间歇曝气SBR工艺脱氮除磷试验研究

采用间歇曝气序批式反应器(SBR)工艺,通过曝气时间、交替次数的调整对该系统的脱氮除磷效果进行了研究,最终将工艺确定为厌氧1.5 h、好氧1.0 h、缺氧1.0 h、好氧20 min、缺氧1.0 h、好氧20 min.同时进行批式试验,对不同阶段的反硝化除磷菌(DPAOs)占除磷菌(PAOs)的比例进行了计算.结果表明:该系统与最初的厌氧/好氧SBR相比节省了44%的曝气量,且对COD、总氮、氨氮和磷的去除率分别达88%、89%、100%和100%,系统中DPAOs所占比例为39%.     

Application of computational fluid dynamics to closed-loop bioreactors: II. Simulation of biological phosphorus removal using computational fluid dynamics.

Based on the International Water Association's (London) Activated Sludge Model No. 2 (ASM2), biochemistry rate expressions for general heterotrophs and phosphorus-accumulating organisms (PAOs) were introduced to a previously developed, three-dimensional computational fluid dynamics (CFD) activated sludge model that characterized the mixing pattern within the outer channel of a full-scale, closed-loop bioreactor. Using acetate as the sole carbon and energy source, CFD simulations for general heterotrophs or PAOs individually agreed well with those of ASM2 for a chemostat with the same operating conditions. Competition between and selection of heterotrophs and PAOs was verified using conventional completely mixed and tanks-in-series models. Then, competition was studied in the CFD model. These results demonstrated that PAOs and heterotrophs can theoretically coexist in a single bioreactor when the oxygen input is appropriate to allow sufficient low-dissolved-oxygen zones to develop.     

不同电子受体对聚磷菌吸磷性能的影响研究

采用人工配水,在厌氧/好氧交替运行的序批式活性污泥反应器(SBR)中,富集了全菌数量80%以上的聚磷菌(Candi-datus Accumulibacter Phosphates)。以此为基础,研究了O2及不同浓度NO3--N、NO2--N对聚磷菌吸磷的影响。结果表明,在一定的条件下,聚磷菌可以NO3--N和NO2--N为电子受体进行缺氧吸磷;NO3--N浓度对聚磷菌的吸磷速率影响很小;聚磷菌可以低质量浓度NO2--N(≤40mg/L)为电子受体,但不能以高质量浓度NO2--N(≥80mg/L)为电子受体,而且高浓度NO2--N对聚磷菌吸磷产生抑制甚至对细菌本身存在毒害;NO2--N为电子受体时,其抑制浓度和污泥本身以及外界条件都存在很大的关系,各个研究结论不尽相同,其影响过程有待进一步的探讨。     

Biodegradation of triclosan and formation of methyl-triclosan in activated sludge under aerobic conditions

Triclosan is an antimicrobial agent which is widely used in household and personal care products. Widespread use of this compound has led to the elevated concentrations of triclosan in wastewater, wastewater treatment plants (WWTPs) and receiving waters. Removal of triclosan and formation of triclosan-methyl was investigated in activated sludge from a standard activated sludge WWTP equipped with enhanced biological phosphorus removal. The removal was found to occur mainly under aerobic conditions while under anoxic (nitrate reducing) and anaerobic conditions rather low removal rates were determined. In a laboratory-scale activated sludge reactor 75% of the triclosan was removed under aerobic conditions within 150 h, while no removal was observed under anaerobic or anoxic conditions. One percent of the triclosan was converted to triclosan-methyl under aerobic conditions, less under anoxic (nitrate reducing) and none under anaerobic conditions.     

Biotransformation of estrogens in nitrifying activated sludge under aerobic and alternating anoxic/aerobic conditions.

