2,5-二甲基呋喃-空气燃烧过程研究

利用球形发展火焰研究了常温常压下不同当量比,不同相态时2,5-二甲基呋喃-空气的层流燃烧速度和马克斯坦长度,分析了火焰拉伸对火焰传播速度的影响。研究结果表明:随着当量比的增加,2,5-二甲基呋喃-空气混合气的马克斯坦长度减少,火焰的稳定性减弱。并且分别计算出当量比为1.25和1.5的层流燃烧速度,分别为:1.189m/s,1.135m/s.。对于同一当量比1.5的情况下,不同相态的2,5-二甲基呋喃-空气混合物,在相同时刻的气液两相混合物的火焰半径已经拉伸火焰传播速度远远大于纯气相的混合物。     

Combined effects of initial pressure and turbulence on explosions of hydrogen-enriched methane/air mixtures

Hydrogen-enrichment has been proposed as a useful method to overcome drawbacks (local flame extinction, combustion instabilities, lower power output, etc.) associated to turbulent premixed combustion of natural gas in both stationary and mobile systems. For the safe use of hydrogen-enriched hydrocarbon fuels, explosion data are needed.In this work, a comparative experimental study of the explosion behavior of stoichiometric hydrogen-enriched methane/air (with 10% of hydrogen molar content in the fuel) and pure methane/air mixtures is presented. Tests were carried out in a 5 l closed cylindrical vessel at different initial pressures (1, 3 and 6 bar), and starting from both quiescent and turbulent conditions.Results allow quantifying the combined effects of hydrogen substitution to methane, pressure and turbulence on maximum pressure, maximum rate of pressure rise, burning velocity and Markstein lengths.     

初始温度和压力对排污空间甲烷-空气混合物爆燃特性影响的模拟研究

市政排污空间作为城市公共基础设施的重要组成部分，易积聚可燃气体形成爆炸性环境。结合排污空间的特殊环境条件，采用Fluidyn-MP多物理场数值模拟软件，建立了20 L球形爆炸罐分析模型，通过改变初始温度和初始压力，对排污空间甲烷-空气混合物爆燃特性及其变化规律进行模拟研究。结果表明:初始温度升高导致甲烷-空气混合物最大爆炸压力降低，缩短了到达最大爆炸压力的时间；初始压力增加导致最大爆炸压力急剧升高，并延长了到达最大爆炸压力的时间；最大爆炸压力对初始压力的敏感程度远大于初始温度的影响。此外，随着初始温度和初始压力的升高，爆炸火焰平均传播速度增加，而火焰传播速度对初始温度较敏感。     

调节风窗对瓦斯爆炸影响的数值分析*

为研究调节风窗的面积、位置对瓦斯爆炸传播特性的影响,通过FLACS软件构建不同面积和不同位置调节风窗的风门-巷道模型,对瓦斯在该模型中的爆炸及其传播进行数值模拟,并分析瓦斯爆炸压力、火焰传播速度。研究结果表明:风门前最大瓦斯爆炸压力值与调节风窗边长呈现指数减小关系,而风门后最大瓦斯爆炸压力值与调节风窗边长呈现指数增加关系;火焰传播速度与调节风窗边长呈现指数增加关系;相同面积情况下,调节风窗中心位置对瓦斯爆炸影响较小。     

非线性拉伸对甲烷-空气预混火焰燃烧特性的影响

使用定容燃烧弹与高速纹影照相系统研究了不同当量比下甲烷-空气预混气体的层流火焰燃烧特性。实验数据同时应用传统线性模型和非线性模型分析了不同当量比对球形扩展火焰的传播速率和马克斯坦长度的影响。结果显示:随着当量比的增加,层流燃烧速率先增大后减小,直到当量比为1.1时,火焰速率达到最大值。马克斯坦长度始终为正值,且随着当量比的增大而增大。在所有当量比条件下,线性和非线性方法计算的火焰速率大致相同,差值小于0.01 m/s;线性方法得到的马克斯坦长度均大于非线性模型计算的结果,并随着当量比的增大,两种方法得到的马克斯坦长度的差值更加显著。     

