应温度65℃、反应时间3h、反应物配比n（双氰胺）：n（尿素）：n（氯化铵）：n（甲醛）为0．714：0．286：0．9：1．4的最佳条件下,改性双氰胺-甲醛絮凝脱色剂具有优异的絮凝脱色性能,对实际印染废水的脱色率和COD去除率可分别达到99％和93．4％。     

低醛环保型脲醛胶研制成功

脲醛树脂胶由于具有价格低廉、胶合强度好、一定耐水性等优点 ,作为胶粘剂被广泛应用于木材加工行业 ,尤其是室内装饰装修材料———人造板的加工 ,用量最大。但是 ,在使用脲醛树脂制板和人造板装饰装修的过程中 ,会释放出大量的游离甲醇 ,刺激人的眼睛及呼吸系统 ,危害人体健康。发达国家 (如欧洲、日本、美国等 )早就人造板甲醛释放限量制订了标准 ,我国政府部门也充分认识到胶粘剂及人造板中甲醛的危害性 ,于 2 0 0 1年 12月制订出强制性标准ＧＢ185 80— 2 0 0 1《室内装饰装修材料人造板及其制品甲醛释放限量》等 10项国家标准。新出台…     

利用含铜蚀刻废液生产碱式碳酸铜

介绍了利用含铜蚀刻废液生产碱式碳酸铜的生产工艺、技术特点、工艺流程和产品质量。以碳酸钠作蚀刻废液的除杂剂,对其进行除杂前处理,控制反应液的pH为3．5～4．0、反应液中碳酸钠的浓度为0．02～0．03mol／L。可除去其中大部分杂质。用碳酸钠与含铜溶液中的铜进行合成反应,控制反应温度为70～80℃、pH为8～9、碳酸钠和含铜溶液中铜的浓度均为1mol／L,反应生成碱式碳酸铜,此产品中铜的质量分数为56％,产品质量优于木材防腐用碱式碳酸铜国内外同类产品。     

用废杂铜制备碱式碳酸铜

以废杂铜为原料,用稀硝酸浸出硝酸铜溶液,与碳酸氢钠反应得到碱式碳酸铜粗品,漂洗后得到高纯度碱式碳酸铜。实验结果表明,废杂铜与质量分数为30％的硝酸反应,开始比较平缓,后期反应剧烈,有少量红棕色的NO：生成,采用碱液吸收方式处理生成的NO：可减少其对大气的污染。碳酸氢钠与硝酸铜进行合成反应,反应温度50～80℃,反应液pH6．5～7．0,产品中铜的质量分数为55％-56％,产品质量较好。     

木材胶粘剂生产中的污染及防治

阐述了木材胶粘剂－脲醛树脂胶粘剂（ＵＦ）,密胺甲醛树脂胶粘剂（ＭＦ）,酚醛树脂胶粘剂（ＰＦ）生产过程中产生的废气,釜垢及碱洗废液的污染,提出了从工艺上改善排放条件及治理的方法,同时提出了控制产品中游离甲醛的方法。     

氧化钆掺杂二氧化钛催化超声降解甲基橙的研究

用实验室合成的Gd2O3掺杂TiO2为催化剂,以甲基橙超声降解反应为模型,研究了各种因素对Gd2O3掺杂TiO2催化超声降解甲基橙的影响。研究结果表明,Gd2O3掺杂TiO2催化超声降解甲基橙的效果明显优于非掺杂的锐钛矿型TiO2的情况;在甲基橙溶液pH1．0～3．0、甲基橙质量浓度20mg／L、溶液用量100mL、催化剂用量0．5～1．0g／L的条件下,用输出功率1．0W／cm^2和频率25kHz的超声波照射60min,甲基橙降解率可达98．6％,COD去除率可达99．0％。     

邻氨基苯甲醚的清洁生产工艺

采用清洁生产的理论与思维模式,对合成邻氨基苯甲醚的传统工艺进行了改造,开发出以质量分数5％的Pd／C为催化剂、加氢制备邻氨基苯甲醚的清洁生产工艺。最佳生产工艺条件为：100g邻硝基苯甲醚中加入0．9g催化剂、溶剂与邻硝基苯甲醚的质量比0．75、反应压力0．7MPa、反应温度80℃。与传统的硫化钠还原工艺相比,该工艺使反应时间由6h缩短到1．75h,产品收率由90．5％提高到93．8％,解决了原工艺产生大量含硫废水的问题,每吨产品的生产成本可降低1650元。     

