Removing nitrogen and phosphorus from simulated wastewater using algal biofilm technique

Algal biofilmtechnology is a new and advanced wastewater treatment method. Experimental study on removing nitrogen and phosphorus from simulated wastewater using algal biofilm under the continuous light of 3500 Lux in the batch and continuous systems was carried out in this paper to assess the performance of algal biofilm in removing nutrients. The results showed that the effect of removing nitrogen and phosphorus by algal biofilm was remarkable in the batch system. The removal efficiencies of total phosphorus (TP), total nitrogen (TN), ammonia-nitrogen (NH₃-N), and chemical oxygen demand (COD) reached 98.17%, 86.58%, 91.88%, and 97.11%, respectively. In the continuous system, hydraulic retention time (HRT) of 4 days was adopted; the effects of removing TP, TN, NH₃-N, and COD by algal biofilm were very stable. During a run of 24 days, the removal efficiencies of TP, TN, NH₃-N, and COD reached 95.38%, 83.93%, 82.38%, and 92.31%, respectively. This study demonstrates the feasibility of removing nitrogen and phosphorus from simulated wastewater using algal biofilm.     

人工湿地组合生态工艺对规模化猪场养殖废水的净化效果研究

研究了表面流、水平潜流和垂直潜流人工湿地以及地下渗滤系统组合生态工艺对模拟和实际猪场养殖废水的净化效果。结果表明,在进水ρ（COD）=709.2 mg.L-1,ρ（TN）=597.1 mg.L-1,ρ（NH4＋-N）=560.4 mg.L-1和ρ（TP）=42.5 mg.L-1的质量浓度条件下组合生态系统对于COD、TN、NH4＋-N和TP的去除率分别可以达到87%、95%、97%和95%,其中COD的去除主要在第一级表面流人工湿地,NH4＋-N和TN去除主要是在水平潜流和垂直潜流人工湿地,水平潜流和垂直潜流人工湿地对溶解性磷酸盐去除效果明显,地下渗滤起到进一步稳定出水水质的作用。水平潜流和垂直潜流人工湿地的运行结果对比表明,后者对污染物的去除率均高于前者。     

Short-term effects of excessive anaerobic reaction time on anaerobic metabolism of denitrifying polyphosphate-accumulating organisms linked to phosphorus removal and N2O production

The short-term effect of anaerobic reaction time (AnRT) (i.e., 90, 120 and 150 min) on the denitrifying phosphorus (P) removal performance and N₂O production was examined using a denitrifying enhanced biologic phosphorus removal (EBPR) sludge acclimatized with mixed acetate (HAc) and propionate (Pro) (in the molar ratio 3:1) as carbon sources. The results showed that when the AnRT was prolonged from 90 to 150 min, the anaerobic polyhydroxyalkanoate (PHA) synthesis was decreased by 15.3%. Moreover, the ineffective PHA consumption occurred in anaerobic phases and contributed to an increased NO ₂ ^? -N accumulation and higher free nitrous acid (FNA) concentrations (?0.001–0.0011 mg HNO₂-N/L) in the subsequent anoxic phases, causing a severe inhibition on anoxic P-uptake and denitrification. Accordingly, the total nitrogen (TN) and total phosphorus (TP) removal efficiencies dropped by approximately 6.3% and 85.5%, respectively; and the ratio of anoxic N₂O-N production to TN removal increased by approximately 3.8%. The fluorescence in situ hybridization (FISH) analysis revealed that the sludge was mainly dominated by Accumulibacter (62.0% (SE_mean = 1.5%)). In conclusion, the short-term excessive anaerobic reaction time negatively impacted denitrifying P removal performance and stimulated more N₂O production, and its effect on P removal was more obvious than that on nitrogen removal.     