Experimental study on CO2/CF3I suppression of methane-air explosion and flame propagation

To explore the inhibitory effects of CF₃I and CO₂ gas on the explosion pressure and flame propagation characteristics of 9.5% methane, a spherical 20 L experimental explosion device was used to study the effect of the gas explosion suppressants on the maximum explosion pressure, maximum explosion pressure rise rate and flame propagation speed of methane. The results indicated that with a gradual increase in the volume fraction of the gas explosion suppressant, the maximum explosion pressure of methane and maximum explosion pressure rise rate gradually decreased, and the time taken to reach the maximum explosion pressure and maximum explosion pressure rise rate was gradually delayed. At the same time, the flame propagation speed gradually decreased. Additionally, the time taken for the flame to reach the edge of the window and the time taken for a crack as well as a cellular structure to appear on the flame surface was gradually delayed. The fluid dynamics uncertainty was suppressed. The explosion pressure and flame propagation processes were markedly suppressed, but the flame buoyancy instability was gradually enhanced. By comparing the effects of the two gas explosion suppressants on the pressure and flame propagation characteristics, it was found that at the same volume fraction, trifluoroiodomethane was significantly better than carbon dioxide in suppressing the explosion of methane. By comparing the reduction rates of the characteristic methane explosion parameters at a volume fraction of 9.5%, it was observed that the inhibitory effect of 4% trifluoroiodomethane on the maximum explosion pressure was approximately 4.6 times that of the same amount of carbon dioxide, and the inhibitory effect of 4% trifluoroiodomethane on the maximum explosion pressure rise rate and flame propagation speed was approximately 2.7 times that of the same amount of carbon dioxide. The addition of 0.5%–1.5% trifluoromethane to 4% and 8% carbon dioxide can improve the explosion suppression efficiency of carbon dioxide. This enhancing phenomenon is a comprehensive manifestation of the oxygen-decreasing effect of carbon dioxide and the trifluoroiodomethane-related endothermic effect and reduction in key free radicals.     

密闭空间内天然气混合及爆炸传播规律研究

为研究密闭容器内甲烷-空气不均匀分布对混合气体燃烧的影响,将数值模拟和实验相结合,发现在重力作用下混合气体浓度分布不均匀,长径比越大的容器,混合气体浓度分布梯度越大。混合气体浓度分布影响气体火焰传播规律。宏观浓度为5%的甲烷与空气混合后,容器上部甲烷浓度高于5%,在该处点火时非均匀混合甲烷-空气火焰传播较快,非均匀混合气体的爆炸压力比均匀混合气体压力上升快,且分层混合气体的超压峰值高于均匀混合气体的值。由于浓度分布不均匀,点火位置影响甲烷/空气火焰传播的规律。     

长径比对管道油气爆炸特性与火焰传播规律影响研究*

为了探究长径比对油气爆炸传播特性与火焰传播规律的影响，为复杂管道受限空间油气爆炸防控提供理论参考，结合油气爆炸与爆炸抑制工程实际需要，构建不同长径比管道油气爆炸模拟实验系统,在此基础上开展不同初始浓度的预混油气-空气混合气爆炸实验。研究结果表明:管道内部的预混油气爆炸超压信号呈先上升后下降的趋势，由于耗散以及憋压效应导致超压下降平稳后仍大于初始压力；同时长径比增加会导致达到最大爆炸超压的油气浓度增加，油气爆炸超压峰值随着长径比的增加呈现上升→下降→上升的规律，小长径比管道的油气爆炸超压峰值高于大长径比管道，但同为小长径比管道或大长径比管道工况的实验结果对比显示爆炸超压峰值随着长径比增加而提升；而超压上升速率则会随着长径比的增加而上升；长径比的增加同时也会促进火焰的加速传播并减小火焰持续时间。     

