Effect of chemical and microbial amendment on phosphorus runoff from composted poultry litter

Environmental impacts of composting poultry litter with chemical amendments at the field scale have not been well quantified. The objectives of this study were to measure (i) P runoff and (ii) forage yield and N uptake from small plots fertilized with composted and fresh poultry litter. Two composting studies, aerated using mechanical turning, were conducted in consecutive years. Composted litter was collected at the completion of each study for use in runoff studies. Treatments in runoff studies included an unfertilized control, fresh (uncomposted) poultry litter, and litter composted with no amendment, H3PO4, alum, or a microbial mixture. An additional treatment, litter composted with alum plus the microbial mixture, was evaluated during the first year. Fertilizer treatments were applied at rates equivalent to 8.96 Mg ha(-1) and rainfall simulators were used to produce a 5 cm h(-1) storm event. Composted poultry litter, regardless of treatment, had higher total P concentrations than fresh poultry litter. Composting poultry litter resulted in reductions of N/P ratios by as much as 51%. Soluble reactive P concentrations were lowest in alum-treated compost, which reduced soluble P concentrations in runoff water by as much as 84%. Forage yields and N uptake were greatest from plots fertilized with fresh poultry litter. Composting poultry litter without the addition of C sources can increase P concentrations in the end product and surface runoff. This study also indicated that increased rates of composted poultry litter would be required to meet equivalent N rates supplied by fresh poultry litter.     

Alum treatment of poultry litter: decomposition and nitrogen dynamics

While the poultry industry is a major economic benefit to several areas in the USA, land application of poultry litter to recycle nutrients can lead to impaired surface and ground water quality. Amending poultry litter with alum [Al3(SO4)2 x 14H2O] has received considerable attention as a method of economically reducing ammonia volatilization in the poultry house and soluble phosphorus in runoff waters. The objective of this study was to characterize the effect of alum on broiler litter decomposition and N dynamics under laboratory conditions. Litter that had been amended with alum in the poultry house after each of the first four of five flock cycles (Experiment I) and litter that had been amended with alum after removal from a poultry house after the third flock cycle (Experiment II) were compared with unamended litter in separate studies. The litters in Experiment I were surface-applied to simulate application to grasslands, while the litters in Experiment II were incorporated to simulate application to conventionally tilled crops. The only statistically significant differences in decomposition due to alum occurred early in Experiment II and the differences were small. The only statistically significant differences in net N mineralization, soil inorganic N, and soil NH4+-N in either experiment was found in Experiment I after 70 d of incubation where soil inorganic N was significantly greater for the alum treatment. Thus, alum had little effect on decomposition or N dynamics. Results of many of the studies on litter not amended with alum should be applicable to litters amended with alum to reduce P availability.     

Ammonia volatilization from surface-applied poultry litter under conservation tillage management practices

Land application of poultry litter can provide essential plant nutrients for crop production, but ammonia (NH(3)) volatilization from the litter can be detrimental to the environment. A multiseason study was conducted to quantify NH(3) volatilization rates from surface-applied poultry litter under no-till and paraplowed conservation tillage managements. Litter was applied to supply 90 to 140 kg N ha(-1). Evaluation of NH(3) volatilization was determined using gas concentrations and the flux-gradient gas transport technique using the momentum balance transport coefficient. Ammonia fluxes ranged from 3.3 to 24% of the total N applied during the winter and summer, respectively. Ammonia volatilization was rapid immediately after litter application and stopped within 7 to 8 d. Precipitation of 17 mm essentially halted volatilization, probably by transporting litter N into the soil matrix. Application of poultry to conservation-tilled cropland immediately before rainfall events would reduce N losses to the atmosphere but could also increase NO(3) leaching and runoff to streams and rivers.     

