好氧硝化颗粒污泥膜生物反应器性能和膜污染研究

实验研究了好氧硝化颗粒污泥膜生物反应器AGMBR的处理性能,并将其与活性污泥膜生物反应器ASMBR进行对比,考察了颗粒污泥在减缓膜污染中所起的作用.好氧硝化颗粒污泥膜生物反应器AGMBR连续稳定运行102 d,系统具有良好的去除有机物和同时硝化反硝化能力,在进水COD和NH+4-N浓度分别为500和200 mg/L时,COD、NH+4-N和TN的去除率分别稳定在86%、94%和45%以上.颗粒污泥有效减缓了膜污染,延长了膜清洗的周期,AGMBR中的膜污染以膜孔堵塞为主,占总阻力的64.81%;滤饼层的阻力为2.1×1012m-1,远小于ASMBR中的16.07×10"m-1;膜清洗周期是相同条件下ASMBR的2.43倍以上;而且AGMBR内不断有新颗粒生成,维持了AGMBR系统性能和运行的稳定.     

颗粒化序列间歇式活性污泥反应器工艺处理化粪池污水

在序列间歇式活性污泥反应器(SBR)中成功培养出适应化粪池污水水质的好氧颗粒污泥.并将其应用于化粪池污水的处理.在好氧颗粒污泥培养的第15天左右,SBR中开始出现细小的颗粒,然后微生物在其上繁殖生长使颗粒逐渐增大而成熟;在第24天时,SBR中絮状活性污泥已基本实现了颗粒化.培养出的好氧颗粒污泥对化粪池污水有稳定的处理效果,在进水完全为化粪池污水时,COD、NH_4~+-N、TN的平均去除率分别为77%、61%、47%.但是,由于化粪池污水COD较低,因此无法维持较高的生物量,在后期的稳定运行过程中MLSS始终维持在2 500 mg/L左右.好氧颗粒污泥的同步硝化反硝化作用是其稳定脱氮的保证.     

好氧硝化颗粒污泥的培养及其性能

为考察不同接种污泥培养好氧硝化颗粒污泥的可行性,分别采用絮状活性污泥和厌氧颗粒污泥作为接种污泥,在气升内循环序批式反应器(SBAR)中进行好氧硝化颗粒污泥的培养,探讨不同性质的种泥对好氧硝化颗粒污泥的培养及其性能影响.结果表明,以絮状活性污泥、厌氧颗粒污泥为接种污泥均可培养出好氧硝化颗粒污泥,其颗粒成熟时间分别为62和80 d,SVI为25.52和27.68 mL/g,氨氮去除率为93.15％和75.43％,COD去除率在90％以上,SOUR、Zeta和EPS显著提高,微生物活性及疏水性能增强,以絮状活性污泥培养的好氧硝化颗粒污泥性能更优.     

连续流气提式反应器中有机物去除和氮转化的行为

以城市污水为处理对象,以絮状污泥为接种污泥,在连续流气提式好氧颗粒污泥流化床(CAFB)反应器中成功培养得到好氧颗粒污泥.探讨了CAFB中颗粒污泥的形成过程、生物多样性、有机物的去除行为及氮转化特性.研究结果表明,CAFB运行第7天颗粒污泥占主要优势,系统中依次出现原、后生动物,表明颗粒污泥趋于成熟.CAFB反应器中培养的好氧颗粒污泥具有良好的COD及NH4+-N去除能力.稳定运行阶段,当进水的COD容积负荷在1.5 ～3.5 kg COD/(m3·d)的范围时,COD的去除负荷稳定在1.0～2.0 kg COD/(m3·d).控制水力停留时间为(4 ±0.25)h、溶解氧质量浓度为(5 ±0.5) mg/L,可达到最高的硝化效率,但此控制条件下反硝化作用不明显.分析认为,作为完全混合式反应器的CAFB,需要较严格的控制溶解氧才能实现同步硝化反硝化作用.     

