模拟烟气中NO、NO_x的微生物净化效率强化研究

NO的脱除效率已成为微生物净化燃煤烟气NOx双塔流程的瓶颈。为了提高微生物净化烟气中NO、NOx的效率,分别研究了脱硫塔添加Fe SO4·7H2O、脱氮塔添加Na NO2对微生物净化模拟烟气中NO、NOx效率的影响作用。结果表明:脱硫塔添加0.23 g/L Fe SO4·7H2O,其NO平均脱除率为61.04%,比空白试验的35.31%提高明显;脱硫塔NOx平均脱除率为62.16%,比空白试验的31.10%提高约1倍;双塔NOx平均总脱除率从空白试验的61.8%增至86.9%。浓度梯度试验结果表明:0.23 g/L Fe SO4·7H2O是脱硫塔内较为合适的添加浓度。脱氮塔添加0.50 g/L Na NO2后,脱氮塔NO平均脱除率从空白试验的39.92%提高到52.11%;脱氮塔NOx平均脱除率从空白试验的47.67%增至58.90%;双塔NOx平均总脱除率从空白试验的70.75%增至79.32%。反复多次验证试验均证明:Fe SO4·7H2O和Na NO2的分别添加的确大幅度地强化了烟气中NO、NOx的微生物净化效率。     

V_2O_5/ACF低温选择性催化还原烟气中NO的研究

文章对V2O5/ACF(活性炭纤维)进行低温选择性催化还原(SCR)NO的影响研究。实验表明:ACF用硝酸处理形成ACFN,然后采用等体积浸渍法制备V2O5/ACFN催化剂,NO脱除率明显增加。同时研究了V2O5负载量、反应温度、NH3初始浓度、NO初始浓度、O2含量等因素对NO脱除效率的影响,发现V2O5/ACFN在180℃低温时,在NH3/NO为1.1、NO初始体积分数1000×10-6和O2体积分数5%时NO脱除效率较高。     

V_2O_5/TiO_2催化剂用于烟气同时脱硫脱硝的研究

研究了用V2O5/TiO2催化剂同时脱除烟气中的SO2和NO,考察了H2还原温度及其它反应条件对SO2和NO脱除率的影响。结果表明,经H2还原后所制得的V2O5/TiO2催化剂可以提高脱硫脱硝活性,最佳还原温度为700℃;在450～500℃的烟气温度范围内,该催化剂有较佳的脱硫脱硝活性;在相同反应温度下,空速越大,SO2和NO的脱除率越低;烟气中的氧气可大大提高V2O5/TiO2的脱硫脱硝活性,且氧气体积含量在5%～10%范围内变化时,对SO2和NO脱除率的影响较小。     

气相组分对氨吸收同步脱除模拟烟气SO2 和NOx 的影响

在pH值5.9～6.1,吸收液浓度≥1 mol·L-1的条件下,分析了模拟烟气的NOx氧化度、O2和SO2浓度,以及添加液相S(Ⅳ)氧化抑制剂Na2S2O3对SO2、NOx吸收脱除效率的影响.结果表明,氨可高效吸收脱除SO2和NO2,但对NO的吸收脱除效率几乎为0,因此,NO氧化是其吸收脱除NOx的前提.吸收液S(Ⅳ)浓度是影响NO2脱除效率的关键因素,气相O2浓度越高或SO2浓度越低,吸收液S(Ⅳ)浓度降低越快,继而使NO2吸收脱除效率降低越快.通过添加S(Ⅳ)氧化抑制剂S2O23-到吸收液,可在一定程度上抑制其氧化,从而延缓NO2吸收脱除效率的降低.     

