Harnessing dark fermentative hydrogen from pretreated mixture of food waste and sewage sludge under sequencing batch mode

Food waste and sewage sludge are the most abundant and problematic organic wastes in any society. Mixture of these two wastes may provide appropriate substrate condition for dark fermentative biohydrogen production based on synergistic mutual benefits. This work evaluates continuous hydrogen production from the cosubstrate of food waste and sewage sludge to verify mechanisms of performance improvement in anaerobic sequencing batch reactors. Volatile solid concentration and mixing ratio of food waste and sludge were adjusted to 5 % and 80:20, respectively. Five different hydraulic retention times (HRT) of 36, 42, 48, 72, and 108 h were tested using anaerobic sequencing batch reactors to find out optimal operating condition. Results show that the best performance was achieved at HRT 72 h, where the hydrogen yield, the hydrogen production rate, and hydrogen content were 62.0 mL H₂/g VS, 1.0 L H₂/L/day, and ~50 %, respectively. Sufficient solid retention time (143 h) and proper loading rate (8.2 g COD/L/day as carbohydrate) at HRT 72h led to the enhanced performance with better hydrogen production showing appropriate n-butyrate/acetate (B/A) ratio of 2.6. Analytical result of terminal-restriction fragment length polymorphism revealed that specific peaks associated with Clostridium sp. and Bacillus sp. were strongly related to enhanced hydrogen production from the cosubstrate of food waste and sewage sludge.     

耐酸厌氧消化污泥处理餐厨垃圾

采用耐酸驯化的厌氧消化污泥处理餐厨垃圾，在酸性条件下（pH=4．5），对实验装置容积负荷从1．0kgVS／（m3·d）分9次逐级增加到5．0kgVS／（m3·d）的过程进行了跟踪监测，并较深入地研究了驯化污泥代谢活性和处理效果。实验结果表明，pH4．5的耐酸厌氧消化污泥，最佳投加负荷约为4．5kgVS／（m3·d），此负荷下容积产气率，CH4含量平均值均达最大，分别为1．68m3／（m3·d），75．0％。耐酸厌氧消化装置持续增料运行46d，产甲烷菌仍能保持较高的活性，其COD去除率范围为40．4％-75．0％，仍能保持pH7．2时处理效果的65．0％-91．8％，表明在低pH、低碱度下实现稳定的产甲烷过程是可行的。     

Pilot‐scale field study for ammonia removal from lagoon biogas using an acid wet scrubber

The anaerobic activities in swine slurry storage and treatment generate biogas containing gaseous ammonia component which is a chemical agent that can cause adverse environmental impacts when released to the atmosphere. The aim of this pilot plant study was to remove ammonia from biogas generated in a covered lagoon, using a sulfuric acid wet scrubber. The data showed that, on average, the biogas contained 43.7 ppm of ammonia and its concentration was found to be exponentially related to the air temperature inside the lagoon. When the air temperature rose to 35°C and the biogas ammonia concentration reached 90 ppm, the mass transfer of ammonia/ammonium from the deeper liquid body to the interface between the air and liquid became a limiting factor. The biogas velocity was critical in affecting ammonia removal efficiency of the wet scrubber. A biogas flow velocity of 8 to 12 mm s^?1 was recommended to achieve a removal efficiency of greater than 60%. Stepwise regression revealed that the biogas velocity and air temperature, not the inlet ammonia concentration in biogas, affected the ammonia removal efficiency. Overall, when 73 g L^?1 (or 0.75 M) sulfuric acid solution was used as the scrubber solution, removal efficiencies varied from 0% to 100% with an average of 55% over a 40‐d measurement period. Mass balance calculation based on ammonium–nitrogen concentration in final scrubber liquid showed that about 21.3 g of ammonia was collected from a total volume of 1169 m³ of biogas, while the scrubber solution should still maintain its ammonia absorbing ability until its concentration reaches up to 1 M. These results showed promising use of sulfuric acid wet scrubber for ammonia removal in the digester biogas.     

