Stabilization of metal processing plant sludge via sequential application of phytoremediation and pyrolysis

The aim of this study is to evaluate the metal removal ability of three different plants from metal processing sludge containing Pb, Cd, and Zn. Therefore, phytoremediation and pyrolysis were sequentially applied. In the phytoremediation applications, sunflower (Helianthus annuus), corn (Zea mays), and rape (Brassica napus) seeds were sown in sludge/soil mixtures at four different levels (25/75, 50/50, 75/25, 100/0). The chelating agent, ethylenediaminetetraacetic acid, was added to the mixtures for plant uptake during phytoremediation. At the phytoremediation stage, it was noted that rape was the most effective plant for the mixture of 75/25 sludge/soil, with metal removal efficiencies ranging between 80%–90%. At the pyrolysis stage, after harvesting, contaminated plants grown in a 75/25 sludge/soil mixture were pyrolyzed at 500 °C, with a heating rate of 35 °C/min. The results show that 60%–90% of the initial metal content was held by the solid product. In addition to this, it can be concluded that pyrolysis stabilizes metals into a solid product and that this solid product can be safely landfilled as inert waste since its toxicity leaching value is lower than the limit values.     

污泥和盐渍土混配介质的性质及对5种野生植物生长的影响

将污泥与滨海盐渍土按照不同比例(污泥质量分数分别为0、20%、40%、60%、80%和100%)混配,开展三叶鬼针草(Bidens pilosa)、稗(Echinochloa crusgalli)、荆芥(Schizonepeta tenuifolia)、金叶马兰(Kalimeris indica)和蒲公英(Taraxacum mongolicm)5种野生植物的盆栽试验,研究污泥混配介质的理化性质,污泥比例对植物成活率、叶绿素含量和干质量的影响,以及植物体内各种重金属的累积浓度,探索污泥在滨海区盐渍土中的最佳施用比例,并对野生植物资源进行评价。结果表明,污泥改良滨海盐渍土是可行的,污泥质量分数为20%～60%时,混配介质的理化指标符合CJ/T 340—2011《绿化种植土壤》,Cd、Cu、Zn、Cr、Pb和Ni含量符合GB 15618—95《土壤环境质量标准》中的二级标准,并以60%污泥+40%滨海盐渍土的质量配比效果最佳,该混配介质中植物存活率达100%;三叶鬼针草、稗子、荆芥、金叶马兰和蒲公英是上海市滨海地区优良的植被恢复先锋植物。     

利用植物复合床技术处理工业污水

选取风车草、蝴蝶兰、吊兰、小纸莎、菖蒲、香根草6种植物作为人工湿地植物,砾石、活性炭、河沙、砾石+河沙、活性炭+河沙、活性炭+砾石共6种填料作为人工湿地填料,进行不同植物和不同填料组合处理某胶水厂洗釜过程产生的工业废水能力的实验研究.结果表明,在相同的进水水质和水力负荷条件下,从经济成本角度考虑,蝴蝶兰与活性炭+河沙组合较好,对CODCr、氨氮的去除率分别达到95%、99%,出水水质符合DB44/26—2001广东省地方标准水污染物排放限制标准一级标准.该技术处理效果好,操作简单,易维护,适合推广.     

Reclamation of phytotoxic tailing

The reclamation of tailing that is toxic to vegetation (phytotoxic) was the subject of laboratory and field research. Using trona tailing as an example of phytotoxic waste, research identified three areas that may be critical to reclamation:

establishment and maintenance of a capillary barrier to prevent upward migration of plant toxicants into the plant-rooting zone;

water drainage or evaporation to prevent or control water accumulation within the tailing;

soil requirements for revegetation.

A pilot reclamation program was developed in which a 20-cm layer of coarse gravel formed a capillary barrier between phytotoxic tailing and overlying material. To maintain the integrity of the capillary barrier, a 20-cm layer of fine gravel was applied to the coarse gravel surface; soil was then applied to the fine gravel surface. A zone of shallow soil was used to allow water, which collected during the late winter, to evaporate from the tailing during the dry summer. Soil depth requirements were assessed by measuring the response of shrubs and grasses to increasing soil depth.     