Long-term effects of poultry litter, alum-treated litter, and ammonium nitrate on phosphorus availability in soils

Alum (Al2(SO4)(3).14H2O) additions to poultry litter result in lower ammonia (NH3) volatilization and phosphorus (P) runoff; however, the long-term effects of alum on soil P behavior have been unknown. The objectives of this study were to evaluate the long-term effects of poultry litter, alum-treated litter, and ammonium nitrate (NH4NO3) on P availability in soils and P runoff. Two studies were initiated in 1995: a small plot (1.5x3.0 m) study and a paired watershed (0.405 ha) study. In the small plot study 13 treatments (control, four rates of normal litter, four rates of alum-treated litter, and four rates of NH4NO3) were applied to tall fescue (Festuca arundinacea Schreb.) plots. Results show that after 7 yr water-extractable P (WEP) in surface soil samples was greater with normal litter, but Mehlich III P was greater in surface soils fertilized with alum-treated litter. When soil samples were taken at depth intervals to 50 cm in Year 7, Mehlich III P was only greater in the surface 5 cm for soils fertilized with alum-treated litter. At lower depths Mehlich III P was greater with normal litter, and WEP was up to 288% greater when normal litter was used, indicating that alum significantly reduced P leaching. Uptake of P by fescue was not affected by alum. Results from the paired watershed study showed P loss in runoff was 340% greater for normal litter than for alum-treated litter. This research, combined with earlier work that shows alum use improves air and soil quality, supports the use of alum as a long-term solution to reducing P runoff and leaching.     

Long-term effects of poultry litter, alum-treated litter, and ammonium nitrate on aluminum availability in soils

Research has shown that alum [Al(2)(SO(4))(3).14H(2)O] applications to poultry litter can greatly reduce phosphorus (P) runoff, as well as decrease ammonia (NH(3)) volatilization. However, the long-term effects of fertilizing with alum-treated litter are unknown. The objectives of this study were to evaluate the long-term effects of normal poultry litter, alum-treated litter, and ammonium nitrate (NH(4)NO(3)) on aluminum (Al) availability in soils, Al uptake by tall fescue (Festuca arundinacea Schreb.), and tall fescue yields. A long-term study was initiated in April of 1995. There were 13 treatments (unfertilized control, four rates of normal litter, four rates of alum-treated litter, and four rates of NH(4)NO(3)) in a randomized block design. All fertilizers were broadcast applied to 52 small plots (3.05 x 1.52 m) cropped to tall fescue annually in the spring. Litter application rates were 2.24, 4.49, 6.73, and 8.98 Mg ha(-1) (1, 2, 3, and 4 tons acre(-1)); NH(4)NO(3) rates were 65, 130, 195, and 260 kg N ha(-1) and were based on the amount of N applied with alum-treated litter. Soil pH, exchangeable Al (extracted with potassium chloride), Al uptake by fescue, and fescue yields were monitored periodically over time. Ammonium nitrate applications resulted in reductions in soil pH beginning in Year 3, causing exchangeable Al values to increase from less than 1 mg Al kg(-1) soil in Year 2 to over 100 mg Al kg(-1) soil in Year 7 for many of the NH(4)NO(3) plots. In contrast, normal and alum-treated litter resulted in an increase in soil pH, which decreased exchangeable Al when compared to unfertilized controls. Severe yield reductions were observed with NH(4)NO(3) beginning in Year 6, which were due to high levels of acidity and exchangeable Al. Aluminum uptake by forage and Al runoff from the plots were not affected by treatment. Fescue yields were highest with alum-treated litter (annual average = 7.36 Mg ha(-1)), followed by normal litter (6.93 Mg ha(-1)), NH(4)NO(3) (6.16 Mg ha(-1)), and the control (2.89 Mg ha(-1)). These data indicate that poultry litter, particularly alum-treated litter, may be a more sustainable fertilizer than NH(4)NO(3).     

Evaluation of nitrogen retention and microbial populations in poultry litter treated with chemical, biological or adsorbent amendments

Poultry litter is a valuable nutrient source for crop production. Successful management to reduce ammonia and its harmful side-effects on poultry and the environment can be aided by the use of litter amendments. In this study, three acidifiers, two biological treatments, one chemical urease inhibitor and two adsorber amendments were added to poultry litter. Chemical, physical and microbiological properties of the litters were assessed at the beginning and the end of the experiment. Application of litter amendments consistently reduced organic N loss (0-15%) as compared to unamended litter (20%). Acidifiers reduced nitrogen loss through both chemical and microbiological processes. Adsorbent amendments (water treatment residuals and chitosan) reduced nitrogen loss and concentrations of ammonia-producing bacteria and fungi. The use of efficient, cost-effective litter amendments to maximum agronomic, environmental and financial benefits is essential for the future of sustainable poultry production.     

