Enhancement of chemical-oxygen demand and color removal of distillery spent-wash by ozonation.

Distillery spent-wash has very high organic content (75,000 to 125,000 mg/L chemical-oxygen demand [COD]), color, and contains difficult-to-biodegrade organic compounds. For example, anaerobic treatment of the distillery spent-wash used in this study resulted in 60% COD reduction and low color removal. Subsequent aerobic treatment of the anaerobic effluent resulted in enhancement of COD removal to 66%. In this paper, the effect of ozonation on various properties of the anaerobically treated distillery effluent, including the effect on its subsequent aerobic biodegradation, was investigated. Ozonation of the anaerobically treated distillery effluent at various ozone doses resulted in the reduction of total-organic carbon (TOC), COD, COD/TOC ratio, absorbance, color, and increase in the biochemical-oxygen demand (BOD)/COD ratio of the effluent. Further, ozonation of the anaerobically treated distillery effluent at an ozone dose of 2.08 mg/mg initial TOC and subsequent aerobic biodegradation resulted in 87.4% COD removal, as compared to 66% removal when ozonation was not used.     

Comparison of AC/O3-BAC and O3-BAC processes for removing organic pollutants in secondary effluent

AC (activated carbon)/O3-BAC (biological activated carbon) process was employed to treat secondary effluent and compared to O3-BAC process. The effects of ozone dosages and empty bed contact time (EBCT) in BAC on dissolved organic carbon (DOC) removal were investigated. The results showed that the presence of AC improved ozone utilization and biodegradability of the effluent. DOC removal increased with ozone dosage and EBCT in BAC, however, 3 mg l(-1) ozone dosage with 15 min oxidation time and 15 min EBCT in BAC were more economical and efficient. For DOC removal, AC/O3-BAC was more efficient than O3-BAC and its synergetic effect was more than that in O3-BAC process. The biomass of the subsequent BAC unit in AC/O3-BAC process was more than that in O3-BAC process and much more than that in BAC alone. Except for organic pollutants with molecular weight (MW) >10 kDa, those of other MW range were decomposed much more by AC/O3 process than by O3 process. GC/MS analysis showed that dibutyl phthalate, bis(2-ethylhexyl) phthalate, 4-bromo-3-chloroaniline, 2-propanone-ethylhydrazone and phenol derivatives were prevalent organic compounds in the secondary effluent. Some aromatic compounds, such as 4-bromo-3-chloroaniline and 2,4-dichloro-benzenamine disappeared after AC/O3 treatment. However, some small molecules were generated, after further biological treatment by BAC, the kinds and concentration of organic compounds were greatly reduced.     

Ozonation of Procaine Penicillin G formulation effluent Part I: Process optimization and kinetics

Ozonation characteristics of synthetic Procaine Penicillin G (PPG) formulation effluent were investigated in a semi-batch ozone reactor at different pH (3, 7 and 12), ozone feed rates (600-2600 mg h-1) and COD values (200-600 mg l-1). Ozonation of aqueous PPG effluent resulted in 37 (82)% COD removal after 60 (120) min ozonation when the reaction pH was kept constant at pH=7.900 mg l-1 (corresponding to 50% of the total introduced) ozone was absorbed during a reaction period of 1 h. The effects of increasing the applied ozone dose and the initial COD on the COD abatement rates of PPG effluent were also studied. Results have indicated that increasing the ozone dose and decreasing the COD content both have positive effects on COD removal rates. The significant contribution of the free radical (.OH) reaction pathway to PPG ozonation could be traced using tert-butyl alcohol as the .OH probe compound at varying concentrations. The bimolecular reaction rate constants for the direct reaction of PPG with ozone were found as 152 and 2404 M-1 h-1 at pH=3 and 7, respectively, using the gas phase ozone partial pressures determined from of the outlet gas stream analysis. It could be demonstrated that ozone decomposition to free radicals being triggered by increasing the pH from 3 to 7 is essential for the rate enhancement of PPG effluent ozonation.     