三峡水库香溪河库湾氮磷分布状况及沉积物污染评价

为了解三峡大坝蓄水完成之后香溪河库湾水体及沉积物中氮、磷的分布状况以及沉积物污染水平,2013年4月对三峡水库香溪河库湾进行调查采样,测定表层水及沉积物中氮磷含量和形态组成。结果表明,香溪河库湾表层水总磷(TP)含量范围为0.20~0.51 mg·L~(-1),总氮(TN)含量范围为0.54~2.25 mg·L~(-1),TP主要由磷酸盐(PO_4~(3-))组成,TN主要由硝酸盐(NO_3~-)以及氨氮(NH_4~+)组成,TP在空间上呈现从河口向库尾逐渐升高的分布格局,TN分布从河口向库尾逐渐降低。香溪河库湾沉积物中TP含量变化范围为642~1 189 mg·kg~(-1),TN含量变化范围为867~1 718 mg·kg~(-1),沉积物TP含量分布呈现上游高下游低,沉积物TN分布趋势呈现中间高,两头低。沉积物中TP主要由无机磷(IP)组成,有机磷(OP)所占比例较小,其中IP由钙磷(Ca-P)、铁铝磷(Fe/Al-P)组成,三者含量:Ca-POPFe/Al-P,且沉积物TP含量空间变化受到三者影响(P0.05)。采用单一因子标准指数法对香溪河库湾沉积物中TN、TP污染水平进行评价,结果表明,表层沉积物中TN、TP最低级别污染指数平均值为2.0和1.6,表层沉积物中TN、TP污染指数均超过最低污染水平,且TP的严重级别污染指数达到0.5以上。三峡水库三期蓄水完成以后,香溪河库湾表层水体中氮磷含量较初期蓄水有所升高,各样点沉积物中氮磷含量表现出相同的趋势,沉积物中不稳定磷释放对水体富营养化具有影响,香溪河库湾的表层沉积物已经受到一定的污染,磷污染水平较高。     

两级人工湿地用于村镇污水脱氮的长期运行特性研究

对沙田人工湿地稳定运行后的情况进行了长达6 a的监测,探讨了不同流态的两级潜流人工湿地长期运行的脱氮效能、不同形态氮的空间转化规律和几种主要影响因素。研究表明,在整个运行期间人工湿地的脱氮能力呈现低-高-低的变化趋势,这个过程的发生和湿地内部堵塞物的累积关联密切。在华南地区,季节变化对湿地脱氮的影响依然十分强烈：一方面,体现为季节温差对脱氮效果的明显影响,低温月份采用低负荷方式运行,TN去除率也仅有36.0%～47.6%,而高温期采用高负荷的运行方式,大多数月份TN去除率也能达到45.4%以上;另一方面,季节性雨量的不同会引起进水质量浓度的变化,导致湿地系统TN负荷率的改变,进而显著影响脱氮效果。有机氮、NH3-N、NO2--N、NO3--N在湿地内部存在明显的转化迹象,沿流程随着有机物的大量消耗,NO3--N去除能力逐渐下降并在湿地的末端出现了累积现象。通常情况下,由于采用了跌水曝气等措施,DO在湿地内的大部分区域都维持了较高水平,未对脱氮效果产生明显不利影响。     

Case Study on Nitrogen and Phosphorus Emissions from Paddy Field in Taihu Region

The agricultural non-point source pollution by nitrogen (N) and phosphorus (P) loss from typical paddy soil (whitish soil, Bai Tu in Chinese) in the Taihu Lake region was investigated through a case study. Results shown that the net load of nutrients from white soil is 34.1 kg ha^–1 for total nitrogen (TN), distributed as 19.4 kg ha^–1, in the rice season and 14.7 kg ha^–1in the wheat season, and for total phosphorus (TP) 1.75 kg ha^–1, distributed as 1.16 kg ha^–1 in the rice season and 0.58 kg ha^–1 in the wheat season. The major chemical species of N loss is different in the two seasons. NH₄-N is main the form in the rice season (53% of TN). NO₃-N is the main form in wheat season (46% of TN). Particle-P is the main form in both seasons, (about 56% of TP). The nutrient loss varied with time of the year. The main loss of nutrients happened in the 10 days after planting, 64% of TN and 42% of TP loss, respectively. Rainfall and fertilizer application are the key factors which influence nitrogen and phosphorus loss from arable land, especially rainfall events shortly after fertilizer application. So it is very important to improve the field management of the nutrients and water during the early days of planting.     