Effectiveness of emergent and submergent aquatic plants in mitigating a nitrogen–permethrin mixture

Hydraulically connected wetland microcosms (～50?L) in series were used to test the effectiveness of varying combinations of two common aquatic vascular plants, parrot feather (Myriophyllum aquaticum) and cattail (Typha latifolia), for mitigating contamination from a mixture of nitrogen (ammonium nitrate) and permethrin. The upstream series included Myriophyllum only (M) and Typha only (T) while the combination upstream effluent into downstream series included Myriophyllum into Myriophyllum (M?+?M) and Typha into Myriophyllum (T?+?M). During flow, M into M?+?M more efficiently mitigated nitrogen than T into T?+?M. Post-flow, nitrogen removal efficiency was greater for T versus M and M?+?M versus T?+?M. Mean aqueous dissipation half-lives (t_1/2) of NH₄-N and NO₃-N were more rapid in T than M treatments. Ammonium and nitrate t_1/2 was highly correlated with aquatic plant above-ground shoot biomass. Permethrin mitigation efficiencies and t_1/2 were not significantly affected by plant species either singly or in combination. Trans-permethrin t_1/2 was moderately correlated with plant biomass, but not cis-permethrin t_1/2. Results of this study indicate differences in aquatic plant species and flow path influence nitrogen removal but not permethrin. However, plant species appears less important than overall plant biomass in ascertaining aquatic plant effectiveness in mitigating a nitrogen–permethrin mixture.     

Fate of herbicides and nonylphenol in soil–plant–water systems amended with contaminated sewage sludge

We studied the fate of sludge spiked with ¹⁴C-labelled diuron, glyphosate and nonylphenol applied to the soil by the way of contaminated sewage sludge in the soil-plant-water system. Here we show that the mineralization of the chemicals in mixture is reduced by 40–80% by comparison with a direct soil contamination. The persistence of the chemicals in soils is increased in the presence of sludge. We showed also that the chemicals present in the sludge are mobile and partly transferred to soil leachates and plant seedlings. These results allow postulating that these compounds may induce an ecotoxicological impact on the soil ecosystem.     

Identification and assay of microbial fatty acids during co-composting of active sewage sludge with palm waste by TMAH-thermochemolysis coupled with GC-MS

The fatty acids of two composts of active sludge with palm tree waste were investigated by thermochemolysis coupled to gas chromatography-mass spectrometry. This method (tetramethylammonium hydroxide-pyrolysis-gas chromatography-mass spectrometry) allowed the direct determination of total fatty acids (analysed as fatty acid methyl esters: FAMEs) present in the organic matter of the samples without any separation procedures. Mixture A was 1/3 sludge+2/3 palm waste and mixture B was 1/2 sludge+1/2 palm waste. The level of FAMEs rose by 8.4–33.3% and 10.8–13.4% in mixtures A and B, respectively, after 6 months of co-composting. Branched FAMEs of bacterial origin (iC15:0) rose during the thermophilic phase, in mixture A the aC17:0/aC15:0 ratio increased during the co-composting process, also in mixture B the aC16:0/C16:0 ratio rose but only during the thermophilic phase. All the FAMEs identified showed a drop at the end of co-composting except for C18:0 and C16:0. The stabilisation phase was characterised by a significant rise in the length of the aliphatic chains; the carbon preference index thus increased at the end of the composting process, indicating that the final product was proportionally richer in fatty acids of plant origin.     

粉煤灰钝化污泥人工土壤上高麦草生长发育及营养状况研究

通过温室盆栽试验研究不同比例粉煤灰钝化污泥人工土壤上高麦草的生长发育及营养状况，试验结果表明：土壤中加入粉煤灰钝化污泥显著增加了高麦草的干物重．脱水污泥加入其鲜重的10％粉煤灰钝化后再按1∶1和1∶5体积比与土壤混合配成的人工土处理和加入其鲜重的35％粉煤灰钝化后再按1∶1体积比与土壤混合配成的人工土处理高麦草的产量都显著高于自然土壤施用化肥的处理，高麦草的发芽率也不受影响．随着粉煤灰加入量的增加，高麦草地上部Ca，Mg和B的浓度（w／％或w／mg．kg－1）增加而K，Fe，Mn和Zn的浓度下降，高麦草根中Fe，Mn，Cu和Zn的浓度显著高于其地上部中的浓度．所有粉煤灰钝化后污泥人工土壤高麦草都没有出现N和P的缺乏和重金属毒害，说明合适比例的粉煤灰钝化污泥人工土壤是高麦草的良好生长介质．     

Application of standard statistical methods in the analysis of complex data generated from soil bioassays to assess the impacts of agrochemical-containing sludge amendments