Treatment of distillery spent-wash by ozonation and biodegradation: significance of pH reduction and inorganic carbon removal before ozonation.

This study is aimed at exploring strategies for mineralization of refractory compounds in distillery effluent by anaerobic biodegradation/ozonation/aerobic biodegradation. Treatment of distillery spent-wash used in this research by anaerobic-aerobic biodegradation resulted in overall COD removal of 70.8%. Ozonation of the anaerobically treated distillery spent-wash was carried out as-is (phase I experiments) and after pH reduction and removal of inorganic carbon (phase II experiments). Introduction of the ozonation step resulted in an increase in overall chemical oxygen demand (COD) removal, with the highest COD removals of greater than 95% obtained when an ozone dose of approximately 5.3 mg ozone absorbed/mg initial total organic carbon was used. The COD removal during phase II experiments was slightly superior compared with phase I experiments at similar ozone doses. Moreover, efficiency of ozone absorption from the gas phase into distillery spent-wash aliquots was considerably enhanced during phase II experiments.     

Bacterial cell monitoring in wastewater treatment plants by flow cytometry.

The activated sludge process is performed by a variable and mixed community of microorganisms in an aerobic aquatic environment, in which bacteria constitute the majority and represent the main microorganisms responsible for the degradation process in a plant. In this work, we monitored bacterial charge in different wastewater treatment plants by flow cytometry, also evaluating chlorination effects on bacterial viability, both by flow cytometry and traditional plate counts. Maximum values of bacterial charge were registered in the aeration tank of all plants monitored. Cell viability did not show significant differences (p > 0.05) in samples collected in "before chlorination" and "wastewater effluent" treatment steps; this suggests that the chlorination was not able to decrease total viable bacterial charge. In this work, we discuss the need to improve microbiological analyses, both in terms of measuring other potential pathogens and of using new methodological approaches in the traditional evaluation of the microbiological quality of effluents.     

Fate of biodegradable dissolved organic carbon produced by ozonation on biological activated carbon

The adsorption and desorption characteristics of BDOC produced by ozonation and the replacement of BDOC by non-BDOC on BAC was studied. The fate of BDOC produced by ozonation in the BAC column was also evaluated by comparative experiment between the BAC supplied with the mixture of BDOC and non-BDOC and the BAC supplied only with non-BDOC. Fulvic acids extracted from two river sediments and one forest soil were used. BDOC produced by ozonation showed the same or lower adsorption capacity than non-BDOC after biodegradation. The adsorption rate of BDOC on GAC was lower than that of non-BDOC. BDOC produced by ozonation had low desorbability and majority of BDOC produced were not replaced by non-BDOC. BDOC in the ozonated fulvic acid did not affect the breakthrough of the ozonated fulvic acid on GAC in the early stage of adsorption, suggesting that most of BDOC were biodegraded on the surface of GAC before adsorption. Therefore, the production of BDOC by ozonation before the GAC treatment is very effective for the extension of GAC service life and the reduction of DOC loading to GAC.     

Ozonation of oxytetracycline and toxicological assessment of its oxidation by-products

Antibiotic formulation effluents are well known for their difficult elimination by traditional bio-treatment methods and their important contribution to environmental pollution due to its fluctuating and recalcitrant nature. In the present study the effect of ozonation on the degradation of oxytetracycline (OTC) aqueous solution (100mgl(-1)) at different pH values (3, 7 and 11) was investigated. Ozone (11mgl(-1) corresponds the concentration of ozone in gas phase) was chosen considering its rapid reaction and decomposition rate. The concentration of oxytetracycline, chemical oxygen demand (COD), biochemical oxygen demand (BOD) and BOD5/COD ratio were the parameters to evaluate the efficiency of the ozonation process. In addition, the toxic potential of the OTC degradation was investigated by the bioluminescence test using the LUMIStox 300 instrument and results were expressed as the percentage inhibition of the luminescence of the marine bacteria Vibrio fischeri. The results demonstrate that ozonation as a partial step of a combined treatment concept is a potential technique for biodegradability enhancement of effluents from pharmaceutical industries containing high concentration of oxytetracycline provided that the appropriate ozonation period is selected. At pH 11 and after 60min of ozonation of oxytetracycline aqueous solutions (100 and 200mgl(-1)) the BOD5/COD ratios were 0.69 and 0.52, respectively. It was also shown that COD removal rates increase with increasing pH as a consequence of enhanced ozone decomposition rates at elevated pH values. The results of bioluminescence data indicate that first by-products after partial ozonation (5-30min) of OTC were more toxic than the parent compound.     