金属铁铝对混凝强化初沉污泥中温厌氧消化的影响简

选取FeCl₃和AlCl₃·6H₂O作为混凝剂对城市污水进行一级强化混凝处理，降低二级生物处理的进水负荷，减少污水生物处理系统的能量消耗。主要研究混凝过程投加的金属盐对一级强化混凝产生的初沉污泥中温厌氧消化的影响。和剩余污泥相比，初沉污泥更适合厌氧消化处理，污泥降解性能和产气性能更高。当采用城市污水一级强化混凝处理时，污泥中的金属和金属盐水解引起的pH降低，使混凝强化初沉污泥的厌氧消化受到一定抑制。随着污泥中铝含量的降低和铁含量的增加，厌氧消化的COD降解率和挥发性固体（VS）降解率逐渐升高，生物气产量逐渐增大，产气速率加快。当混凝强化初沉污泥只含有铁时（铁含量为10.16 mg/L），混凝强化初沉污泥厌氧消化效果最好，产气稳定，而且产气速率高，生物气产量为237 mL，生物气甲烷含量为55.5%，降解单位VS产气量为0.80 L/g，均高于其他含铝的混凝强化初沉污泥。污泥中的铁对初沉污泥厌氧消化的抑制作用远远小于铝的作用，说明铁盐适合用于城市污水的一级强化混凝处理。     

UASB启动及不同HRT对老龄垃圾渗滤液处理效果的影响

在UASB反应器中接种好氧污泥培养厌氧颗粒污泥进行启动,研究不同HRT对老龄(13年)垃圾渗滤液对处理效果的影响情况。通过保持进水COD浓度不变、逐步缩短HRT从而提高容积负荷到40 g COD/(L.d)的方法,可以培育出直径为1～3 mm颗粒污泥,最终产气量稳定在100 L/d,甲烷含量在60%～70%之间,COD去除率保持在90%左右,污泥层最底部MLSS为81 g/L。逐步提高HRT依次为6、12、24、48和72 h考察其对处理效果的影响,当HRT为24 h时处理效果最好,COD去除率最高达到35%左右。     

Bioenergy production from diluted poultry manure and microbial consortium inside Anaerobic Sludge Bed Reactor at sub-mesophilic conditions

In this study, anaerobic treatability of diluted chicken manure (with an influent feed ratio of 1 kg of fresh chicken manure to 6 L of tap water) was investigated in a lab-scale anaerobic sludge bed (ASB) reactor inoculated with granular seed sludge. The ASB reactor was operated at ambient temperature (17–25°C) in order to avoid the need of external heating up to higher operating temperatures (e.g., up to 35°C for mesophilic digestion). Since heat requirement for raising the temperature of incoming feed for digestion is eliminated, energy recovery from anaerobic treatment of chicken manure could be realized with less operating costs. Average biogas production rates were calculated ca. 210 and 242 L per kg of organic matter removed from the ASB reactor at average hydraulic retention times (HRTs) of 13 and 8.6 days, respectively. Moreover, average chemical oxygen demand (COD) removal of ca. 89% was observed with suspended solids removal more than 97% from the effluent of the ASB reactor. Influent ammonia, on the other hand, did not indicate any free ammonia inhibition due to dilution of the raw manure while pH and alkalinity results showed stability during the study. Microbial quantification results indicated that as the number of bacterial community decreased, the amount of Archaea increased through the effective digestion volume of the ASB reactor. Moreover, the number of methanogens displayed an uptrend like archaeal community and a strong correlation (?0.645) was found between methanogenic community and volatile fatty acid (VFA) concentration especially acetate.     

耐酸厌氧消化污泥处理餐厨垃圾简

采用耐酸驯化的厌氧消化污泥处理餐厨垃圾，在酸性条件下（pH=4.5），对实验装置容积负荷从1.0 kg VS/（m³·d）分9次逐级增加到5.0 kg VS/（m³·d）的过程进行了跟踪监测，并较深入地研究了驯化污泥代谢活性和处理效果。实验结果表明，pH 4.5的耐酸厌氧消化污泥，最佳投加负荷约为4.5 kg VS/（m³·d），此负荷下容积产气率，CH₄含量平均值均达最大，分别为1.68 m³/（m³·d），75.0%。耐酸厌氧消化装置持续增料运行46 d，产甲烷菌仍能保持较高的活性，其COD去除率范围为40.4%~75.0%，仍能保持pH 7.2时处理效果的65.0%~91.8%，表明在低pH、低碱度下实现稳定的产甲烷过程是可行的。     

Combined anaerobic/aerobic digestion: effect of aerobic retention time on nitrogen and solids removal

A combined anaerobic/aerobic sludge digestion system was studied to determine the effect of aerobic solids retention time (SRT) on its solids and nitrogen removal efficiencies. After the anaerobic digester reached steady state, effluent from the anaerobic digester was fed to aerobic digesters that were operated at 2- to 5-day SRTs. The anaerobic system was fed with a mixture of primary and secondary sludge from a local municipal wastewater treatment plant. Both systems were fed once per a day. The aerobic reactor was continuously aerated with ambient air, maintaining dissolved oxygen level at 1.1 +/- 0.3 mg/L. At a 4-day or longer SRT, more than 11% additional volatile solids and 90% or greater ammonia were removed in the aerobic digester, while 32.8 mg-N/L or more nitrite/nitrate also was measured. Most total Kjeldahl nitrogen removal was via ammonia removal, while little organic nitrogen was removed in the aerobic digester.     

