两种粉煤灰的烟气脱硫实验

采用粉煤灰(FA)和Ca(OH)2水合制得的高活性吸收剂作为二氧化硫的干法脱硫剂，重点研究了两种粉煤灰(电除尘灰和湿式水膜除尘灰)在同一配比、同一水合温度、同一水合时间下的脱硫效率，结果表明：电除尘灰比湿式水膜除尘灰脱硫效率高，并且电除尘的脱硫效率略微低于活性炭，同时介绍了粉煤灰的脱硫机理。     

转化高新技术促进烟气脱硫技术发展

文章综述了国内烟气脱硫技术及设备发展的历程和现状，分析了引进国外全套烟气脱硫技术装置对国内用户所造成的巨大经济压力，提出走转化高新技术发展国内烟气脱硫技术的道路，介绍了国内外脱硫技术与国内技术相结合，在天津市重点工程项目上实施的实例。     

脱硫脱硫弧菌去除SO2的工艺条件研究

从太原污水处理厂分离到1株硫酸盐还原菌,对其进行形态学观察及生理生化特征测定,鉴定为脱硫脱硫弧菌(Desulfovibriodesulfuricans).该菌株在pH=7、温度30℃、搅拌速度270r/min时生长最好,处理SO2的能力最强.当二氧化硫进口浓度小于10334mg/m3,SO2-3累积浓度小于87.31mg/L时,菌体生长良好,碱液流加速率较小,但当二氧化硫进口浓度达到11582mg/m3,SO2-累积至124.06mg/L时,菌体生长受到抑制,系统被破坏.图6参11     

循环流化床锅炉烟气脱硫除尘技术改造

对承德市热电厂CG35／3．82－MX型循环流化术锅炉的脱硫除尘系统进行了改造,解决了原水膜除尘器效率低,烟法排放严重超标的问题,取得了良好的环境效益,社会效益和经济效益。     

改性半焦烟气脱硫的机理研究

本文对海拉尔褐煤半焦及其水蒸气活化和高温氧化改性后的烟气脱硫性能进行了研究。     

一步法烟气浸锰-脱硫的工艺参数及机理

应用一步法烟气浸锰-脱硫的新工艺,考察烟气流量、烟气SO2浓度、吸收时间、液固比及浸出时间等工艺参数对烟气氧化脱硫效果的影响,并运用溶液化学原理,对SO2及Mn2 在溶液中的组分进行了计算,研究Mn2 液相催化氧化烟气脱硫的机理.在吸收液pH值5-6时,锰主要以Mn2 形态存在,Mn2 的存在强化了从HSO-3开始发生的SO2氧化反应.采用菱锰矿为原料,能有效地脱除含SO2烟气中的硫,在实现烟气脱硫的同时自动调节溶液的pH值,并可从浸出液中回收高价值的硫酸锰.在最佳的工艺条件下,仅一步吸收过程,取得了锰浸出率85%,含SO2烟气脱硫率70%以上的效果.     

燃煤烟气脱硫脱硝脱碳一体化技术的研究进展

我国长期以来一直以煤炭为主要能源,其燃烧排放的SOx和NOx是大气环境中主要的污染物,而CO2的大量排放也会导致一系列环境问题的出现.本文总结了燃煤烟气的净化方法,重点介绍了吸附法、吸附机理、传统吸附剂以及新型吸附剂、影响吸附效果的因素和吸附剂循环再生情况.最后总结了吸附剂目前存在的一些缺陷以及未来的发展方向.     

臭氧氧化结合氨水吸收的烟气脱硫脱氮研究

用氨水溶液吸收法脱除烟气中被臭氧氧化后的SOx、NOx,分析了吸收反应的产物,得出了化学反应的总方程式,利用热力学原理计算了化学反应达到平衡时SOx、NOx、CO2的分压;对氨水吸收法脱除烟气中被臭氧氧化后的SOx、NOx的吸收机理进行了研究,分析了SOx、NOx在氨水溶液中的吸收特性.结果表明:臭氧氧化结合氨水吸收同...     

