氧化亚铁硫杆菌浸提废旧线路板铜的浸出率与时间的关系

探讨氧化亚铁硫杆菌SW-02(Thiobacillus ferrooxidans SW-02)浸提废旧印刷线路板Cu的适宜浸出时间,对Cu的浸出率与时间的关系进行了研究。通过摇瓶培养的方式,在30℃,摇床转速为170 r/min条件下进行浸出实验,按不同时间间隔取样测定溶液Cu2+浓度,pH值与氧化还原电位。分析发现,线路板加入量在30 g/L及以上时,浸出40 h后浸出反应停止,而线路板加入量在15 g/L时,浸出40 h后Cu的浸出率达到70%,继续浸出,浸出率不再显著增加。研究结果表明,铜的适宜浸出时间为40 h。     

废印刷电路板的静电分选实验研究

金属与非金属材料的分离是回收利用废印刷电路板的关键环节。对废印刷电路板物料的静电分选进行了实验研究。实验以电压、辊筒转速、电晕电极与辊筒之间的距离、静电极位置、电晕电极位置、电晕电极数量等为考察因素,研究各因素对电选效果的影响规律。结果表明,影响金属与非金属材料分离的主要因素是电压、辊筒转速和电晕电极与辊筒之间的距离,对于-0.9 0.45mm的破碎物料,当电压为24kV,辊筒转速为15Hz(54.6r/min),电晕电极与辊筒之间的距离为5.2cm时,得到最大静电分选综合效率67.37%。     

氧化亚铁硫杆菌浸出线路板中铜的研究

从煤堆积水中分离得到氧化亚铁硫杆菌,利用该菌种对线路板中的铜进行了浸出实验.研究了不同线路板粉末添加量对浸出效果的影响,观察了浸出过程中pH和氧化还原电位(Eh)的变化,结果表明添加量为10 g/L和20 g/L时,在15 d内线路板Cu几乎全部浸出,而50g/L和100g/L在15 d内亦有较高的浸出效率,并呈持续上升趋势.     

001×14.5离子交换树脂对镍(Ⅱ)的吸附

实验采用离子交换树脂法吸附镍(Ⅱ),树脂选型确定了强酸性阳离子交换树脂001×14.5对镍(Ⅱ)吸附容量最大.用所选的001×14.5树脂吸附镍(Ⅱ)的过程,静态吸附实验表明,转速大于100 r/min时,对树脂吸附的影响可忽略,即基本消除外扩散,pH =7.0时吸附最佳,镍(Ⅱ)吸附率随树脂用量的增加而增大;001×14.5树脂吸附镍(Ⅱ)过程符合Langmuir等温吸附方程,且为优惠吸附;吸附过程符合拟二级动力学模型,吸附过程活化能为E=30.9 kJ/mol,由颗粒内扩散控制;用1 mol/L的硫酸对吸附饱和树脂进行脱附再生,脱附率可达98％以上.     

氧化亚铁硫杆菌浸出废弃线路板中铜的研究

对废弃线路板中的铜进行了细菌浸出、只有硫酸亚铁环境下的浸出及酸浸出实验，研究了不同条件对比浸出效果，研究结果表明，细菌浸出比只有硫酸亚铁存在的浸出和酸浸要快得多。研究了在线路板粉末浓度12、24、40、60和120 g/L下浸出速率的变化，结果表明， 在考察范围内，浸出速度随着加入的废弃线路板粉末浓度的升高而降低，当线路板粉末的浓度＞60 g/L时，浸出速度维持在较低水平，选取24 g/L作为浸出的线路板粉末的浓度。分别在细菌培养0、24、48和72 h时加入线路板粉末24 g/L进行浸出实验，结果表明，细菌培养时间长，使得浸出过程进行得也更快。     

粉末活性炭对三烯丙基异氰脲酸酯的吸附性能

用静态吸附法考察粉末活性炭对水中三烯丙基异氰脲酸酯(CAIC)的吸附行为,采用单因素分析法对活性炭吸附化工废水中TAIC的工艺条件进行研究。实验结果表明,在TAIC模拟废水中,其TAIC初始浓度为800 mg/L,pH为7,在温度为298 K、转速为150 r/min的条件下,当活性炭的投加量达到4.4 g/L,吸附反应时间为50 min时,TAIC的去除效率最高为96.17%;对于实际废水,其TAIC初始浓度为1 500 mg/L,溶液pH为3,在温度为298 K、转速为150 r/min的条件下,当活性炭投加量达到10 g/L,吸附反应时间为2 h时,TAIC的去除效率最高为46.8%。这也是由于实际废水组分复杂,其他有机物存在一定的吸附竞争机制。     