Fenton法氧化脱除烟气中NO的影响因素的实验研究

在自制反应器中,研究了烟气温度、Fenton试剂温度、初始p H值、NO初始浓度、烟气流量、n(Fe~(2+))/n(H_2O_2)和溶液中Cl~-等对Fenton法氧化脱除NO的影响。从单因素不同取值带来的NO氧化率的波动幅度来看,烟气流量对NO的氧化效率影响最为显著,试剂温度、NO初始浓度和n(Fe~(2+))/n(H_2O_2)的影响次之,而烟气温度和初始p H值影响较小。分别选取烟气温度为70℃,Fenton试剂温度为25℃,烟气流量为400~600 m L/min,NO初始浓度为982 mg/m~3,初始p H值为3,以及n(Fe~(2+))/n(H_2O_2)为0.05∶1时,对应的NO氧化效率较好。而溶液中Cl~-的存在,则会降低NO的氧化效率。此外,以原位滴加方式获得的Fenton体系,有效提高了寿命极短的(·OH)自由基的产出率和利用率,从而提高了NO的氧化效率。     

O3/H2O2氧化苯乙烯气体性能及机制

O3/H2O2体系能产生大量自由基,臭氧与自由基的耦合氧化作用能提高苯乙烯的氧化去除效率.采用O3/H2O2氧化高浓度苯乙烯有机废气,研究了臭氧投加量、停留时间、H2O2体积分数、循环液喷淋密度和O3/C8H8摩尔比对苯乙烯去除率的影响.结果表明,O3/H2O2气液两相氧化能高效净化苯乙烯有机废气,苯乙烯去除率可达85.7%.适宜运行条件:停留时间为20.6 s,H2O2体积分数为10%,喷淋密度为1.72 m3·(m2·h)-1,O3/C8H8摩尔比为0.46.采用GC-MS分析O3/H2O2气液两相高级氧化苯乙烯出口气样,研究结果表明苯甲醛(C6H5CHO)和苯甲酸(C6H5COOH)为O3/H2O2氧化苯乙烯的中间产物,并推测出苯乙烯的降解机制.     

NO/SO_2臭氧协同氧化与吸收特性的实验研究

为研究燃煤烟气中NO/SO_2协同高效脱除方法,某热电厂通过现场实验研究了O3对烟气中NO、SO_2的选择性氧化规律以及脱硫浆液、半干法循环脱硫灰对氧化产物的吸收效能。结果表明:烟气中NO、SO_2同时存在时,烟气中的O3优先氧化NO,当O3过量30%时,SO_2氧化率可达到42%;实际湿法脱硫循环浆液对混合烟气中SO_2吸收率达到近100%,对NOx(x>1)最大吸收率仅为42%;含水量1)最大吸收率仅为30%,且吸收剂在218s后即丧失脱除效能;含水量为15%的半干法脱硫灰对混合烟气中SO_2吸收率达到100%,对NOx(x>1)最大吸收率为75%,吸收剂脱除效果良好且具备长时间稳定脱除效果。     

烟气条件对直流电晕自由基簇射NO氧化过程的影响

运用以湿空气为自由基源物质的直流电晕自由基簇射系统,研究了烟气在反应器内的滞留时间、烟气流速和NO浓度对NO氧化过程的影响.结果表明:烟气流速的增加会抑制电晕放电的发展,而烟气中NO浓度的增加则使放电变得更加容易.NO的氧化受烟气在反应器内滞留时间的影响较小,而它受烟气流速的影响较大.在2W的输入功率下,当烟气在反应器内的滞留时间从8.5s增加到34.2s时,NO的氧化率只从54.5 %提高到57.6 %.而在1.7W·h/m³的能量密度下,当烟气流速从1.4cm/s增加到6.3cm/s时,NO的氧化率从60.0%减少到38.6%,能量利用率也从20.8g/(kW·h)下降到了13.3g/(kW·h).在湿空气流量一定的情况下,NO初始浓度存在一个最佳值,本实验中最佳的NO浓度为100×10^-6左右.     