Subsurface application of poultry litter in pasture and no-till soils

Poultry litter provides a rich nutrient source for crops, but the usual practice of surface-applying litter can degrade water quality by allowing nutrients to be transported from fields in surface runoff while much of the ammonia (NH3)-N escapes into the atmosphere. Our goal was to improve on conventional titter application methods to decrease associated nutrient losses to air and water while increasing soil productivity. We developed and tested a knifing technique to directly apply dry poultry litter beneath the surface of pastures. Results showed that subsurface litter application decreased NH3-N volatilization and nutrient losses in runoff more than 90% (compared with surface-applied litter) to levels statistically as low as those from control (no litter) plots. Given this success, two advanced tractor-drawn prototypes were developed to subsurface apply poultry litter in field research. The two prototypes have been tested in pasture and no-till experiments and are both effective in improving nutrient-use efficiency compared with surface-applied litter, increasing crop yields (possibly by retaining more nitrogen in the soil), and decreasing nutrient losses, often to near background (control plot) levels. A paired-watershed study showed that cumulative phosphorus losses in runoff from continuously grazed perennial pastures were decreased by 55% over a 3-yr period if the annual poultry litter applications were subsurface applied rather than surface broadcast. Results highlight opportunities and challenges for commercial adoption of subsurface poultry litter application in pasture and no-till systems.     

Decreasing phosphorus runoff losses from land-applied poultry litter with dietary modifications and alum addition

Phosphorus (P) losses from pastures fertilized with poultry litter contribute to the degradation of surface water quality in the United States. Dietary modification and manure amendments may reduce potential P runoff losses from pastures. In the current study, broilers were fed a normal diet, phytase diet, high available phosphorus (HAP) corn diet, or HAP corn + phytase diet. Litter treatments were untreated control and alum added at 10% by weight between flocks. Phytase and HAP corn diets reduced litter dissolved P content in poultry litter by 10 and 35%, respectively, compared with the normal diet (789 mg P kg(-1)). Alum treatment of poultry litter reduced the amount of dissolved P by 47%, while a 74% reduction was noted after alum treatment of litter from the HAP corn + phytase diet. The P concentrations in runoff water were highest from plots receiving poultry litter from the normal diet, whereas plots receiving poultry litter from phytase and HAP corn diets had reduced P concentrations. The addition of alum to the various poultry litters reduced P runoff by 52 to 69%; the greatest reduction occurred when alum was used in conjunction with HAP corn and phytase. This study demonstrates the potential added benefits of using dietary modification in conjunction with manure amendments in poultry operations. Integrators and producers should consider the use of phytase, HAP corn, and alum to reduce potential P losses associated with poultry litter application to pastures.     

On-farm evaluation of aluminum sulfate (alum) as a poultry litter amendment: effects on litter properties

Aluminum sulfate [alum; Al2(SO4)3] amendment of poultry litters has been suggested as a best management practice to help reduce the potential environmental effects of poultry production. Past research has shown that alum treatment reduced NH3 emissions from litters, decreased the loss in runoff of P and trace metals from litter-amended soils, improved poultry health, and reduced the costs of poultry production. We conducted a large scale, "on-farm" evaluation of alum as a poultry (broiler) litter amendment on the Delmarva peninsula to determine the effect of alum on (i) litter properties and elemental composition and (ii) the solubility of several elements in litter that are of particular concern for water quality (Al, As, Cu, P, and Zn). Alum was applied over a 16-mo period to 97 poultry houses on working poultry farms; 97 houses on other farms served as controls (no alum). Litter samples were analyzed initially and after approximately seven alum applications. We found that alum decreased litter pH and the water solubility of P, As, Cu, and Zn. Alum-treated houses also had higher litter total N, NH4-N, and total S concentrations and thus a greater overall fertilizer value than litters from the control houses. Higher litter NH4-N values also suggest that alum reduced NH3 losses from litters. Thus, alum appears to have promise as a best management practice (BMP) for poultry production. Future research should focus on the long-term transformations of P, Al, As, Cu, and Zn in soils amended with alum-treated litters.     

