玉米浸泡液制备苏云金杆菌生物杀虫剂的影响因素研究

以玉米淀粉生产过程中的浸泡液为培养基,摇瓶发酵培养苏云金杆菌生物杀虫剂,通过一系列单因子试验,考察了不同培养条件(种子液的种龄、接种量、浸泡液的含固率、初始pH值、摇床转速、发酵温度及发酵时间)对苏云金杆菌在玉米浸泡液中的生长(菌数增长与芽孢形成)以及发酵液的生物毒效的影响.研究表明,在最佳摇瓶培养条件(种子液种龄10 h,接种量2%,浸泡液含固量3%,初始pH值7.0～7.5,摇床转速200 r/min,发酵温度30℃)下发酵48 h,活菌数和活芽孢数分别可达到7.9×108 CFU/mL和5.5×108 CFU/mL,毒力效价为698.0 IU/μL.本试验可为生物农药的工业化生产提供实用参数.     

味精废水发酵培养苏云金芽孢杆菌的研究

利用30L全自动搅拌式发酵罐研究了驯化后的苏云金芽孢杆菌Bt菌析在只添加少量营养物质的味精厂高浓度有机废水中的发酵特性并进行了生物毒性测定。结果表明该技术在有效处理味精废水的同时中大量发酵生产经济效益和社会效益均良好的无公害生物农,具有较高的工业应用价值。     

甲醛降解细菌的分离鉴定和降解效果测定

从某化工厂污水处理系统的活性污泥中分离纯化得到一株能降解甲醛的革兰氏阳性菌,对其进行形态及生理生化特性测定,提取并纯化其基因组DNA,通过PCR扩增菌株的16S rDNA,测序结果表明,该菌株和苏云金芽孢杆菌的同源性为100%。在含1.2 μL/mL的甲醛的培养基上培养该菌36 h后,甲醛降解去除率达到72％以上。     

产微生物絮凝剂菌株的分离及絮凝特性研究

从某环保公司的污水处理设备好氧活性污泥和广西民族大学思源湖周边土壤中共分离出64个株菌,经过初筛和复筛得到14个絮凝率大于50%的株菌,最后对其中3个絮凝率最高的菌株进行了鉴定,分别属于蜡状芽孢杆菌(Bacillus cereus)、阿氏芽孢杆菌(Priestia aryabhattai)、拉尔宽假单胞菌(Pseudomonas lalkuanensis)。每50 mL 2.5 g/L高岭土悬液只需投加1.0 mL发酵液,蜡状芽孢杆菌在发酵时间为36 h、发酵pH为7.0时,絮凝率最高可达87.7%;阿氏芽孢杆菌在发酵时间为48 h、发酵pH为7.0时,絮凝率最高可达91.1%;拉尔宽假单胞菌在发酵时间为84 h、发酵pH为8.0时,絮凝率最高可达91.0%。3个产微生物絮凝剂菌株发酵条件比较温和,所需发酵液投加量少,表现出较高的絮凝率。因此,3个产微生物絮凝剂菌株具有实现工业化生产的潜在价值。     

连续培养酱油曲霉(Aspergillus sojae)产微生物絮凝剂的研究

为了利用廉价材料规模化生产微生物絮凝剂,以味精废水作为廉价培养基质,对酱油曲霉的摇瓶连续培养和发酵罐连续培养进行了研究。摇瓶中以5%的接种量进行连续培养,最适温度在30~33℃之间,每6 h替换一次新鲜废水培养基,5次替换新鲜废水培养基后最大絮凝率仍达到97.8%。在发酵罐扩大连续培养中以5%的接种量接种后经过9 h预培养达到稳定生产絮凝剂后,以4 mL/min的补料流量进行连续培养,生产的絮凝剂产量达到2.392 g/L,且最大絮凝率为98.1%。生产36 h后对发酵系统中菌体进行稀释,使菌体量保持在50~200 g/L之间可持续进行生产。     

