垃圾焚烧发电厂渗滤液MBR-NF截留液中腐植酸的超滤分离回收

垃圾焚烧发电厂渗滤液MBR-NF膜截留液因含有高浓度的难降解有机物和无机盐而难以处理。考虑其所含有机物大部分为腐植酸，可加于资源利用。本研究采用超滤对MBR—NF膜截留液中的腐植酸进行分离回收。实验结果表明，超滤能有效分离截留液中有机物和无机盐离子，分离因子与体积浓缩倍数（CF）呈良好的线性关系；回收样品的腐植酸含量达到36g／L以上，重金属含量低于相关标准限值，表明采用超滤分离回收垃圾焚烧发电厂渗滤液MBR-NF截留液中的腐植酸是可行的。     

MBR-NF截留液中腐植酸的纳滤分离浓缩特性

MBR-NF截留液是一类难处理的高浓度有机废水,其所含有机物几乎都是腐植酸,可考虑资源利用。实验室内采用纳滤对其所含腐植酸进行分离浓缩。引入分离因子来表征纳滤的分离效果。实验结果表明,分离因子(SF)与体积浓缩倍数(CF)有很好的线性关系,浓缩倍数为5时,截留液中有机碳浓度为9 413 mg/L,重金属浓度处于mg/L水平,分离因子达到2.76,表明纳滤可有效地将MBR-NF截留液中的腐植酸与无机盐分离,并进行浓缩。     

Fenton法处理垃圾渗滤液MBR-NF浓缩液

采用Fenton法处理MBR-NF浓缩液,考察了FeSO4·7H2O投加量、n(H2O2)/n(Fe2+)投加比、初始pH对渗滤液MBR-NF浓缩液处理效果的影响,并在最佳实验条件下,探讨浓缩液富里酸(FA)、亲水性有机物(HyI)组分在Fenton氧化前后组成的变化。研究结果表明,在FeSO4·7H2O投加量为0.055 mol/L、n(H2O2)/n(Fe2+)投加比为4、初始pH为7.58时,对COD、腐植酸(UV254)、色度(CN)的去除率分别为79.6%、93.7%和97.8%。Fenton氧化后,浓缩液中有机物组分含量发生了较大变化,腐植酸含量下降,HyI成为渗滤液溶解性有机物主要成分。紫外-可见光谱表明,Fenton法对FA去除效果较好,而对HyI氧化效果较差;傅立叶红外光谱显示,经Fenton氧化后,FA的结构发生了明显变化,而HyI则变化不明显。     

正渗透膜过滤特性及污染物截留性能

采用Na Cl为汲取液溶质,研究正渗透膜分离过程中膜朝向、汲取液溶质浓度和错流速率对膜过滤性能的影响,以及正渗透膜对Na Cl、生活污水和垃圾渗滤液的污染物截留性能。结果表明,活性层朝向汲取液(AL-DS)时水通量(Jw)明显大于活性层朝向原料液(AL-FS)时,但随时间下降较快;Jw和溶质反向扩散通量(Js)均与汲取液溶质浓度正相关,但非线性增加,原因与内浓差极化有关;Jw同样与错流速率正相关,但随错流速率增加不明显。以葡萄糖为汲取液溶质时,正渗透膜对Na Cl的截留率能够达到90%以上。相同汲取液浓度下,处理生活污水时的Jw略大于垃圾渗滤液。正渗透膜对2种废水的污染物截留效果均较好。处理生活污水时,总有机碳和总氮的平均截留率分别为82%和90%以上;处理垃圾渗滤液时则分别能达到77%和95%以上。正渗透膜对渗滤液中的二价离子(钙、镁)的截留率达到98%以上。     

TiO2光催化复合分离膜对水中天然有机物的去除

在水源污染越来越严重、水质标准日益严格的背景下，超滤（UF）已逐渐成为替代饮用水常规处理技术的最佳选择之一。本研究中采用相转化法，将聚偏氟乙烯（PVDF）、聚乙二醇（PEG）和二氧化钛（TiO2）共混制得光催化复合分离膜并对其进行扫描电子显微镜（SEM）、原子力显微镜（AFM）和X射线能谱仪（EDS）等相应的表征。比较了有无光照条件下，PVDF-PEG和PVDF—PEG—TiO2膜对腐殖酸（HA）的截留和超滤过程中的膜污染情况。研究结果表明，TiO2光催化复合分离膜能提高对水中天然有机物的去除并同时降低膜污染。紫外光照强度越强，PVDF-PEG—TiO2膜的抗污染性能越好。另外，光催化能更有效地减少超滤初始浓度较低的腐殖酸溶液过程中的膜通量衰减。     