燃煤烟气脱硫副产物在酸性土上的农用价值与利用原理

燃煤烟气脱硫副产物作为废弃物对环境的潜在威胁,促使人们对其资源化利用研究的重视。文章针对红壤地区土壤普遍缺乏营养元素的问题,通过分析盆栽和田间试验结果,探讨燃煤烟气脱硫副产物在酸性土壤上的农用价值与利用原理。结果表明,燃煤烟气脱硫副产物富含作物所需的营养元素,而红壤地区土壤又普遍缺乏这些元素;它具有独特的形态特征和理化性能,在酸性土壤中可以产生协同效应,因而具极高的农用价值。在酸性土壤上适量施用,可以提高土壤养分含量,改善土壤理化性质,提高土壤供肥性能和持水能力,促进作物对养分的吸收,从而达到废弃物农业资源化利用的目的。     

Design and prediction for highly efficient SO2 capture from flue gas by imidazolium ionic liquids

An efficient method for prediction in the capture of SO2 from flue gas by imidazolium ionic liquids was reported, where the concentration of SO2 is 2000 ppm. On the basis of quantitative calculations through a combination of Langmuir simulation, theoretical calculation and quantum chemical method, SO2 absorption and desorption performance from flue gas by twelve kinds of imidazolium ionic liquids with different anions were designed and predicted. Then, among them, five kinds of imidazolium ionic liquids were chosen and prepared to investigate their behavior of SO2 absorption capacity, desorption residue, and available absorption capacity. The results indicated that the experimental values were in good agreement with the predicted values. Thus, an ideal ionic liquid [Emim][Tetz] was obtained through the predictive method for the capture of SO2 of 2000 ppm, which showed high available absorption capacity of 0.24 g SO2 per g ionic liquid and excellent reversibility.     

Formation of ferric flocks to remove for the removal of Zn and Cu from dockyard wastewater

Wastewater from wash down of boat hulls contains typically Cu, Zn and organometallic biocides, e.g. tributyltin (TBT). In some cases this wastewater is led directly into the marine system. In the present paper, a cheap flocculation method (iron flocculants) for removal of Cu and Zn from the wastewater is investigated and the method was shown successful. TBT concentration in a sample from a German dockyard was also decreased during flocculation, but the TBT removed was already associated with small particulates in the original sample. Low concentrations of heavy metals were obtained by flocculation: <0.05 mg Cu/l and 0.2 mg Zn/l. An erratum to this article can be found at     

Fe2+EDTA溶液络合-铁还原脱除烟气中NO

提出了“Fe2 螯合剂络合-铁粉还原-酸吸收”回收法脱除烟气中NO的新工艺,重点研究了模拟烟气中O2体积分数对NO络合量的影响,以及铁粉用量、铁粉粒径、搅拌速度对NO脱除效率的影响,确定了最佳的铁粉脱氮工艺条件,并对铁粉和铁屑的脱氮效果进行了比较。结果表明,烟气中O2的体积分数从0%增加到4.2%,NO络合量下降90.2%;NO脱除效率随铁粉用量和反应器搅拌速度的增加而增加,随铁粉粒径的增加而降低;过程的最佳工艺参数为,铁粉用量0.8g,铁粉粒径≤0.077mm,搅拌速度900r·min-1,在此条件下,对O2体积分数为5%的模拟烟气在搅拌反应器中可取得90%以上的NO脱除效率;用铁粉在1台搅拌反应器中取得的NO脱除效率和用铁屑在2个鼓泡反应器串联时所取得的效率相当。     

The disposal of flue gas desulphurisation waste: sulphur gas emissions and their control

Flue gas desulphurisation (FGD) equipment to be fitted to UK coal-fired power stations will produce more than 0.8 Mtonnes of calcium sulphate, as gypsum. Most gypsum should be of commercial quality, but any low grade material disposed as waste has the potential to generate a range of sulphur gases, including H₂S, COS, CS₂, DMS and DMDS. Literature data from the USA indicates that well-oxidised waste with a high proportion of calcium sulphate (the main UK product of FGD) has relatively low emissions of sulphur gases, which are comparable to background levels from inland soils. However, sulphur gas fluxes are greatly enhanced where reducing conditions become established within the waste, hence disposal strategies should be formulated to prevent the sub-surface consumption of oxygen.     

