缺氧反应时间对反硝化除磷系统脱氮除磷效果的影响

反硝化除磷工艺具有节省碳源、曝气量以及污泥产量低等优点,因而在处理城市生活污水中具有显著优势。反硝化除磷效能主要在缺氧阶段完成。缺氧时间直接影响系统的脱氮除磷效率。本实验以SBR反应器在厌氧/缺氧/好氧条件下富含的反硝化聚磷菌(DPAOs)为研究对象,通过调节不同的缺氧反应时间(150 min,210 min和270 min),考察缺氧反应时间冲击对下一周期代谢的影响和长期对整个反硝化除磷系统的影响。冲击实验发现:缺氧时间的改变基本不影响下一周期挥发性脂肪酸(VFAs)的吸收以及硝氮去除。在长期缺氧反应时间不同的系统中,当缺氧时间分别为150 min、210 min和270 min时,除磷效率分别是-10.4%、62.5%、73.6%,脱氮率均达到100%。当缺氧反应时间从150 min延长到270 min时,微生物体内聚羟基脂肪酸酯(PHAs)水平和聚磷(poly-P)水平以及释磷量都升高。实验表明,缺氧时间的适当延长利于提高除磷效率。     

Operation strategy of a sequencing batch reactor for simultaneous removal of wastewater organic matter and nutrients

The Sequencing Batch Reactor (SBR) system employing activated sludge process is an alternative wastewater treatment technology. A cycle of the conventional SBR system generally consists of five periods, with complete aeration during the React period to oxidize the organic matter and nitrify the ammonium-nitrogen of wastewater. Laboratory-scale reactors were used to evaluate the feasibility of incorporating alternative aerobic-anoxic-aerobic stages within the React period for simultaneous removal of organic matter, N and P. Two cycles of SBR process per day were maintained.Under the operation strategy of 0.75-h fill, 8-h react (with continuous aeration), 3.25-h settle, draw and idle periods, the treatment performance became consistent after running the system for two to four cycles (1–2 days). The percentages of both BOD₅ and COD removal were around 94% from Cycle 2 onwards, the BOD₅ content dropped from initial 251 mg L⁻¹ to less than 14 mg L⁻¹ in the final effluent. A steady nitrification (about 97%) was obtained from Cycle 4 onwards, with 1 mg NH₄⁺-N L⁻¹ and 25 mg NO₃⁻-N L⁻¹ present in the final effluent. This suggested that the time required for SBR system to acclimate and reach an equilibrium state was relatively short when compared with the time needed for continuous flow activated sludge system. The findings also show that 4-h aeration during the react period was long enough to achieve more than 90% nitrification. With the incorporation of a 3-h anoxic stage after the initial 4-h aeration of the react period, a satisfactory denitrification process was observed, with nitrate level dropped from 27 to around 8 mg L⁻¹ within 3 h. The second aeration stage did not cause significant change in wastewater nitrogen content. The wastewater phosphate content declined rapidly during the initial 4-h aeration and P-release was not observed during the anoxic stage. A slight reduction of P was found in the second aeration stage suggesting that more P-uptake occurred in this stage. A 12-h cyclic SBR system with the incorporation of 4-h aerobic, 3-h anoxic and final 1-h aerobic stages into the 8-h react period was demonstrated to be able to remove C, N and P simultaneously.     

好氧颗粒污泥同时脱氮除磷技术研究

采用序批式活性污泥法(SBR)处理新疆油田公司准东石油基地污水,作为生物膜的一种特殊形式,介绍了该工艺的优点,在适宜的运行条件下进行实验。讨论了好氧颗粒污泥脱氮以及除磷的过程,分析了该工艺对氮、磷的去除率及好氧颗粒污泥在好氧、缺氧条件下的吸磷情况,当进水氨氮、磷和乙酸碳浓度分别为38.2 mg/L、27.7 mg/L和134.6 mg/L,MLSS和MLVSS分别为7.0 mg/L、6.4 mg/L时,氨氮、总无机氮、磷、乙酸碳的平均去除率分别达到98.8%、90.2%、98.9%、97.2%.     