可燃气体爆炸破坏效应的试验研究

借助高速摄像机及ProAnalyst软件,研究可燃气体体积分数和障碍物对可燃气体爆炸破坏力的影响。测定不同体积分数下的甲烷-空气预混气体爆炸冲击波超压,和爆炸火焰波在有无乒乓球方向传播的平均速度。试验结果表明:超压和平均速度均随着甲烷体积分数的增加呈现先增大后减小的变化趋势,其最大值均出现在甲烷体积分数为10%～11%之间;同一体积分数下的甲烷-空气预混气体爆炸火焰波在有乒乓球方向传播的平均速度比没有乒乓球方向传播的平均速度大。根据试验结果,推导出可燃气体爆炸冲击波超压和爆炸火焰波传播平均速度与可燃气体体积分数之间的函数关系,并得出障碍物对爆炸火焰波传播的加速作用随着体积分数的增加呈现先加强后减弱的变化趋势。     

Effects of nitrogen and carbon dioxide on hydrogen explosion behaviors near suppression limit

By varying inert gas content, equivalence ratio and initial pressure, this study is aimed at investigating flame propagation behaviors and explosion pressure characteristics near suppression limit. For carbon dioxide, the weakest flame floating phenomenon is observed at Φ = 1.5 and the buoyant instability is enhanced when the equivalent ratio deviates to the rich and lean sides. For nitrogen, the buoyant instability decreases with increasing equivalent ratio. Both maximum explosion pressure and maximum pressure rise rate increase firstly and then decrease with the increase of equivalence ratio, and they decrease significantly with increasing content of carbon dioxide and nitrogen. For carbon dioxide, the critical suppression ratio of Φ = 0.6, 0.8, 1.0, 1.5 and 2.0 is 7.50, 7.18, 5.74, 3.83, and 2.87. For nitrogen, the critical suppression ratio of Φ = 0.6, 0.8, 1.0, 1.5 and 2.0 is 15.83, 11.87, 9.50, 6.33 and 4.75. Compared to nitrogen, the carbon dioxide is more effective on suppressing hydrogen explosion pressure. The adiabatic flame temperature, thermal diffusivity and mole fraction of active radicals continue to decrease with increasing content of carbon dioxide and nitrogen, which contributes to the decrease of laminar burning velocity.     

Experimental study on the synergistic inhibition effect of nitrogen and ultrafine water mist on gas explosion in a vented duct

In this study, in order to research the synergistic inhibition effect of nitrogen and ultrafine water mist on gas explosion in a vented duct, a semi-confined transparent chamber was designed with the size of 120 × 120 × 840 mm, and the experiments were carried out with stoichiometric methane/air premixed mixture (fraction of methane: 9.5%), adding different fractions of nitrogen and ultrafine water mist. The experimental results showed the following: The combination of nitrogen and ultrafine water mist had a synergistic inhibiting effect on methane/air explosion, which was preferable to the single use of any kind. With the increase of spraying time of water mist and fraction of nitrogen, the initial shape of the explosion flame became snakelike, and at the same time the peak flame propagation speed and peak overpressure decreased significantly. When the nitrogen fraction was increased to 10% and the mist spraying time was increased to 2min, synergistic inhibiting effect on overpressure was high efficient. However, with the increase of spraying time of water mist and fraction of nitrogen going on, the amount of increase of explosion inhibition efficiency was gradually reduced.     

甲烷/空气混合气燃爆特性的实验研究

对不同初始压力和温度条件下的甲烷/空气混合气的爆炸极限进行实验研究,利用最大-最小准则来确定爆炸极限.分析了温度和压力对甲烷/空气混合气燃爆特性的影响.采用氮气作为惰性气体,对其防爆抑爆效果进行了实验研究.     

甲烷爆炸传播过程膜状障碍物的激励效应研究

针对管状空间内膜状障碍物对甲烷爆炸传播的激励效应现象,基于机理分析进行了数值模拟和实验研究,计算分析薄膜附近爆炸冲击波压力峰值大小与火焰速度变化,同时运用激波管道进行相同工况条件下的实验,并对两者结果对比分析,发现有无膜状障碍物的压力峰值相差6倍以上。研究表明,膜状障碍物的激励效应是破膜以后形成的带压燃烧,提高了燃烧速率,导致甲烷爆炸的火焰传播速度剧增。实验结果一定意义诠释了同样数量的甲烷气体爆炸在不同环境内后果上的巨大差异,研究结果对矿井瓦斯爆炸事故调查及防治具有指导意义。     