粉末活性炭对三烯丙基异氰脲酸酯的吸附性能简

用静态吸附法考察粉末活性炭对水中三烯丙基异氰脲酸酯（CAIC）的吸附行为，采用单因素分析法对活性炭吸附化工废水中TAIC的工艺条件进行研究。实验结果表明，在TAIC模拟废水中，其TAIC初始浓度为800 mg/L，pH为7，在温度为298 K、转速为150 r/min的条件下，当活性炭的投加量达到4.4 g/L，吸附反应时间为50 min时，TAIC的去除效率最高为96.17%；对于实际废水，其TAIC初始浓度为1 500 mg/L，溶液pH为3，在温度为298 K、转速为150 r/min的条件下，当活性炭投加量达到10 g/L，吸附反应时间为2 h时，TAIC的去除效率最高为46.8%。这也是由于实际废水组分复杂，其他有机物存在一定的吸附竞争机制。     

D006树脂对Cd(Ⅱ)的吸附性能研究

通过树脂筛选实验,选用大孔强酸性阳离子树脂D006作为Cd(Ⅱ)的吸附材料,通过静态实验考察吸附时间、振荡转速、溶液pH和树脂用量对吸附效果的影响,并探讨了吸附的热力学和动力学性能,同时对树脂进行了再生实验。结果表明,D006树脂对Cd(Ⅱ)的平衡吸附量可达20.98mg/g;D006树脂吸附Cd(Ⅱ)的最佳条件为吸附时间120min、振荡转速120r/min、溶液pH 2.9左右、树脂用量0.20g;D006树脂对Cd(Ⅱ)的吸附过程符合Langmuir方程,为单分子层吸附;准二级动力学模型能较好地描述Cd(Ⅱ)在D006树脂上的吸附行为,吸附的活化能为5.46kJ/mol,该吸附过程主要为物理吸附;于30℃下采用1mol/L硫酸对吸附后的D006树脂进行脱附,脱附率可达到96%以上,可实现对Cd(Ⅱ)的富集与回收。     

氧化亚铁硫杆菌浸出线路板中铜及过程中铁的变化研究

从煤堆积水中分离得到氧化亚铁硫杆菌,利用该菌种对线路板中的Cu进行了浸出实验.研究了不同线路板粉末添加量对浸出效果的影响,在220 mL溶液中添加量为2.2、4.4 g时Cu的浸出率很快达到了90%,而添加量为11.0、22.0 g时浸出率表现了缓慢上升,在15 d左右达到了90%.观察了浸出过程中铁浓度及价态的变化,结果表明,浸出初期随着添加量的增加,Fe2 增加明显,但是随着浸出时间的推移,Fe3 、Fe2 和总Fe都呈现降低趋势.     

电选法回收利用废印刷线路板

废印刷线路板含有多种有价值的物质,随意丢弃或处理处置方法不当既污染环境,又造成资源流失。采用剪切式破碎和电力分选技术对废印刷线路板的机械分离进行了研究。结果表明,电选法可以实现废印刷线路板中金属和玻璃纤维、树脂的分离;在实验的粒径范围内(-14+20目到-120+200目分为5个粒径级别),金属主要集中在-20+120目粒级范围内,且该粒级范围分选效果最好。     

Patterns of volatile metabolites and nonvolatile trichothecenes produced by isolates of <Emphasis Type="Italic">Stachybotrys,Fusarium, Trichoderma,Trichothecium</Emphasis> and <Emphasis Type="Italic">Memnoniella</Emphasis>

We reported previously that trichodiene, a volatile trichothecene derivative, was produced by a Stachybotrys isolate, also known to produce highly cytotoxic, non-volatile, macrocyclic trichothecenes (satrotoxins). We investigated the relationship between the production of trichodiene and various non-volatile trichothecenes for several molds. Volatile metabolites were concentrated by adsorption on Tenax TA and analyzed by GC/MS, while non-volatile metabolites were separated by HPLC, derivatized and analyzed by GC/MS. Stachybotrys chartarum isolates producing macrocyclic trichothecenes secreted significantly larger amounts of trichodiene and other sesquiterpenes than isolates which only produced simple trichothecenes. The amounts of secreted trichodiene were relatively small in all cases. With the exception of Memnoniella, which excreted small amounts of sesquiterpenes, the other isolates produced varying amounts of sesquiterpenes, including trichodiene, as well as simple tricothecenes, no detectable trichodiene, but large amounts of griseofulvin derivatives. In Stachybotrys there is apparently a correlation between trichodiene and macrocyclic trichothecene production. In the remaining isolates, there was no simple relationship between trichodiene and non-volatile trichothecene synthesis. Trichodiene is produced in larger amounts by Stachybotrys isolates, which also produce satratoxins, but it will be difficult to utilize this metabolite to detect toxic isolates in buildings due to the relatively small amounts excreted.     

