Removal,Handling, and Thermal Desorption Treatment Techniques for Manufactured Gas Plant Wastes

Due to the nature of contamination typically found at former MGP (manufactured gas plant) sites, excavation and thermal desorption of MGP wastes has proven to be an effective method for the remediation of MGP‐contaminated soil. The use of on‐site thermal desorption enables MGP sites to be quickly remediated at a low cost. Tar pits, holders, and other underground storage structures typically contain coal tar residuals and waste from former operations, and the areas around these structures are often significantly contaminated. Thus, excavation techniques, odor and vapor management, and material preparation for the treatment method are important factors to consider when developing a site remediation strategy. This article reviews typical excavation and handling methods associated with the remediation of former MGP sites and discusses the treatment of MGP wastes using on‐site thermal desorption technology. © 2001 John Wiley & Sons, Inc.     

In Situ solidification—A case study at a former manufactured gas plant in Macon,Georgia

In situ solidification (ISS) is a reliable, EPA‐recognized technology for the treatment of industrial and waste sites. ISS was employed at a former manufactured gas plant (MGP) site in Macon, Georgia, for the treatment of approximately 33,000 cubic yards of coal tar residues in the saturated zone soil. The site is regulated by the Georgia Environmental Protection Division (EPD) under the Hazardous Site Rehabilitation Act (HSRA) and is located approximately four blocks from downtown Macon. This article will review the technical and regulatory basis for the successful use of this technology, provide an overview of the treatability and pilot testing used to develop the design and implementation of the treatment process, and present the results of the application of ISS to an MGP site. The results of groundwater monitoring, pre and postremediation, will also be discussed. © 2004 Wiley Periodicals, Inc.     

Groundwater Impacts on Surface Water and Sediment—Gowanus Canal,Brooklyn, New York

The Gowanus Canal Superfund Site in Brooklyn, New York, is an approximately 1.5‐mile (1.61‐km) long estuary that was historically converted into a canal for industrial and commercial purposes. Three manufactured gas plants (MGPs) were formerly located on the Gowanus Canal and discharged waste into it. Surface sediments remain highly contaminated with polycyclic aromatic hydrocarbons (PAHs) long after the MGPs were razed. A hydrogeologic assessment indicates that groundwater passes through the deeper coal tar–contaminated sediment prior to discharging to the canal. This study was undertaken to investigate if groundwater passing through coal tar–contaminated sediment could be responsible for the ongoing contamination of both surface sediments and surface water in the canal. PAH compound distributions in surface water samples collected from the tidal canal at low tide were compared with PAH compounds found in adjacent groundwater‐monitoring wells, point sources (combined sewer overflows [CSOs]), and surface sediments. The results indicate a strong correlation between PAH contaminant distributions in groundwater, sediment, and surface water, indicating that contaminated groundwater passing through the deeper coal tar–contaminated sediments is the primary mechanism contributing to the contamination of both surface sediment and surface water in the canal. Therefore, any sediment remediation efforts in the Gowanus Canal that fail to evaluate and control the upward transport processes have a high chance of failure due to recontamination from below.  ©2016 Wiley Periodicals, Inc.     

Application of source removal and natural attenuation remediation strategies at MGP sites in Wisconsin

This article presents site closure strategies of source material removal and dissolved‐phase groundwater natural attenuation that were applied at two manufactured gas plant (MGP) sites in Wisconsin. The source removal actions were implemented in 1999 and 2000 with groundwater monitoring activities preceding and following those actions. Both of these sites have unique geological and hydrogeological conditions. The article briefly presents site background information and source removal activities at both of these sites and focuses on groundwater analytical testing data that demonstrate remediation of dissolved‐phase MGP‐related groundwater impacts by natural attenuation. A statistical evaluation of the data supports a stable or declining MGP parameter concentration trend at each of the sites. A comparison of the site natural attenuation evaluation is made to compare with the requirements for site closure under the Wisconsin Department of Natural Resources regulations and guidance. © 2003 Wiley Periodicals, Inc.     

Low waste feed concentrations and destruction removal efficiency

In the early 1980s, the Environmental Protection Agency (EPA) funded research on destruction and removal efficiencies (DREs) at eight hazardous waste incinerators. This research appeared to show that DREs of 99.99% could not be achieved at low waste feed principal hazardous organic constituent (POHC) concentrations. During the mid 1980s and 1990s however, testing at Superfund sites has indicated that DREs of 99.9999% or greater can be achieved at low waste feed POHC concentrations. This paper will summarize testing which includes 32 test runs at five Superfund sites and the EPA's incineration research facility. The tests include POHC concentrations from 6552 parts per million down to 28 parts per million at typical DREs of 6–9 s or greater.     