Effects of hydrogen addition on the confined and vented explosion behavior of methane in air

Multi-component gas mixture explosion accidents occur and recur frequently, while the safety issues of multi-component gas mixture explosion for hydrogen–methane mixtures have rarely been addressed.Numerical simulation study on the confined and vented explosion characteristics of methane-hydrogen mixture in stoichiometric air was conducted both in the 5 L vessel and the 64 m³ chamber, involving different mixture compositions and initial pressures. Based on the results and analysis, it is shown that the addition of hydrogen has a negative effect on the explosion pressure of methane-hydrogen mixture at adiabatic condition. While in the vented explosion, the addition of the hydrogen has a significant positive effect on the explosion hazard degree. Additionally, the addition of hydrogen can induce a faster reactivity and enhance the sensitivity of the mixture by reducing the explosion time and increasing the rate of pressure rise both in confined and vented explosion. Both the maximum pressure and the maximum rate of pressure rise increase with initial pressure as a linear function, and also rise with the increase of hydrogen content in fuel. The increase in the maximum rate of pressure rise is slight when hydrogen ratio is lower than 0.5, however, it become significant when hydrogen ratio is higher than 0.5. The maximum rate of pressure rise for stoichiometric hydrogen-air is about 10 times the one of stoichiometric methane-air.Furthermore, the vent plays an important role to relief pressure, causing the decrease in explosion pressure and rate of pressure rise, while it can greatly enhance the flame speed, which will extend the hazard range and induce secondary fire damages. Additionally it appears that the addition of hydrogen has a significant increasing effect on the flame speed. The propagation of flame speed in confined explosion can be divided into two stages, increase stage and decrease stage, higher hydrogen content, higher slope. But in the vented explosion, the flame speed keeps increasing with the distance from the ignition point.     

多分支管道油气爆炸特性大涡模拟

为了研究油库常见的分支结构空间内发生油气爆炸时火焰和压力的传播特性,建立了基于WALE湍流模型及Zimont预混火焰模型的油气爆炸模型;模拟了6种不同分支管道结构空间内汽油/空气混合物爆炸发生发展过程;研究了分支管道数量及相对设置位置对爆炸超压的影响规律,以及分支管道对火焰传播形态和速度的影响规律;模拟结果与前人相关实验规律进行对比。研究结果表明:分支管道对汽油/空气混合气预混爆炸具有明显的强化激励作用;火焰锋面传播经过分支管道时,经历规则—褶皱—规则的变化过程;主管道内火焰传播速度,在分支管道对流场的突扩作用和湍流作用的共同影响下呈震荡变化的规律。     

长管中立体障碍物对瓦斯爆炸特性影响的研究

管道内可燃气体火焰传播与障碍物相互作用的过程的研究对爆炸场所预估和防爆工程设计具有重要的意义,在实际生产、生活中,火焰传播方向上的障碍物往往具有立体结构,基本没有平面结构,因此,利用长管密闭容器,在立体障碍物存在的条件下,研究了瓦斯爆炸压力和火焰传播速度。研究结果表明:随着障碍物数量的增加,瓦斯爆炸压力和火焰传播速度随之增大;阻塞率增加,瓦斯爆炸压力和火焰传播速度出现先增大后减小的现象,当阻塞率为50%时,其爆炸压力和火焰传播速度达到最大;障碍物的摆放形式对瓦斯爆炸压力和火焰传播速度也有一定的影响。     

管道燃气爆炸特性实验研究

管道是化工及油气储运系统的重要组成部分,却时常受燃烧爆炸事故的威胁,因此对管道中燃气燃烧爆炸特性与规律的研究就十分必要。以甲烷作为研究对象,采用压力传感器以及火焰传感器等对水平封闭管道内甲烷-空气预混燃烧爆炸进行了实验研究,通过大量实验来研究可燃气体爆炸压力与火焰及其传播变化规律。根据实验结果将超压以及气体燃烧的变化情况,对前驱冲击波与火焰面的相对时间及相对位置关系进行了分析。结果显示,管道中会产生前驱压力波,并超前火焰阵面甲烷气体在管道传播过程中,出现冲击波反压射、波叠加及反冲现象,压力的持续时间较火焰光信号持续时间长。所做的工作为油气受限空间中燃气燃烧爆炸特性与规律的进一步研究及工业防爆抑爆技术及工艺的实施、系统设计以及关键参数计算提供了理论依据。     