IC反应器处理高浓度硫酸盐废水的启动研究

采用木糖生产废水,进行了(IC)反应器处理高浓度硫酸盐有机废水的启动研究.结果表明,接种厌氧颗粒污泥,当进水COD/SO2-4值约为3.5时,控制COD负荷提高幅度为每次20%左右,经过26 d的驯化培养,COD和SO2-4负荷分别可达20 kg/(m3·d)和5.5 kg/(m3·d),COD去除率达到80%以上,硫...     

Biogas production from anaerobic digestion of food waste and relevant air quality implications

Biopower can diversify energy supply and improve energy resiliency. Increases in biopower production from sustainable biomass can provide many economic and environmental benefits. For example, increasing biogas production through anaerobic digestion of food waste would increase the use of renewable fuels throughout California and add to its renewables portfolio. Although a biopower project will produce renewable energy, the process of producing bioenergy should harmonize with the goal of protecting public health. Meeting air emission requirements is paramount to the successful implementation of any biopower project. A case study was conducted by collecting field data from a wastewater treatment plant that employs anaerobic codigestion of fats, oils, and grease (FOG), food waste, and wastewater sludge, and also uses an internal combustion (IC) engine to generate biopower using the biogas. This research project generated scientific information on (a) quality and quantity of biogas from anaerobic codigestion of food waste and municipal wastewater sludge, (b) levels of contaminants in raw biogas that may affect beneficial uses of the biogas, (c) removal of the contaminants by the biogas conditioning systems, (d) emissions of NO_x, SO₂, CO, CO₂, and methane, and (e) types and levels of air toxics present in the exhausts of the IC engine fueled by the biogas. The information is valuable to those who consider similar operations (i.e., co-digestion of food waste with municipal wastewater sludge and power generation using the produced biogas) and to support rulemaking decisions with regards to air quality issues for such applications.

Implications: Full-scale operation of anaerobic codigestion of food waste with municipal sludge is viable, but it is still new. There is a lack of readily available scientific information on the quality of raw biogas, as well as on potential emissions from power generation using this biogas. This research developed scientific information with regard to quality and quantity of biogas from anaerobic co-digestion of food waste and municipal wastewater sludge, as well as impacts on air quality from biopower generation using this biogas. The need and performance of conditioning/pretreatment systems for biopower generation were also assessed.     

EGSB反应器处理产氢发酵液

以厌氧颗粒污泥为接种污泥，对厌氧颗粒污泥膨胀床（EGSB）反应器处理产氢发酵液的启动性能进行了研究。结果表明，在温度为（35±1）℃，水力停留时间（HRT）为6h的条件下，逐渐提高进水COD，经过40d连续运行，EGSB反应器启动成功。容积负荷达到14kgCOD／（m3·d）时，COD去除率约为80％，产气量为26．84L／d，甲烷含量为57．9％。     

金属铁铝对混凝强化初沉污泥中温厌氧消化的影响

选取FeCl3和AlCl2·6H2O作为混凝剂对城市污水进行一级强化混凝处理，降低二级生物处理的进水负荷，减少污水生物处理系统的能量消耗。主要研究混凝过程投加的金属盐对一级强化混凝产生的初沉污泥中温厌氧消化的影响。和剩余污泥相比，初沉污泥更适合厌氧消化处理，污泥降解性能和产气性能更高。当采用城市污水一级强化混凝处理时，污泥中的金属和金属盐水解引起的pH降低，使混凝强化初沉污泥的厌氧消化受到一定抑制。随着污泥中铝含量的降低和铁含量的增加，厌氧消化的COD降解率和挥发性固体（Vs）降解率逐渐升高，生物气产量逐渐增大，产气速率加快。当混凝强化初沉污泥只含有铁时（铁含量为10．16mg／L），混凝强化初沉污泥厌氧消化效果最好，产气稳定，而且产气速率高，生物气产量为237mL，生物气甲烷含量为55．5％，降解单位Vs产气量为0．80L／g，均高于其他含铝的混凝强化初沉污泥。污泥中的铁对初沉污泥厌氧消化的抑制作用远远小于铝的作用，说明铁盐适合用于城市污水的一级强化混凝处理。     

Influence of a three-phase separator configuration on the performance of an upflow anaerobic sludge bed reactor treating wastewater from a fruit-canning factory.