Natural and synthetic estrogens present in municipal wastewater can be biodegraded during treatment, particularly in activated sludge. The objective was to assess the extent of transformation of 17-beta-estradiol (E2) and 17-alpha-ethinylestradiol (EE2) by nitrifying activated sludge and evaluate potential relationships between availability of oxygen, nitrification rate, and estrogen removal. For each batch experiment, two reactors were set up--aerobic and alternating anoxic/aerobic-which were then amended with E2 and EE2 from methanolic stock solutions. The EE2 was persistent under anoxic conditions; under aerobic conditions, the observed level of its removal was 22%. The E2 was readily converted to estrone (El)--faster under aerobic (nitrifying) than anoxic (denitrifying) conditions. During the initial anoxic conditions, a metabolite consistent with 17-alpha-estradiol transiently accumulated and was subsequently removed when the reactor was aerated. Higher removal rates of estrogens were associated with higher nitrification rates, which supports the contention that the nitrifying biomass was responsible for their removal.     

反硝化除磷颗粒污泥的活性恢复及对生活污水处理能力

实验利用序批式反应器(SBR)考察反硝化除磷颗粒污泥搁置1个月后重新投入运行,其活性恢复能力及对实际生活污水的处理效果。结果表明,颗粒污泥搁置后外观由淡黄色转变为灰黑色,颗粒重新投入反应器,11 d后颜色基本恢复,污泥浓度及活性迅速增加;对COD处理能力的恢复历时14 d,去除率稳定在80.32%以上;颗粒污泥对NH4+-N和PO34--P的去除在40 d时也恢复到正常水平;反硝化聚磷菌(DNPAOs)活性恢复期为50 d。颗粒污泥对低碳氮比的实际生活污水处理结果显示,当C/N<5.1时(生活污水比例>60%),无法满足系统内微生物生长要求,需要外加适量碳源进行补充。     

Recovery of phosphates from wastewater using converter slag: Kinetics analysis of a completely mixed phosphorus crystallization process

A phosphorus crystallization process for recovering phosphates was developed using a completely mixed reactor and powdered converter slag as a seed crystal. This completely mixed phosphorus crystallization process achieved a stable and high phosphorus recovery: the average PO4-P removal efficiency during 200 d of operation was 87%, with a range of 70-98%. The apparent volume of the slag doubled due to crystal growth during the long-term phosphorus-removal experiments. The Ca2+ concentration, slag dosage, and temperature were found to govern the phosphorus recovery system for a given condition of pH and hydraulic retention time. The equations for the rate constant and reaction order were obtained by evaluating the model parameters. The model developed in this study was observed to successfully simulate the behavior of effluent PO4-P in a completely mixed phosphorus crystallization reactor over a wide variety of operating conditions of temperature, Ca2+ concentration, and influent PO4-P. Model investigations of design factors suggest that the completely mixed phosphorus crystallization process with influent PO4-P concentrations of less than 10 mg l(-1) could ensure effluent PO4-P concentrations of less than 0.5 and 1.0 mg l(-1) during summer and winter in Korea, respectively.     

青萍生长特征及其对受污染河水的修复效果

以浮萍优势品种青萍（Lemna minor）为研究对象,开展受污染河水修复。分析了青萍在不同营养盐浓度条件下的生长特征,探讨了青萍对受污染河水的修复效果。在表面积为0.0095 m2的限制空间条件下,青萍在1、2和5 mg总氮（TN）/L营养液中的生长特征都能较好地服从Logistic生长模型,受制约的临界鲜重（FW）分别为1.20、1.36和1.36 g;青萍对受污染河水中氮磷污染物具有较好的去除效果,氨氮（NH＋4-N）的平均去除率、平均去除量和平均去除速率分别为56.87%、1.22 mg/d和0.0466 mg/（g FW·h）,正磷酸盐（PO3-4-P）的平均去除率、平均去除量和平均去除速率分别为66.95%、0.25 mg/d和0.0088 mg/（g FW·h）。根据相关性分析,进水NH＋4-N和PO3-4-P浓度与其对应去除量之间极显著相关;青萍FW与NH＋4-N去除速率之间显著负相关,但与PO3-4-P去除速率之间不存在显著相关性;NH＋4-N进水浓度与去除速率相关性不显著,但PO3-4-P进水浓度与去除速率显著正相关。     

Investigating phosphorus limitation in a fixed bed filter with phosphorus and nitrogen profile measurements

