脱硫灰中杂质对石灰石脱硫活性的影响

研究脱硫灰中杂质对石灰石脱硫活性的影响具有重要意义,采用烟气湿法脱硫用石灰石粉反应速率的测定方法,使用瑞士万通902智能电位滴定仪,分析了SiO2、Al2O3、Fe2O3、CaSO3与MgO等脱硫灰中5种杂质对石灰石脱硫活性的影响。结果表明,在实验浓度范围内,SiO2、Al2O3、CaSO3的加入在一定程度上促进了石灰石的溶解,而MgO、Fe2O3的加入在一定程度上抑制了石灰石的溶解。将脱硫灰与石灰石掺合作脱硫剂时,要综合考虑这5种杂质对石灰石溶出的影响,选择适宜的脱硫灰和石灰石掺合比。     

烟气脱硫石灰石活性测试装置设计研究

石灰石的活性对烟气脱硫工艺具有重要意义.设计了一套石灰石活性测试装置,该装置可模拟实际脱硫塔的反应过程,测试结果能够准确反映石灰石的活性.     

浙江浙能节能科技有限公司

正STI系列石灰石粉活性激发剂适用于石灰石-石膏法脱硫系统石灰石-石膏法脱硫工艺是世界上应用最广泛的一种脱硫技术。为克服现有石灰石-石膏法脱硫工艺的不足,实现脱硫系统可经济、高效地进行调节,浙江浙能节能科技有限公司开发了STI系列石灰石粉活性激发剂(专利申请号:201010295283.9)。经科技成果省级鉴定,达到国际先进水平。产品特性·可停运一台或二台浆液循环泵,减少液气比,降低脱硫系统电耗和阻力。     

型煤燃烧过程中石灰石固硫的试验研究（Ⅱ）

采用石灰石作固硫剂，考察其加入量和空气流量对北宿型煤固硫的影响，研究了固硫型煤矿析出特性和石灰石对不同煤的固硫能力。研究表明：石灰石的最佳固硫温度为８００℃、Ｃａ／Ｓ＝２：１；石灰石中所含的杂质对低温固硫有利，煤中所含钙基组分对固硫有利，石灰石对低灰熔点煤高温固硫不利。     

无机盐对SO2—H2O—CaCO3气液固三相反应系统pH值的影响

研究了硫酸钠、硝酸钠和氯化钠及相应钙盐对石灰石浆液烟气脱硫条件下ＳＯ２－Ｈ２Ｏ－ＣａＣＯ３气、液、固三相反应系统中ｐＨ值的影响。发现硫酸钠能明显提高系统的ｐＨ值，硝酸钠和氯化钠使ｐＨ值提高的幅度不大，而３种钙盐均使ｐＨ值降低。根据膜模型的分析结果，认为无机盐影响该反应系统ｐＨ值的主要原因是无机盐的加入改变了石灰石表面的ｐＨ值。     

石灰石高温煤气脱硫的试验研究

采用天然石灰石做脱硫剂，在固定床上进行硫化氢高温脱除的试验研究，考察了脱硫剂粒径、反应温度、气速及高温煤气中H2对石灰石脱硫性能的影响，同时还用热重分析(TG)、扫描电镜(SEM)、X-射线衍射(XRD)等测试手段对脱硫剂的物相组成和结构等进行了表征。结果表明，脱硫剂的粒径对脱硫效果的影响很大，0.38～0.83 mm的石灰石脱硫效果最佳；温度对脱硫效果的影响比较复杂，最佳的操作温度为850℃；气速对脱硫效果的影响较明显，脱硫剂的穿透时间随气速的减小而加长；H₂对脱硫过程起阻碍作用，气速越小，这种阻碍作用越明显。     

鼓泡塔中有机酸强化粗颗粒石灰石新型烟气脱硫

对传统石灰石湿法烟气脱硫进行了改进,提出了一种新型烟气脱硫方法,即在鼓泡塔中添加有机酸,采用大颗粒石灰石(210 μm)代替传统的细颗粒石灰石(5～20 μm)进行脱硫.实验在鼓泡搅拌吸收反应器中对比研究了新老两种脱硫工艺.结果表明,当210 μm石灰石浆液中醋酸摩尔浓度达10～30 mmol/L,其脱硫率和石灰石利用率分别为95%和93.5%,均达到甚至优于传统石灰石脱硫结果.实验研究了影响脱硫率的各种因素:添加醋酸浓度、入口SO2浓度、石灰石浆液浓度、气体停留时间以及温度等,并提出添加醋酸促进SO2吸收的机理.运用该新型烟气脱硫方法,可降低电厂的基础投资和运行费用,大大加强系统的稳定性和抗击烟气中SO2波动的能力.     