Removal of nitrogen and phosphorus from textile wastewater by soilless culture of Lolium multiflorum

A technique of soilless culture for removal of total nitrogen (TN) and total phosphorus (TP) from textile wastewater using Lolium multiflorum was conducted in this research. The TN concentration decreased from 50.72 mg/L to 24.64–27.89 mg/L and TP decreased from 6.9 mg/L to 3.7–4.1 mg/L in the experimental tank with the size of 4.7 m x 1.2 m x 0.75 m. The results suggested that L. multiflorum could absorb a large amount of N and P elements from the wastewater. This technique of soilless culture has many advantages such as simple equipment, low cost, easy operation, low energy consumption, convenient management and flexible disposition.     

Impact of photosynthesis and transpiration on nitrogen removal in constructed wetlands

To determine the impact of photosynthesis and transpiration on nitrogen removal in wetlands, an artificial wetland planted with reeds was constructed to treat highly concentrated domestic wastewater. Under different meteorological and hydraulic conditions, the daily changes of photosynthesis and transpiration of reeds, as well as nitrogen removal efficiency were measured. It was found that net photosynthesis rate per unit leaf area was maintained on a high level (average 19.0 μmol CO₂/(m²·s)) from 10:00 to 14:00 in July 2004 and reached a peak of 21.1 μmol CO₂/(m²·s) when Photon Flux Density was high during the day. Meanwhile, TN and NH₄ ⁺-N removal efficiency rose to 79.6% and 89.6%, respectively—the maximum values observed in the test. Correlation coefficient analysis demonstrated a positive correlation among photon flux density, net photosynthetic rate, transpiration rate, and TN and NH₄ ⁺-N removal efficiency. In contrast, there was a negative correlation between stomatal conductance and TN and NH₄ ⁺-N removal efficiency. Results suggest that the photosynthesis and transpiration of wetland plants have a great impact on nitrogen removal efficiency of wetlands, which can be enhanced by an increase in the photosynthesis and transpiration rate. In addition, the efficiency of water usage by reeds and nitrogen removal efficiency could be affected by the water level in wetlands; a higher level boosts nitrogen removal efficiency.     

Pilot-scale studies of domestic wastewater treatment by typical constructed wetlands and their greenhouse gas emissions

Three typical constructed wetlands (CWs) including Vertical Flow (VF), Free Water Surface (FWS), and Subsurface Flow (SF), and combined VF-SF-FWS constructed wetlands were investigated for the treatment of domestic wastewater with low C/N ratio. The performance of nutrient removal and the characteristics of greenhouse gas emissions, such as CH₄ and N₂O, from these CWs were compared. The results indicated that the four types of CWs had high removal efficiencies for organic matter and suspended solid (SS). The combined wetland also showed a comparatively good performance for nitrogen and phosphorus removal, and the removal efficiencies for total nitrogen (TN) and total phosphorus (TP) were 81.3% and 84.5%, respectively. The combined CWs had a comparative lower global warming potential. The FWS CW had the highest tendency to emit CH₄ and led to a higher global warming potential among the four types of CWs, which was about 586 mg CO₂/m²·h.     