厌氧／缺氧SBR反硝化除磷效能的研究

采用厌氧 缺氧SBR反应器对以硝酸盐作为电子受体的反硝化除磷过程进行了研究。结果表明 ,反硝化聚磷菌完全可以在厌氧 缺氧交替运行条件下得到富集。稳定运行的厌氧 缺氧SBR反应器的反硝化除磷效率 >90 % ,出水磷浓度 <1mg L。进水COD浓度对反硝化除磷的效率影响很大 ,在COD浓度 <180mg L时 ,进水COD浓度越高 ,除磷效率也就越高。较高浓度的进水COD浓度将导致有剩余的COD进入缺氧段 ,对反硝化吸磷构成不利影响。污泥龄为 16d时 ,厌氧 缺氧SBR反应器取得稳定和理想的反硝化除磷效果。污泥龄减少到 8d ,由于反硝化聚磷菌的流失导致反硝化除磷效率的下降。当污泥龄恢复到 16d时 ,经过一段时间的运行 ,反硝化聚磷菌重新得到富集 ,除磷效率恢复到 90 %以上。     

螺旋升流式反应器脱氮除磷系统的运行效果与污泥性能分析

对螺旋升流式反应器脱氮除磷及去除COD的运行效果进行了研究 ,该系统连续稳定运行 6个月的结果表明 ,能保证出水平均质量浓度TN小于 1 0mg/L ,TP小于 0 5 0mg/L ,COD小于 31mg/L ,对TN、TP和COD的去除率分别达 86 %、96 %和 94 %以上。并且对SUFR系统的污泥性能进行了分析 :(1 )螺旋升流特征使本反应系统中的污泥易于颗粒化 ;(2 )SUFR系统中的微生物种群具有多样性 ;(3)污泥在好氧反应器中表现出了同步硝化反硝化功能 ;(4 )污泥在缺氧反应器表现出了反硝化吸磷现象     

碳源投加方式对SBR工艺脱氮速率的影响

为了提高生物反应器的脱氮效率,研究采用SBR处理模拟生活污水,利用醋酸钠作为碳源,考察碳源投加方式对脱氮速率的影响。结果表明,当温度为10~15℃,进水COD为330~550 mg/L时,采用不同的碳源投加方式,COD去除率均高于95%。进水一次投加2.4 g碳源,COD平均反应速率为5.3 mg/(g·h),平均反硝化速率为0.28 mg/(g·h)。进水、反应器运行3 h时分别投加1.2 g碳源,COD平均反应速率为6.89 mg/(g·h),平均反硝化速率为0.37 mg/(g·h)。进水、反应6 h时分别投加1.2 g碳源,COD平均反应速率为6.50 mg/(g·h),平均反硝化速率为0.52 mg/(g·h)。进水投加1.2 g碳源、反应器运行3 h和6 h时分别投加0.6 g醋酸钠碳源,COD平均反应速率为6.2 mg/(g·h),平均反硝化速率为0.39 mg/(g·h)。分次投加碳源能够提高COD反应速率和TN去除率,同时保持较高的硝化反硝化速率。     

一体化生物膜反应器处理生活污水试验研究

根据传统好氧硝化和缺氧反硝化生物脱氮的工艺原理，开发了一体化生物膜反应器，并对其进行了处理生活污水的试验研究。试验结果表明，在有机负荷提高的前提下，通过对进水方式和曝气速率的调节，反应器对COD和TN的去除率达到97％和82％；污泥活性测定表明，硝化反应和反硝化反应分别在反应器的好氧区和缺氧区占优势，但由于生物膜内部微环境的存在，反应器不同区域均有同时硝化和反硝化(SND)现象的发生。     

曝气生物流化床处理高氨氮粪便污水

应用好氧曝气生物流化床反应器处理动车集便器粪便污水,研究反应器同步硝化反硝化脱氮及去除COD效能,以及DO对处理效能的影响,通过镜检观察反应器内微生物特性,探究反应器同步硝化反硝化脱氮机理。结果表明,反应器维持DO在2.5 mg/L左右时,对粪便污水中氨氮、TN和COD的去除率分别达99.8%、84.1%和95.5%,在好氧曝气生物流化床反应器中,实现同步硝化反硝化脱氮并去除有机物。分析认为,反硝化脱氮主要发生在生物膜内的厌氧微环境,反硝化反应主要由厌氧反硝化菌完成,曝气生物流化床反应器同步硝化反硝化脱氮机理主要从微环境理论解释。     