多相催化湿式氧化法处理高浓度难降解有机废水的研究

在高压反应釜内，采用自制颗粒贵金属催化剂催化湿式氧化法处理高浓度饲料抗氧化剂合成废水，探讨了温度、压力、进水pH等反应条件对废水处理效果的影响。在温度为220℃、总压为8MPa条件下，COD，TOC，TN和色度的去除率分别达到77．0％，66．1％，70．2％，91％；处理后的废水pH很低，催化剂显示出较好的耐酸性；随进水pH的增加，COD的去除率逐渐降低，出水pH增加。     

过氧化钙的制备及其在废水处理中的应用

开发出一种过氧化钙常温合成新工艺。在氯化铵与过氧化氢质量比为10／130、采用稳定剂ⅠA和稳定剂ⅡB的条件下,使氢氧化钙与过氧化氢反应合成过氧化钙,其收率为35．9％,纯度为72．3％。用制得的过氧化钙去除机械工业废水中的重金属离子,在室温、过氧化钙用量0．1％～0．2％、处理时间30min、处理过程中不调整pH的条件下,含锰35．58μg／mL、铜67μg／mL、锌31．3μg／mL、铬43．56μg／mL(均为质量浓度)的废水经一次处理后,锰、铜、锌浓度和pH均达到国家一级水排放标准,铬的一次去除率达到39％以上。     

Cu2+-Mn2+-H2O2体系催化氧化降解罗丹明B

研究了Cu2＋-Mn2＋-H2O2体系催化氧化降解染料罗丹明B的效果。实验结果表明,Cu2＋-Mn2＋-H2O2体系的罗丹明B降解率比H2O2体系、Mn2＋-H2O2体系和Cu2＋-H2O2体系有显著提高,反应120rain后罗丹明B降解率接近100％。对于Cu2＋-Mn2＋-H2O2体系,最佳罗丹明B降解条件：溶液pH为5,反应温度为45℃,质量浓度为10mg／L的罗丹明B溶液体积100mL,浓度为0．01mol／L的硫酸铜溶液加入量5．0mL,浓度为0．01moVL的硫酸锰溶液加入量3．0mL,体积分数为30％的H2O2溶液加入量1．5mL。在此条件下罗丹明B降解的反应速率常数最大,为0．04228min-1,其拟合相关系数为0．99912。罗丹明B降解符合一级动力学模型。     

Distribution of Cd,Ck, Pb and Zn in Soil and Vegetation Compartments in Stands of Five Boreal Tree Species in N.E. Sweden

Concentrations and total quantity of cadmium (Cd), cupper (Cu),lead (Pb) and zink (Zn) were determined in biomass and soil compartments in a replicated tree species experiment with 27-yr-old stands growing on former farmland in N.E. Sweden. Sequentialextractions of soil samples were performed in order to estimate the exchangeable and an organically bound fraction of each element. The tree species included were Picea abies (L.)H. Karst., Pinus sylvestris L., Pinus contorta Dougl., Larix sibirica Ledeb., and Betula pendula Roth.Tree species influenced the rate of removal of Cu, Pb and Zn incase of stemwood harvesting, and of Cd, Cu and Zn in the case ofwhole-tree harvesting. B. pendula and P. abies had higher quantities and average concentrations of Zn in the biomass. For all species, >50% of the Zn in the stems was found in the bark. P. abies and L. sibirica had higher quantities of Cu in the biomass than the other species.P. abies and P. contorta had high quantities of Cd inthe biomass in relation to the other species. Branches and stembark contained high concentrations of Cd and Pb in relation to foliage and stemwood. Dead branches had especially high concentrations of Pb. The high accumulation rate of Zn in thebiomass of B. pendula was related to a low exchangeable amount of Zn in the A horizon. In the superficial centimeters ofthe A horizon, a depletion similar to that found for Zn was detected for Cu, whereas for Cd and Pb, no correlations were found between quantities of elements in the trees and element pools in the soil.     