水质净化高效复合微生态制剂的研制

在室内模拟条件下,采用正交实验的方法对光合细菌、枯草芽孢杆菌和反硝化细菌的复配比例进行了研究,筛选一种用于水产养殖水质净化的高效复合微生态制剂。结果表明,当光合细菌(菌细胞浓度约为2×109CFU/mL)、枯草芽孢杆菌(菌细胞浓度约为8×108CFU/mL)和反硝化细菌(菌细胞浓度约为8×108CFU/mL)按菌液体积比为1∶2∶1进行复配利于水中溶解氧的提高和COD、氨氮、亚硝态氮、硝态氮的降解。验证实验表明,筛选组合各指标均优于商品微生态制剂和空白对照,其中溶解氧含量显著高于商品微生态制剂EM和复合芽孢菌处理,在实验第5天对COD的降解率为95%,显著优于EM和复合芽孢菌处理的66.3%和47.9%,实验第7天对氨氮、亚硝态氮和硝态氮的降解率分别达到70%、89%和56%。     

猪粪堆肥发酵菌种的分离筛选及特性研究

从多种样品材料中分离筛选出8株能以猪粪为基质生长的菌种,对其中4株菌(8B、8C、8E、2B)进行了初步分类鉴定,并对它们发酵猪粪培养基的特性作了研究.结果表明,这4株菌均属于芽孢杆菌属,其中8C、2B菌种生长最好,8B次之,而8E菌种则不适合作为发酵菌种;对培养基采取完全灭菌对菌种生长繁殖是有利的,间歇灭菌和不灭菌效果相对较差,甚至会对菌种产生不利影响;pH值的变化在一定程度上反映出微生物生长繁殖能力的强弱;较低的pH值不利于微生物菌种生长.     

具有降解亚硝酸盐活性的解淀粉芽孢杆菌的分离与安全性分析

从养殖污泥中分离筛选了一株优良的亚硝酸盐降解菌YX01,经ARIS 2X细菌自动鉴定系统以及16SrRNA系统发育分析,该菌株被鉴定为解淀粉芽孢杆菌(Bacillus am yloliquefaciens,GenBank登录号为JX649949),其16S rRNA序列与基因库中 芽孢杆菌属菌株的16S rRNA序列有99％～100％的同源性,而且与解淀粉芽孢杆菌菌株LD5(GenBank登录号:GQ853414)的亲缘关系最近.该亚硝酸盐降解菌YX01在浓度为2.0×107～2.0×109cfu/L时对小球藻(Chlorella sp.)生长有促进作用;在浓度大于2.0×1011cfu/L时对小球藻生长具有显著抑制作用;亚硝酸盐降解菌YX01对小球藻的半数抑制浓度(IC50)大于2.0×1011cfu/L.亚硝酸盐降解菌YX01对大型蚤(Daphnia magna)的48h-半数致死浓度(LC50)大于2.0×1011cfu/L,对草鱼(Ctenopharyngodon idellus)的96h-LC50大于2.0×1011cfu/kg.经分析,亚硝酸盐降解菌YX01为无毒菌株.     

味精废水培养苏云金芽孢杆菌中的预处理研究

首先对高浓度味精废水主要成分进行了测定和在自来水中添加不同浓度的无机盐模拟味精废水,并与高浓度味精废水培养苏云金芽孢杆菌进行对比实验,确定了味精废水中影响苏云金芽孢杆菌生长的主要因素是废水中存在高浓度的氨氮和硫酸根,其中氨氮的影响大于硫酸根。在此结论基础上,研究了味精废水预处理材料、温度、时间等对苏云金芽孢杆菌培养的影响,并最终确定了最佳预处理工艺条件。     

三七渣固态发酵生产绿色木霉的工艺条件研究

考察了发酵时间、孢子液接种量、固态发酵培养基装料量、培养温度、光照条件等对三七渣固态发酵生产绿色木霉的影响,并采用正交实验优化了发酵工艺条件。结果表明,发酵过程受工艺条件的影响较大,孢子液接种量、固态发酵培养基装料量、发酵时间3个因素的交互作用极显著(p0.01),这3个因素以及它们之间的交互作用对实验结果的影响程度排序为:交互作用固态发酵培养基装料量孢子液接种量发酵时间;在最佳的发酵工艺条件(即培养温度24℃、无光照、接种量20%(1g三七渣接种2mL绿色木霉孢子液)、固态发酵培养基装料量12.5g、发酵时间8d)下,平均产孢量可达10.10×109 cfu/g。     