In 2000, the European Union adopted the European Water Framework Directive (WFD) (European Commission, 2000). The WFD focuses on increasingly stringent nutrient standards including ultra low nitrogen (< 2.2 mg N-total/L) and phosphorus concentrations (< 0.15 mg total phosphorus/L) in receiving surface waters and in relevant point sources like wastewater treatment plant (WWTP) effluent. Expansion of WWTPs with advanced post-treatment processes, like effluent filtration, is widely proposed to meet possible future effluent discharge standards. When combining biological nitrate-nitrogen and chemical phosphorus removal in one filter, phosphorus limitation in the denitrifying process may occur. This study investigated where in the filter bed and under which conditions phosphorus limitation occurs. Profile measurements for nitrate, nitrite, and orthophosphorus (PO4-P) combined with chemical oxygen demand (COD) and 02 were conducted. Results showed that the required PO4-P/NOx-N ratio is approximately 0.006 mg/mg after phosphorous precipitation and flocculation. Profile measurements have proven to be an applicable and useful tool. It showed how nitrate and orthophosphorus are removed through the filter bed based on the PO4-P/NOx-N ratio. When orthophosphorus is removed more rapidly and efficiently compared to nitrate, the PO4-P/NOx-N ratio decreases. When PO4-P/NOx-N ratio thresholds are approximately 0.006 mg/mg for a certain period of time and water temperatures varied significantly, orthophosphorus limitation may occur. Changing the filter-bed configuration or decreasing the coagulant dosage can prevent limitation of the denitrifying process because of a phosphorous shortage.     

(AO)_2SBR同步脱氮除磷的研究

以人工配水为研究对象,采用厌氧/好氧/缺氧/好氧交替运行的序批式反应器,研究了(AO)2SBR系统同步脱氮除磷的效果,并结合批式实验讨论了同步脱氮除磷的反应机理。研究结果表明,该系统以厌氧1.5 h、好氧1 h、缺氧3h、好氧0.5 h的方式运行,在DO=2.5 mg/L,SRT=15 d的条件下,具有良好的脱氮除磷效果,配水中的总氮、总磷、COD和总有机碳的去除率分别为96.26%、99.87%、90.46%和85.57%。批式实验表明,合成的内碳源越多,氨氮的硝化越充分,反硝化除磷越多。     

Dairy manure treatment, digestion and nutrient recovery as a phosphate fertilizer

A combined approach of biological treatment, solids digestion and nutrient recovery was tested on dairy manure. A sequencing batch reactor (SBR) was operated in three modes, in order to optimize nutrient (nitrogen and phosphorus) removals. The highest average removal efficiencies of 91% for NH4-N, 59% for PO4-P and 80% for total chemical oxygen demand (COD) were achieved. Staining experiments suggested the coexistence of glycogen and phosphorus accumulating organisms. Anaerobic digestion of wasted bio-solids was able to produce a PO4-P concentration of 70 mgL-1 in the supernatant. A pilot-scale experiment, designed to recover phosphorus in the supernatant as struvite (magnesium ammonium phosphate), was able to remove 82% of soluble PO4-P.     

Effect of dissolved oxygen on biological nutrient removal by denitrifying phosphorus-accumulating organisms in a continuous-flow system

A laboratory-scale continuous-flow system with an anaerobic/anoxic/aerobic configuration was set up to study the effect of oxygen in the internal recycle stream; of particular interest was its performance of denitrifying phosphorus-accumulating organisms (DPAOs). It was found that, by using a degas device, the dissolved oxygen in the nitrate recycle stream was effectively decreased from 0.1 +/- 0.02 to 0.01 +/- 0.01 mg/L. This provided a favorable condition for DPAOs to grow under an anoxic condition and thus be sustained successfully in the system. When the degas device was removed from the system, the dissolved oxygen concentration in the anoxic reactor increased to 0.1 +/- 0.02 mg/L. The proliferation of the denitrifying glycogen-accumulating organisms (DGAOs) population and deterioration of DPAOs performance was observed. The increased population of DGAO/GAOs, which competed for the carbon source with DPAO/ PAOs, resulted in a poor performance of biological phosphorus removal.     