原位臭氧氧化对活性污泥系统硝化和反硝化作用的影响研究

将厌氧序批式间歇反应器(ASBR)和序批式间歇反应器(SBR)串联组成污泥减量新工艺,着重探讨了对SBR段进行原位臭氧投加时,臭氧氧化作用对系统硝化和反硝化能力的影响,并以不投加作为对照。结果表明,将臭氧原位投加到ASBR—SBR组合工艺的SBR段,臭氧投加量为0.027g(以每克MLSS计),每隔3个周期再次投加、连续运行40d,试验组SBR段臭氧投加当期出水COD去除率为86%,比对照组下降了9百分点,但臭氧氧化细胞内大量有机物进入混合液中,为反硝化作用提供了外加碳源,对污泥反硝化能力的提高起到了一定的促进作用;试验组部分硝化细菌由于臭氧的强氧化作用而失去活性,但是随着剩余污泥量的减少,系统的污泥龄延长,有利于硝化细菌的生长,使得系统的硝化能力基本未受影响;试验组臭氧投加当期SBR段出水NO2--N平均浓度比对照组的高18.9%,但经过3个周期的运行后,其SBR段出水NO2--N平均质量浓度降低至7.57mg/L,基本与对照组持平;试验组臭氧投加当期SBR段出水NO3--N的平均浓度高于对照组,但经过3个周期的运行后,试验组出水NO3--N平均浓度低于对照组;试验组臭氧投加当期SBR段出水TN和对照组的出水TN平均去除率分别为65%和75%,但试验组再经过3个周期的运行后,出水TN平均去除率可以达到72%。可见,原位投加臭氧并未对SBR段的硝化和反硝化能力产生明显的影响。     

Efficacy of in-situ for the remediation of PAH contaminated soils

Polycyclic aromatic hydrocarbons (PAHs) are of environmental concern because many PAHs are either carcinogens or potential carcinogens. Petroleum products are a major source of PAHs. The occurrence of PAH contamination is widespread and novel treatment technologies for the remediation of contaminated soils are necessary.Ozone has been found to be extremely useful for the degradation of PAHs in soils. For these compounds, the reaction with molecular ozone appears to be the more important degradation pathway. Greater than 95% removal of phenanthrene was achieved with an ozonation time of 2.3 h at an ozone flux of 250 mg h⁻¹. After 4.0 h of treatment at an ozone flux of 600 mg h⁻¹, 91 % of the pyrene was removed. We have also found that the more hydrophobic PAHs (e.g. chrysene) react more slowly than would be expected on the basis of their reactivity with ozone, suggesting that partitioning of the contaminant into soil organic matter may reduce the reactivity of the compound. Even so, after 4 h of exposure to ozone, the chrysene concentration in a contaminated Metea soil was reduced from 100 to 50 mg kg⁻¹ .Ozone has been found to be readily transported through columns packed with a number of geological materials, including Ottawa sand, Metea soil, Borden aquifer material and Wurtsmith aquifer material. All of these geological materials exerted a limited (finite) ozone demand, i.e. the rate of ozone degradation in soil columns is very slow after the ozone demand is met. Moisture content was found to increase the ozone demand, most likely owing to the dissolution of gaseous ozone into the pore water. As once the initial ozone demand is met, little degradation of ozone is observed, it should be possible to achieve ozone penetration to a considerable distance away from the injection well, suggesting that in-situ ozonation is a feasible means of treating uncontaminated unsaturated soils. This is substantiated by two field studies where in-situ ozonation was apparently successful at remediating the sites.     