Biological treatment of tannery wastewater in the presence of chromium

Experiments were carried out to determine the feasibility of treating tannery wastewater containing chromium, an inhibiting compound, with sequencing batch reactors (SBR). The maximum chromium concentration tolerated by microorganisms was determined through aerobic and anoxic batch experiments, and the biomass inhibition process was analyzed in a lab scale reactor at increasing chromium concentrations. The results obtained, in batch experiments and in the SBR reactor, have demonstrated that chromium addition had less influence on the denitrification bacteria than on the nitrification bacteria. In addition, it was observed that nitrification and denitrification rates, at the same chromium concentration, were higher in the SBR reactor than in batch experiments with unacclimated biomass. Experimental results confirm that sequencing batch reactors are able to produce a more resistant biomass, which acclimates quickly to inhibiting conditions. A large amount of chromium was found in the sludge from the reactor, while the effluent was devoid of the inhibiting metal.     

Nitrogen removal in laboratory model leachfields with organic-rich layers

Septic system leachfields can release dissolved nitrogen in the form of nitrate into ground water, presenting a significant source of pollution. Low cost, passive modifications, which increase N removal in traditional leachfields, could substantially reduce the overall impact on ground water resources. Bench-scale laboratory models were constructed to evaluate the effect of placing an organic layer below the leachfield on total N removal. The organic layer provides a carbon source for denitrification. Column units representing septic leachfields were constructed with sawdust-native soil organic layers placed 0.45 m below the influent line and with thicknesses of 0.0, 0.3, 0.6, and 0.9 m. Using a synthetic septic tank effluent, NO(3)-N concentrations at 3.8 m below the influent line were consistently below 1 mg L(-1) during 10 months of operation compared with a NO(3)-N concentration of nearly 12 mg L(-1) in the control column. The average total N removal increased from 31% without the organic layer to 67% with the organic layer. Total N removal appeared limited by the extent of organic N oxidation and nitrification in the 0.45-m aerobic zone. Design modifications targeted at improving nitrification above the organic layer may further increase total N removal. Increased organic layer thicknesses from 0.3 m to 0.9 m did not significantly improve average total N removal, but caused a shift in residual nitrogen from organic N to ammonia N. Results indicate that addition of a layer of carbon source material at least 0.3 m thick below a standard leachfield substantially improves total N removal.     

Effect of sequentially combining methanol and acetic acid on the performance of biological nitrogen and phosphorus removal

A sequentially combined carbon (SCC) source using methanol and acetic acid was investigated for biological nitrogen and phosphorus removal in a wastewater treatment process consisting of an anoxic zone, an oxic zone and a final settling tank. The anoxic zone was divided into two separate anoxic zones to feed methanol in the first anoxic zone and acetic acid in the second anoxic zone. Methanol and acetic acid, each as the sole carbon source, were also tested for comparison. The use of SCC was superior in nitrogen removal with all combined COD ratios of methanol/acetic acid tested, yielding 95.8-97% efficiency (less than 1 mg N/l in the final effluent). The highest phosphorus removal of above 92% (final effluent concentration of 0.12 mg P/l) was achieved when only acetic acid was used at a quantity equivalent to 50 mg COD/l. However, when SCC was used, the acetic acid dosage of 50 mg COD/l could be reduced down to 20 mg COD/l when 30 mg COD/l was replaced by methanol; this resulted in a final effluent phosphorus concentration of 0.6 mg P/l. Additional benefits of SCC included the excellent sludge settling properties compared to the use of methanol or acetic acid alone.     

The effect of landfill leachate composition on organics and nitrogen removal in an activated sludge system with bentonite additive