Fenton氧化-序批式膜生物反应器耦合处理干法腈纶废水

采用Fenton氧化-序批式膜生物反应器(SBMBR)组合工艺处理干法腈纶废水。结果表明,在废水初始pH值为3.0,H2O2投加量为90.0 mmol/L,Fe2+投加量为20.0 mmol/L,反应时间为2.0 h的条件下,Fenton氧化预处理对腈纶生产废水的COD去除率达到47.0%以上,COD由1 091 mg/L降至560 mg/L,废水的BOD5/COD由0.32升至0.69,废水的可生化性得到显著提高。Fenton处理出水与丙烯腈废水等比例混合后,采用SBMBR进行生化处理,在水力停留时间为24 h,90 min缺氧/150 min好氧交替运行的条件下,COD、NH4+-N和TN的平均去除率分别为71.7%、97.2%和47.4%,碳源不足是限制TN去除效果的主要影响因素。在无外加碳源的条件下,组合工艺处理后出水COD和NH4+-N浓度分别为117 mg/L和1.7 mg/L,出水水质可以稳定达到国家一级排放标准(GB8978-1996)。     

Determination of the nitrous oxide emission potential of deammonification under anoxic conditions

Various studies have been performed to determine nitrous oxide (N2O) emissions from conventional biological nitrogen removal processes in wastewater treatment like nitrification and denitrification in the main stream. However, with respect to the overall emissions of a wastewater treatment plant, part-stream treatment for high-strength wastewater (e.g., sludge liquor) is also expected to hold a significant emission potential because of high concentrations and extreme boundary conditions. This paper presents results from a laboratory-scale study on nitrous oxide production by biomass from a deammonification process (nitritation + anammox) under anoxic conditions. It was discovered that N2O formation results from incomplete endogenous denitrification rather than anammox and is dependent on substrate availability. Based on direct measurements of the dissolved N2O concentrations in a sequencing batch reactor, the dynamic behavior of N2O production is characterized in more detail. The results show that, during anoxic conditions, the N2O emission potential of deammonification is significantly lower than from conventional denitrification.     

Biological nitrogen and carbon removal in a gravity flow biomass concentrator reactor for municipal sewage treatment

A novel membrane system, the Biomass Concentrator Reactor (BCR), was evaluated as an alternative technology for the treatment of municipal wastewater. Because the BCR is equipped with a membrane whose average poresize is 20 μm (18–28 μm), the reactor requires low-pressure differential to operate (gravity). The effectiveness of this system was evaluated for the removal of carbon and nitrogen using two identical BCRs, identified as conventional and hybrid, that were operated in parallel. The conventional reactor was operated under full aerobic conditions (i.e., organic carbon and ammonia oxidation), while the hybrid reactor incorporated an anoxic zone for nitrate reduction as well as an aerobic zone for organic carbon and ammonia oxidation. Both reactors were fed synthetic wastewater at a flow rate of 71 L d^?1, which resulted in a hydraulic retention time of 9 h. In the case of the hybrid reactor, the recycle flow from the aerobic zone to the anoxic zone was twice the feed flow rate. Reactor performance was evaluated under two solids retention times (6 and 15 d). Under these conditions, the BCRs achieved nearly 100% mixed liquor solids separation with a hydraulic head differential of less than 2.5 cm. The COD removal efficiency was over 90%. Essentially complete nitrification was achieved in both systems, and nitrogen removal in the hybrid reactor was close to the expected value (67%).     

厌氧／缺氧SBR反硝化除磷效能的研究

采用厌氧 缺氧SBR反应器对以硝酸盐作为电子受体的反硝化除磷过程进行了研究。结果表明 ,反硝化聚磷菌完全可以在厌氧 缺氧交替运行条件下得到富集。稳定运行的厌氧 缺氧SBR反应器的反硝化除磷效率 >90 % ,出水磷浓度 <1mg L。进水COD浓度对反硝化除磷的效率影响很大 ,在COD浓度 <180mg L时 ,进水COD浓度越高 ,除磷效率也就越高。较高浓度的进水COD浓度将导致有剩余的COD进入缺氧段 ,对反硝化吸磷构成不利影响。污泥龄为 16d时 ,厌氧 缺氧SBR反应器取得稳定和理想的反硝化除磷效果。污泥龄减少到 8d ,由于反硝化聚磷菌的流失导致反硝化除磷效率的下降。当污泥龄恢复到 16d时 ,经过一段时间的运行 ,反硝化聚磷菌重新得到富集 ,除磷效率恢复到 90 %以上。     