The use of sludge as soil amendment is widely encouraged by its high contents in organic matter and plant nutrients. Nevertheless, agrochemicals potentially present in sludge could be harmful to terrestrial ecosystems. The present work aimed to apply standard statistical methods for suitable assessment of the ecotoxicological impacts of sludge amendments on soil, involving the following factors: the type of treated sludge, their application dose, and their contents in agrochemicals. Terrestrial Model Ecosystems were used to assess the effects of sludge amendments on endpoints from different trophic levels of the soil ecosystem, including an in vitro estrogenic bioassay on soil leachates. Here, we show the significant negative effects of the highest dose of sludge in most of the soil bioassays. Thermally dried sludge increased significantly the microbial activity leading to lower contamination of leachates with endocrine disrupting molecules. Agrochemicals contents of sludge have only significant impacts on increasing the delay of germination of plant seeds. Soil bioassays are thus complementary to sludge chemical analysis when the impacts of its application on soil should be assessed: significant negative impacts were related to the intrinsic composition of sludge rather than its agrochemicals contents. We conclude that standard statistical methods are relevant tools for the analysis of complex data generated from this type of experiment.     

Biomanagement of paper mill sludge using an indegenous (Lampito mauritii) and two exotic (Eudrilus eugineae and Eisenia foetida) earthworms

Paper mills have severe problem in disposing effluent or semisolid sludge despite repeated recycling. It requires treatment prior to disposal of sludge. In recent years biological treatment methods received much attention and considered as efficient low-cost treatment. One such method is vermiculture treatment. The present study was carried out to dispose the paper mill sludge biologically using 2 exotic species (Eudrilus eugineae and Eiseniafoetida) and an indigenous species (Lampito mauritii) of earthworm. The paper mill sludge in various concentration 25%,50% and 75% were subjected to vermitub treatment for a period of 60 days. During the period of study data were collected on reproductive strategies of earthworm and chemical analysis of wastes before and after treatment. Results obtained indicate that 25% concentration of sludge was ideal and of the three worms used Eiseniafoetida proved to be the best worm for biomanagement.     

农用污泥中铜的生态安全阈值研究

本论文采用污泥和土壤外源铜的活性差异系数法研究了农用污泥中铜的生态安全阈值。首先通过比较确定不同土壤条件下污泥中铜和水溶性铜的活性差异的系数,然后利用系数法得到相应土壤条件下污泥铜HC5值(即能够保护95%物种的浓度),并建立了土壤理化性质参数与污泥铜HC5值的量化关系和预测模型。最后与我国现行污泥农用标准值进行了比较,提出了修改建议。结果表明,土壤中来源污泥的铜活性均值约为来源水溶性盐的40%左右。土壤阳离子交换量(CEC)是影响土壤中污泥源铜的毒性的主控因子,可影响污泥铜HC5值变异的84.6%,而土壤pH值和有机碳含量(OC)分别可影响污泥铜HC5值变异的8.4%和1.8%。基于土壤pH、OC和CEC的三因子模型进行预测优于基于土壤pH和CEC的两因子模型,其相关性达到94.8%。与模型预测值相比,我国现行污泥农用标准GB4284-84与CJ/T309-2009中对铜限值的规定均存在着不同程度的保护不足或保护过度问题。     

Phytoremediation of petroleum-contaminated soils: Pre-screening for suitable plants and rhizospheral fungi

A field study was conducted in a petroleum-contaminated site in Kermanshah refinery (Iran) to find the petroleum-resistant plant species and the rhizospheral fungi for being used in bioremediation. Results showed that the amounts of petroleum pollution in non-vegetated areas is 6.8% and in vegetated areas is 2.2%. Plant samples were collected from petroleum-polluted areas and determined using morphological characters. It was found that eight plant species were growing on the contaminated sites: Polygonum aviculare, Amaranthus retroflexus, Noea mucronata, Alhaji cameleron, Crozophora heirosolymitrana, Poa sp., Convolvulus arvensis and Trifolium repense. The rhizospheral fungi of the plants were collected and determined using microscopic studies and taxonomical keys. The results determined the presence of 21 species in the rhizosphere of the plants growing in the polluted areas; three of these species were common in all of the plants and the others have species-specific distribution within the plants. The highest number of rhizospheral fungi (11 species) were determined for P. aviculare in non-polluted areas and nine species in polluted areas. It seems that the plant is the best candidate for using phytoremediation. However, the variation of fungi in petroleum-polluted areas was more than non-polluted zones. The culture of fungi in oil-contaminated media showed that, although all the studied fungi were resistant to low petroleum pollution (1% v/v), a few species, especially Fusarium species, showed higher resistance to petroleum pollution (10% v/v) and hence they may be suitable for mycoremediation in highly polluted areas.     