好氧颗粒污泥的培养及处理味精废水

以厌氧颗粒污泥为接种污泥,在模拟废水条件下利用SBR 35 d成功培养出了具有同步硝化反硝化作用的好氧颗粒污泥,反应器对COD和NH4+-N去除率分别高于95%和99%。将该反应器用于处理味精废水,当COD、NH4+-N的容积负荷分别为2.4 kg/(m3.d)、0.24 kg/(m3.d)时,COD、NH4+-N和TN去除率分别高于90%、99%和85%。处理味精废水后的颗粒污泥粒径由之前的0.8～2.5 mm减小至0.6～1.8 mm,颗粒结构较之前更加密实。     

加速厌氧污泥颗粒化的研究进展

厌氧污泥颗粒化过程是一个多阶段过程,取决于操作条件、基质组成等多种因素.在简述污泥颗粒化机理及影响因素的基础上,综述了近年来加速厌氧污泥颗粒化的研究进展,指出厌氧污泥颗粒化应用前景广阔,并提出了几点建议.希望能为厌氧污泥颗粒化技术的工程实践提供一定的理论基础.     

加速厌氧污泥颗粒化的研究进展

厌氧污泥颗粒化过程是一个多阶段过程,取决于操作条件、基质组成等多种因素.在简述污泥颗粒化机理及影响因素的基础上,综述了近年来加速厌氧污泥颗粒化的研究进展,指出厌氧污泥颗粒化应用前景广阔,并提出了几点建议.希望能为厌氧污泥颗粒化技术的工程实践提供一定的理论基础.     

UASB反应器处理链霉素废水启动及运行性能

采用上流式厌氧污泥床(UASB)反应器处理链霉素生产废水,研究了中温条件下反应器启动和稳定运行中废水处理性能及厌氧污泥颗粒化过程。结果表明,通过逐步提高链霉素废水进水比例和负荷,可以实现UASB反应器的启动和稳定运行,并对高浓度链霉素实际废水具有良好的处理性能,COD去除率稳定在80%以上,COD去除负荷达7.2 kg/(m3·d),CH4产生量达到6.2 L/d。UASB反应器启动运行过程中,链霉素废水对污泥活性具有抑制影响,造成短期反应器运行性能明显下降,而后很快恢复。同时高负荷链霉素废水造成甲烷产率降低。污泥性状变化显著,污泥形态逐渐转变为颗粒态,污泥粒径增大,出现大量0.5~1.0 mm颗粒污泥,污泥VSS/SS比值升高,污泥沉降性明显增强,比产甲烷活性显著升高,表明污泥开始实现颗粒化。     

Petroleum refinery stripped sour water treatment using the activated sludge process

A pilot study was performed over 91 days to determine if the activated sludge process could treat a segregated stripped sour water (SSW) stream from a petroleum refinery. The study was performed in two periods. The first period was terminated after 19 days, as a result of excessive sludge bulking. The elimination of sludge bulking during the 70-day second period is attributed to operational changes, which included aerating the influent to oxidize reduced sulfur, adjusting the influent pH, and adding micronutrients to satisfy biological requirements. The pilot plant provided a chemical oxygen demand (COD) removal of up to 93%. Nitrification was achieved, with effluent ammonia values < 1 mg-N/L. These results indicate that direct treatment of SSW with the activated sludge process is possible and has direct application to full-scale petroleum refinery wastewater plant upgrades.     

好氧颗粒污泥形成的影响因素及其应用

结合近年来国内外学者关于好氧污泥颗粒化的研究成果,对影响好氧污泥颗粒化的影响因素进行了较为深入系统的分析,提出了适宜的运行控制条件及所需注意的问题。     

Ca2+对上流式多级厌氧反应器处理蔗渣渗滤液的影响

研究了上流式多级厌氧反应器(UMAR)处理蔗渣渗滤液过程中Ca2+浓度对反应器运行特性和颗粒污泥性质的影响。结果表明,对于蔗渣渗滤液而言,进水中低浓度的Ca2+浓度(80～300 mg/L)对颗粒污泥产甲烷活性无抑制,COD去除率最高可达93.3%;Ca2+浓度达到500 mg/L以上时,对厌氧颗粒污泥的活性有抑制作用;随着Ca2+浓度进一步升高,抑制作用加强,污泥灰分明显升高,活性成分下降,COD去除效率明显降低,污泥粘结沉积在反应器底部,导致系统内循环出现障碍。因此,在实际生产中应减少废水中Ca2+的引入量。     