改性活性焦及其脱硫性能的研究

以褐煤为主要原料,以煤焦油为粘结剂,加入一定量的金属氧化物制成的改性活性焦,具有良好的吸附能力和机械性能,脱硫效率高并易于再生,为烟气脱硫提供了一种新的吸附剂。     

National monument locations and remediation of World War II battle sites

In December 2008, George W. Bush established the World War II Valor in the Pacific National Monument, including eight locations connected with World War II fighting. The executive proclamation designating the monument briefly described the individual sites, mentioning remaining battlefield debris. World War II battle locations in Hawaii and Alaska are currently designated for remediation under different programs of the U.S. Environmental Protection Agency or Department of Defense (DOD). The Pearl Harbor Naval Complex is a “Superfund” National Priority List site. Former military locations in the Aleutian Islands, involved in Japanese occupation and the U.S. offensive to regain control, are included in DOD's Formerly Used Defense Sites (FUDS) remediation program. These monument sites, the regulatory frameworks of the applicable programs, and the current cleanup status are described. © 2009 Wiley Periodicals, Inc.     

Treatment of tar pond sludge in a circulating fluidized bed combustor

A series of tests to burn mixtures of tar pond sludge and coal was carried out using a mini‐circulating fluidized bed combustor (mini‐CFBC). During the tests, carbon dioxide, oxygen, carbon monoxide, sulfur dioxide, and nitrogen oxides in the flue gas were monitored continuously. Stack gas sampling was carried out for hydrochloric acid, metals, particulate matter, volatile organic compounds (VOCs), total hydrocarbons, semivolatile organic compounds (SVOCs), dioxins and furans (PCDD/Fs), and polychlorinated biphenyls (PCBs). Results showed that hydrochloric acid, mercury, particulate matter, PCDD/F, and metal concentrations were all below both the current limits and the gas‐release limits to be implemented in 2008 in Canada. The new 2008 emissions limits will reduce the maximum allowable concentrations of most pollutants by half. Thus, the maximum concentration for particulate matter will be 5 mg/m³ (from the current maximum concentration of 10 mg/m³);the maximum concentration for hydrochloric acid will be 5 mg/m³ (from 10 mg/m³); and the‐maximum concentration for dioxins and furans will be 0.032 ng/m toxic equivalent (from 0.08 ng/mcurrently). Sulfur capture efficiency was 89–91 percent. The percentage of fuel nitrogen converted to nitrogen oxides was of the order of 4.7 to 6.1, which is significantly lower than that of conventional pulverized coal‐fired boilers and well within the normal range for fluidized bed combustors (FBCs). PCB and polycyclic aromatic hydrocarbon (PAH) emissions levels were comparable or lower than levels reported in the literature for industrial‐scale FBCs. VOC concentrations were low except for benzene, for which the concentration was higher than that reported for pulverized coal‐fired utility boilers. In addition, carbon monoxide concentration was high at 1,200 to 2,200 parts per million. However, these carbon monoxide concentrations are typical of the mini‐CFBC firing coal. The trials showed that for 10 percent by weight tar pond sludge mixed with 90 percent by weight coal, the combustion was both stable and efficient. The tests demonstrated that CFBC technology is an environmentally sound option for eliminating tar pond waste sludge. © 2005 Wiley Periodicals, Inc.     

Superfund cleanup: Designing containment remedies for recreational reuse

In July, 1999, EPA announced its Superfund Redevelopment Initiative, the Agency's effort to help communities bring Superfund sites back into productive use in a manner that is protective of human health and the environment. As part of the Superfund Redevelopment Initiative, the Agency is developing reuse design guides that provide technical information related to the design of remedies that safely support reuse. The design guides focus on the reuse of containment sites, and address such topics as settlement, gas control, irrigation, drainage, and operation and maintenance. Case studies of redeveloped sites are also presented in the guides. EPA is currently developing design guides that address the reuse of Superfund sites for commercial purposes, wildlife areas, parking lots, recreational sports fields, and golf courses. This article provides information on the first guide in the series‐the reuse of Superfund sites for recreational purposes.     

Defining a successful superfund clean-up: A community representative's perspective

The successful use of the Superfund program involves developing partnerships with all of the stakeholders early in the process. Citizens living near Superfund sites are the primary stakeholders, falling victim to many health risks and economic costs. When equipped with technical advisors, citizens can play a primary role in the remediation decisions being made at hazardous waste sites. This article illustrates the important role and impact of concerned citizens living near the Niagara Mohawk Power Corporation Superfund site in Saratoga Springs, New York. The Superfund program was used successfully at this site in a number of ways, mainly in that it provided technical advisors through a technical assistance grant (TAG) for the citizens, which resulted in a thorough and conclusive remedial investigation.     