风车草对生活污水的净化效果及其在人工湿地的应用

研究了风车划（Cyerus alternifolius）的生长特性和对生活污水的净化效果。风车草全年保持生长，即使在冬天仍能维持一定的生长速率。风车草在生活污水中培养10d后，污水中TN、TP、COD和BOD的去除率分别达到91％、92％、70％和73％，其中风车草对N、P的吸收量分别占净化量的55％和53％。种植风车草的潜流型人工湿地对TN、TP、COD和BOD的去除率分别为64％、47％、74％和74％，与不种植物的人工湿地相比，TN、TP、COD和BOD的去除率分别提高了28％、19％、14％和13％。图2表3参12     

Advanced nitrogen and phosphorus removal in A2O-BAF system treating low carbon-to-nitrogen ratio domestic wastewater

A laboratory-scale anaerobic-anoxic-aerobic process (A²O) with a small aerobic zone and a bigger anoxic zone and biologic aerated filter (A²O-BAF) system was operated to treat low carbon-to-nitrogen ratio domestic wastewater. The A²O process was employed mainly for organic matter and phosphorus removal, and for denitrification. The BAF was only used for nitrification which coupled with a settling tank Compared with a conventional A²O process, the suspended activated sludge in this A²O-BAF process contained small quantities of nitrifier, but nitrification overwhelmingly conducted in BAF. So the system successfully avoided the contradiction in sludge retention time (SRT) between nitrifying bacteria and phosphorus accumulating organisms (PAOs). Denitrifying phosphorus accumulating organisms (DPAOs) played an important role in removing up to 91% of phosphorus along with nitrogen, which indicated that the suspended activated sludge process presented a good denitrifying phosphorus removal performance. The average removal efficiency of chemical oxygen demand (COD), total nitrogen (TN), total phosphorus (TP), and NH ₄ ⁺ -N were 85.56%, 92.07%, 81.24% and 98.7% respectively. The effluent quality consistently satisfied the national first level A effluent discharge standard of China. The average sludge volume index (SVI) was 85.4 mL·g^?1 additionally, the volume ratio of anaerobic, anoxic and aerobic zone in A²O process was also investigated, and the results demonstrated that the optimum value was 1:6:2.     

长三角城郊樟溪流域水体氮磷分布特征及其影响因素

快速城镇化和人类活动导致城郊流域水体营养盐污染和富营养化问题加重,识别氮、磷污染对流域水质的管控具有重要的意义。本研究选取长三角典型城郊地区宁波樟溪流域,在流域内根据土地利用类型、地形特征等布设样点,于2016年连续4个季度进行水样采集,研究樟溪流域河流水体氮、磷的含量及形态,及氮、磷在该流域的时空分布特征,并对其来源和影响因素进行分析。研究结果表明,流域内氮、磷分布具有较大的空间差异性,其中NH+4-N(n.d.~1.375 mg·L~(-1))、TN-N(0.570~11.363 mg·L~(-1))、DIP(n.d.~0.169 mg·L~(-1))、TP(0.010~1.908 mg·L~(-1))。在子流域空间分布上,人类活动频度越高的区域氮、磷的浓度越高,各采样点水体不同形态氮含量和磷含量具有明显的季节变化规律:春季和秋季的含量要高于夏季和冬季。本研究选取采样点距城镇距离、距源头距离以及土地利用类型所占采样点缓冲区的比例来表征人类活动的影响,结果表明,TN和TP含量与距城镇距离呈显著负相关关系,表明城镇化水平对流域氮、磷污染的重要影响。另外,典型城郊流域河流水体氮、磷污染主要受土地利用类型的影响,其含量与农业和城镇用地呈显著正相关关系(P0.01),其含量随人类活动频度的增加而升高。     

人工湿地处理富营养化水体的效果研究

通过在北京市野生动物救护中心构建表流湿地与潜流湿地相结合的复合人工湿地处理富营养化水体,研究该复合人工湿地对总氮（TN）、总磷（TP）及水体浊度的去除效果。结果表明：人工湿地对TP的去除效果好于对TN的去除效果,经过人工湿地处理的富营养化水体,表流湿地、潜流湿地和复合人工湿地对TP的平均去除率可分别达42%、55%、60%,对TN的平均去除率分别为27%、30%、34%,对水体浊度的平均去除率分别达43%、55%、75%。复合人工湿地对TP、TN以及浊度的去除效果受水体温度和溶解氧（DO）的影响,通过相关性分析发现,TP、TN和浊度的去除量与水体中的DO水平之间存在显著的负相关性,而与水体温度有正相关性,在显著性水平为0.05的条件下,相关系数分别为-0.829、-0.767、-0.765和0.674、0.757、0.774。复合人工湿地对TP、TN及浊度的去除率高于表流湿地和潜流湿地,表明复合人工湿地具有优于表流湿地和潜流湿地的整体性功能,能有效提高人工湿地对TN、TP以及浊度的去除率。     