金属铁铝对混凝强化初沉污泥中温厌氧消化的影响简

选取FeCl₃和AlCl₃·6H₂O作为混凝剂对城市污水进行一级强化混凝处理,降低二级生物处理的进水负荷,减少污水生物处理系统的能量消耗。主要研究混凝过程投加的金属盐对一级强化混凝产生的初沉污泥中温厌氧消化的影响。和剩余污泥相比,初沉污泥更适合厌氧消化处理,污泥降解性能和产气性能更高。当采用城市污水一级强化混凝处理时,污泥中的金属和金属盐水解引起的pH降低,使混凝强化初沉污泥的厌氧消化受到一定抑制。随着污泥中铝含量的降低和铁含量的增加,厌氧消化的COD降解率和挥发性固体（VS）降解率逐渐升高,生物气产量逐渐增大,产气速率加快。当混凝强化初沉污泥只含有铁时（铁含量为10.16 mg/L）,混凝强化初沉污泥厌氧消化效果最好,产气稳定,而且产气速率高,生物气产量为237 mL,生物气甲烷含量为55.5%,降解单位VS产气量为0.80 L/g,均高于其他含铝的混凝强化初沉污泥。污泥中的铁对初沉污泥厌氧消化的抑制作用远远小于铝的作用,说明铁盐适合用于城市污水的一级强化混凝处理。     

Levels of dioxin-like compounds in sewage sludge determined with a bioassay based on EROD induction in chicken embryo liver cultures

A bioassay for the detection of dioxin-like compounds was used to estimate levels in sewage sludge from Swedish sewage treatment plants (STPs). The sludge extracts were HPLC-separated into three fractions containing a) monoaromatic/aliphatic, b) diaromatic (e.g. polychlorinated biphenyls [PCBs], polychlorinated dibenzodioxins and polychlorinated dibenzofurans [PCDDs/Fs]), and c) polyaromatic compounds (e.g. polycyclic aromatic hydrocarbons [PAHs]). The bioassay, which is based on EROD (7-ethoxyresorufin O-deethylase) induction in cultured chicken embryo livers detected dioxin-like activity in all unfractionated extracts and in the di- and polyaromatic fractions of all sludge extracts, but not in the monoaromatic/aliphatic fractions. The levels ranged between 6 and 109 pg bio-TEQ/g sludge (d.w.). In sediment samples from rural lakes in Sweden, levels of about 5 pg bio-TEQ/g (d.w.) have been found. The polyaromatic fractions of the sludge samples were potent in the bioassay, probably due to various PAHs and other polyaromatics in the sludge. The levels of six PAHs that are screened for in the sludge at Swedish STPs accounted for only 3-10% of the observed EROD-induction by the polyaromatic fractions. Consequently, many other polyaromatic EROD-inducing compounds were present in the sludge. Inclusion of a biological test like the chicken embryo liver bioassay in the screening of sludge would improve the ability to detect the presence of bioactive dioxin-like compounds. A theoretical estimation of bio-TEQ concentrations in farm-soil following long-term application of sludge with bio-TEQ concentrations similar to those observed in this investigation indicated that the bio-TEQ levels in soil would increase very slowly over time. The chicken embryo liver bioassay proved useful in assessing levels of dioxin-like compounds in sewage sludge and it gives valuable complementary information to chemical analysis data.     

