卷式活性炭纤维电极电吸附除盐试验研究

自行研发并制作一种新型卷式活性炭纤维电极电吸附除盐装置,采用了单因素试验分析方法,研究了电压、溶液初始浓度、溶液体积、流量和电极板间距对电吸附除盐效果的影响。结果表明:2 V为最佳电压,当溶液初始浓度1 000 u S/cm,溶液体积100 m L,流量10 m L/min,电极板间距1 mm时,电导率去除率达到40%以上,这表明了卷式活性炭纤维电极在电吸附除盐方面良好的应用前景。     

超滤-反渗透集成膜技术深度处理酒精废水

采用超滤-反渗透集成膜技术对酒精废水二级生化处理出水进行深度处理,考察了不同超滤膜对废水的预处理性能,研究了超滤-反渗透集成膜技术对废水污染物的去除效果,并探索了不同清洗方式对反渗透膜通量恢复的影响。试验结果表明:超滤能有效地去除废水浊度和大分子有机物,为反渗透提供良好的进水水质;超滤-反渗透膜系统产水浊度、硬度、总铁均小于0.1 NTU、0.03 mmol/L和0.03 mg/L,电导率处于60~120μS/cm之间,可回用作锅炉补充水;酸洗+碱洗组合清洗方式能有效恢复反渗透膜通量,其废水膜通量可恢复为新膜废水通量的93.75%。     

曝气生物滤池—超滤—反渗透工艺处理石化综合废水实例

以某石化公司为例,综合废水水质参数：CODcr≤80mg/L,BOD5≤15mg/L,电导率=800~1550μS/cm,浊度≤6NTU,水温25~35℃,采用曝气生物滤池—超滤—反渗透工艺处理。运行结果表明,处理后出水CODcr≤50mg/L,BOD5≤10mg/L,电导率≤50μS/cm,浊度≤5NTU,达到工业循环冷却水补水标准。     

铁盐和铝盐混凝微滤工艺除As(V)的比较研究

选择FeCl₃和Al₂(SO₄)₃作混凝剂,采用小试规模的混凝微滤膜反应器比较了铁盐和铝盐混凝微滤工艺的除As(V)效果、相关性能指标及适用范围.结果发现,Fe³⁺投加量为4 mg/L、Al₂(SO₄)₃投加量为50 mg/L时,铁盐和铝盐工艺的除As(V)效果大致相当,均可使水中As(V)的浓度从100 μg/L左右降低到10 μg/L以下,最低为1.68 μg/L.出水浊度均小于0.1 NTU,出水中铁、铝和SO^2-₄浓度均符合饮用水标准.铁盐工艺出水pH值比原水大约高0.5,铝盐工艺处理前后水的pH值基本不变.反应器运行结束静沉24 h后,铁盐工艺浓缩比为1 791,是铝盐工艺的2.54倍,污泥中As(V)的含量也大大高于铝盐工艺,去除同等重量的As(V)所产生的污泥量较铝盐工艺少得多.因此,对于仅有砷超标的饮用水,应优先考虑铁盐工艺.按除氟所需混凝剂数量投加Al₂(SO₄)₃,铝盐工艺即可在去除As(V)的同时去除氟,铁盐工艺则不能去除氟.因此,对于砷和氟均超标的饮用水,可采用铝盐工艺同时去除砷和氟.     

金属加工含磷废水的处理及水回用研究

以某金属加工企业废水为研究对象,考察了含磷废水回用工艺,即钙盐除磷和过滤的工艺条件,结果表明,废水p H调至10.0~10.5,Ca Cl2投加浓度为700~800 mg/L,PAC投加浓度为150~200 mg/L,除磷系统沉淀出水TP=3~5 mg/L,去除率可达95%,同时去除了废水中少量的重金属离子。沉淀池出水经过砂滤和炭滤后TP3 mg/L,Zn2+1 mg/L,Ni2+0.8 mg/L,水质优于回用水指标直接回用,减少了排放。     

混凝-臭氧-曝气生物滤池处理港口洗舱废水的中试研究

根据船舶清洗废水水质变化大,成分复杂,生物毒性高的特点,提出了混凝-臭氧氧化-曝气生物滤池(BAF)的组合工艺.该组合工艺的关键是采用臭氧进行氧化处理,去除色度和部分有机物,并且提高废水的可生化性,再通过后续的BAF工艺去除大部分有机物.中试结果表明,在原水CODCr为2 000～3 500 mg/L的情况下,最终出水的CODCr低于300 mg/L,能有效处理此类有机物浓度高,水质变化复杂的洗舱废水.     