海藻酸钠-超滤组合处理含铅废水

胶团强化超滤技术(MEUF)中通常采用表面活性剂作为外加有机物,存在价格昂贵且具有二次污染的风险。本研究选取天然有机物海藻酸钠作为外加物,研究了海藻酸钠强化超滤去除含Pb废水的特性及影响因素。实验结果表明,Freundlich模型可用于海藻酸钠溶液对Pb2+的吸附过程;海藻酸钠及其与Pb络合物的红外光谱分析表明,海藻酸钠中的OC-OH基团在吸附Pb2+中起着重要的作用。当Pb2+的浓度40 mg/L,海藻酸钠投加量为100 mg/L,pH7时,MWCO为4 kDa、6 kDa、10 kDa、30 kDa、50 kDa和70 kDa的膜均可实现对其的高效截留,截留效率均达到95%以上。随着pH值的升高,超滤膜对于Pb2+的截留效果越好。超滤浓缩液在pH值调节到13时,可将几乎100%的Pb回收。     

石化综合污水处理厂出水溶解性微生物产物的特性

溶解性微生物产物(soluble microbial products,SMP)是生化系统出水残留COD的主要组成部分,通过采用分子量截留超滤分离、有机物树脂分离等方法对某石化综合污水处理厂出水SMP的分子量分布、亲水特性进行了分析研究.结果表明,水样中的SMP占出水残留COD的85%左右。SMP中主要成分是蛋白质,出水中小于1 kDa的有机物是SMP中的主要物质。树脂分离实验表明,亲水性有机物和疏水酸性有机物分别约占出水SMP的50%和20%,是需要进一步处理削减的主要物质类别。     

TiO2光催化复合分离膜对水中天然有机物的去除

在水源污染越来越严重、水质标准日益严格的背景下,超滤(UF)已逐渐成为替代饮用水常规处理技术的最佳选择之一。本研究中采用相转化法,将聚偏氟乙烯(PVDF)、聚乙二醇(PEG)和二氧化钛(TiO₂)共混制得光催化复合分离膜并对其进行扫描电子显微镜(SEM)、原子力显微镜(AFM)和X射线能谱仪(EDS)等相应的表征。比较了有无光照条件下,PVDF-PEG和PVDF-PEG-TiO₂膜对腐殖酸(HA)的截留和超滤过程中的膜污染情况。研究结果表明,TiO₂光催化复合分离膜能提高对水中天然有机物的去除并同时降低膜污染。紫外光照强度越强,PVDF-PEG-TiO₂膜的抗污染性能越好。另外,光催化能更有效地减少超滤初始浓度较低的腐殖酸溶液过程中的膜通量衰减。     

不同垃圾渗滤液组合处理工艺中DOM的变化特征

为了快速表征垃圾渗滤液处理过程中有机物的特性变化,分别采用紫外光谱和三维荧光光谱对2种垃圾渗滤液处理工艺不同单元溶解性有机物(DOM)的变化进行了系统分析。结果表明,二级RO和厌氧+好氧+MBR+NF+RO工艺对渗滤液COD和NH3-N的去除率分别为98.7%、99.0%和98.8%、98.6%。随着处理过程的进行,2个处理工艺中DOM的SUVA254、E253/E203分别由0.74、0.33和0.46、0.12下降至0.015、0.014和0.010、0.012,有机物的芳香性和不饱和性下降,脂肪链芳香烃化合物开始增加。不同处理阶段渗透液DOM三维荧光光谱表明,随着处理过程的进行,类富里酸和类蛋白物质的含量逐渐下降,芳构化程度开始降低。其中二级RO系统对渗滤液中类富里酸物质的去除效果较好,而厌氧-好氧-MBR-NF-RO工艺中,类酪氨酸物质主要通过微生物降解去除,NF和RO膜对类富里酸和类腐殖酸物质的截留效果较好。     