The objective of this study was to investigate the influence of a three-phase separator configuration on the performance of an upflow anaerobic sludge bed (USAB) treating wastewater from a fruit canning factory. The performances of two 30-L UASB reactors--one with a modified three-phase separator giving a spiral flow pattern and the other with a conventional configuration-were investigated in parallel. Wastewater, with a chemical oxygen demand (COD) concentration between 2000 and 7000 mg/L, was obtained from a fruit-canning factory. Based on the effluent data of the first 100 operation days, the UASB with the three-phase separator giving spiral flow patterns yielded up to 25% lower biomass washout. It also showed better efficiencies in treating wastewater--up to 60% lower effluent COD, up to 20% higher COD percent removal, and up to 29% higher biogas production. This work presents evidence of an improvement on the conventional physical design of a UASB.     

Coupling digestion in a pilot-scale UASB reactor and electrochemical oxidation over BDD anode to treat diluted cheese whey

The efficiency of the anaerobic treatment of cheese whey (CW) at mesophilic conditions was investigated. In addition, the applicability of electrochemical oxidation as an advanced post-treatment for the complete removal of chemical oxygen demand (COD) from the anaerobically treated cheese whey was evaluated. The diluted cheese whey, having a pH of 6.5 and a total COD of 6 g/L, was first treated in a 600-L, pilot-scale up-flow anaerobic sludge blanket (UASB) reactor. The UASB process, which was operated for 87 days at mesophilic conditions (32?±?2 °C) at a hydraulic retention time (HRT) of 3 days, led to a COD removal efficiency between 66 and 97 %, while the particulate matter of the wastewater was effectively removed by entrapment in the sludge blanket of the reactor. When the anaerobic reactor effluent was post-treated over a boron-doped diamond (BDD) anode at 9 and 18 A and in the presence of NaCl as the supporting electrolyte, complete removal of COD was attained after 3–4 h of reaction. During electrochemical experiments, three groups of organochlorinated compounds, namely trihalomethanes (THMs), haloacetonitriles (HANs), and haloketons (HKs), as well as 1,2-dichloroethane (DCA) and chloropicrin were identified as by-products of the process; these, alongside free chlorine, are thought to increase the matrix ecotoxicity to Artemia salina.     

Anaerobic codigestion of municipal, farm, and industrial organic wastes: a survey of recent literature.

Codigestion of organic wastes is a technology that is increasingly being applied for simultaneous treatment of several solid and liquid organic wastes. The main advantages of this technology are improved methane yield because of the supply of additional nutrients from the codigestates and more efficient use of equipment and cost-sharing by processing multiple waste streams in a single facility. Many municipal wastewater treatment plants (WWTPs) in industrialized countries currently process wastewater sludge in large digesters. Codigestion of organic wastes with municipal wastewater sludge can increase digester gas production and provide savings in the overall energy costs of plant operations. Methane recovery also helps to reduce the emission of greenhouse gases to the atmosphere. The goal of this literature survey was to summarize the research conducted in the last four years on anaerobic codigestion to identify applications of codigestion at WWTPs. Because the solids content in municipal wastewater sludge is low, this survey only focuses on codigestion processes operated at relative low solids content (slurry mode). Semi-solid or solid codigestion processes were not included. Municipal wastewater sludge, the organic fraction of municipal solid waste, and cattle manure (CAM) are the main wastes most often used in codigestion processes. Wastes that are codigested with these main wastes are wood wastes, industrial organic wastes, and farm wastes. These are referred to in this survey as codigestates. The literature provides many laboratory studies (batch assays and bench-scale digesters) that assess the digestibility of codigestates and evaluate the performance and monitoring of codigestion, inhibition of digestion by codigestates, the design of the process (e.g., single-stage or two-stage processes), and the operation temperature (e.g., mesophilic or thermophilic). Only a few reports on pilot- and full-scale studies were found. These evaluate general process performance and pretreatment of codigestates, energy production, and treatment costs.     

Steam-explosion pretreatment for enhancing anaerobic digestion of municipal wastewater sludge.