Effect of alum treatment on the concentration of total and ureolytic microorganisms in poultry litter

Microbial mineralization of urea and uric acid in poultry litter results in the production of ammonia, which can lead to decreased poultry performance, malodorous emissions, and loss of poultry litter value as a fertilizer. Despite the fact that this is a microbial process, little is known about how the microbial populations, especially ammonia-producing (ureolytic) organisms in poultry litter, respond to litter amendments such as aluminum sulfate (Al(2)(SO(4))(3).14H(2)O; alum). The goal of this study was to measure the temporal changes in total bacterial and fungal populations and urease-producing microorganisms in nontreated litter or litter treated with 10% alum. Quantitative real-time polymerase chain reaction was used to target the bacterial 16S rRNA gene, the fungal 18S rRNA gene, or the urease gene of bacterial and fungal ammonia producers in a poultry litter incubation study. Nontreated poultry litter had relatively high total (2.8 +/- 0.8 x 10(10) cells g(-1) litter) and ureolytic (2.8 +/- 1.3 x 10(8) cells g(-1) litter) bacterial populations. Alum treatment reduced the total bacterial population by 50% and bacterial urease producers by 90% within 4 wk. In contrast, at 16 wk after alum treatment, the fungal population was three orders of magnitude higher in alum-treated litter than in nontreated litter (3.5 +/- 0.8 x 10(7) cells g(-1) litter and 5.5 +/- 2.5 x 10(4) cells g(-1) litter, respectively). The decrease in pH produced by alum treatment is believed to inhibit bacterial populations and favor growth of fungi that may be responsible for the mineralization of organic nitrogen in alum-treated litters.     

Nitrogen and phosphorus availability in composted and uncomposted poultry litter

Poultry litter applications to land have been based on crop N requirements, resulting in application of P in excess of plant requirements, which may cause degradation of water quality in the Chesapeake Bay watershed. The effect of litter source (the Delmarva Peninsula and Moorefield, West Virginia) and composting of poultry litter on N mineralization and availability of P in two soil types (sandy loam and silt loam) was determined in a controlled environment for 120 d. Nitrogen mineralization (percent total organic N converted to inorganic nitrogen) rates were higher for fresh litter (range of 42 to 64%) than composted litter (range of 1 to 9%). The N mineralization rate of fresh litter from the Delmarva Peninsula was consistently lower than the fresh litter from Moorefield, WV. The N mineralization rate of composted litter from either source was not significantly different for each soil type (7 to 9% in sandy loam and 1 to 5% in silt loam) even though composting conditions were completely different at the two composting facilities. Litter source had a large effect on N mineralization rates of fresh but not composted poultry litter. Composting yielded a more predictable and reliable source of mineralizable N than fresh litter. Water-extractable phosphorus (WEP) was similar in soils amended with composted litter from WV and fresh litter from both sources (approximately 10 to 25 and 2 to 14 mg P kg(-1) for sandy loam and silt loam, respectively). Mehlich 1-extractable phosphorus (MEP) was similar in soils amended with WV fresh litter and composted litter from both sources (approximately 100 to 140 and 60 to 90 mg P kg(-1) for sandy loam and silt loam, respectively). These results suggest that the composting process did not consistently reduce WEP and MEP, and P can be as available in composted poultry litter as in fresh poultry litter.     

Water-quality effects of incorporating poultry litter into perennial grassland soils

Poultry litter provides a rich source of nutrients for perennial forages, but the usual practice of surface-applying litter to pastures can degrade water quality by allowing nutrients to be transported from fields in surface runoff, while much of the NH4-N volatilizes. Incorporating litter into the soil can minimize such problems in tilled systems, but has not been used for perennial forage systems. In this study, we minimized disturbance of the crop, thatch, and soil structure by using a knifing technique to move litter into the root zone. Our objective was to determine effects of poultry litter incorporation on quantity and quality of runoff water. Field plots were constructed on a silt loam soil with well-established bermudagrass [Cynodon dactylon (L.) Pers.] and mixed grass forage. Each plot had 8 to 10% slopes, borders to isolate runoff, and a downslope trough with sampling pit. Poultry litter was applied (5.6 Mg ha(-1)) by one of three methods: surface-applied, incorporated, or surface-applied on soil-aeration cuts. There were six treatment replications and three controls (no litter). Nutrient concentrations and mass losses in runoff from incorporated litter were significantly lower (generally 80-95% less) than in runoff from surface-applied litter. By the second year of treatment, litter-incorporated soils had greater rain infiltration rates, water-holding capacities, and sediment retention than soils receiving surface-applied litter. Litter incorporation also showed a strong tendency to increase forage yield.     