Radionuclides and trace elements in fish collected upstream and downstream of Los Alamos national laboratory and the doses to humans from the consumption of muscle and bone

Abstract

The purpose of this study was to determine radionuclide and trace element concentrations in bottom‐feeding fish (catfish, carp, and suckers) collected from the confluences of some of the major canyons that cross Los Alamos National Laboratory (LANL) lands with the Rio Grande (RG) and the potential radiological doses from the ingestion of these fish. Samples of muscle and bone (and viscera in some cases) were analyzed for ³H, ⁹⁰Sr, ¹³⁷Cs, ^totU, ²³⁸Pu, ^239,240Pu, and ²⁴¹Am and Ag, As, Ba, Be, Cr, Cd, Cu, Hg, Ni, Pb, Sb, Se, and Tl. Most radionuclides, with the exception of ⁹⁰Sr, in the muscle plus bone portions of fish collected from LANL canyons/RG were not significantly (p<0.05) higher from fish collected upstream (San Ildefonso/background) of LANL. Strontium‐90 in fish muscle plus bone tissue significantly (p<0.05) increases in concentration starting from Los Alamos Canyon, the most upstream confluence (fish contained 3.4E‐02 pCi g^‐1 [126E‐02 Bq kg^‐1]), to Frijoles Canyon, the most downstream confluence (fish contained 14E‐02 pCi g^‐1 [518E‐02 Bq kg^‐1]). The differences in ⁹⁰Sr concentrations in fish collected downstream and upstream (background) of LANL, however, were very small. Based on the average concentrations (±2SD) of radionuclides in fish tissue from the four LANL confluences, the committed effective dose equivalent from the ingestion of 46 lb (21 kg) (maximum ingestion rate per person per year) of fish muscle plus bone, after the subtraction of background, was 0.1 ± 0.1 mrem y^‐1 (1.0 ± 1.0 μSv y^‐1), and was far below the International Commission on Radiological Protection (all pathway) permissible dose limit of 100 mrem y^‐1 (1000 μSv y^‐1). Of the trace elements that were found above the limits of detection (Ba, Cu, and Hg) in fish muscle collected from the confluences of canyons that cross LANL and the RG, none were in significantly higher (p<0.05) concentrations than in muscle of fish collected from background locations.     

A History of Dry Cleaners and Sources of Solvent Releases from Dry Cleaning Equipment

Approximately 25, 000-35, 000 dry cleaning facilities currently operate in the U.S. The release of perchloroethylene and other solvents from these establishments represents a major source of soil and groundwater contamination. The manner in which dry cleaning solvents escape from dry cleaning plants is, for all practical purposes, identical for chlorinated and petroleum hydrocarbon solvents and is related to one of the following events: the catastrophic failure of a component of the dry cleaning system, the improper installation, operation or maintenance of the dry cleaning equipment or a combination of all of these causes. Acceptable customs, codes and regulations can also dictate what is authorized for operation of a dry cleaning facility in a particular community, geographic area during a particular time frame. Environmental litigation dealing with the origin of a solvent release from dry cleaners tends to focus on the design and manufacture of dry cleaning industry machines such as washers, washer extractors, tumblers, solvent filters, water separators, stills and spotting boards. A thorough analysis of the daily operations of dry cleaners often reveals that poor maintenance, failure to follow the manufacturer's instructions and the actions of the operator are the most likely causes of soil and groundwater pollution. In order to forensically evaluate the most probable origins of a solvent release and to examine issues regarding liability, a thorough understanding of the history of dry cleaning and a detailed analysis of the operation and maintenance of the dry cleaning equipment are necessary. The discovery of solvent plumes in the vicinity of dry cleaning plants may suggest that the solvent source is the dry cleaning plant; however, the presence of these plumes does not necessarily indicate that the dry cleaning equipment was defectively designed or manufactured. A thorough review of the type of equipment used over the life of the dry cleaning plant and verifiable solvent mileage records frequently indicates that operators of the plant have disposed of solvent and contaminated solids into the municipal sewer or on ground surfaces.     