SITE Demonstration of Enhanced In-Situ Bioremediation of Chlorinated and Nonchlorinated Organic Compounds in Fractured Bedrock

A field demonstration of an enhanced in-situ bioremediation technology was conducted between March 1998 and August 1999 at the ITT Industries Night Vision (ITTNV) Division plant in Roanoke, Virginia. The bioremediation process was evaluated for its effectiveness in treating both chlorinated and nonchlorinated volatile organic compounds (VOCs) in groundwater located in fractured bedrock. Chlorinated compounds, such as trichloroethene (TCE), in fractured bedrock pose a challenging remediation problem. Not only are chlorinated compounds resistant to normal biological degradation, but the fractured bedrock presents difficulties to traditional techniques used for recovery of contaminants and for delivery of amendments or reagents for in-situ remediation. The demonstration was conducted under the U.S. Environmental Protection Agency's Superfund Innovative Technology Evaluation (SITE) program. The SITE program was established to promote the development, demonstration, and use of innovative treatment technologies for the cleanup of Superfund and other hazardous waste sites. This article presents selected results of the demonstration and focuses on understanding the data in light of the fractured bedrock formation. © 2002 Wiley Periodicals, Inc.     

Soil washing for volume reduction of radioactively contaminated soils

The Office of Radiation and Indoor Air of the U.S. Environmental Protection Agency has demonstrated a soil washing plant for the treatment of radioactively contaminated soils from two Superfund sites in New Jersey. The plant employs unit operations that are widely used in the processing of minerals and coal. These operations were examined and tested to determine how they would apply to volume reduction of these contaminated soils. In this context, they are considered to be innovative candidates for remediation of other sites with large volumes of soil contaminated with low-level radioactivity. Laboratory testing of soil characteristics and behavior in unit processes is used to assess the applicability of volume reduction/chemical extraction (VORCE) technology to specific sites.     

In‐Canal Stabilization/Solidification of NAPL‐Impacted Sediments

In situ solidification (ISS) has been used with increasing frequency as a remedial technology for source area treatment at upland sites impacted with a variety of organic contaminants, including coal tar, creosote, and other nonaqueous phase liquids (NAPLs). With several large, complex, urban water ways and rivers impacted with NAPLs, ISS is more recently being considered as a technology of choice to help reduce remedial costs, minimize short‐ and long‐term impacts of mobile NAPL, and lower the carbon footprint. This article presents the results of a successful pilot study of ISS at the Gowanus Canal Superfund site in Brooklyn, New York. This represents the first major sediment ISS field demonstration project in a saline environment and the first project to evaluate large‐scale implementation of ISS from a barge and through overlaying sediment. ©2016 Wiley Periodicals, Inc.     

Superfund site remediation by landfilling—overview of landfill design,operation, closure,and postclosure issues

This article discusses the appropriateness of using landfills as part of remediating hazardous chemical and Superfund sites, with particular emphasis on providing for true long‐term public health and environmental protection from the wastes and contaminated soils that are placed in the landfills. On‐site landfilling or capping of existing wastes is typically the least expensive approach for gaining some remediation of existing hazardous chemical/Superfund sites. The issues of the deficiencies in US EPA and state landfilling approaches discussed herein are also applicable to the landfilling of municipal and industrial solid “nonhazardous” wastes. These deficiencies were presented in part as “Problems with Landfills for Superfund Site Remediation” at the US EPA National Superfund Technical Assistance Grant Workshop held in Albuquerque, New Mexico, in February 2003. They are based on the author's experience in investigating the properties of landfill liners and the characteristics of today's landfills, relative to their ability to prevent groundwater pollution and to cause other environmental impacts. Discussed are issues related to both solid and hazardous waste landfills and approaches for improving the ability of landfills to contain wastes and monitor for leachate escape from the landfill for as long as the wastes in the landfill will be a threat. © 2004 Wiley Periodicals, Inc.     