Programs assessing implementation and effectiveness of state forest practice rules and BMPs in the West

The major forest nonpoint source control programs in the West are largely regulatory, either under forest practices acts (California, Idaho, New Mexico, Nevada, Oregon, and Washington) or a streamside management act (Montana). These programs and the specific rules they enforce continue to undergo intensive scrutiny. Still, the questions are the same for these regulatory programs as for states that base nonpoint source control on voluntary BMPs (Arizona, Colorado, Utah, Wyoming). Are the rules or BMPs being applied, and are they effective in reducing nonpoint source pollution to levels that protect beneficial uses of water? The level of debate about forestry in the West has resulted in detailed monitoring and research to answer these questions. In the past, state agencies have assumed levels of BMP compliance based on the percent of operations without enforcement actions. These estimates are being replaced by statistically valid and reproducible monitoring of forest practices rules and BMP compliance levels. BMP effectiveness is being assessed using both qualitative and quantitative methods. This can involve field assessments, process-based research, and control watershed studies. Some trend monitoring is also beginning. With the regional implementation rate for forestry BMPs at about 94% and rising, it is likely that effectiveness testing will continue to be a priority and consume the majority of assessment resources for this region.     

Starch-plastic materials—Preparation,physical properties,and biodegradability (a review of recent USDA research)

Recent starch-plastic research at the National Center for Agricultural Utilization Research is reviewed and related worldwide efforts are noted. Properties of starch that influence its formulation and performance in plastics are discussed. Methods are given for preparation of starch-poly(methyl acrylate) graft copolymer, starch-poly(ethylene-co-acrylic acid), and starch-poly(ethylene-co-acrylic acid)-polyethylene plastics. Their physical properties are discussed, as is degradability by enzymes or amylolytic organisms from soil, ponds, and streams.The mention of firm names or trade products does not imply that they are endorsed or recommended by the U.S. Department of Agriculture over other firms or similar products not mentioned.     

Application of Cellulose Microfibrils in Polymer Nanocomposites

Cellulose microfibrils obtained by the acid hydrolysis of cellulose fibers were added at low concentrations (2–10% w/w) to polymer gels and films as reinforcing agents. Significant changes in mechanical properties, especially maximum load and tensile strength, were obtained for fibrils derived from several cellulosic sources, including cotton, softwood, and bacterial cellulose. For extruded starch plastics, the addition of cotton-derived microfibrils at 10.3% (w/w) concentration increased Young’s modulus by 5-fold relative to a control sample with no cellulose reinforcement. Preliminary data suggests that shear alignment significantly improves tensile strength. Addition of microfibrils does not always change mechanical properties in a predictable direction. Whereas tensile strength and modulus were shown to increase during addition of microfibrils to an extruded starch thermoplastic and a cast latex film, these parameters decreased when microfibrils were added to a starch–pectin blend, implying that complex interactions are involved in the application of these reinforcing agents.     

四氮唑废水处理工艺设计

高浓度、高盐分的四氮唑生产废水通过三效蒸发浓缩,馏出液经铁炭氧微电解和混凝预处理,再采用水解酸化一接触氧化一反应二沉主体组合工艺进行处理。研究了该工艺所需构筑物和设备的设计与选型。该工艺在正常运行条件下,处理后出水pH6～9,COD 302mg／L,BOD5 108mg／L,SS30mg／L,色度36倍,水质达到GB8978--1996（污水综合排放标准》三级标准。     

Hysteresis in Reversal of Central European Mountain Lakes from Atmospheric Acidification

Extremely high emissions of S and N compounds in Central Europe (both 280 mmol m^-2 yr^-1) declined by 70and 35%, respectively, during the last decade. Decreaseddeposition rates of SO₄ ^-2, NO₃ ^-, and NH₄ ⁺ in the region paralleled emission declines. The reduction in atmospheric inputs of S and N to mountain ecosystemshas resulted in a pronounced reversal of acidification in the Tatra Mountains and Bohemian Forest lakes. Between the 1987–1990and 1997–1999 periods, concentrations of SO₄ ^-2 and NO₃ ^- decreased (average ± standard deviation) by 22±7 and 12±7 mol L^-1, respectively, in theTatra Mountains, and by 19±7 and 15±10 mol L^-1, respectively, in the Bohemian Forest. Their decrease was compensated in part (1) by a decrease in Ca²⁺ + Mg²⁺ (17±7 mol L^-1) and H⁺ (4±6 mol L^-1), and an increase in HCO₃ ^-(10±10 mol L^-1) in the Tatra Mountains lakes, and (2) by a decrease in Al (7±4 mol L^-1), Ca²⁺ + Mg²⁺ (9±6 mol L^-1), and H⁺ (6±5 mol L^-1), in Bohemian Forest lakes. Despite the rapid decline in lake water concentrations of SO₄ ^-2 and NO₃ ^- in response to reduced S and N emissions, their present concentrations in some lakes are higher than predictionsbased on observed concentrations at comparable emission rates during development of acidification. This hysteresis in chemical reversal from acidification has delayed biological recovery of the lakes. The only unequivocal sign of biological recovery hasbeen observed in erné Lake (Bohemian Forest) where a cladoceran species Ceriodaphnia quadrangular has recentlyreached its pre-acidification abundance.     