Radionuclides in deer and elk from Los Alamos national laboratory and the doses to humans from the ingestion of muscle and bone

Abstract

This paper summarizes radionuclide concentrations (³H, ⁹⁰Sr, ¹³⁷Cs, ²³⁸Pu, ^239,240Pu, ²⁴¹Am, and ^totU) in muscle and bone tissue of mule deer (Odocoileus hemionus) and Rocky Mountain elk (Cervus elaphus) collected from Los Alamos National Laboratory (LANL), Los Alamos, New Mexico, lands from 1991 through 1998. Also, the committed effective dose equivalent (CEDE) and the risk of excess cancer fatalities (RECF) to people who ingest muscle and bone from deer and elk collected from LANL lands were estimated. Most radionuclide concentrations in muscle and bone from individual deer (n = 11) and elk (n = 22) collected from LANL lands were either at less than detectable quantities (where the analytical result was smaller than two counting uncertainties) and/or within upper (95%) level background (BG) concentrations. As a group, most radionuclides in muscle and bone of deer and elk from LANL lands were not significantly higher (p<0.10) than in similar tissues from deer (n = 3) and elk (n = 7) collected from BG locations. Also, elk that had been radio collared and tracked for two years and spent an average time of 50% on LANL lands were not significantly different in most radionuclides from road kill elk that have been collected as part of the environmental surveillance program. Overall, the upper (95%) level net CEDEs (the CEDE plus two sigma for each radioisotope minus background) at the most conservative ingestion rate (50 lbs of muscle and 13 lbs of bone) were as follows: deer muscle = 0.22 mrem y^‐1 (2.2 μSv y^‐1), deer bone = 3.8 mrem y^‐1 (38 μSv y^‐1), elk muscle = 0.12 mrem y^‐1 (1.2 μSv y^‐1), and elk bone = 1.7 mrem y^‐1 (17 μSv y^‐1). All CEDEs were far below the International Commission on Radiological Protection guideline of 100 mrem y^‐1 (1000 μSv y^‐1), and the highest muscle plus bone net CEDE corresponded to a RECF of 2E‐06, which is far below the Environmental Protection Agency upper level guideline of 1E‐04.     

Leaching of seven pesticides currently used in cotton crop in Mato Grosso State—Brazil

This study aimed to evaluate the leaching of pesticides and the applicability of the Attenuation Factor (AF) Model to predict their leaching. The leaching of carbofuran, carbendazim, diuron, metolachlor, α and β endosulfan and chlorpyrifos was studied in an Oxisol using a field experiment lysimeter located in Dom Aquino – Mato Grosso. The samples of percolated water were collected by rain event and analyzed. Chemical and physical soil attributes were determined before pesticide application to the plots. The results showed that carbofuran was the pesticide that presented a higher leaching rate in the studied soil, so was the one representing the highest contamination potential. From the total carbofuran applied in the soil surface, around 6 % leached below 50 cm. The other pesticides showed lower mobility in the studied soil. The calculated values to AF were 7.06E-12 (carbendazim), 5.08E-03 (carbofuran), 3.12E-17 (diuron), 6.66E-345 (α-endosulfan), 1.47E-162 (β-endosulfan), 1.50E-06 (metolachlor), 3.51E-155 (chlorpyrifos). AF Model was useful to classify the pesticides' potential for contamination; however, that model underestimated pesticide leaching.     