A pre-denitrification activated sludge system (AS) without internal recycle was used in lab-scale studies of landfill leachate treatment. A bentonite supplement at a ratio of 1:4 (mineral : biomass) was used to ensure high sludge settling levels and to serve as a micro-organisms carrier. The system was operated within different parameters such as hydraulic retention time (HRT), ammonia loading rate (ALR) or external recycle ratio, which was adapted to treat varying leachate concentrations of COD and ammonia, ranging from 1020 to 2680 mgO(2)l(-1) and 400-890 mgNH(4)-Nl(-1) respectively. The nitrification was complete and ammonia oxidation reached 99%; this was obtained while the ALR did not exceed 0.09 g NH(4)(+)-Ng(-1)MLVSS d(-1) and HRT was not lower than 1 day (in the aeration reactor). The performance of denitrification was successfully improved by controlling the external recycle rate, when the BOD(5)/N ratio in the raw leachate was 4.1. Consequently, N-removal of up to 80% was achieved. A 10-fold decrease in the denitrification rate was obtained at a BOD(5)/N ratio of 0.5. The efficiency of COD removal varied significantly from 36% to 84%. The positive effect of bentonite addition was determined and is discussed based on preliminary studies. The experiments were carried out in fill-and-draw activated sludge with bentonite; the biomass ratio was 1:2. The activated sludge with bentonite was fed with a synthetic high ammonia and organic-free medium.     

SBR中好氧颗粒污泥的培养

采用竖式SBR作为反应器，利用城市污水处理厂剩余污泥作为接种污泥，通过不间断运行培养出好氧颗粒污泥。实验结果表明，采用非限量曝气模式好氧颗粒污泥降解模拟污水的效果较好，其COD去除率可达98％以上。曝气量对好氧颗粒污泥的形成和稳定具有重要影响，当气速为26．5m／h时，好氧颗粒污泥的性状和处理有机废水效果最佳。同时好氧颗粒污泥对pH值的变化不明显，当pH为5—8范围内，其COD去除率都可达到85％以上。但是未经驯化的好氧颗粒污泥对对硝基苯酚和对氯苯酚两种芳香类有机物较敏感，而对硝基苯酚对其毒性更大。当对硝基苯酚和。对氯苯酚浓度为10mg／L时，其COD去除率仅为42．5％和52％。     

中空纤维膜生物反应器处理炼厂浮选池出水试验研究

研究设计的膜生物反应器处理炼厂浮选池出水,在每天进水容积负荷1.0 kg COD/m3,进水COD浓度600 mg/L,MLSS为900～5500 mg/L的条件下,无论活性污泥表现正常还是膨胀,过滤出水中COD均稳定地小于90 mg/L,处理效果好于目前炼油厂的合建式曝气池(容积负荷为0.5 kg COD/m3左右,出水COD100 mg/L左右)。试验运行期间,膜通量最高可达到42 L/m2·h。该工艺的技术关键是采用特殊流态来降低膜堵塞的膜生物反应器和优良质量的膜。     

Nitrogen and phosphorus removal from domestic strength synthetic wastewater using an alternating pumped flow sequencing batch biofilm reactor

Nutrient removal from domestic strength synthetic wastewater by an alternating pumped flow sequencing batch biofilm reactor (APFSBBR) was investigated in this laboratory study. The APFSBBR comprised two reactor tanks (Reactors 1 and 2) with two identical biofilm modules of vertical tubular plastic media with a high specific surface area, one in each tank. The APFSBBR was operated in cycles of four phases: fill, anaerobic, aerobic, and draw. During the fill phase, Reactor 1 was half-filled with domestic strength synthetic wastewater. During the subsequent anaerobic phase, most of the phosphorus release took place from the submerged biofilm in this reactor. In the aerobic phase, the wastewater was circulated by pumps between Reactors 1 and 2, resulting in denitrification at the start of the aerobic phase due to low oxygen concentrations, followed by nitrification and luxury uptake of phosphorus when oxygen concentrations increased. During the draw phase, Reactor 2 was half-emptied of the treated water. At the chemical oxygen demand (COD), total nitrogen (TN), and total phosphorus (TP) loading rates on the total biofilm area of 3.20 g COD, 0.33 g TN, and 0.06 g TP m(-2) d(-1), the removal efficiencies were 97, 85, and 92% for COD, TN, and TP, respectively.     