氧活性粒子脱除烟气中SO2的实验研究

为了解决目前气体电离放电脱硫方法存在的等离子源体积庞大、能耗高、以及需要依靠传统脱硫方法的协同作用等问题.拟用小流量高浓度氧活性粒子[O2+、O(1D)、O(3P)、O3]及引发剂HO2-分别注入烟道中,与烟气中H2O反应生成·OH;在无吸收剂、无催化剂及没有其他技术协同作用下,进行·OH氧化脱除大烟气量中的微量SO2并生成H2SO4的实验.结果表明:烟气温度为30℃,氧活性粒子与SO2摩尔比为3~4时,脱硫率达到94.6%,回收酸液中SO42-浓度达到9.3g/L.     

络合-氧化-还原耦合方法脱除烟气中NOx的研究

NO与Fe2+反应生成络合物[Fe(NO)]2+易被O2氧化解络形成NO2-和NO3-离子,进而被尿素溶液还原生成N2.基于上述反应原理,本文提出脱除烟气中NOx的新方法,即以FeSO4为吸收液、O2为氧化剂、尿素为还原剂的络合-氧化-还原耦合法.考察了尿素初始浓度、吸收液pH值、NOx初始浓度、烟气流量等因素对NOx脱除率的影响.结果表明,尿素初始浓度越高、吸收液pH值越低、NOx初始浓度越大、烟气流量越小时,NOx脱除率越高;当尿素初始浓度为1.19mol/L,吸收液pH值为3.2,NOx初始浓度为1493mg/m3以及烟气流量为800mL/min时,反应初期(0~6min)NOx脱除率可达92%以上,且反应1h后脱除率仍可保持在69%左右.     

NO conversion by positive streamer discharge-effects of gas compositions and reaction conditions

The effects of gas compositions and reaction conditions on NO conversion by positive streamer discharge were experimentally investigated by using a link tooth wheel-cylinder reactor. The results showed that NO conversion increased with increasing O₂ concentration and NH₃ concentration, but decreased with increasing inlet NO concentration and gas flow rate. The addition of CO₂ or H₂O to the feed gas promoted NO conversion by increasing the maximum discharge voltage, and NH₄NO₃ was formed in the presence of NH₃. There was a most suitable range interval between discharge tooth wheels if both NO conversion and energy consumption were considered. Increasing applied voltage resulted in the increase in the amount of O₃ generated by streamer discharge.     

Characterization and performance of Pt/SBA-15 for low-temperature SCR of NO by C3H6

Pt supported on mesoporous silica SBA-15 was investigated as a catalyst for low temperature selective catalytic reduction(SCR) of NO by C 3 H 6 in the presence of excess oxygen.The prepared catalysts were characterized by means of XRD,BET surface area,TEM,NO-TPD,NO/C 3 H 6-TPO,NH 3-TPD,XPS and 27 Al MAS NMR.The effects of Pt loading amount,O 2 /C 3 H 6 concentration,and incorporation of Al into SBA-15 have been studied.It was found that the removal efficiency increased significantly after Pt loading,but an optimal loading amount was observed.In particular,under an atmosphere of 150 ppm NO,150 ppm C 3 H 6,and 18 vol.% O 2,0.5% Pt/SBA-15 showed remarkably high catalytic performance giving 80.1% NOx reduction and 87.04% C 3 H 6 conversion simultaneously at 140°C.The enhanced SCR activity of Pt/SBA-15 is associated with its outstanding oxidation activities of NO to NO 2 and C 3 H 6 to CO 2 in low temperature range.The research results also suggested that higher concentration of O 2 and higher concentration of C 3 H 6 favored NO removal.The incorporation of Al into SBA-15 improved catalytic performance,which could be ascribed to the enhancement of catalyst surface acidity caused by tetrahedrally coordinated AlO 4.Moreover,the catalysts could be easily reused and possessed good stability.     