流化床反应器石灰石固硫特性研究

采集了兖矿地区华聚能源各电厂附近的6种石灰石,在流化床反应器中对其进行固硫实验,研究探讨了石灰石品种、粒径及脱硫温度对石灰石固硫性能的影响.实验结果表明,兖矿地区石灰石粒径小于1.5 mm时,最佳脱硫温度在900℃左右.当粒径小于0.5 mm时,石灰石的钙利用率最高可达43.86%,并且钙利用率对温度的敏感度较高,不同...     

日本排烟脱硫的湿式石灰石法概况

在世界各国研制和已实现工业化的排烟脱硫方法中,比较盛行湿式石灰石法。因该法的原料石灰石价廉易得,工艺简单,能获得较高的脱硫率。例如在美国,有近80％     

天然矿物组合材料渗透反应墙修复地下水镉污染

实验模拟地下环境,以天然矿物材料石灰石、海泡石和膨润土作为可渗透反应墙(PRB)填充材料,采用正交实验法设计了16种可渗透反应器,研究了天然矿物组合材料组配对污染地下水模拟液中镉污染的修复效果、出水pH、有效孔隙度和渗透系数的影响,同时对机理进行了分析。实验结果显示,组合材料对镉去除率达99.8%以上,石灰石对处理效果贡献最大,增加石灰石用量,处理效果明显改善,当石灰石含量为10%及更高时,对含镉1.0 mg/L的污染地下水模拟液处理后镉浓度低于0.7μg/L,达到地下水质量标准GB/T 14848-93规定的II类水质标准;石灰石用量的增加对渗透系数影响不大,但出水pH呈弱碱性(7pH9),随反应时间延长逐渐降低并稳定于8。增加海泡石和膨润土用量对处理效果改善作用不大,但显著降低体系渗透系数,影响透水性。以正交实验直观分析法计算得到修复效果最优的PRB填充材料组配为石灰石/海泡石/膨润土=20/10/2(质量分数)。     

Limestone Dissolution in Flue Gas Scrubbing: Effect of Sulfite

Batch limestone dissolution experiments were carried out in a pH stat apparatus at 55°C with CO2 sparging and dissolved sulfite. Particle size distribution, utilization, sulfite in solution, limestone type, and the approach to calcite equilibrium were all found to contribute to the limestone reactivity. In the absence of sulfite, limestone dissolution was controlled solely by mass transfer. For a given stone under mass transfer control, film thickness was found to be independent of pH. The dissolution rate in the presence of sulfite was controlled by a combined surface kinetics/mass transfer regime. SEM micrographs supported this conclusion. A surface rate correlation was developed which accounted for observed inhibition by an inverse dependence on calcium sulfite concentration at the limestone surface. While the form of the rate expression was applicable to all stones, the surface rate constant was stone dependent. A computer code which accounted for mass transfer with surface kinetics was tested against experimental observations of four limestone types. Changes in pH and the concentrations of calcium, carbonate, sulfite, sulfate, and adipic acid were accurately modeled.     

Effective adsorbent for arsenic removal: core/shell structural nano zero-valent iron/manganese oxide

Recently, nano zero-valent iron (nZVI) has emerged as an effective adsorbent for the removal of arsenic from aqueous solutions. However, its use in various applications has suffered from reactivity loss resulting in a decreased efficiency. Thus, the aim of this study was to develop an effective arsenic adsorbent as a core/shell structural nZVI/manganese oxide (or nZVI/Mn oxide) to minimize the reactivity loss of the nZVI. As the major result, the arsenic adsorption capacities of the nZVI/Mn oxide for As(V) and As(III) were approximately two and three times higher than that of the nZVI, respectively. In addition, the As(V) removal efficiency of the nZVI/Mn oxide was maintained through 4 cycles of regeneration whereas that of the nZVI was decreased significantly. The enhanced reactivity and reusability of the nZVI/Mn oxide can be successfully explained by the synergistic interaction of the nZVI core and manganese oxide shell, in which the manganese oxides participate in oxidation reactions with corroded Fe²⁺ and subsequently retard the release of aqueous iron providing additional surface sites for arsenic adsorption. In summary, this study reports the successful fabrication of a core/shell nZVI/Mn oxide as an effective adsorbent for the removal of arsenic from aqueous solutions.     