Effects of premixed methane concentration on distribution of flame region and hazard effects in a tube and a tunnel gas explosion

Study of flame distribution laws and the hazard effects in a tunnel gas explosion accident is of great importance for safety issue. However, it has not yet been fully explored. The object of present work is mainly to study the effects of premixed gas concentration on the distribution law of the flame region and the hazard effects involving methane-air explosion in a tube and a tunnel based on experimental and numerical results. The experiments were conducted in a tube with one end closed and the other open. The tube was partially filled with premixed methane-air mixture with six different premixed methane concentrations. Major simulation works were performed in a full-scale tunnel with a length of 1000 m. The first 56 m of the tunnel were occupied by methane–air mixture. Results show that the flame region is always longer than the original gas region in any case. Concentration has significant effects on the flame region distribution and the explosion behaviors. In the tube, peak overpressures and maximum rates of overpressure rise (dp/dt)_max for mixtures with lower and higher concentrations are great lower than that for mixtures close to stoichiometric concentration. Due to the gas diffusion effect, not the stoichiometric mixture but the mixture with a slightly higher concentration of 11% gets the highest peak overpressure and the shock wave speed along the tube. In the full-scale tunnel, for fuel lean and stoichiometric mixture, the maximum peak combustion rates is achieved before arriving at the boundary of the original methane accumulation region, while for fuel rich mixture, the maximum value appears beyond the region. It is also found that the flame region for the case of stoichiometric mixture is the shortest as 72 m since the higher explosion intensity shortens the gas diffusion time. The case for concentration of 13% can reach up to a longest value of 128 m for longer diffusion time and the abundant fuel. The “serious injury and death” zone caused by shock wave may reach up to 3–8 times of the length of the original methane occupied region, which is the widest damage region.     

惰性气体抑制瓦斯爆燃火焰传播特性实验研究*

为研究惰性气体抑制瓦斯爆燃火焰传播特性,在自行搭建的中尺度爆炸激波管道上,采用数据采集系统、压电式传感器、火焰传感器、同步控制系统和激光纹影测试系统,通过对比4种不同喷射压力（0.5,1.5,2.5,3.5 MPa）的实验工况,选用N2做为惰性介质时抑制火焰的传播特性与喷射压力密切相关,火焰传播速度随着喷射压力增加呈现先增加后减弱的趋势。研究结果表明:少量N2在管道中扩散,加剧了未反应预混气体的扰动状态,造成火焰阵面褶皱的卷吸能力增强,进而加速化学反应进程,促进预混气体燃烧;喷射压力为1.5 MPa时,火焰阵面拉升、变形最强,火焰传播速度提高,最高可达到250 m/s;喷射压力为3.5 MPa时,火焰阵面出现明显三维凹陷结构,运动发生明显滞后现象,火焰传播速度大幅度降低至5.4 m/s,惰性气体抑制火焰传播效果明显。     

Explosion behavior of hydrogen–methane/air mixtures

The effects of enriching natural gas with hydrogen on local flame extinction, combustion instabilities and power output have been widely studied for both stationary and mobile systems. On the contrary, the issues of explosion safety for hydrogen–methane mixtures are still under investigation.In this work, experimental tests were performed in a 5 L closed cylindrical vessel for explosions of hydrogen–methane mixtures in stoichiometric air. Different compositions of hydrogen–methane were tested (from pure methane to pure hydrogen) at varying initial pressures (1, 3 and 6 bar).Results have allowed the quantification of the combined effects of both mixture composition (i.e., hydrogen content in the fuel) and initial pressure on maximum pressure, maximum rate of pressure rise and burning velocity. The measured burning velocities were also correlated by means of a Le Chatelier’s Rule-like formula. Good predictions have been obtained (at any initial pressure), except for mixtures with hydrogen molar content in the fuel higher than 50%.