Microbial mineralization of organic nitrogen forms in poultry litters

Ammonia volatilization from the mineralization of uric acid and urea has a major impact on the poultry industry and the environment. Dry acids are commonly used to reduce ammonia emissions from poultry houses; however, little is known about how acidification affects the litter biologically. The goal of this laboratory incubation was to compare the microbiological and physiochemical effects of dry acid amendments (Al+Clear, Poultry Litter Treatment, Poultry Guard) on poultry litter to an untreated control litter and to specifically correlate uric acid and urea contents of these litters to the microbes responsible for their mineralization. Although all three acidifiers eventually produced similar effects within the litter, there was at least a 2-wk delay in the microbiological responses using Poultry Litter Treatment. Acidification of the poultry litter resulted in >3 log increases in total fungal concentrations, with both uricolytic (uric acid degrading) and ureolytic (urea degrading) fungi increasing by >2 logs within the first 2 to 4 wk of the incubation. Conversely, total, uricolytic, and ureolytic bacterial populations all significantly declined during this same time period. While uric acid and urea mineralization occurred within the first 2 wk in the untreated control litter, acidification resulted in delayed mineralization events for both uric acid and urea (2 and 4 wk delay, respectively) once fungal cell concentrations exceeded a threshold level. Therefore, fungi, and especially uricolytic fungi, appear to have a vital role in the mineralization of organic N in low-pH, high-N environments, and the activity of these fungi should be considered in best management practices to reduce ammonia volatilization from acidified poultry litter.     

The impact of alum addition on organic P transformations in poultry litter and litter-amended soil

Poultry litter treatment with alum (Al(2)(SO(4))(3) . 18H(2)O) lowers litter phosphorus (P) solubility and therefore can lower litter P release to runoff after land application. Lower P solubility in litter is generally attributed to aluminum-phosphate complex formation. However, recent studies suggest that alum additions to poultry litter may influence organic P mineralization. Therefore, alum-treated and untreated litters were incubated for 93 d to assess organic P transformations during simulated storage. A 62-d soil incubation was also conducted to determine the fate of incorporated litter organic P, which included alum-treated litter, untreated litter, KH(2)PO(4) applied at 60 mg P kg(-1) of soil, and an unamended control. Liquid-state (31)P nuclear magnetic resonance indicated that phytic acid was the only organic P compound present, accounting for 50 and 45% of the total P in untreated and alum-treated litters, respectively, before incubation and declined to 9 and 37% after 93 d of storage-simulating incubation. Sequential fractionation of litters showed that alum addition to litter transformed 30% of the organic P from the 1.0 mol L(-1) HCl to the 0.1 mol L(-1) NaOH extractable fraction and that both organic P fractions were more persistent in alum-treated litter compared with untreated litter. The soil incubation revealed that 0.1 mol L(-1) NaOH-extractable organic P was more recalcitrant after mixing than was the 1.0 mol L(-1) HCl-extractable organic P. Thus, adding alum to litter inhibits organic P mineralization during storage and promotes the formation of alkaline extractable organic P that sustains lower P solubility in the soil environment.     

Effect of poultry diet on phosphorus in runoff from soils amended with poultry manure and compost

Phosphorus in runoff from fields where poultry litter is surface-applied is an environmental concern. We investigated the effect of adding phytase and reducing supplemental P in poultry diets and composting poultry manures, with and without Fe and Al amendments, on P in manures, composts, and runoff. We used four diets: normal (no phytase) with 0.4% supplemental P, normal + phytase, phytase + 0.3% P, and phytase + 0.2% P. Adding phytase and decreasing supplemental P in diets reduced total P but increased water-extractable P in manure. Compared with manures, composting reduced both total P, due to dilution of manure with woodchips and straw, and water-extractable P, but beyond a dilution effect so that the ratio of water-extractable P to total P was less in compost than manure. Adding Fe and Al during composting did not consistently change total P or water-extractable P. Manures and composts were surface-applied to soil boxes at a rate of 50 kg total P ha(-1) and subjected to simulated rainfall, with runoff collected for 30 min. For manures, phytase and decreased P in diets had no significant effect on total P or molybdate-reactive P loads (kg ha(-1)) in runoff. Composting reduced total P and molybdate-reactive P loads in runoff, and adding Fe and Al to compost reduced total P but not molybdate-reactive P loads in runoff. Molybdate-reactive P in runoff (mg box(-1)) was well correlated to water-extractable P applied to boxes (mg box(-1)) in manures and composts. Therefore, the final environmental impact of dietary phytase will depend on the management of poultry diets, manure, and farm-scale P balances.     