SBR法处理垃圾渗滤液及其同时硝化反硝化生物脱氮研究

采用SBR系统处理城市垃圾渗滤液，研究了不同C／N、130和MLSS对同时硝化反硝化脱氮效率的影响。结果表明：总氮去除率随着C／N、MLSS升高而上升；DO越低，总氮去除率越高；当进水CODCr与NH3-N浓度分别为420mg／L和112mg／L,DO和MLSS分别为1．5mg／L和5016mg／L时，CODCr、NH3-N及TN去除率分别为81．54％、96．57％和46．66％。根据试验结果，对同时硝化反硝化一个代表周期作了分析。     

Removal of bis (2-ethylhexyl) phthalate from reject water in a nitrogen-removing sequencing batch reactor

Reject water from sewage sludge processing may contain high concentrations of nutrients and organic pollutants and cause internal pollution load at a sewage treatment plant (STP) if circulated to the headworks of an STP. In the present study removal of nitrogen and bis (2-ethylhexyl) phthalate (DEHP) from reject water was studied in two sequencing batch reactors (SBRs) with different aerobic/anoxic periods during a 6-h total cycle period. Ammonia-nitrogen (NH(4)-N) was almost totally removed in both reactors, apparently by nitrification throughout the run, while denitrification declined with decreasing SCOD in the influent resulting in an increase in the effluent nitrate-nitrogen (NO(3)-N) concentration. DEHP removals from the water phases were above 95% in both reactors, while the average total removals were 36 and 42%, calculated on a mass basis. Much higher removals occurred in the experiment where one of the systems was spiked with a given amount of DEHP. The spiking experiment suggested that SBRs had the potential to remove DEHP biologically from reject water but that the removal was restricted by the poor bioavailability of DEHP as a result of sorption to solids. This study showed that SBR has the potential to cut the internal load of nitrogen and hydrophobic organic pollutants in cases where reject water is circulated to the headworks of an STP.     

同步硝化好氧反硝化生物脱氮机理分析及其研究进展

通过对比传统生物脱氮理论，提出同步硝化好氧反硝化技术优点，对好氧反硝化的机理进行了初步探讨，并从不同角度做了理论分析。同时阐述了同步硝化反硝化技术的控制因素及其研究进展。并对好氧反硝化的应用前景作了展望，提出了好氧反硝化今后的研究方向。     

Nitrification and denitrification rates of Everglades wetland soils along a phosphorus-impacted gradient

Little information is available on the effect of phosphorus (P) enrichment on nitrogen (N) biogeochemical cycling in wetland soil. Of particular importance are the coupled nitrification-denitrification reactions that regulate the microbially mediated loss of N from wetland systems. Soils from the northern Florida Everglades have been affected by P loading from surface waters over the past 40 years. Elevated P levels have been show to have an effect on the size and activity of the microbial pool and a decrease in the N to P ratio of the microbial biomass. The objective of the study was to determine if P enrichment in soils affected microbial activities related to nitrification and denitrification in these flooded, peat soils. Potential nitrification rates of soil and detritus were determined using constantly stirred reactors under aerobic conditions while denitrification rates were determined from anaerobic incubations of slurry. Nitrification rates showed two distinct linear phases, a slower initial rate, signifying activity of nitrifiers present, followed by a sharp increase in the NH4+ conversion rate indicative of maximum potential rates. Initial rates of nitrification were highest in the surficial detrital layer decreasing with soil depth and did not correlate to soil total P. The potential rates of nitrification were 13 times greater than the initial rates. Potential denitrification rates were highest in the detritus and 0- to 10-cm soil interval with significantly lower values in the 10- to 30-cm soil interval, significantly correlated to total P of the soil. A significant (P < 0.01) relationship was seen between potential denitrification rates and soil total P suggesting an increased rate of N removal from P-enriched regions of the northern Everglades.     

Performance of sequential anaerobic/aerobic digestion applied to municipal sewage sludge