Bioavailability of dissolved organic nitrogen in treated effluents.

The research objective was to assess dissolved organic nitrogen (DON) bioavailability in wastewater effluents from a pilot-scale nitrification plant and a laboratory-scale total nitrogen (TN) removal plant. The DON bioavailability was assessed using a 14-day bioassay protocol containing bacterial and algal inocula. Nitrogen species, dissolved organic carbon, chlorophyll a, and biomass (as total suspended solids and culturable cell counts) concentrations were measured to assess DON bioavailability. The results showed an increase in algal chlorophyll a concentration, with a concurrent increase in algal biomass over time; increased bacterial counts and a decrease in DON concentration over time; and increased carbon-to-nitrogen ratio at the end of the 14-day bioassay, indicating effluent DON bioavailability to algae and bacteria. Approximately 18 to 61% of the initial DON in low-total-nitrogen wastewater effluent (TN = 4 to 5 mg/L) sample was bioavailable. The results show that bacteria and algae uptake and release DON during their growth.     

臭氧处理剩余污泥的减量化实验研究

采用质子交换聚合物膜电解法（PEM）产生臭氧,单独对剩余污泥进行氧化破解实验,结果表明,随着臭氧化反应时间的增加,污泥微生物细胞裂解,胞内物质进入到污泥溶液中,污泥固体物质减少,使得TS和VTS均显著下降,处理40 min后,其去除率分别达到57.33%和72.76%;SCOD前30 min呈线性增长,通入臭氧60 min后,由处理前的3 501.24mg/L上升到6 298.32 mg/L,增长率达79.88%;SV30及滤饼含水率均呈下降趋势,表明剩余污泥的沉淀性能及脱水性能得到明显改善。实验结果表明,直接利用臭氧对剩余污泥进行处理,可获得良好的减量化效果。     

臭氧/ 生物活性炭深度处理循环养殖废水

随着工厂化循环水养殖的不断发展,高浓度循环养殖废水对环境污染日益严重.为实现环境友好和资源节约,采用臭氧/生物活性炭对循环养殖废水进行深度处理中试研究.实验结果表明,臭氧化臭氧最佳投加量为4 mg/L,显著增强水体的可生化性,使TOC(总有机碳)/UV254(在波长为254 nm处的单位比色皿光程下的紫外吸光度)提高80%.臭氧/生物活性炭对循环养殖废水中的有机物和氨氮具有良好的去除效果.臭氧/生物活性炭对TOC、高锰酸盐指数和UV254的最终去除率比生物活性炭分别高11.9%、13.4%和6.5%.臭氧/生物活性炭和生物活性炭对氨氮的最终去除率分别为96.0%、90.7%.     

臭氧氧化法深度处理生活垃圾焚烧厂沥滤液

采用臭氧氧化法对生活垃圾焚烧厂沥滤液经生化处理后的废水(称沥滤液生化处理水)进行深度处理。实验结果表明,COD降解速率随废水pH的提高明显增加,其中pH=10.5时的COD降解速率常数约为pH=4时的5.8倍。在臭氧投量为52.92 mg/min、pH=10.5的条件下反应70 min后,UV254和COD去除率分别达到84.7%和59.3%。向反应体系投加叔丁醇后COD去除率下降了约15%,由羟自由基氧化去除的COD占总COD去除量的26.7%。毒性实验结果表明,沥滤液生化处理水的96 h-EC50为38%,经臭氧氧化进一步处理后出水的96 h-EC50为77%,表明经臭氧深度处理后沥滤液生化处理水的毒性明显降低。     