一体化厌氧氨氧化工艺处理垃圾渗滤液的性能研究

以垃圾渗滤液为研究对象,研究UASB-除碳-一体化ANAMMOX工艺的除碳脱氮特性.结果表明:该工艺可实现高效除碳脱氮;在进水COD浓度6210~16365mg/L?TN浓度为990~2100mg/L时工艺出水COD浓度最低为655mg/L,出水TN浓度最低为39.9mg/L.进水中的可降解COD主要在UASB和除碳池中去除(分别为59%和31%),进入到一体化ANAMMOX池中的多为惰性有机物质;TN的去除在除碳池和一体化ANAMMOX池中进行,其中除碳池中TN去除量占工艺TN去除量的53%,主要通过同步硝化反硝化去除;ANAMMOX池中TN去除46%,主要通过AOB和AnAOB的协同作用实现.当除碳池出水含可降解有机物时,对后续一体化ANAMMOX池的自养脱氮抑制严重;充分降解除碳池中的可降解有机物是影响系统脱氮效率的关键因素.     

超滤工艺净化微污染原水的试验研究

采用混凝沉淀-超滤工艺对微污染原水进行试验,对组合工艺的除污染特性进行了研究。结果表明,组合工艺对浊度、颗粒物和藻类的去除效果非常好。出水浊度稳定在0.1NTU以下,水中粒径>2μm的颗粒数约19个/mL,藻类平均数量约为2.2×104个/L。在去除有机物方面,组合工艺对高锰酸盐指数、UV254和DOC的去除率分别为38.0%、15.2%和32.6%,其中对高锰酸盐指数的去除效果较为突出,出水高锰酸盐指数浓度为2.69~2.87mg/L。组合工艺去除的有机物是分子量大于3KD的大分子有机物,对小分子有机物去除效果不明显。其中,混凝沉淀主要去除了水中的疏水性有机物和亲水荷电有机物,超滤膜去除的有机物则以亲水中性有机物为主。在工艺运行期间,超滤膜的跨膜压差增加了约12.3%,跨膜压差的升高主要由被超滤膜吸附的小分子有机物产生。     

RSSP工艺处理海产品废水工艺参数研究

实验研究了基于A2/O工艺理论开发出的RSSP回流污泥分离高效脱氮除磷新工艺对海产品废水的处理,重点考察了处理海产品废水重要参数之一即不同总水力停留时间下对海产品废水脱氮除磷的处理效果.实验表明:在进水质量浓度COD为450～780.2 mg/L,TN为67～120 mg/L,TP为9～13 mg/L时,在满足国家出水水质一级标准要求的前提下,得出最佳的总水力停留时间为12 h,厌氧段水力停留时间为3 h,缺氧段水力停留时间为2 h.也达到降低处理系统的基建和运行费用的目的,从而更好的为海产品废水处理提供适合的工艺条件.     

新型高效聚合铝的生产性试验研究

为进一步提高饮用水水质,通过系统研究筛选混凝剂及优化混凝过程来达到高效去除污染物,以提供经济合理的水处理工艺途径.结果表明:新型药剂具有显著提高出水水质的性能,改善了沉淀后水体颗粒物的粒度分布特征,提高了过滤效率.同时表现出明显优越的去除有机物能力,传统工艺TOC去除大约在9%～11%,而新型药剂则可以达到17%～20%.应用树脂分离分级对不同有机物表征的结果也得到进一步证实.原水的TTHMFP为20.98μg/L,而原有工艺为11.01μg/L,使用新药剂后仅为6.40μg/L.使用新药可以明显节约成本,具有显著的经济效益,同时降低生产工艺的复杂性.     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.     

Simultaneous removal of ammonium and phosphate by zeolite synthesized from coal fly ash as influenced by acid treatment

Zeolite synthesized from fly ash （ZFA） without modification is not efficient for the purification of NH4＋ and phosphate at low concentrations that occur in real effluents, despite the high potential removal capacity. To develop an effective technique to enhance the removal efficiency of ammonium and phosphate at low concentrations, ZFA was modified with acid treatment and the simultaneous removal of ammonium and phosphate in a wide range of concentration was investigated. It was seen that when compared with untreated ZFA, only the treatment by 0.01 mol/L of H2SO4 significantly improved the removal efficiency of ammonium at low initial concentrations. The behavior was well explained by the pH effect. Treatment by more concentrated H2SO4 led to the deterioration of the ZFA structure and a decrease in the cation exchange capacity. Treatment by 0.01 mol/L H2SO4 improved the removal efficiency of phosphate by ZFA at all initial P concentrations, while the treatment by concentrated H2SO4 （≥0.9 mol/L） resulted in a limited maximum phosphate immobilization capacity （PIC）. It was concluded that through a previous mild acid treatment （e.g. 0.01 mol/L of H2SO4）, ZFA can be used in the simultaneous removal of NH4＋ and P at low concentrations simulating real effluent.