Application of In-Situ Vitrification at the Parsons Chemical Site

This article presents the results of demonstration of Geosafe Corporation's in-situ vitrification (ISV) technology at the Parsons Chemical/ETM Enterprises Superfund site in Grand Ledge, Michigan. The primary focus of this article is on the EPA's Superfund Innovative Technology Evaluation (SITE) Program assessment of the sixth melt. A total of eight melts were performed during this project. This demonstration was part of the SITE Program Demonstration (USEPA, 1994), which helped develop innovative hazardous waste treatment technologies, especially those offering permanent remedies for contaminated Superfund and other hazardous waste sites. The demonstration results are not only applicable to this particular project, but are also indicative of other Geosafe project experiences and demonstrate the current state of the ISV technology. The demonstration included two phases. In the first phase, the ISV technology was used to treat the Parsons contaminated soil. In the second phase, post-testing and analysis were conducted about one year after the ISV technology was applied to confirm that the vitrification was completed and that no contamination migration had occurred.     

The active role of state laws in superfund cleanups

The Comprehensive Environmental Response, Compensation, and Liability Act (CERCLA or Superfund) did not ignore the fifty individual states when establishing responsibility, authority, and liability for cleaning up hazardous waste sites. Although CERCLA gives EPA the ultimate authority to select a remedy for a contaminated site, the law was drafted not only to allow for state activity without EPA, but also for significant state input when EPA is involved. The relationship between a state (and its environmental laws) and EPA can help decide the remedial and financial interests of any potentially responsible party (PRP). This article discusses the relevant CERCLA provisions, recent court decisions, and resolved and unresolved issues in federal-state Superfund involvement, and recommends several common-sense strategies for PRPs when working with a state in a Superfund cleanup.     

Understanding the RCRA corrective action process

The Resource Conservation and Recovery Act (RCRA) was enacted in 1976. The Hazardous and Solid Waste Amendments (HSWA) of 1984 specify “corrective action” requirements for protecting human health and the environment from environmental contamination at active hazardous waste treatment, storage, and disposal facilities. RCRA and its corrective action requirements are designed to prevent the creation of new Superfund sites by regulating and remediating active facilities. The RCRA corrective action process has four basic components: the facility assessment, facility investigation, corrective measures study, and corrective measures implementation. This article presents an overview of the RCRA corrective action process and presents four case studies from three U.S. EPA regions.     

Study on chlorine removal from mixture of waste plastics

The recycling of waste plastics that include plastics that contain chlorine, such as polyvinyl chloride, is difficult because the chlorine leads to the corrosion of equipment. Then, the dechlorination method of waste plastics containing chlorine (CCWP) that consists of a series of melt process and hot water process was examined. CCWP was put into the melt process with coal tar (HOB) and converter dust (CD) to inhibit the diffusion of the chlorine-containing gas. The results indicated that iron oxide of the principal element of CD combines with chlorine eliminated from CCWP, and forms water-soluble iron chloride on the melt process. HOB dissolves or adsorbs a part of the chlorine during the melt process, and inhibits the diffusion of the chlorine-containing gas. Approximately 98% of the chlorine in the CCWP reacts with CD and forms iron chloride, which can be extracted on the hot water process.     

On-site remediation of PCB contamination using transportable incineration systems

Many Superfund or hazardous waste sites prove to be excellent candidates for remediation using transportable incineration. Transportable incineration has been selected as the alternative of choice to remediate numerous sites throughout the United States. There are a number of firms that provide mobile and transportable incineration equipment and services. A variety of treatment systems are available, including rotary kilns, fluidized beds, and infrared incinerators. Roy F. Weston, Inc., has been instrumental in the development, design, permitting, construction, performance testing, and operation of hazardous and toxic waste thermal treatment systems. Weston owns and operates two high-temperature transportable incineration systems (TISs). The first system is Weston's seven-ton-per-hour (tph) TIS-5. The second is the TIS-20, with a design capacity of up to 30 tph. These units are typical rotary kiln incinerators, the most flexible, adaptable type of incineration unit. This article discusses Weston's use of these incinerators to remediate soils at sites contaminated with polychlorinated biphenyls (PCBs).     

SITE Program Success: Cost Savings to Government and Increased Revenue for Technology Vendors

The Superfund Innovative Technology Evaluation (SITE) program is a program mandated by Congress through the 1986 Superfund Amendments and Reauthorization Act (SARA). The original Superfund allowed no provisions for research and development of needed remediation technologies. Problems arose when the demand for involved, complex treatment could not be met by the traditional contain, haul, and dispose process that hazardous waste handlers had become familiar with. In response to the increasing complexity of hazardous waste site remediation, SARA called for an “Alternative or Innovative Treatment Technology Research and Demonstration Program.” As a result, EPA's Office of Solid Waste and Emergency Response and the Office of Research and Development established the SITE program. This article is a historical analysis of the unique cost savings of the SITE program.