This study evaluated the use of steam explosion as a pretreatment for municipal wastewater treatment sludges and biosolids as a technique for enhancing biogas generation during anaerobic digestion. Samples of dewatered anaerobic digester effluent (biosolids) and a mixture of thickened waste activated sludge (TWAS) and biosolids were steam-exploded under differing levels of intensity in this study. The results indicate that steam explosion can solublize components of these sludge streams. Increasing the intensity of the steam-explosion pressure and temperature resulted in increased solublization. The steam-explosion pretreatment also increased the bioavailability of sludge components under anaerobic digestion conditions. Increasing the steam-explosion intensity increased the ultimate yield of methane during anaerobic digestion. Batch anaerobic digestion tests suggested that pretreatment at 300 psi was the most optimal condition for enhanced biogas generation while minimizing energy input. Semicontinuous anaerobic digestion revealed that the results that were observed in the batch tests were sustainable in prolonged operation. Semicontinuous digestion of the TWAS/biosolids mixture that was pretreated at 300 psi generated approximately 50% more biogas than the controls. Semicontinuous digestion of the pretreated biosolids resulted in a 3-fold increase in biogas compared with the controls. Based on capillary suction test results, steam-explosion pretreatment at 300 psi improved the dewaterability of the final digested sludge by 32 and 45% for the TWAS/ biosolids mixture and biosolids, respectively, compared with controls. The energy requirements of the nonoptimized steam-explosion process were substantially higher than the additional energy produced from enhanced digestion of the pretreated sludge. Substantial improvements in energy efficiency will be required to make the process viable from an energy perspective.     

城市垃圾焚烧渗沥液中Ca2+对厌氧EGSB处理效果的影响简

研究了城市生活垃圾焚烧厂渗沥液中Ca²⁺对厌氧颗粒污泥膨胀床反应器（EGSB）处理效果的影响，并采用静态实验方法考察了Ca²⁺对厌氧颗粒污泥产甲烷活性的影响。实验结果表明，进水COD为17 000 mg/L的条件下，当Ca²⁺浓度低于6 000 mg/L时，EGSB对COD去除率达93%以上；当Ca²⁺浓度高于6 000 mg/L时，COD去除率随运行时间明显下降，并在污泥中形成大量沉淀。静态实验结果表明，废水中低浓度Ca²⁺促进了厌氧颗粒污泥的产甲烷活性，但高浓度Ca²⁺明显抑制了其产甲烷活性，这是导致高Ca²⁺浓度条件下EGSB对COD去除率降低的主要原因。研究表明，颗粒污泥产甲烷活性恢复程度随Ca²⁺浓度增加而减弱。     

餐厨垃圾的高温厌氧消化处理研究

在55℃条件下，研究了餐厨垃圾高温厌氧消化过程中pH、VFA、总磷、产气量以及COD、TS和VS的变化，结果表明：在消化过程中pH先下降后上升，总VFA浓度增大，而其中游离态VFA浓度先增大后减少。消化过程总产气量为43 211 mL，整个过程消耗TS的平均产气率为158.98 mL/g TS，COD去除率为38.76％，总磷去除率达到98.87％，底物TS和VS去除率分别31.71％和50.24％。经过厌氧消化处理，沼渣中不含对人体和许多动物有害的沙门氏菌、痢疾杆菌、大肠杆菌及粪大肠杆菌，而富含有机质、氮、磷和钾等的营养物质和芽孢杆菌、防线菌等有益菌种。     

Application of dynamic models to estimate greenhouse gas emission by wastewater treatment plants of the pulp and paper industry

Greenhouse gas (GHG) emission in wastewater treatment plants of the pulp-and-paper industry was estimated by using a dynamic mathematical model. Significant variations were shown in the magnitude of GHG generation in response to variations in operating parameters, demonstrating the limited capacity of steady-state models in predicting the time-dependent emissions of these harmful gases. The examined treatment systems used aerobic, anaerobic, and hybrid—anaerobic/aerobic—biological processes along with chemical coagulation/flocculation, anaerobic digester, nitrification and denitrification processes, and biogas recovery. The pertinent operating parameters included the influent substrate concentration, influent flow rate, and temperature. Although the average predictions by the dynamic model were only 10 % different from those of steady-state model during 140 days of operation of the examined systems, the daily variations of GHG emissions were different up to ±30, ±19, and ±17 % in the aerobic, anaerobic, and hybrid systems, respectively. The variations of process variables caused fluctuations in energy generation from biogas recovery by ±16, ±17, and ±14 % in the three examined systems, respectively. The lowest variations were observed in the hybrid system, showing the stability of this particular process design.