Metal immobilization by sludge-derived biochar: roles of mineral oxides and carbonized organic compartment

Pyrolyzing sludge into biochar is a potentially promising recycling/disposal solution for municipal wastewater sludge, and the sludge-derived biochar (SDBC) presents an excellent sorbent for metal immobilization. As SDBC is composed of both mineral oxides and carbonized organic compartment, this study therefore compared the sorption behaviour of Pb and Zn on SDBC to those of individual and mixture of activated carbon (AC) and amorphous aluminium oxide (Al₂O₃). Batch experiments were conducted at 25 and 45 °C, and the metal-loaded sorbents were artificially aged in the atmosphere for 1–60 days followed by additional sorption experiments. The Pb sorption was generally higher than Zn sorption, and the co-presence of Pb reduced Zn sorption on each studied sorbent. Higher sorption capacities were observed at 45 °C than 25 °C for SDBC and AC, while the opposite was shown for Al₂O₃, indicating the significance of temperature-dependent diffusion processes in SDBC and AC. Nevertheless, metal sorption was more selective on Al₂O₃ that showed a greater affinity towards Pb over Zn under competition, correlating with the reducible fraction of sequential extraction. Furthermore, significant amounts of Pb and Zn were additionally sorbed on SDBC following 30-day ageing. The X-ray diffraction revealed the formation of metal-phosphate precipitates, while the X-ray photoelectron spectroscopy showed a larger quantity of metal–oxygen bonding after 30-day ageing of metal-loaded SDBC. The results may imply favourable long-term transformation and additional sorption capacity of SDBC. In conclusion, SDBC resembles the sorption characteristics of both organic and mineral sorbents in different aspects, presenting an appropriate material for metal immobilization during soil amendment.     

Diffusive gradient in thin-film (DGT) models Cd and Pb uptake by plants growing on soils amended with sewage sludge and urban compost

Food contamination by Cd and Pb is of increasing concern because contaminated composts and sewage sludges are used as soil fertilizers. Indeed, Cd and Pb from sewage sludge and compost can be transferred to plants and, in turn, to food. Predicting the quantity of metals transferred to plants is difficult and actual models are unable to give accurate concentrations. Therefore, new techniques are needed. For instance, diffusive gradient in thin-film (DGT) is commonly used to measure metal bioavailability in waters, sediments and soils, but DGT has not been well studied for metal uptake in plants. Moreover, actual models for soil–plant transfer are too complex and require many soil parameters. Here, we simplified the modelization of metal uptake by plants by considering only DGT fluxes and roots surfaces. We grew durum wheat in a greenhouse on sandy soils amended with urban compost or sewage sludge. Results show that Cd uptake was slightly underestimated when whole roots were considered as an absorbing surface. For Pb, the best estimation was found by using root tip surface. Overall, our model ranks correctly the samples but underestimates Pb uptake by 15 % and Cd uptake by 45 %. It is nonetheless a simpler way of modelling by using only DGT fluxes and root system morphology.     

The use of legumes for reclaiming copper mine wastes in the Southwestern USA

Seeds of three legumes, blue lupine (Lupinus hirsutus L.), sesbania (Sesbania macrocarpa Muhl.), and alfalfa (Medicago sativa L.) were broadcast planted on four soil materials (desert soil, overburden, overburden plus tailings, and tailings) associated with copper mines near Tucson, Arizona. Experiments were conducted to study the effects of the four soil materials on germination (emergence), seedling establishment, and growth over a two-year period (1974 and 1975). All species grew best on desert soil, followed by overburden, overburden plus tailings, and tailings, in decreasing order. The presence of copper in overburden plus tailings and in tailings may have created a toxicity effect that limited the growth of plants in these two soil materials. Alfalfa was superior on all soil materials. Sesbania and blue lupine grew equally well. All three species were able to adapt to the different soil materials. For revegetation on copper mine wastes, it is desirable to plant a variety of plant species rather than a single species, to help blend the disturbed areas into the surrounding environmentApproved for publication as Arizona Agricultural Experiment Station Research Contribution No. 3100.     