Kinetics of soil ozonation: an experimental and numerical investigation

This study investigates the use of ozone for soil remediation. Batch experiments, in which ozone-containing gas was continuously recycled through a soil bed, were conducted to quantify the rate of ozone self-decomposition and the rates of ozone interaction with soil organic and inorganic matter. Column experiments were conducted to measure ozone breakthrough from a soil column. Parameters such as ozone flow rate, soil mass, and ozonation time were varied in these experiments. After ozone concentration had reached steady state, the total organic carbon concentration was measured for all soil samples. The ozonation efficiency, represented by the ratio of soil organic matter consumed to the total ozone input, was quantified for each experiment. Numerical simulations were conducted to simulate experimentally obtained column breakthrough curves. Experimentally obtained kinetic rate constants were used in these simulations, and the results were in good agreement with experimental data. In contrast to previous studies in which soil inorganic matter was completely ignored, our experiments indicate that soil inorganic matter may also promote depletion of ozone, thus reducing the overall ozonation efficiency. Three-dimensional numerical simulations were conducted to predict the efficacy of ozonation for soil remediation in the field. These simulations indicate that such ozonation can be very effective, provided that effective circulation of ozone is achieved through appropriately placed wells.     

不同工艺再生水补给对景观湖水质变化的影响

再生水回用于景观水体过程中,为了比较不同再生水工艺对景观水体富营养化的影响,以"二级出水+BAF+O3+GFH"和"二级出水+O3"作为再生水处理工艺,以岸滤(bank filtration,BF)作为水质维持工艺,进行再生水景观水体水质保障技术研究。结果表明,"二级出水+O3"出水流量较大,水力流动快,每天运行24 h,平均出水流量25.5 m3/d,氮磷含量偏高;"二级出水+BAF+O3+GFH"出水的氮磷指标控制在较低水平,GFH出水流量8～14 m3/d,水力流动较缓,湖中出现蓝藻。2套系统中BF对NH4+-N的去除率分别为30.5%和20.8%。"二级出水+O3+BF"系统中人工湖进水TN平均浓度24.309 mg/L,TP平均浓度0.583 mg/L,N/P=41,适宜水网藻生长,对湖中N(主要是NH4+-N)、P有较强的去除能力;"二级出水+BAF+O3+GFH+BF"系统中人工湖进水TP<0.05 mg/L,适宜蓝藻生长。     

Wastewater disinfection alternatives: chlorine, ozone, peracetic acid, and UV light.

Disinfection tests were carried out at pilot scale to compare the disinfection efficiency of ozone, sodium hypochlorite (NaOCl), peracetic acid (PAA), and UV irradiation. Total coliforms, fecal coliforms, and Escherichia coli were monitored as reference microorganisms. Total heterotrophic bacteria (THB) were also enumerated by cytometry. At similar doses, NaOCl was more effective than PAA, and its action was less affected by contact time. The results obtained by ozonation were comparable for total coliforms, fecal coliforms, and E. coli. On the contrary, some differences among the three indicators were observed for NaOCl, PAA, and UV. Differences increased with increasing values of the disinfectant concentration times contact time (C x t) and were probably the result of different initial counts, as total coliforms include fecal coliforms, which include E. coli. The UV irradiation lead to complete E. coli removals, even at low doses (10 to 20 mJ/cm2). Total heterotrophic bacteria appeared to be too wide a group to be a good disinfection indicator; no correlation was found among THB inactivation, dose, and contact time.     

Catalytic activity of Ru/Al2O3 for ozonation of dimethyl phthalate in aqueous solution

With dimethyl phthalate as the model pollutant and Ru/Al(2)O(3) as catalyst, this paper systemically investigates the removal of total organic carbon (TOC) of system. Our results have confirmed that Ru/Al(2)O(3) can significantly increase the effect of ozonation. TOC removal in 120 min can reach 72% while only 24% with ozone alone. The optimal catalyst preparing condition was 0.1 wt% Ru content, 600 degrees C calcination temperature, 0.5-1.0mm particle diameter, which is characterized by a high surface area and a large population of surface active sites. The contrasting experiments of ozone alone, catalyst adsorption after ozonation, and catalytic ozonation confirmed that catalytic reaction was the most important process to TOC removal in system with Ru/Al(2)O(3) as catalyst.     