电晕放电与络合催化联合同时去除烟气中SO_2、NO实验研究

采用电晕放电与液相络合催化协同同时去除烟气中SO2和NO,电压、水流量、乙二胺合钴浓度、pH、SO2和NO初始浓度以及气流量对同时去除SO2和NO效率的影响进行了实验研究.结果表明:NO去除率随着放电电压、水流量、乙二胺合钴浓度、pH的增加而增加,而随SO2和NO初始浓度、烟气流量的增大而减小;SO2去除率也随放电电压,水流量的增加而增加,随烟气流量的增加而下降,但溶液pH,SO2和NO初始浓度和乙二胺合钴浓度对其影响很小.溶液中加入Mn2+和尿素能分别增强SO2和NO的去除效果.最佳条件为:电压25 kV、水流量80 L·h-1,乙二胺合钴浓度0.02 mol·L-1,烟气流量1.0 m3·h-1、尿素浓度0.02 mol·L-1,Mn2+浓度为0.02 mol·L-1时,NO和SO2去除率分别可达68%和94%,对应能量消耗分别为22.2 g·k Wh-1和75.2 g·k Wh-1.     

富氧条件下等离子体协同改性NaY分子筛催化分解NO_x研究

用不同浓度的Cu、Ce和La离子交换Na Y分子筛,对比了不同改性条件下等离子体协同分解NO_x的性能.实验结果表明:Cu是NO_x催化分解的主要活性组分,对于8%Cu-Na Y催化剂,当放电电压为10 k V,放电功率为7.6 W时,NO_x转化率可达46.3%,反应产物中没有NO_2,只有11 ppm的N_2O.Ce的加入可以有效提高催化剂催化活性,对于5%Ce-8%Cu-NaY催化剂,当放电电压为7.8 kV,功率为3.6 W时,NO_x转化率可达67.3%.La的加入同样可以使催化剂活性上升,但不同La含量催化剂的NO_x转化率相差较小.     

非热等离子体结合CuO催化剂或Ca(OH)2吸收剂去除氮氧化物

采用非热等离子体结合催化或现场化学吸收的2种方法来去除气流中的NO_x.结果表明,非热等离子体结合催化,反应器内的CuO催化剂能有效地促进NO的还原反应;相对于催化还原NO而言,脉冲电晕作用下能有效地降低NO催化还原的反应温度.当催化剂为CuO,脉冲电压为18kV,反应温度为200℃,还原剂为1%CO及NO进口浓度为719 mg/m³条件下,NO的去除率达到了100%.非热等离子体结合现场化学吸收方法,是一种在常温下从气流中净化氮氧化物的有效方法,NO的去除率远远高于反应器内没有吸收剂的情况.可以认为反应器内的Ca(OH)₂吸收剂通过与NO的氧化产物NO₂或NO₃的吸收反应促进了NO的去除.当反应器内有Ca(OH)₂吸收剂存在时,在脉冲电压为18kV,O₂浓度为2%及NO进口浓度为1 050 mg/m³条件下,NO的去除率达到了100%.     

Experimental study of NO2 reduction in N2/Ar and O2/Ar mixtures by pulsed corona discharge

Non-thermal plasma technology has been regarded as a promising alternative technology for NOx removal. The understanding of NO2 reduction characteristics is extremely important since NO2 reduction could lower the total NO oxidation rate in the plasma atmosphere. In this study, NO2 reduction was experimentally investigated using a non-thermal plasma reactor driven by a pulsed power supply for different simulated gas compositions and operating parameters. The NO2 reduction was promoted by increasing the specific energy density （SED）, and the highest conversion rates were 33.7%, 42.1% and 25.7% for Ar, N2/Ar and O2/Ar, respectively. For a given SED, the NO2 conversion rate had the order N2/Ar 〉 Ar 〉 02/Ar. The highest energy yield of 3.31 g/kWh was obtained in N2/Ar plasma and decreased with increasing SED; the same trends were also found in the other two gas compositions. The conversion rate decreased with increasing initial NO2 concentration. Furthermore, the presence of N2 or O2 led to different reaction pathways for NO2 conversion due to the formation of different dominating reactive radicals.     