Spatial heterogeneity influences native and nonnative plant species richness

Spatial heterogeneity may have differential effects on the distribution of native and nonnative plant species richness. We examined the effects of spatial heterogeneity on native and nonnative plant species richness distributions in the central part of Rocky Mountain National Park, Colorado, USA. Spatial heterogeneity around vegetation plots was characterized using landscape metrics, environmental/topographic variables (slope, aspect, elevation, and distance from stream or river), and soil variables (nitrogen, clay, and sand). The landscape metrics represented five components of landscape heterogeneity and were measured at four spatial extents (within varying radii of 120, 240, 480, and 960 m) using the FRAGSTATS landscape pattern analysis program. Akaike's Information Criterion adjusted for small sample size (AICc) was used to select the best models from a set of multiple linear regression models developed for native and nonnative plant species richness at four spatial extents and three levels of ecological hierarchy (i.e., landscape, land cover, and community). Both native and nonnative plant species richness were positively correlated with edge density, Simpson's diversity index and interspersion/juxtaposition index, and were negatively correlated with mean patch size. The amount of variation explained at four spatial extents and three hierarchical levels ranged from 30% to 70%. At the landscape level, the best models explained 43% of the variation in native plant species richness and 70% of the variation in nonnative plant species richness (240-m extent). In general, the amount of variation explained was always higher for nonnative plant species richness, and the inclusion of landscape metrics always significantly improved the models. The best models explained 66% of the variation in nonnative plant species richness for both the conifer land cover type and lodgepole pine community. The relative influence of the components of spatial heterogeneity differed for native and nonnative plant species richness and varied with the spatial extent of analysis and levels of ecological hierarchy. The study offers an approach to quantify spatial heterogeneity to improve models of plant biodiversity. The results demonstrate that ecologists must recognize the importance of spatial heterogeneity in managing native and nonnative plant species.     

Chemical profile of Festuca arundinacea extract showing allelochemical activity

The allelopathic potential of fescue (Festuca arundinacea Shreb.) was investigated under field and laboratory conditions. In the field, incorporation of fescue aboveground biomass into the soil provided an effective weed control as it significantly reduced both the number and the dry weight of all weed species. The effect on weeds was species specific. The reduction of the most abundant species, Picris echioides, with respect to the number of individuals and their dry weight was 67 and 45%. Fescue aboveground biomass, harvested immediately before soil incorporation, was utilized in a bioassay-oriented fractionation, aimed at identifying the compounds in the toxic extracts of the plant. While phytotoxic activity was detected for the n-butanol fraction, no activity was found for the aqueous one. Germination of an indicator species, lettuce (Lactuca sativa L.), was reduced by 33% at the higher extract concentration of 20 mg/mL, owing to the increase of the number of abnormal seedlings. The LC/MS profile of the extract revealed the presence of two alkaloids, seven flavonol glycosides, and two flavonol aglyca. Quercetin 3-O-rutinoside, isorhamnetin 3-O-rutinoside, and kaempferol 3-O-rutinoside were reported in fescue for the first time.     

Ontogeny of space use and diet of two temperate damselfish species, <Emphasis Type="Italic">Parma microlepis</Emphasis> and <Emphasis Type="Italic">Parma unifasciata</Emphasis>

Studies of reef fish herbivory have mainly focused on the impacts and behaviour of adults of tropical species. In this study, the ontogenetic shifts in home range, aggression, feeding rate, diet and gut morphology in juveniles and adults of two temperate territorial damselfishes, Parma microlepis and Parma unifasciata, were determined. Both P. microlepis and P. unifasciata juveniles under 80 mm TL exhibited no aggressive chases towards conspecifics or other species, while above 80 mm TL aggressive chase frequency increased in conjunction with an increase in home range, defended as a territory. Ontogenetic diet shifts, characterised by an increase in herbivory (P. unifasciata: juveniles: 64% plant material, adults: 95% plant material; P. microlepis: juveniles: 43% plant material, adults: 67% plant material) were observed for both species. The ratio of digestive tract length to body length, which often accompanies a switch to herbivory, increased significantly with ontogeny for both species. Compared to tropical confamilial grazers, these temperate damselfish species feeding rates were lower, and they had larger territories which were not as strongly defended (fewer aggressive chases).     

Association between plant species diversity and edaphic factors in the lower reaches of the Heihe River,northwestern China

The lower reaches of the Heihe River, in northwestern China, is characterised by unique local edaphic conditions that have influenced the development of local desert riparian forests. This study examines the variations in spatial variation patterns to reveal the relationships between plant species diversity and soil moisture/salinity/texture gradients at different soil depths, providing insights into the management and restoration of vegetation in ecosystems in the study area. The species–environmental relationships are investigated by redundancy analysis based on the plant species diversity matrix and the edaphic gradient matrix. A survey of 61 sampling plots identified 37 plant species in the study area. The distribution pattern of the plant species diversity are mainly affected by soil moisture, soil salinity, and soil texture at different soil depths. These edaphic factors are able to explain 98.47% of the total variation in the analysed vegetation dataset. Soil moisture, salinity, and texture content vary in terms of both the soil depths and the vegetation types in the study area. The plant community Class IV, xeric shrub, has the lowest soil water content among different vegetation types. The surface soil salinity differs for different plants and follows the order: Sophora alopecurides?>?Tamarix chinensis?>?Populus euphratica.