Oxidative decomposition of formaldehyde by metal oxides at room temperature

Formaldehyde (HCHO) is still a major indoor air pollutant in Japanese air-tight houses and is the subject of numerous complaints regarding health disorders. Authors have developed a passive-type air-cleaning material and an air cleaner using manganese oxide (77% MnO₂) as an active component and successfully reduced indoor HCHO concentrations in newly built multi-family houses. In this study, the reactivity between manganese oxide and HCHO was discussed. We tested the removal efficiencies of several metal oxides for HCHO in a static reaction vessel and found manganese oxide could react with HCHO and release carbon dioxide even at room temperature. The reactivity and mechanisms were discussed for the proposed chemical reactions. A mass balance study proved that a major product through the heterogeneous reaction between manganese oxide and HCHO was carbon dioxide. Harmful by-products (HCOOH and CO) were not found.     

Photochemical Reactivities of N-Butane and Other Paraffinic Hydrocarbons

Photooxidation of lower-reactivity paraffinic hydrocarbons with nitrogen oxide was investigated. Maximum oxidant yield occurred at much lower ratios of hydrocarbon to nitrogen oxide than in more reactive systems such as propylene-nitrogen oxide mixtures. Appreciable oxidant yields were obtained even from irradiation of propane-nitrogen oxide mixtures at low ratios of nitrogen oxide to propane. These results, and nitrogen dioxide and oxidant dosages computed from these measurements, substantiate the importance of reactivity characteristics in formulation of decisions on control of hydrocarbons and nitrogen oxides.     

氧化镁烟气脱硫反应特性研究

利用实验室规模的鼓泡式反应装置,对比了碳酸钙、氧化镁和氧化镁/硫酸镁脱硫剂的反应活性,证实脱硫液中高浓度硫酸镁的存在是保证镁法脱硫效率高于钙法的重要因素,并考察了硫酸镁浓度、脱硫剂(氧化镁)浓度、烟气量、SO2浓度和吸收液温度等因素对脱硫效率的影响。结果表明,脱硫反应可以根据pH分为2个不同阶段;反应过程中脱硫效率随着硫酸镁浓度的增加而显著升高;烟气量增加将会导致脱硫效率有所下降;入口SO2浓度升高,脱硫效率下降;氧化镁浓度、温度对脱硫效率影响不显著。结合实验现象进行推断,氧化镁脱硫的反应过程受SO2在气液两相界面的传质扩散和其水解产物在液相的扩散控制。     

石灰和石灰石湿法脱硫系统运行控制指标探讨

钙基脱硫剂湿式脱硫系统是目前市场上广泛采用的烟气脱硫系统。文章分析了石灰和石灰石自身不同的物理化学特性对湿法脱硫系统运行控制指标的影响,得出了对于采用石灰和石灰石作为脱硫剂的湿式脱硫系统的最佳pH为8．0和5．8～6．2,脱硫浆液流量与烟气流量之比为10．0和5．6,钙硫比(化学过量比)为1．05～1．15和1．25～1．60。     

湿法脱硫石灰石浆液密度的敏感性分析

石灰石浆液的性能是影响湿法烟气脱硫效率的主要因素,而石灰石浆液的密度又是影响其性能的主要参数。现场制浆过程中,运行参数的变动会使得浆液密度值发生变化,从而影响浆液性能。因此,通过调整制浆系统运行参数,寻找石灰石浆液密度敏感因素,对优化浆液性能具有重要意义。以某600 MW火力发电厂湿式脱硫制浆系统作为研究对象,通过现场...     

Mitigation of low stream pH and its effects on salmonids

Crushed limestone (200 tonnes) was spread in bars on the bed of an acidic brook (mean pH 5.0) in Nova Scotia, Canada. A seasonally variable but significant increase in pH of running water resulted, and a longitudinal pH gradient over the limed section extended to the mouth of the brook. The effectiveness persisted after 3 years, during which pH downstream of the limestone increased an average of 0.4 pH units (range < 0.1-1.3 pH units) along with significantly increased Ca, Mg and acid neutralizing capacity. Total and exchangeable Al were not altered by the limestone and non-exchangeable forms dominated. The interstitial water was nearly neutral (mean pH 7.1) in limestone beds but it was acidic (mean pH 5.4) in gravel beds of the control section upstream. Spawning Atlantic salmon (Salmo salar) dug three times more redds in gravel of the limed section than in the control. Salmon fry survived and they were significantly more abundant in the limed section than in the control. The density of juvenile salmon increased over time, indicating a recovery of the population. The density of brook trout (Salvelinus fontinalis) also increased and trout fry were usually more abundant in the limed section than in the control. The observed benefits for salmonids suggest that small-scale application of limestone to stream beds and spawning sites can be used to mitigate the effects of low stream pH.