SBR脱氮系统污泥对磷的去除研究

为了研究缺氧(75 min)-好氧(294 min)交替运行的SBR系统中除磷的原因,采用静态实验,对比了不同碳源、水质及运行环境下对磷的去除情况。实验结果表明,该SBR脱氮系统中的好氧段磷的减少是生物去除的结果。当供给碳源为丙酸-乙酸混合物(摩尔比为2∶1)、葡萄糖、淀粉或蛋白胨时,污泥都可将磷去除,去除效率依次降低;COD/NO3--N为8.77∶1(400 mg/L∶45.6 mg/L)时除磷效果明显好于5.41∶1(400 mg/L∶73.9 mg/L)和3.57∶1(400 mg/L∶112 mg/L);进水磷浓度为8 mg/L时,COD由50 mg/L增加到400 mg/L,污泥对磷的去除效果基本一样;完全的缺氧或完全的好氧环境下,污泥对磷的去除能力逐渐丧失。     

ASBBR-二级SBBR-化学除磷组合工艺处理榨菜腌制废水

针对榨菜腌制废水高盐高氮磷高有机物浓度的特征,提出"厌氧序批式生物膜反应器(ASBBR)-二级序批式生物膜反应器(SBBR)-化学除磷"组合处理工艺,在前期对组合工艺中单元工艺的关键工况参数研究的基础上,考察组合工艺的处理效能。实验结果表明,采用该组合工艺,可使进水COD、NH4+-N、TN及PO43--P分别为10 000、345、550和38.5mg/L的榨菜腌制废水,处理出水COD、NH4+-N、TN及PO43--P分别达到93.6、12.3、18和0.1 mg/L,去除率分别为99.1%、96.4%、96.7%和99.9%,出水达到污水综合排放一级标准。     

回流比对缺氧/好氧生活污水处理装置处理效果的影响

在缺氧／好氧工艺的不同回流比条件下，对处理效果特别是脱氮效果进行了研究。结果表明，混合液和污泥合并回流，当回流比从R=4到R=7时，均能获得良好的脱氮效果，TN去除率达到75．4％以上，出水TN〈10mg／L。而回流比的变化对BOD的去除效果影响较小。当BOD污泥负荷从0．096kg／（kg&#183;d）降低到0．063ks／（kg&#183;d）时，对TN和BOD的去除率影响都很小。     

Optimization of enhanced biological phosphorus removal after periods of low loading.

Enhanced biological phosphorus removal is a well-established technology for the treatment of municipal wastewater. However, increased effluent phosphorus concentrations have been reported after periods (days) of low organic loading. The purpose of this study was to evaluate different operating strategies to prevent discharge of effluent after such low-loading periods. Mechanisms leading to these operational problems have been related to the reduction of polyphosphate-accumulating organisms (PAOs) and their storage compounds (polyhydroxy alkanoates [PHA]). Increased effluent phosphorus concentrations can be the result of an imbalance between influent loading and PAOs in the system and an imbalance between phosphorus release and uptake rates. The following operating conditions were tested in their ability to prevent a reduction of PHA and of overall biomass during low organic loading conditions: (a) unchanged operation, (b) reduced aeration time, (c) reduced sludge wastage, and (d) combination of reduced aeration time and reduced sludge wastage. Experiments were performed in a laboratory-scale anaerobic-aerobic sequencing batch reactor, using acetate as the carbon source. Without operational adjustments, phosphorus-release rates decreased during low-loading periods but recovered rapidly. Phosphorus-uptake rates also decreased, and the recovery typically required several days to increase to normal levels. The combination of reduced aeration time and reduced sludge wastage allowed the maintenance of constant levels of both PHA and overall biomass. A mathematical model was used to explain the influence of the tested operating conditions on PAO and PHA concentrations. While experimental results were in general agreement with model predictions, the kinetic expression for phosphorus uptake deviated significantly for the first 24 hours after low-loading conditions. Mechanisms leading to these deviations need to be further investigated.