污泥好氧颗粒化过程中微生物群落结构的演变与分析

为了揭示颗粒污泥形成过程中微生物群落结构多样性的演变过程,以人工配水为进水,在SBR中采用厌氧/好氧循环的手段成功培育出具有聚磷特性的颗粒污泥,利用基于16S rDNA的PCR-DGGE技术获得了微生物群落的DNA特征指纹图谱,对条带进行了统计分析和切胶测序,并建立了系统发育树。结果表明,污泥沉降性能的改善要先于颗粒污...     

Enhanced sludge granulation in upflow anaerobic sludge blanket (UASB) reactors by aluminum chloride.

Two upflow anaerobic sludge blanket (UASB) reactors were concurrently operated for 146 days to examine the effects of aluminum chloride (AlCl3) on the sludge granulation process during start-up. Sludge granulation (defined as that over 10% of granules were larger than 2.0 mm) was achieved in the control reactor (R1) in approximate three months. Introduction of Al3+ at a concentration of 300 mg/l reduced the sludge granulation time by approximate one month. Throughout the experiment the AlCl3-added reactor (R2) had a higher biomass concentration, e.g., 13.8 g-MLVSS/l versus 12.8 g-MLVSS/l on Day 146. Granules became visible earlier in R2 compared with R1 (35 days versus 65 days). The average size of granules from R2 was larger than that from R1. The results demonstrated that AlCl3 enhanced the sludge granulation process in the UASB reactors.     

An observation on sludge granulation in an enhanced biological phosphorus removal process

A sequencing batch reactor (SBR) seeded with flocculated sludge and fed with synthetic wastewater was operated for an enhanced biological phosphorus removal (EBPR) process. Eight weeks after reactor startup, sludge granules were observed. The granules had a diameter of 0.5 to 3.0 mm and were brownish in color and spherical or ellipsoidal in shape. No significant change was observed in sludge granule size when operational pH was changed from 7 to 8. The 208-day continuous operation of the SBR showed that sludge granules were stably maintained with a sludge volume index (SVI) between 30 to 55 mL/g while securing a removal efficiency of 83% for carbon and 97% for phosphorus. Fluorescent in situ hybridization (FISH) confirmed the enrichment of polyphosphate accumulating organisms (PAOs) in the SBR. The observations of sludge granulation in this study encourage further studies in the development of granules-based EBPR process.     

16S ribosomal RNA tools identify an unexpected predominance of Paenibacillus-like bacteria in an industrial activated sludge system suffering from poor biosolids separation.

Molecular biology tools targeting 16S ribosomal RNA (16S rRNA) were used to identify a predominant bacterial population in a full-scale dairy wastewater activated sludge system suffering from poor biosolids separation. Gram and acridine orange staining indicated that viable, Gram-positive microorganisms were present in samples removed from the influent waste stream and represented approximately 50% of total cell counts in samples removed from the mixed liquor. Subsequently, the "full-cycle 16S rRNA approach" showed that phylogenetic relatives of Paenibacillus spp., a low guanine-plus-cytosine percent DNA-content, Gram-positive microorganism, represented up to 30% of total 4,6-diamidino-2-phenylindole (DAPI)-stained cell counts in samples of mixed liquor. Although fluorescent in situ hybridizations with 16S rRNA-targeted oligonucleotide hybridization probes identified Paenibacillus-like spp. in samples removed from the influent waste stream, their abundance was less than 10% of total stained cell counts. Results of this study suggest that Paenibacillus-like spp. were present in low abundance in the influent waste stream, increased in relative abundance within the treatment system, and should be examined further as a candidate bacterial population responsible for poor biosolids separation. This study demonstrates that the full-cycle 16S rRNA approach can be used to identify candidate bacterial populations that may be responsible for operational upsets in full-scale activated sludge systems without prior information from cultivation or microscopic analyses.