XANES spectroscopic analysis of phosphorus speciation in alum-amended poultry litter

Aluminum sulfate (alum; Al(2)(SO(4))(3).14H(2)O) is used as a chemical treatment of poultry litter to reduce the solubility and release of phosphate, thereby minimizing the impacts on adjacent aquatic ecosystems when poultry litter is land applied as a crop fertilizer. The objective of this study was to determine, through the use of X-ray absorption near edge structure (XANES) spectroscopy and sequential extraction, how alum amendments alter P distribution and solid-state speciation within the poultry litter system. Our results indicate that traditional sequential fractionation procedures may not account for variability in P speciation in heterogeneous animal manures. Analysis shows that NaOH-extracted P in alum amended litters is predominantly organic ( approximately 80%), whereas in the control samples, >60% of NaOH-extracted P was inorganic P. Linear least squares fitting (LLSF) analysis of spectra collected of sequentially extracted litters showed that the P is present in inorganic (P sorbed on Al oxides, calcium phosphates) and organic forms (phytic acid, polyphosphates, and monoesters) in alum- and non-alum-amended poultry litter. When determining land application rates of poultry litter, all of these compounds must be considered, especially organic P. Results of the sequential extractions in conjunction with LLSF suggest that no P species is completely removed by a single extractant. Rather, there is a continuum of removal as extractant strength increases. Overall, alum-amended litters exhibited higher proportions of Al-bound P species and phytic acid, whereas untreated samples contained Ca-P minerals and organic P compounds. This study provides in situ information about P speciation in the poultry litter solid and about P availability in alum- and non-alum-treated poultry litter that will dictate P losses to ground and surface water systems.     

Tillage, cropping systems, and nitrogen fertilizer source effects on soil carbon sequestration and fractions

Quantification of soil carbon (C) cycling as influenced by management practices is needed for C sequestration and soil quality improvement. We evaluated the 10-yr effects of tillage, cropping system, and N source on crop residue and soil C fractions at 0- to 20-cm depth in Decatur silt loam (clayey, kaolinitic, thermic, Typic Paleudults) in northern Alabama, USA. Treatments were incomplete factorial combinations of three tillage practices (no-till [NT], mulch till [MT], and conventional till [CT]), two cropping systems (cotton [Gossypium hirsutum L.]-cotton-corn [Zea mays L.] and rye [Secale cereale L.]/cotton-rye/cotton-corn), and two N fertilization sources and rates (0 and 100 kg N ha(-1) from NH(4)NO(3) and 100 and 200 kg N ha(-1) from poultry litter). Carbon fractions were soil organic C (SOC), particulate organic C (POC), microbial biomass C (MBC), and potential C mineralization (PCM). Crop residue varied among treatments and years and total residue from 1997 to 2005 was greater in rye/cotton-rye/cotton-corn than in cotton-cotton-corn and greater with NH(4)NO(3) than with poultry litter at 100 kg N ha(-1). The SOC content at 0 to 20 cm after 10 yr was greater with poultry litter than with NH(4)NO(3) in NT and CT, resulting in a C sequestration rate of 510 kg C ha(-1) yr(-1) with poultry litter compared with -120 to 147 kg C ha(-1) yr(-1) with NH(4)NO(3). Poultry litter also increased PCM and MBC compared with NH(4)NO(3). Cropping increased SOC, POC, and PCM compared with fallow in NT. Long-term poultry litter application or continuous cropping increased soil C storage and microbial biomass and activity compared with inorganic N fertilization or fallow, indicating that these management practices can sequester C, offset atmospheric CO(2) levels, and improve soil and environmental quality.     