老港填埋场渗滤液性质随工艺变化研究

经老港填埋场渗滤液处理系统的各处理单元处理后的流出液,用不同孔径的系列膜进行了梯度分离。分离前后的渗滤液进行了TOC、TP、TN、氨氮和可溶性P等参数的测定,并建立了各参数与不同孔径膜的关系。结果表明,此工艺对老港填埋场渗滤液的处理具有一定的功效;随着处理工艺的进行,渗滤液的组成发生了较大的改变,其中细胶体部分的百分含量增加,而可溶性部分降低;渗滤液的绝大部分污染物质集中于可溶性部分,而渗滤液中的P主要与大分子的悬浮物和粗胶体结合。     

Characteristics of leachate from pyrolysis residue of sewage sludge

The pyrolysis residue (SP) of sewage sludge (SS) produced at 500 degrees C was subjected to batch and column leaching tests to investigate the release of its organic and inorganic constituents and metals. For comparison, incineration ash (SI) obtained from a SS incinerator was also tested. Pyrolysis and incineration reduced organic matter of SS from 0.78 kg kg(-1)-dry SS to 0.16 and 0.01 kg kg(-1)-dry SS, respectively. Heavy metals remained in SP without being volatilized, although Cd and Pb were transferred into the off-gas during incineration. In the batch leaching test with the leaching liquid-to-solid mass ratio (L/S)=10, the pH of the SS, SP, and SI filtrates was 6.3, 7.9, and 11.0, respectively. The total organic carbon concentrations were in the order SS (877 l mg l(-1))>SP (99 mg l(-1))>SI (26 mg l(-1)). The SP and SI filtrates met the landfill standard for the Cd and Pb concentrations (<0.3 mg l(-1)). In the column tests, although the SP contained more organic matter than that of SI, its carbon discharge into the leachate under aerobic conditions was similar to that of SI under anaerobic conditions. The leaching of heavy metals, such as Cd, Cr, Pb, and Zn, was also suppressed in SP during the active decomposition of organic matter. We demonstrated that pyrolysis reduces the potential release of pollutants from sewage sludge in landfill, making it a promising method of treating sewage sludge before landfilling.     

EGSB反应器处理城市生活垃圾沥滤液

采用膨胀颗粒污泥床(EGSB)反应器对城市生活垃圾焚烧厂产生的垃圾沥滤液进行处理。实验结果表明:中温条件下,当COD浓度为55 000 mg/L左右,有机容积负荷(OLR)为22.8 kg COD/(m3.d)时,EGSB对垃圾沥滤液具有较好的的处理效果,COD去除率可达94.2%。当进水COD为72 000 mg/L左右时,为保证反应器的稳定运行,OLR应降低至18.2 kg COD/(m3.d),此时COD去除率可以达到88%左右,出水COD平均为9 103 mg/L。垃圾沥滤液和EGSB处理出水均以小分子量有机物为主,其中<4 kDa的有机物分别占76.5%和74.4%。EGSB对整个分子量区间的溶解性有机物都有较好的处理效果,其中对大分子有机物的处理效率相对更高。     

Heavy metals mobility in full-scale bioreactor landfill: initial stage

Selected heavy metals (HMs) including Cd, Cr, Cu, Ni, Pb and Zn initially released from a full-scale bioreactor landfill were monitored over the first 20 months of operation. At the initial landfill stage, the leachate exhibited high HMs release, high organic matter content (27000-43000gl(-1) of TOC) and low pH (5-6). By the fifth month of landfilling, the methanogenic stage had been established, and HMs release was reduced below the Chinese National Standards. Total released HMs accounted for less than 1% of landfill deposited during the investigated period. Most landfill HMs were inorganic. Fourier-transform infrared (FT-IR) spectra data and model calculations using Visual MINTEQ indicated that humic substances strongly affected the mobility of organic fractions of HMs in the methanogenic landfill. The initial rates of HMs release could be enhanced by recycling the leachate back to bioreactor landfill, but the total quantity released may be reduced by early establishment of methanogenic stage in bioreactor landfill.     

