中空纤维膜生物反应器处理生活污水的特性

中空纤维膜生物反应器生活污水处理特性的试验研究结果表明：Ｄ ＨＲＴ为１．５ｈ,ＣＯＤ容积负荷为５．７６ｋｇ／（ｍ＾３·ｄ）条件下,均可实现９０％以上的ＣＯＤ去除率;对ＮＨ３－Ｎ的去除率可稳定在９０％以上,高ＭＬＳＳ浓度８０００－１００００ｍｇ·Ｌ）提供了内部厌氧环境,使膜生物反应器的Ｔ－Ｎ去除率可达５０－６０％,中空纤维生物反应器处理高效,不受冲击负荷影响,操作管理方便,其生活物反应器体积比常规生     

错流式膜-生物反应器处理生活污水及其生物学研究

用错流式膜－生物反应器（ＣｒｏｓｆｌｏｗＭｅｍｂｒａｎｅＢｉｏＲｅａｃｔｏｒ简称ＣＭＢＲ）进行处理生活污水试验并研究其生物动力学参数．结果表明：当ＨＲＴ为５ｈ,ＳＲＴ为１５ｄ,膜面流速为４ｍ／ｓ,膜通量为７５、１５０Ｌ／（ｍ２·ｈ）时,ＣＭＢＲ处理生活污水试验的去除率为：ＣＯＤ＞９７％、ＮＨ３－Ｎ＞９７％、浊度≥９８％;对ＳＳ和总Ｅ．ｃｏｌｉ则达到１００％,出水水质优于建设部生活杂用水回用标准ＣＪ２５．１－８９．生物相分析表明,污泥中没有原、后生动物,只有菌胶团．推导了ＣＭＢＲ稳态运行时的生物浓度计算公式,进而求得表观产率因数Ｙｇ为０．６５,衰减常数Ｋｄ为０．１ｄ－１．     

超滤膜-生物反应器处理生活污水及其水力学研究

用超滤膜－生物反应器进行处理生活污水试验并研究其水力学行为。结果表明,当ＨＲＴ为５ｈ、ＳＲＴ为３０ｄ、膜面流速为４ｍ／ｓ膜流量为７５Ｌ／（ｍ＾２·ｈ）时,试验出水水质优于建设部生活杂用水水质标准ＣＪ２５．１－８９,可直接回用。     

影响一体式好氧膜生物反应器膜清洗周期的几个因素

一体式好氧中空纤维膜生物反应器不同操作条件下处理生活污水的试验结果表明,在膜通量１０．４Ｌ／ｍ＾２．ｈ）污泥龄２０ｄ,污泥去除负荷（ＣＯＤ／ＶＳＳ）为０．２２ｋｇ（ｋｇ．ｄ）的正常稳定运行条件下,该系统可在整个膜寿命期限内（３－５ａ）不同洗燕得到优质出水;ＣＯＤ〈２０ｍｇ／Ｌ,ＮＨ３－Ｎ〈１．０ｍｇ／Ｌ,无色无味透明,未检出大肠杆菌,其中,污泥去除负荷,系统运行稳定状况和反应器流态是影响膜清洗周期     

UBF反应器处理鸡粪混合液离心出水的试验研究

采用ＵＢＦ反应器在中温３５℃对蛋鸡场鸡粪混合液离心出水进行处理，试验结果表明，在进水ＣＯＤＣＲ为１９５００ｍｇ／Ｌ，ＮＨ３－Ｎ为１８００ｍｇ／Ｌ的条件下，水力停留时间为２４．８５ｈ，容积负荷为１８．８４ＫＣＯＤＣｒ／ｍ＾３．ｄ时〉ＣＩＯＤＣｒ去除率为８０．２８％，ＢＯＤ３去除率为８９．６５％，产气率为０．５５８ｍ＾３／去除ＫｇＣＯＤＣｒ，反应器运行状态良好。     

上流式厌氧污泥床(UASB)处理制药废水的研究

用上流式厌氧污泥床（ＵＡＳＢ）在自然温度条件下处理ＶＣ、ＳＤ和葡萄糖生产废水。反应器容积１００Ｌ,发酵温度－２４℃,进水ＣＯＤｃｒ３０００－５０００ｍｌ／Ｌ,有机负荷３－６ｋｇＣＯＤ／（ｍ＾３．ｄ）,ＨＲＴ为１８－２４ｈ,产气率达到０．３ｍ＾３／ｋｇＣＯＤ,甲烷含量７０％,ＣＯＤｃｒ去除率达到９０％,取得较好的实验效果,为厌氧处理较低深度的制药废水找出可行的途径。     