A promising alternative to conventional single phase processing, the use of sequential anaerobic-aerobic digestion, was extensively investigated on municipal sewage sludge from a full scale wastewater treatment plant. The objective of the work was to evaluate sequential digestion performance by testing the characteristics of the digested sludge in terms of volatile solids (VS), Chemical Oxygen Demand (COD) and nitrogen reduction, biogas production, dewaterability and the content of proteins and polysaccharides. VS removal efficiencies of 32% in the anaerobic phase and 17% in the aerobic one were obtained, and similar COD removal efficiencies (29% anaerobic and 21% aerobic) were also observed. The aerobic stage was also efficient in nitrogen removal providing a decrease of the nitrogen content in the supernatant attributable to nitrification and simultaneous denitrification. Moreover, in the aerobic phase an additional marked removal of proteins and polysaccharides produced in the anaerobic phase was achieved. The sludge dewaterability was evaluated by determining the Optimal Polymer Dose (OPD) and the Capillary Suction Time (CST) and a significant positive effect due to the aerobic stage was observed. Biogas production was close to the upper limit of the range of values reported in the literature in spite of the low anaerobic sludge retention time of 15 days. From a preliminary analysis it was found that the energy demand of the aerobic phase was significantly lower than the recovered energy in the anaerobic phase and the associated additional cost was negligible in comparison to the saving derived from the reduced amount of sludge to be disposed.     

IABR-IBAF工艺处理猪场稳定塘废水的实验研究

难降解有机物含量高且碳氮比失调是造成养猪场稳定塘废水难于处理的主要原因。本文采用基于固定化微生物技术的厌氧折流板（IABR）与曝气生物滤池（IBAF）组合工艺处理稳定塘废水,对比了IABR-IABF组合工艺与单一IBAF工艺的处理效果,研究了碱度和碳源对硝化反硝化过程的影响。组合工艺平均进水COD1532．6mg／L,平均出水为332．7mg／L,去除率为78％,NH3-N平均进水538．6mg／L,平均出水为12．3mg／L,去除率97．7％。以新鲜废水做反硝化阶段的碳源时TN去除率93％,可有效解决脱氮过程中的碳源成本问题。     

复合式膜生物反应器处理城市生活污水特性的研究

HSMBR系统表现了对于COD高且稳定的去除效果。对于TN、TP,由于不排泥,污泥浓度的升高,并且填料内部的生物膜不断形成,以及在填料内部的污泥受曝气的扰动小,而变的较为密实,反应器内形成好氧、缺氧两种微环境并存,有利于系统对于TN、TP去除率的提高。     

膜曝气生物膜反应器生物膜影响因素分析

膜曝气生物膜反应器（MABR）是一种利用透气膜进行曝气，可以实现同步硝化反硝化的污水生物处理新工艺。本文阐述了膜曝气生物反应器生物膜的原理和特点，总结了国内外在该领域的研究成果，重点介绍了C／N、氧气压力、流速、生物膜厚度、温度和pH对生物膜性能的影响。     

污泥沉降比在活性污泥法处理污水中的应用

炼油化工废水水量大,含有较高浓度的COD、NH3-N、硫、酚、石油类等污染物,活性污泥法具有运行稳定,耐负荷运行、成本低、维护方便和处理效果良好的特点。文章通过分析污泥沉降比与各因素之间的关系,得出:温度是影响沉降比主要因素,外界环境因素也影响污泥沉降比,污泥沉降比对维持曝气池稳定有重要作用,利用污泥沉降比可以调节剩余污泥排放量,控制污泥浓度;通过污泥沉降比的变化可以及早判断和发现污泥膨胀,及时做出工艺运行调整。     

FACTORS THAT AFFECT ACTIVATED SLUDGE PHOSPHATE RELEASE1

The activated sludge process can remove significant amounts of phosphorus from sewage, but the removal efficiency is usually significantly reduced by the release of phosphate back to solution during subsequent treatment steps. This research presents a study of soluble phosphate release from activated sludge with emphasis on defining the factors that affect such release and the actual release mechanisms. Laboratory units were used for experimental purposes. The experiments were designed to study the relationship between soluble phosphate release and various environmental factors such as redox potential (ORP), dissolved oxygen (DO), pH, solids concentration, solids destruction, and sulfate salt addition. The effect of substrate utilization on phosphate uptake and the relationship between uptake characteristics and subsequent phosphate release were also studied. The results show that some phosphate storage occurs during aerobic substrate utilization. Following substrate utilization, activated sludge phosphate release is directly related to the amount of biological stress the organisms are subjected to, and the mechanism of release is primarily cell lysis. The phosphate released per unit sludge under anoxic conditions is relatively constant. Under normal environmental conditions, neither ORP or pH change have a significant affect on phosphate release.