Ozonation of oil sands process water removes naphthenic acids and toxicity

Naphthenic acids are naturally-occurring, aliphatic or alicyclic carboxylic acids found in petroleum. Water used to extract bitumen from the Athabasca oil sands becomes toxic to various organisms due to the presence of naphthenic acids released from the bitumen. Natural biodegradation was expected to be the most cost-effective method for reducing the toxicity of the oil sands process water (OSPW). However, naphthenic acids are poorly biodegraded in the holding ponds located on properties leased by the oil sands companies. In the present study, chemical oxidation using ozone was investigated as an option for mitigation of this toxicity. Ozonation of sediment-free OSPW was conducted using proprietary technology manufactured by Seair Diffusion Systems Inc. Ozonation for 50min generated a non-toxic effluent (based on the Microtox bioassay) and decreased the naphthenic acids concentration by approximately 70%. After 130min of ozonation, the residual naphthenic acids concentration was 2mgl(-1): <5% of the initial concentration in the filtered OSPW. Total organic carbon did not change with 130min of ozonation, whereas chemical oxygen demand decreased by approximately 50% and 5-d biochemical oxygen demand increased from an initial value of 2mgl(-1) to a final value of 15mgl(-1). GC-MS analysis showed that ozonation resulted in an overall decrease in the proportion of high molecular weight naphthenic acids (n> or = 22).     

污泥减量过程中臭氧氧化对硝化和反硝化影响的试验研究

采用AO工艺,考察了在污泥减量过程中臭氧(O3)氧化对生物系统硝化和反硝化能力的影响.结果表明,在每克SS中O3投量为0.05 g时,氧化后污泥中的CODcr由37.5 mg/L增至700mg/L,TN由4.86 mg/L增至36.6 mg/L,NH4 -N由0.353mg/L增至7.49 mg/L,NO3--N由2.19 mg/L增至5.15 mg/L.虽然氧化系统出水NH4 -N浓度略高于对照系统,但氧化系统NH4 -N的去除率大于98%,硝化能力基本没有受到O3氧化的影响.O3氧化污泥后增加的有机物作为附加的碳源循环至缺氧段,提高了反硝化的效果,当污泥氧化比例分别为10%、20%、30%时,进入缺氧段的CODCr/TN分别平均增至11.21、11.56、11.88,氧化系统的反硝化效果也随之分别提高5%、25%、37%.     

Combination of ozonation with conventional aerobic oxidation for distillery wastewater treatment

Laboratory-scale experiments were conducted in order to investigate the effect of ozone as pre-aerobic treatment and post-aerobic treatment for the treatment of the distillery wastewater. The degradation of the pollutants present in distillery spent wash was carried out by ozonation, aerobic biological degradation processes alone and by using the combinations of these two processes to investigate the synergism between the two modes of wastewater treatment and with the aim of reducing the overall treatment costs. Pollutant removal efficiency was followed by means of global parameters directly related to the concentration of organic compounds in those effluents: chemical oxygen demand (COD) and the color removal efficiency in terms of absorbance of the sample at 254 nm. Ozone was found to be effective in bringing down the COD (up to 27%) during the pretreatment step itself. In the combined process, pretreatment of the effluent led to enhanced rates of subsequent biological oxidation step, almost 2.5 times increase in the initial oxidation rate has been observed. Post-aerobic treatment with ozone led to further removal of COD along with the complete discoloration of the effluent. The integrated process (ozone-aerobic oxidation-ozone) achieved approximately 79% COD reduction along with discoloration of the effluent sample as compared to 34.9% COD reduction for non-ozonated sample, over a similar treatment period.