Endosulfan in China 2—emissions and residues

Background, aim, and scope  Endosulfan is one of the organochlorine pesticides (OCPs) and also a candidate to be included in a group of new persistent organic pollutants (UNEP 2007). The first national endosulfan usage inventories in China with 1/4° longitude by 1/6° latitude resolution has been reported in an accompanying paper. In the second part of the paper, we compiled the gridded historical emissions and soil residues of endosulfan in China from the usage inventories. Based on the residue/emission data, gridded concentrations of endosulfan in Chinese soil and air have been calculated. These inventories will provide valuable data for the further study of endosulfan. Methods  Emission and residue of endosulfan were calculated from endosulfan usage by using a simplified gridded pesticide emission and residue model—SGPERM, which is an integrated modeling system combining mathematical model, database management system, and geographic information system. By using the emission and residue inventories, annual air and soil concentrations of endosulfan in each cell were determined. Results and discussion  Historical gridded emission and residue inventories of α- and β-endosulfan in agricultural soil in China with 1/4° longitude by 1/6° latitude resolution have been created. Total emissions were around 10,800 t, with α-endosulfan at 7,400 t and β-endosulfan at 3,400 t from 1994 to 2004. The highest residues were 140 t for α-endosulfan and 390 t for β-endosulfan, and the lowest residues were 0.7 t for α-endosulfan and 170 t for β-endosulfan in 2004 in Chinese agricultural soil where endosulfan was applied. Based on the emission and residue inventories, concentrations of α- and β-endosulfan in Chinese air and agricultural surface soil were also calculated for each grid cell. We have estimated annual averaged air concentrations and the annual minimum and maximum soil concentrations across China. The real concentrations will be different from season to season. Although our model does not consider the transport of the insecticide in the atmosphere, which could be very important in some areas during some special time, the estimated concentrations of endosulfan in Chinese air and soil derived from the endosulfan emission and residue inventories are in general consistent with the published monitoring data. Conclusions  To our knowledge, this work is the first inventory of this kind for endosulfan published on a national scale. Concentrations of the chemical in Chinese air and agricultural surface soil were calculated for each grid cell. Results show that the estimated concentrations of endosulfan in Chinese air and soil agree reasonably well with the monitoring data in general. Recommendations and perspectives  The gridded endosulfan emission/residue inventories and also the air and soil concentration inventories created in this study will be updated upon availability of new information, including usage and monitoring data. The establishment of these inventories for the OCP is important for both scientific communities and policy makers.     

Impact of spiked concentrations of Cd,Pb, As and Zn in growth medium on elemental uptake of Nasturtium officinale (Watercress)

This study is aimed at investigating the impact of water quality on the uptake and distribution of three non-essential and toxic elements, namely, As, Cd and Pb in the watercress plant to assess for metal toxicity. The plant was hydroponically cultivated under greenhouse conditions, with the growth medium being spiked with varying concentrations of As, Cd and Pb. Plants that were harvested weekly for elemental analysis showed physiological and morphological symptoms of toxicity on exposure to high concentrations of Cd and Pb. Plants exposed to high concentrations of As did not survive and the threshold for As uptake in watercress was established at 5 ppm. Translocation factors were low in all cases as the toxic elements accumulated more in the roots of the plant than the edible leaves. The impact of Zn on the uptake of toxic elements was also evaluated and Zn was found to have an antagonistic effect on uptake of both Cd and Pb with no notable effect on uptake of As. The findings indicate that phytotoxicity or death of the watercress plant would prevent it from being a route of human exposure to high concentrations of As, Cd and Pb in the environment.     

Butyltin compounds in sediment and fish from the Polish Coast of the Baltic Sea

Concentrations of mono- (MBT), di- (DBT), and tri-(TBT) butyltin compounds were measured in eggs, liver, and muscle of nine species of fish from four regions of the Baltic Sea - the Firth of Vistula, the Gulf of Gdańsk, Puck Bay, and the mouth of the Vistula River. The overall concentration ranges among all the fish sampled from the four sites were: < 7 to 79 ng/g for MBT, 6 to 1100 ng/g for DBT, 7 to 3600 ng/g for TBT, and 16 to 4800 ng/g for total BTs, on a wet wt basis. The highest concentration of total BTs was found in herring liver from the Firth of Vistula (4800 ng/g, wet wt) and in roach muscle from Puck Bay (3300 ng/g, wet wt), while the least concentration was found in burbot eggs and liver from the Vistula River (39 and 32 ng/g, wet wt, respectively). TBT was the major form of BTs present in most samples analyzed. Sediment samples collected from shipyards in the Gulf of Gdańsk contained butyltin concentrations ranging from 1.2 to 46 μg/g (dry wt) for MBT, 2.0 to 42 μg/g for DBT, and 2.6 to 40 μg/g for TBT. As with the fish, the majority of the BTs in sediment were present as TBT, which suggested recent exposure of the aquatic environment of the region to TBT.     

Malathion-induced sublethal toxicity on the intestine of cricket frog (Fejervarya limnocharis)

The effect of malathion [diethyl(dimethoxythiophosphorylthio)succinate] at sublethal concentration (0.006 ppm) on intestinal parameters of cricket frog (Fejervarya limnocharis) was studied for 24 hrs to 240 hrs of exposure and remarkable histopathological alterations were observed. The study on intestinal parameters revealed acute pathological conditions in the intestinal wall. The toxic effect became evident as the cytoplasm of the cells disintegrated and the cells became empty and vacuolated. The cell membranes were also ruptured. Degenerative changes of the absorptive surface (villi) of the intestine in the different periods of exposure were pronounced. Severe atrophic nature (necrotic mucosa) of the intestine began from 48 hrs onwards to 96 hrs of exposure.