厌氧-水解反应器稳定运行的试验研究

采用造纸废水对厌氧水－水解反应器的启动、运行进行试验研究。结果表明，当ＭＬＶＳＳ在１５ｇ／Ｌ左右，ＣＯＤ容积负荷为１．４５ｋｇ／（ｍ＾３·ｄ），水力负荷为２．０ｍ＾３／（ｍ＾２·ｈ），水国停留时间为４ｈ，污泥颗粒化程度较高，反应器运行效果稳定可靠。     

厌氧膜生物反应器处理高浓度食品废水的应用

采用由完全混合的厌氧生物反应器和板杠式超滤膜组成的膜生物反应器对高浓度食品放心水进行处理,考察了厌氧膜生物反应器的处理效果及其对负荷、水力停留时间等的稳定性,膜组件装填面积为０．６４ｍ＾２,膜材质为聚醚砚（ＰＥＳ）,膜截贸分子量为２００００。结果表明：ＣＯＤ负荷在２～３ｋｇ／（ｍ＾３．ｄ）时,膜出水ＣＯＤ去除率可达８０％～９０％,当ＣＯＤ负荷超过４．５ｋｇ（ｍ＾３．ｄ）时,混合液ＶＦＡ出现积累,Ｃ     

曝气生物滤池处理生活污水试验

曝气生物滤池具有体积小、处理效率高等特点。研究结果表明,曝气生物滤池处理生活污水在０．５３ｍ／ｈ的水力负荷下,ＢＯＤ５、ＣＯＤ、ＳＳ、ＮＨ４－Ｎ和ＴＮ的平均去除率９５．３％、９２．６％、９６．７％、９１．８５％和８５．１％,平均出水浓度分别为３．０ｍｇ／Ｌ、１２．５ｍｇ／Ｌ、２．５ｍｇ／Ｌ、１．７ｍｇ／Ｌ和４．３ｍｇ／Ｌ。     

两相厌氧工艺处理含硫酸盐有机废水的研究

采用硫酸盐还原－生物脱除硫化物－甲烷化的方法,考察了酸相反应器的运行效果,以及系统的操作条件和运行情况等。结果表明：①以拉西瓷环为填料的厌氧滤地作为酸相反应器,容积负荷可达５ｋｇ／（ｍ３·ｄ）,去除率为８０％;②在脱硫化物反应器中,硫化物去除率大于９０％,其中９５％的硫化物转化为Ｓ０;③甲烷相反应器ＣＯＤ容积负荷可达１５．８ｋｇ／（ｍ３·ｄ）,ＣＯＤ去除率为８３．３％。整体工艺ＣＯＤ去除率为８７．６％,去除率为９９．４％－１００％。     

厌氧氨氧化微生物颗粒化及其脱氮性能的研究

利用厌氧颗粒污泥作为种泥,启动SBR反应器,旨在培养厌氧氨氧化颗粒污泥以及研究其脱氮性能.结果表明,水力停留时间(HRT)是富集厌氧氨氧化微生物的1个重要控制因素,以HRT为30 d,第58 d时,SBR反应器就出现厌氧氨氧化现象,与此同时,颗粒污泥由灰黑色变为棕褐色,粒径减小.到第90 d时,成功培养出厌氧氨氧化颗粒污泥,NH⁺₄-N和NO^-₂-N同时被去除,最大去除速率分别达到14.6 g/(m³·d)和6.67 g/(m³·d).从第110　d开始,逐步降低HRT,以提高基质负荷促进厌氧氨氧化菌生长.到目前t＝156　d,HRT降到5　d,氨氮和亚硝酸氮的去除率分别达到60.6%和62.5%,亚硝酸氮/氨氮的比率为1.12.污泥也由棕褐色变为红棕色,形成红棕色的具有高厌氧氨氧化活性颗粒污泥,总氮负荷达到34.3 g/(m³·d).     