Reconstruction of Long-Term Changes in Lake water Chemistry,Zooplankton and Benthos of a Small,Acidified High-Mountain Lake: Magic Modelling and Palaeolimnogical Analysis

Starolesnianske pleso is a small and shallow acid lake in the High Tatra Mountains, situated at 2000 m above sea level, on granitic bedrock, with sparse and thin soil cover. When detailed measurements began in the 1980s Starolesnianske pleso had pH below 5 and only one species of cladoceran zooplankton, the ubiquitous Chydorus sphaericusPalaeolimnological investigations show changes in cladoceran zooplankton and chironomid zoobenthic assemblages since about 1920 and a major change in 1970–1980. The dynamic acidification model MAGIC was used to reconstruct changes in water chemistry over the past 150 years. The results from MAGIC agree well with the sediment record; pH levels gradually decreased from 6.5 in the mid-1800s to about 5.6 in 1920 (first response in biota) to below 5.0 by 1970, and concentrations of inorganic aluminium rose dramatically beginning about 1960. In the 1990s the lake water chemistry showed clear signs of reversal in acidification brought about by a major decline in S deposition.     

Does Soil Acidification Affect Spruce Needle Chemical Composition and Tree Growth?

In 1994, a large survey of soil chemistry was undertaken in thecounty of Värmland in central Sweden (Lundström et al., 1998).The southern part of the county was affected by soilacidification whereas there were no such indications in thenorthern part. To investigate the influence of soil chemistryon the trees at the specific sites, the survey was continued byan analysis of needle chemistry (Norway spruce) which wasundertaken at 150 of the 180 sites, and of tree growth at 65 ofthe 180 sites. Growth was expressed as a ratio between expectedgrowth, estimated with a national, empirical growth model, andthe growth observed in the field. In statistical analyses,using rank correlation, PCA and PLS, there were only weakindications of an influence of soil chemistry on needlechemistry and on tree growth. A moderate correlation betweennitrogen and sulphur in needles was found, which wasinterpreted as an effect of deposition and of processes in thetree canopy. No obvious regional pattern of the growth ratiowas found, in contrast to the clear pattern of soilacidification. The statistical analysis could not with anycertainty point out any of the soil chemistry variables asespecially important for the tree growth ratio.     

Heavy Metals Removal by Biosorption and Flotation

The removal of a mixture of heavy (toxic) metal cations (copper, nickeland zinc) from liquid effluents was investigated in this study at pilotscale, using counter-current contact mode. The innovative processinvolved the abstraction of metal ions onto fungal biosorbents, followedby the application of flotation for the subsequent solid/liquid separationof biomass particles. The ability of microorganisms to remove metal ionsfrom aqueous solutions is a well-known phenomenon. Nevertheless,engineering considerations are very important in decisions, concerningthe commercial future of biosorption and practical solutions are neededfor certain problems, such as the efficient post-separation ofmetal-loaded biomass. The two processes (flotation and biosorption) caneffectively operate in combination, in what it was termed biosorptiveflotation process. The sorbents may be recycled, after appropriate elutionof metals, as well as the treated (clean) water.     

Bioassessment of silvicultural impacts in streams and wetlands of the Eastern United States

Bioassessment is a useful tool to determine the impact of logging practices on the biological integrity of streams and wetlands. Measuring biota directly has an intuitive appeal for impact assessment, and biota can be superior indicators to physical or chemical characteristics because they can reflect cumulative impacts over time. Logging can affect stream and wetland biota by increasing sedimentation rates, altering hydrologic, thermal, and chemical regimes, and changing the base of food webs. Biotic impacts of logging on streams compared to wetlands probably differ, and in this paper we review some of those differences. In streams, invertebrates, fishes, amphibians, algae, and macrophytes have been used as indicators of logging impacts. In wetlands, bioassessment is just beginning to be used, and plants and birds are the most promising indicator taxa. Various best management practices (BMPs) have been developed to reduce the impacts of logging on stream and wetland biota, and we review quantitative studies that have evaluated the efficacy of some of these techniques in streams and wetlands in the eastern United States. Remarkably few studies that address the overall efficacy of BMPs in limiting biotic changes in streams and wetlands after BMP implementation have been published in scientific journals, although some work exists in reports or is unpublished. We review these works, and compile conclusions about BMP efficacy for biota from this body of research.