金属铁铝对混凝强化初沉污泥中温厌氧消化的影响

选取FeCl3和AlCl2·6H2O作为混凝剂对城市污水进行一级强化混凝处理,降低二级生物处理的进水负荷,减少污水生物处理系统的能量消耗。主要研究混凝过程投加的金属盐对一级强化混凝产生的初沉污泥中温厌氧消化的影响。和剩余污泥相比,初沉污泥更适合厌氧消化处理,污泥降解性能和产气性能更高。当采用城市污水一级强化混凝处理时,污泥中的金属和金属盐水解引起的pH降低,使混凝强化初沉污泥的厌氧消化受到一定抑制。随着污泥中铝含量的降低和铁含量的增加,厌氧消化的COD降解率和挥发性固体（Vs）降解率逐渐升高,生物气产量逐渐增大,产气速率加快。当混凝强化初沉污泥只含有铁时（铁含量为10．16mg／L）,混凝强化初沉污泥厌氧消化效果最好,产气稳定,而且产气速率高,生物气产量为237mL,生物气甲烷含量为55．5％,降解单位Vs产气量为0．80L／g,均高于其他含铝的混凝强化初沉污泥。污泥中的铁对初沉污泥厌氧消化的抑制作用远远小于铝的作用,说明铁盐适合用于城市污水的一级强化混凝处理。     

Inactivation of bacteria in sewage sludge by gamma radiation

The survival of certain bacterial cultures suspended in sewage sludge and exposed to gamma-radiation was studied. The inactivation patterns of most of the organisms were significantly different when irradiation was performed using sewage samples collected in the summer and monsoon seasons. The summer sample collected from the anaerobic digestor afforded significant protection to both Gram negative and Gram positive organisms. This was evident by the increase in dose required to bring about a 6 log cycle reduction in viable count of the bacterial cultures, when suspended in sewage samples instead of phosphate buffer. The observations made using monsoon digestor samples were quite different. This sewage sludge greatly enhanced inactivation by gamma-radiation in most cases. The effects of certain chemicals on the inactivation patterns of two organisms-Salmonella typhi and Shigella flexneri-were examined. Arsenate, mercury and lead salts sensitised S. typhi, while barium acetate and sodium sulphide protected this culture against gamma-radiation. In the case of Sh. flexneri, barium acetate and iodacetamide proved to be radioprotectors. The effects of some chemicals on the inactivation pattern of Sh. flexneri cells irradiated in sludge are also discussed.     

Harnessing dark fermentative hydrogen from pretreated mixture of food waste and sewage sludge under sequencing batch mode

Food waste and sewage sludge are the most abundant and problematic organic wastes in any society. Mixture of these two wastes may provide appropriate substrate condition for dark fermentative biohydrogen production based on synergistic mutual benefits. This work evaluates continuous hydrogen production from the cosubstrate of food waste and sewage sludge to verify mechanisms of performance improvement in anaerobic sequencing batch reactors. Volatile solid concentration and mixing ratio of food waste and sludge were adjusted to 5 % and 80:20, respectively. Five different hydraulic retention times (HRT) of 36, 42, 48, 72, and 108 h were tested using anaerobic sequencing batch reactors to find out optimal operating condition. Results show that the best performance was achieved at HRT 72 h, where the hydrogen yield, the hydrogen production rate, and hydrogen content were 62.0 mL H₂/g VS, 1.0 L H₂/L/day, and ~50 %, respectively. Sufficient solid retention time (143 h) and proper loading rate (8.2 g COD/L/day as carbohydrate) at HRT 72h led to the enhanced performance with better hydrogen production showing appropriate n-butyrate/acetate (B/A) ratio of 2.6. Analytical result of terminal-restriction fragment length polymorphism revealed that specific peaks associated with Clostridium sp. and Bacillus sp. were strongly related to enhanced hydrogen production from the cosubstrate of food waste and sewage sludge.     

Optimising the preparation of activated carbon from digested sewage sludge and coconut husk.