Design of a DBD wire-cylinder reactor for NOx emission control: experimental and modelling approach

The objective of this work was to develop a wire-cylinder dielectric barrier discharge reactor for NO_x removal from a gas mixture simulating exhaust gases. NO conversion was investigated as a function of parameters such as high voltage (HV) electrode material, dielectric material, NO concentration and reactor gap. A complete decomposition path is proposed from ¹⁸O₂ isotope experiments. Finally, a model consisting of ‘Continuous Stirred Tank Reactors’ (CSTR) cascade with multiple injections of atomic oxygen is proposed in order to explain the relationships between the reactor parameters (inlet flow, inlet NO concentration, electrical energy density and electrical gap) and the experimental results (outlet NO_x concentration). Optimization of the model parameters permitted the authors to fit experimental and calculated results with a maximum absolute error of about 5% on NO conversion.     

UV/H2O2降解美罗培南的影响因素及毒性研究

利用波长为254 nm的紫外灯活化过氧化氢(H_2O_2)氧化降解美罗培南(MPN),考察了H_2O_2投加量、初始pH值、水中常见共存阴离子(Cl~-、HCO~-_3、NO~-_3)和天然有机化合物(NOM)等重要影响因素对MPN降解的影响.结果表明,紫外光功率为4 W,初始pH为7.0,n(H_2O_2)/n(MPN)=20∶1时,反应20 min后,MPN的降解率达到97.8%.H_2O_2投加量的增加会加快MPN的降解速率,Cl~-和HCO~-_3对UV/H_2O_2体系中MPN去除效果的影响较小,极少量的NO~-_3会促进MPN的降解,当NO~-_3的浓度≥10 mg·L~(-1)时,MPN的降解受到抑制,且离子浓度越高,抑制程度表现越明显.NOM的存在对MPN的降解有抑制作用.与纯水相比,MPN在实际水体中的去除受到抑制,归因于水体基质的影响.大肠杆菌的急性毒性实验研究表明,MPN的中间转化产物保留了一些抗菌性能,但光解的最终产物无抗菌性能.     

富氧条件下SnO2/Al2O3催化剂上丙烯选择性还原NOx的研究

考察了分别用浸渍法、共沉淀法和溶胶-凝胶法制备的SnO₂/Al₂O₃催化剂上丙烯选择性还原NO_x的催化活性,发现制备方法与Sn的负载量对其活性有重要影响.溶胶-凝胶法制备的SnO₂/Al₂O₃催化剂活性最高,Sn的最佳负载量为5%.与浸渍法和共沉淀法制备的5%SnO₂/Al₂O₃催化剂相比,溶胶-凝胶法制备的5%SnO₂/Al₂O₃催化剂受水蒸汽的抑制作用较弱,并且在水和SO₂共存的条件下活性最高.此外,反应气中丙烯及氧气浓度的增加有利于NO_x转化率的提高.     

V2O5/TiO2催化剂中毒机理的试验研究

选择性催化还原(SCR)催化剂是SCR烟气脱硝技术的核心,是整个SCR系统脱硝效率和经济性的决定因素.本文工作的主要研究思路是以钒钛SCR催化剂为研究对象,研究了H2O和SO2,以及相同含量下K、Na、Ca、Pb的氧化物对钒钛催化剂NO转化率的影响.H2O的存在会抑制V2O5/TiO2催化剂脱硝活性,而SO2在一定程度上促进(V2O5/TiO2)催化剂的SCR脱硝反应,提高NO转化率;碱金属K对钒钛催化剂的钝化作用都是最强,K2O和Na2O的掺入会抑制钒钛催化剂上V2O5的还原能力,而CaO和PbO的掺入对钒钛催化剂上V2O5的还原能力影响较小.