Role of organic and black carbon in the chemical composition of atmospheric aerosol at European background sites

The mass concentrations of inorganic ions, water-soluble organic carbon, water-insoluble organic carbon and black carbon were determined in atmospheric aerosol collected at three European background sites: (i) the Jungfraujoch, Switzerland (high-alpine, PM_2.5 aerosol); (ii) K-puszta, Hungary (rural, PM_1.0 aerosol); (iii) Mace Head, Ireland (marine, total particulate matter). At the Jungfraujoch and K-puszta the contribution of carbonaceous compounds to the aerosol mass was higher than that of inorganic ions by 33% and 94%, respectively. At these continental sites about 60% of the organic carbon was water soluble, 55–75% of the total carbon proved to be refractory and a considerable portion of the water soluble, refractory organic matter was composed of humic-like substances. At Mace Head the mass concentration of organic matter was found to be about twice than that of nonsea-salt ions, 40% of the organic carbon was water soluble and the amount of highly refractory carbon was low. Humic-like substances were not detected but instead low molecular weight carboxylic acids were responsible for about one-fifth of the water-soluble organic mass. These results imply that the influence of carbonaceous compounds on aerosol properties (e.g. hygroscopic, optical) might be significant.     

Fluorescence characterization of cross flow ultrafiltration derived freshwater colloidal and dissolved organic matter

3-D fluorescence excitation-emission matrix (EEM) spectrophotometry was applied to investigate the fluorescence characterization of colloidal organic matter (COM) and truly dissolved organic matter (DOM) from an urban lake and a rural river fractionated by the cross flow ultrafiltration (CFUF) process with a 1kDa membrane. Relatively high tryptophan-like fluorescence intensity is found in the urban water, although the fluorescence of both water samples is mainly dominated by humic/fulvic-like fluorophores. During CFUF processing, the fluorescence intensities of humic/fulvic-like materials in the retentate increased rapidly, but a slight increase is also observed in the permeate fluorescence intensity. Very different ultrafiltration behaviour occurred with respect to the tryptophan-like fluorophore, where both permeate and retentate fluorescence intensities increase substantially at the beginning of the CFUF process, then tend to remain constant at high concentration factor (cf) values. Comparison with tryptophan standards demonstrates that freshwater tryptophan-like fluorescence is not dissolved and 'free', but is, in part, colloidal and related to the ultrafiltration behaviour of fulvic/humic-like matter. A good linear relationship between the retentate humic/fulvic-like fluorescence intensity and organic carbon concentration further reveals that fluorescent humic/fulvic-like substances are the dominant contributors to colloidal organic carbon, mainly in the colloidal fraction.     

渗滤液中污染物的粒度分布及其应用

渗滤液是一种难于处理的废水.论述了渗滤液中污染物的粒度分布.指出了不同粒度污染物中胶体态组分富含难降解有机物和重金属,其性质稳定,含量较高,对渗滤液的处理工艺选择和去除效果影响重大.最后对渗滤液的资源化进行了初步探讨.     

Investigation of 1,4-dioxane originating from incineration residues produced by incineration of municipal solid waste

As a groundwater contaminant, 1,4-dioxane is of considerable concern because of its toxicity, refractory nature to degradation, and rapid migration within an aquifer. Although landfill leachate has been reported to contain significant levels of 1,4-dioxane, the origin of 1,4-dioxane in leachate has not been clarified until now. In this study, the origins of 1,4-dioxane in landfill leachate were investigated at 38 landfill sites and three incineration plants in Japan. Extremely high levels of 1,4-dioxane 89 and 340 microg l(-1), were detected in leachate from two of the landfill sites sampled. Assessments of leachate and measurement of 1,4-dioxane in incineration residues revealed the most likely source of 1,4-dioxane in the leachate to be the fly ash produced by municipal solid waste incinerators. Effective removal of 1,4-dioxane in leachate from fly ash was achieved using heating dechlorination systems. Rapid leaching of 1,4-dioxane observed from fly ash in a sequential batch extraction indicated that the incorporation of a waste washing process could also be effective for the removal of 1,4-dioxane in fly ash.