NUTRIENT AND β17‐ESTRADIOL LOSS IN RUNOFF WATER FROM POULTRY LITTERS1

ABSTRACT: A main water quality concern is accelerated eutrophication of fresh waters from nonpoint source pollution, particularly nutrient transport in surface runoff from agricultural areas and confined animal feeding operations. This study examined nutrient and β₁₇‐estradiol concentrations in runoff from small plots where six poultry litters were applied at a rate of about 67 kg/ha of total phosphorus (TP). The six poultry litter treatments included pelleted compost, pelleted litter, raw litter, alum (treated) litter, pelleted alum litter, and normal litter (no alum). Four replicates of the six poultry litter treatments and a control (plots without poultry litter application) were used in this study. Rainfall simulations at intensity of 50 mm/hr were conducted immediately following poultry litter application to the plots and again 30 days later. Composite runoff samples were analyzed for soluble reactive phosphorus (SRP), ammonia (NH₄), nitrate (NO₃), TP, total nitrogen (TN) and β₁₇‐estradiol concentrations. In general, poultry litter applications increased nutrient and β₁₇‐estradiol concentrations in runoff water. Ammonia and P concentrations in runoff water from the first simulation were correlated to application rates of water extractable NH₄ (R²= 0.70) and P (R²= 0.68) in the manure. Results suggest that alum applications to poultry litter in houses in between flocks is an effective best management practice for reducing phosphorus (P) and β₁₇‐estradiol concentrations in runoff and that pelleted poultry litters may increase the potential for P and β₁₇‐estradiol loss in runoff water. Inferences regarding pelleted poultry litters should be viewed cautiously, because the environmental consequence of pelleting poultry litters needs additional investigation.     

How accurate is the assessment of phosphorus pools in poultry litter by sequential extraction?

Amending poultry litter with Al sulfate (alum) has proven effective in reducing water-soluble P in the litter and in runoff from fields that have received litter applications. Although its effectiveness has been demonstrated on a macroscopic scale in the field or in the poultry houses, little is known about P speciation in either alum-amended or unamended litter. This knowledge is important for the evaluation of long-term stability and bioavailability of P, which is a necessary prerequisite for the assessment of the sustainability of intensive poultry operations. Here we report results from an investigation of alum-amended poultry litter (PL) that combined a chemical extraction sequence with solid-state 31P nuclear magnetic resonance (NMR) spectroscopic analysis of the residues. Aluminum is predominantly found in the fine size separate (<125 microm), indicating that the alum added to the poultry houses hydrolyzed without being completely dispersed in the litter. The NMR spectra confirmed the hypothesis that calcium phosphate phases are only dissolved during extraction with dilute acid and phosphate associated with Al is mainly dissolved during extraction with NaOH. Extraction of phosphate associated with Al was incomplete, however, as evidenced by 31P NMR spectroscopy. It could also be demonstrated that the extraction sequence overestimates the calcium phosphate fraction by an order of magnitude in this particular sample. Results from sequential chemical extraction should therefore be used with caution when assessing the magnitude of different phosphate pools in poultry litter.     

Efficacy of alum and coal combustion by-products in stabilizing manure phosphorus

Animal manures contain large amounts of soluble phosphorus (P), which is prone to runoff losses when manure is surface-applied. Here we report the efficacy of alum and three coal combustion by-products in reducing P solubility when added to dairy, swine, or broiler litter manures in a laboratory incubation study. Compared with unamended controls, alum effectively reduced readily soluble P, determined in water extracts of moist manure samples with 1 h of shaking, for all three manures. The reduction ranged from 80 to 99% at treatment rates of 100 to 250 g alum kg(-1) manure dry matter. The fluidized bed combustion fly ash (FBC) reduced readily soluble P by 50 to 60% at a rate of 400 g kg(-1) for all three manures. Flue gas desulfurization by-product (FGD) reduced readily soluble P by nearly 80% when added to swine manure and broiler litter at 150 and 250 g kg(-1). Another by-product, anthracite refuse fly ash (ANT), was ineffective for all three manures. In all cases, reduction in readily soluble P is primarily associated with inorganic phosphorus (P(i)) with little change in organic phosphorus (P(o)). Sequential extraction results indicate that the by-product treatments shifted manure P from H2O-P into a less vulnerable fraction, NaHCO3 - P, while the alum treatment shifted the P into even more stable forms, mostly NaOH-P. Such shifts in P fractions would have little influence on P availability for crops over the long-term but would retard and reduce potential losses of P following manure applications.