Preparation of activated carbon from sewage sludge is a promising way to dispose of sewage sludge as well as to produce a low-cost adsorbent for pollutant removal. This research work aimed to optimise the condition for activated carbon preparation from anaerobically digested sewage sludge with the additive coconut husk. The sewage sludge sample was mixed with the additive coconut husk. The preparation condition variables investigated involved the concentration of the ZnCl2 solutions, heating temperature, dwell time and heating rate in pyrolysis and the mixing ratio of coconut husk to sewage sludge. Surface area, pore size distribution, aqueous phenol adsorption capacity and the production yield of the final products were determined and compared. Experimental results revealed that low concentrations of ZnCl2 solution tended to improve the microporosity of the final product. Heating temperature had a considerable impact on the surface area, pore size distribution and phenol adsorption capacity of the final products, whereas dwell time and heating rate performed comparatively insignificantly. The effect of increasing the mixing ratio of coconut husk to sewage sludge was principally to increase the microporosity of the final products. The activated carbon with the highest BET surface area was produced with the activation of 5 M ZnCl2 solution and, thereafter, pyrolysis at a heating temperature of 500 degrees C for 2 h with a heating rate of 10 degrees C/min. The mixing ratio of 1:4 in terms of coconut husk to sewage sludge based on their dried weights was found to be most cost effective.     

Characterization of eco-cement paste produced from waste sludges

In this study, marble sludge, sewage sludge, drinking water treatment plant sludge, and basic oxygen furnace sludge were used as replacements for limestone, sand, clay, and iron slag, respectively, as the raw materials for the production of cement in order to produce eco-cement. It was found that it is feasible to use marble sludge to replace up to 50% of the limestone and also that other materials can serve as total replacements for the raw materials typically used in the production of cement. The major components of Portland cement were all found in eco-cement clinkers. The eco-cement was confirmed to produce calcium hydroxide and calcium silicate hydrates during the hydration process, increasing densification with the curing age. The compressive strength (S_c) and microstructural evaluations conducted at 28 d revealed the usefulness of eco-cement. It was observed that the S_c data correlated linearly with the pore volume (P) data at 28 d. The proposed model equation could be represented as S_c = 178-461P (correlation coefficient, R² = 0.96). Two parameters, the large capillary pore volume and the medium capillary pore volume, were evaluated using multiple regression analysis.     

城市污水厂污泥替代营养盐培养海水小球藻的研究

为了城市污水厂污泥的资源化利用,对污泥替代F/2培养基培养海水小球藻(Chlorella pacifica)进行了研究。首先采用研磨-离心法制备污泥抽提液,将其与F/2培养基按体积比7∶3混合,接种微藻并在优化的条件下培养6 d,逐日测定混合液中无机氮、磷的浓度,培养结束后测定微藻生物量以及干藻中蛋白质、氨基酸和重金属含量。结果表明,将微藻在最佳条件下培养6 d后,混合液中PO34--P、NO2--N、NH4+-N和NO3--N的吸收率分别达到97.32%、96.72%、97.55%和78.13%;与F/2培养基对照组相比,混合液中微藻的生物量增加11.5%;蛋白质、必需氨基酸和非必需氨基酸的含量变化不大。另外,干藻中的重金属含量符合饲料行业标准的要求。     

微波法污水厂污泥制备活性炭的研究

研究了以污水厂污泥为原料、微波辐照下磷酸活化法制备污泥活性炭的工艺条件,探讨了微波功率、辐照时间以及磷酸浓度对活性炭碘值的影响.结果表明,微波功率480 W、辐照时间315 s、磷酸浓度40%～45%的条件下,制备的污泥活性炭碘值为301 mg/g,总孔孔容是0.37 mL/g,平均孔径8.8 nm,比表面积168 m2/g.将该污泥活性炭用于处理TNT红水,吸附效果良好.     

微波法污水厂污泥制备活性炭的研究

研究了以污水厂污泥为原料、微波辐照下磷酸活化法制备污泥活性炭的工艺条件,探讨了微波功率、辐照时间以及磷酸浓度对活性炭碘值的影响.结果表明,微波功率480 W、辐照时间315 s、磷酸浓度40%～45%的条件下,制备的污泥活性炭碘值为301 mg/g,总孔孔容是0.37 mL/g,平均孔径8.8 nm,比表面积168 m2/g.将该污泥活性炭用于处理TNT红水,吸附效果良好.