一株新的反硝化短程除硫菌的鉴定及主要培养因素筛选

依据反硝化除硫原理,以味精废水污泥为种泥,利用全混流反应器富集并分离出同步反硝化短程除硫菌(SNBI),采用传统与现代分子生物学相结合的手段对其鉴定,以确定其分类地位;同时对SNB1的主要培养因素(营养和环境)进行筛选.结果表明:SNB1的形态特征及生理生化指标与Thauera selenatis最相似,同源性达99.0%,属短杆菌属,尚无中文命名;生理生化指标、富集条件及富集过程物料平衡显示SNB1是一株兼性厌氧反硝化除硫菌;培养SNB1的最佳碳源为蔗糖,最佳氮源为蛋白胨,最佳培养温度为35℃,最适宜pH范围为7～9;最佳条件培养时,OD_(650)和对数细菌数量(CFU)呈直线相关,相关系数R~2=0.981.     

Inorganic element uptake by barley from soil supplemented with flue gas desulphurization waste and fly ash

To evaluate the influence of waste products from coal- and oil-fired power plants on the inorganic element content of plants, barley was grown in pots each with 22 kg of sandy loam supplied with increasing amounts of six waste products. The plants were harvested at maturity and analysed for a number of inorganic elements. The salinity of the soil was the limiting factor for the amount added in terms of plant growth. Concerning the quality of the plants as fodder, addition of the waste to the soil at levels of about 0.5% by weight increased the Se concentration of the barley from a level deficient for animals to that approaching sufficiency for animals. The increase in Cd from the flue gas desulphurization (FGD) products was deemed undesirable, even though the concentrations following this single addition were far from toxic. All other increases in element concentrations were without any biological significance.Environmental Geochemistry and Health, 1988,10(1), 21–25     

Application of Zn-contaminated soil: Feasibility study on the removal of H2S from hot coal-derived gas

In this study, zinc-contaminated soils were chosen as a candidate material for the removal of hydrogen sulfide (H₂S) from hot coal-derived gas. Laboratory experiments showed that H₂S was decreased to less than 10 ppm when the zinc-contaminated soils were reacted with H₂S. The best removal temperature of H₂S was found to be at 550°C in the operating conditions. In addition to zinc species, free iron oxides in contaminated soils also performed an active species to react with H₂S and enhanced the sulfur capacity. Through the XPS analysis, iron sulfide (FeS) and zinc sulfide (ZnS) were the major products after removal experiments. Regeneration experimental results indicated that the zinc-contaminated soils can be regenerated by pass diluted air and thus be reused on the removal of H₂S for many times.     

CO2 adsorption performance of ZIF-7 and its endurance in flue gas components

Porous ZIF-7 with the sodalite （SOD） cage structure （ZIF, Zeolitic imidazolate framework） were synthesized by the solvothermal method. Synthesized material was characterized by powder X-ray diffraction （PXRD）, thermal gravity （TG）, scanning electron micro- scopy （SEM） and Na adsorption analysis. ZIF-8 with the SOD structure and a littl larger pore window was synthesized in a similar way and was characterized for comparisons. Thermal stability and structural stability of ZIF-7 were tested through PXRD analysis, and the capability of the material for CO2 capture from simulated flue gas was investigated through physical adsorption method. The results showed that CO： adsorption capacity on ZIF-7 was about 48 mL. gl while the capacity on ZIF-8 was about 18mg.g-1 （at 12C and 0.98 P/Po relative pressure）. Furthermore, the impact of flue gas components on adsorption capacity of ZIF-7 and the selectivity of CO2 against N2 on ZIF-7 was also investigated in this work