不同进水有机物浓度下移动床生物膜反应器(SBMBBR)脱氮除磷特性

考察了不同进水有机物浓度下厌氧/好氧序批式移动床生物膜反应器（SBMBBR）污染物去除特性,实验结果表明,SBMBBR能够实现低碳源污水中氮和磷的同步去除,在进水TN和TP浓度分别为116.7 mg.L-1和11.5 mg.L-1、COD浓度为456 mg.L-1的条件下,TN和TP去除率分别达到94.3%和92.2%以上.反应器除磷是基于常规生物除磷和反硝化除磷过程实现的,脱氮主要是基于好氧段发生的同时硝化反硝化（SND）作用而完成.由于生物膜内部存在的DO扩散梯度,在好氧阶段混合液DO浓度不断提高的条件下反应器内具有良好SND反应的发生.进水COD浓度由149 mg.L-1提高至456 mg.L-1的过程中,反应器硝化效果不变,反硝化和除磷效果改善.反应器在好氧阶段pH值基本维持在7.0—7.1之间,为各类菌群的生长创造了条件.碱度变化较pH值更能反映硝化和反硝化反应发生的程度.反应器中微生物相丰富,生物膜以丝状菌为骨架,其上附着大量的球状菌和杆状菌,而悬浮活性污泥中丝状菌较少,形成了由细菌、真菌到原生动物和后生动物的复杂的生态体系,为系统取得稳定的污水处理效果提供了有效的保证.     

Effect of different carbon sources on performance of an A<Subscript>2</Subscript>N-MBR process and its microbial community structure

Effect of different carbon sources on purification performance and change of microbial community structure in a novel A₂N-MBR process were investigated. The results showed that when fed with acetate, propionate or acetate and propionate mixed (1:1) as carbon sources, the effluent COD, NH₄ ⁺-N, TN and TP were lower than 30, 5, 15 and 0.5 mg?L^–1, respectively. However, taken glucose as carbon source, the TP concentration of effluent reached 2.6 mg?L^–1. Process analysis found that the amount of anaerobic phosphorus release would be the key factor to determine the above effectiveness. The acetate was beneficial to the growth of Candidatus Accumulibacter associated with biological phosphorus removal, which was the main cause of high efficiency phosphorus removal in this system. In addition, it could eliminate the Candidatus Competibacter associated with glycogen-accumulating organisms and guarantee high efficiency phosphorus uptake of phosphorus accumulating organisms in the system with acetate as carbon source.

Open image in new window

     

人工湿地系统对含沼液畜禽废水净化效果试验研究

为了考察人工湿地处理含沼液畜禽废水的可行性,采用水平潜流人工湿地对含沼液畜禽废水进行处理实验。试验结果表明：在进水流量1.5 m3.d-1,水平潜流人工湿地系统对含沼液畜禽废水具有较好的处理效果。废水中COD、TP、TN和NH4＋-N浊度平均去除率分别为59.21%、53.80%、55.09%和55.57%.另外,通过对人工湿地沿程的污染物变化试验分析表明,人工湿地系统对污染物的降解是沿人工湿地水流方向逐渐降低的。     

Comparative experiment on treating digested piggery wastewater with a biofilm MBR and conventional MBR: simultaneous removal of nitrogen and antibiotics