Identical full-scale biogas-lift reactors (BLRs) with anaerobic granular sludge and residual activated sludge for brewery wastewater treatment and kinetic modeling

Two identical full-scale biogas-lift reactors treating brewery wastewater were inoculated with different types of sludge to compare their operational conditions, sludge characteristics, and kinetic models at a mesophilic temperature. One reactor （R1） started up with anaerobic granular sludge in 12 weeks and obtained a continuously average organic loading rate （OLR） of 7.4 kg chemical oxygen demand （COD）/（m3.day）, COD removal efficiency of 80%, and effluent COD of 450 mg/L. The other reactor （R2） started up with residual activated sludge in 30 weeks and granulation accomplished when the reactor reached an average OLR of 8.3 kg COD/（m^3·day）, COD removal efficiency of 90%, and effluent COD of 240 mg/L. Differences in sludge characteristics,biogas compositions, and biogas- lift processes may be accounted for the superior efficiency of the treatment performance of R2 over R1. Grau second-order and modified StoverKincannon models based on influent and effluent concentrations as well as hydraulic retention time were successfully used to develop kinetic parameters of the experimental data with high correlation coefficients （R2 〉 0.95）, which further showed that R2 had higher treatment performance than R1. These results demonstrated that residual activated sludge could be used effectively instead of anaerobic granular sludge despite the need for a longer time.     

蠕虫在膜生物反应器和活性污泥法中的污泥减量研究

通过长达345d的中试规模试验,研究比较了蠕虫在膜生物反应器(MBR)和活性污泥法(CAS)的生长状况及其导致的污泥减量效果.CAS中的蠕虫生长状况明显优于MBR的蠕虫生长状况.MBR曝气池中平均蠕虫密度(10条·mg-1)远低于CAS曝气池中平均蠕虫密度(71条·mg-1),并且CAS中蠕虫连续保持高密度(>30条·mg-1)生长达172d.CAS中红斑瓢体虫和仙女虫交替成为优势蠕虫.蠕虫生长对MBR的污泥产率(0 40kg·kg-1)和污泥沉降性能(污泥沉降指数133mL·g-1)影响很小,但却能显著减少CAS的污泥产率(0 17kg·kg-1)和改善污泥沉降性能(污泥沉降指数为60mL·g-1).仙女虫比红斑瓢体虫能更大地减少污泥产量和更好地改善污泥沉降性能.蠕虫生长不影响MBR的COD去除率和出水水质,但却显著影响CAS的COD去除率和出水水质.     

一体式膜生物反应器污水资源化技术研究

膜生物反应器是高效的污水处理工艺,但其高气水比运行条件产生的动力消耗与国外膜组件昂贵的价格成为膜生物反应器在我国应用的主要限制因素。为此本研究采用分体曝气形式,选择国产高抗污性能PVDF中空纤维膜,设计了间歇式膜生物反应器,研究了污泥浓度、曝气量和水力停留时间对一体式膜生物反应器去除污染物效果的影响。在低气水比条件下,MBR处理生活污水的研究表明,出水COD<50mg/L,BOD<10mg/L,NH3—N<20mg/L,浊度<3NTU,悬浮固体浓度为零,优于生活杂用水水质标准(CJ25.1-89)。     

Settling and dewatering characteristics of granulated methane-oxidizing bacteria

We evaluated the settling ability and dewaterability of granulated methane-oxidizing bacteria (GMOB) after granulation using a continuous-flow reactor. A comparative analysis on settling and dewatering characteristics due to changes in sludge retention time (SRT, 10, 15 and 20 days) during cultivation of GMOB was conducted. In assessing dewaterability, the specific resistance to filtration (SRF) of activated sludge and GMOB was found to be 8.21×1013-2.38×1014 and 4.88 × 1012-1.98×1013 m/kg, respectively. It was confirmed that as SRT decreased, SRF of GMOB increased. In the case of bound extracellular polymeric substance (EPS), activated sludge registered 147.5 mg/g-VSS while GMOB exhibited 171-177.2 mg/g-VSS. In the case of extracellular polymeric substance soluble EPS in effluent, activated sludge measured 62 mg/L and GMOB had 17.4-21.4 mg/L. The particle size analysis showed that mean particle diameters of GMOB were 402, 369, and 350 μm, respectively, at SRTs of 20, 15 and 10 days. In addition, it was found that GMOB had a larger mean particle diameter and exhibited much better settleability and dewaterability than activated sludge did.     

一体化膜生物反应器处理低C/N污水式验研究

研究一体化连续流间歇曝气膜生物反应器(IMBR)处理低C/N城市污水的工艺效能.试验结果表明:反应器在曝气2 h、搅拌2 h的运行模式下,对COD、NH_4~+;-N、TN和SS的平均去除率分别达到了87%,83.4%,75.4%和97.81%,各出水质量浓度平均值分别为17.5,4.59,7.63和2 mg/L,出水水质达到了GB/T18920-2002<城市污水再生利用城市杂用水水质>标准.

Abstract：

The integrated intermittent-aeration membrane biological reactor (IMBR) was investigated to treat the low C/N ratio urban sewage. Pollutants removal efficiency of IMBR under the condition of aeration 2 h and agitation 2 h were researched. The results showed that the average removal rates of COD, NH/ -N, TN and SS were 87% , 83.4% , 75.4% and 97.81% respectively. The average concentrations of COD,NH_4~+ -N,TN and SS in the effluent of IMBR system were 17.5,4.59,7.63 and 2 rag/L respectively. The effluent quality of IMBR could meet the standard of the requirement reclaimed water quality criterion (GB/T18920-2002).     

Enhancing sewage sludge dewaterability by bioleaching approach with comparison to other physical and chemical conditioning methods

The sewage sludge conditioning process is critical to improve the sludge dewaterability prior to mechanical dewatering. Traditionally, sludge is conditioned by physical or chemical approaches, mostly with the addition of inorganic or organic chemicals. Here we report that bioleaching, an efficient and economical microbial method for the removal of sludge-borne heavy metals, also plays a significant role in enhancing sludge dewaterability. The effects of bioleaching and physical or chemical approaches on sludge dewaterability were compared. The conditioning result of bioleaching by Acidithiobacillus thiooxidans and Acidithiobacillus ferrooxidans on sludge dewatering was investigated and compared with the effects of hydrothermal (121℃ for 2 hr), microwave (1050 W for 50 sec), ultrasonic (250 W for 2 min), and chemical conditioning (24% ferric chloride and 68% calcium oxide; dry basis). The results show that the specific resistance to filtration (SRF) or capillary suction time (CST) of sludge is decreased by 93.1% or 74.1%, respectively, after fresh sludge is conditioned by bioleaching, which is similar to chemical conditioning treatment with ferric chloride and calcium oxide but much more effective than other conditioning approaches including hydrothermal, microwave, and ultrasonic conditioning. Furthermore, after sludge dewatering, bioleached sludge filtrate contains the lowest concentrations of chroma (18 times), COD (542 mg/L), total N (TN, 300 mg/L), NH₄⁺-N (208 mg/L), and total P (TP, 2 mg/L) while the hydrothermal process resulted in the highest concentration of chroma (660 times), COD (18,155 mg/L), TN (472 mg/L), NH₄⁺-N (381 mg/L), and TP (191 mg/L) among these selected conditioning methods. Moreover, unlike chemical conditioning, sludge bioleaching does not result in a significant reduction of organic matter, TN, and TP in the resulting dewatered sludge cake. Therefore, considering sludge dewaterability and the chemical properties of sludge filtrate and resulting dewatered sludge cakes, bioleaching has potential as an approach for improving sludge dewaterability and reducing the cost of subsequent reutilization or disposal of dewatered sludge.     

Biological nutrient removal by internal circulation upflow sludge blanket reactor after landfill leachate pretreatment

The removal of biological nutrient from mature landfill leachate with a high nitrogen load by an internal circulation upflow sludge blanket （ICUSB） reactor was studied. The reactor is a set of anaerobic-anoxic-aerobic （A^2/O） bioreactors, developed on the basis of an expended granular sludge blanket （EGSB）, granular sequencing batch reactor （GSBR） and intermittent cycle extended aeration system （ICEAS）. Leachate was subjected to stripping by agitation process and poly ferric sulfate coagulation as a pretreatment process, in order to reduce both ammonia toxicity to microorganisms and the organic contents. The reactor was operated under three different operating systems, consisting of recycling sludge with air （A^2/O）, recycling sludge without air （low oxygen） and a combination of both （A^2/O and low oxygen）. The lowest effluent nutrient levels were realised by the combined system of A^2/O and low oxygen, which resulted in effluent of chemical oxygen demand （COD）, NH3-N and biological oxygen demand （BOD5） concentrations of 98.20, 13.50 and 22.50 mg/L. The optimal operating conditions for the efficient removal of biological nutrient using the ICUSB reactor were examined to evaluate the influence of the parameters on its performance. The results showed that average removal efflciencies of COD and NH3- N of 96.49% and 99.39%, respectively were achieved under the condition of a hydraulic retention time of 12 hr, including 4 hr of pumping air into the reactor, with dissolved oxygen at an rate of 4 mg/L and an upflow velocity 2 m/hr. These combined processes were successfully employed and effectively decreased pollutant loading.