A biofilm membrane bioreactor (BF-MBR) and a conventional membrane bioreactor (MBR) were parallelly operated for treating digested piggery wastewater. The removal performance of COD, TN, NH₄ ⁺-N, TP as well as antibiotics were simultaneously studied when the hydraulic retention time (HRT) was gradually shortened from 9 d to 1 d and when the ratio of influent COD to TN was changed. The results showed that the effluent quality in both reactors was poor and unstable at an influent COD/TN ratio of 1.0±0.2. The effluent quality was significantly improved as the influent COD/TN ratio was increased to 2.3±0.5. The averaged removal rates of COD, NH₄ ⁺-N, TN and TP were 92.1%, 97.1%, 35.6% and 54.2%, respectively, in the BF-MBR, significantly higher than the corresponding values of 91.7%, 90.9%, 17.4% and 31.9% in the MBR. Analysis of 11 typical veterinary antibiotics (from the tetracycline, sulfonamide, quinolone, and macrolide families) revealed that the BF-MBR removed more antibiotics than the MBR. Although the antibiotics removal decreased with a shortened HRT, high antibiotics removals of 86.8%, 80.2% and 45.3% were observed in the BF-MBR at HRTof 5–4 d, 3–2 d and 1 d, respectively, while the corresponding values were only 83.8%, 57.0% and 25.5% in the MBR. Moreover, the BF-MBR showed a 15% higher retention rate of antibiotics and consumed 40% less alkalinity than the MBR. Results above suggest that the BF-MBR was more suitable for digested piggery wastewater treatment.

Open image in new window

     

Circulating fluidized bed biological reactor for nutrients removal

A new biological nitrogen removal process, which is named herein “The circulating fluidized bed bioreactor (CFBBR)”, was developed for simultaneous removal of nitrogen and organic matter. This process was composed of an anaerobic bed (Riser), aerobic bed (Downer) and connecting device. Influent and nitrified liquid from the aerobic bed enters the anaerobic bed from the bottom of the anaerobic bed, completing the removal of nitrogen and organic matter. The system performance under the conditions of different inflow loadings and nitrified liquid recirculation rates ranging from 200% to 600% was examined. From a technical and economic point of view, the optimum nitrified liquid recirculation ratewas 400%. With a shortest total retention time of 2.5 h (0.8 h in the anaerobic bed and 1.5 h in the aerobic bed) and a nitrified liquid recirculation rate of 400% based on the influent flow rate, the average removal efficiencies of total nitrogen (TN) and soluble chemical oxygen demand (SCOD) were found to be 88% and 95%, respectively. The average effluent concentrations of TN and SCOD were 3.5 mg/L and 16 mg/L, respectively. The volatile suspended solid (VSS) concentration, nitrification rate and denitrification rate in the system were less than 1.0 g/L, 0.026-0.1 g NH₄ ⁺-N/g VSS·d, and 0.016–0.074 g NO_x ^?-N/g VSS·d, respectively.     

Effects of nitrite on phosphate uptake in anaerobic-oxic process

An anaerobic-oxic (A/O) biological phosphorus removal reactor was operated to study the effect of nitrite on phosphate uptake. The phosphorus uptake profile was determined under different operating conditions. The results indicated that in addition to oxygen and nitrate (DPB_Na, nitrate denitrifying phosphorus removal), to some extent, nitrite could also serve as an electron acceptor to achieve nitrite denitrifying phosphorus removal (DPB_Ni). The quantity and rate of phosphorus uptake of DPB_Ni, however, were evidently lower than that of DPB_Na. The experiment results revealed that nitrite would bring toxic action to phosphate-accumulating organisms (PAOs) when NO₂ ^?-N ? 93.7 mg/L. The nitrite existing in the anoxic reactor made no difference to the quantity and rate of denitrifying phosphorus removal, but it could reduce the consumption of nitrate. Moreover, the data showed that the aerobic phosphate uptake of DPB_Ni was lower than that of anaerobic phosphorus-released sludge in a traditional A/O process. However, there was not much difference between these two kinds of sludge in terms of the total phosphorus uptake quantity and the effluent quality.