不同通风方式对污泥堆肥的影响

采用2种通风方式和5种调理剂进行污泥堆肥,堆温均能顺利达到设定温度(60℃),并能保持一段高温期,堆肥产品的卫生学指标达到了无害化国家标准.同采用正压强制通风相比,采用自然通风与正压强制通风相结合方式,堆温上升迅速,能耗更低.但正压强制通风能加快堆料含水率的降低和有机质的降解.堆料含水率能极大地影响污泥堆肥过程,堆料的含水率不宜超过80%,在污泥堆肥过程中不必对堆料的pH值进行调整.     

时间温度联合控制的强制通风污泥堆肥技术

采用强制通风高温堆肥技术对生活污水处理厂的污泥进行堆肥化处理 ,通风系统采用时间和温度联合自动化控制 .对堆肥过程中不同的堆料配比 ,通风量对堆温的影响 ,堆肥过程中水分、有机质、pH值、种子发芽率的变化趋势及卫生学指标进行了研究 .在堆料配比 ,污泥∶木片∶回流污泥为 1∶1∶1～3∶1∶1,通风量为 3.3m²/(h·t)的条件下 ,堆温可达 60℃ ,并维持 3d以上 ;堆肥的含水率可降低约 40% ;有机质降解率为 25%～40% ;种子发芽率>80% ;大肠菌值>0.111 ,蛔虫卵的杀灭率>100% .     

高水分蔬菜和花卉废物序批式进料联合堆肥的中试

以滇池流域典型蔬菜废物(西芹、白菜)和花卉废物(石竹)为原料,进行了序批式联合堆肥的试验研究.以西芹和石竹作为初始物料,控制初始混合物料的含水率在60%～70%,每隔4d添加一次白菜;采用温度反馈通气量控制的好氧静态堆肥技术,在堆体温度40℃左右时停止通风.试验分析了堆肥过程中堆体温度、通风速率、水分、pH值、有机质、灰分、体积、NH₄⁺-N,NO₃^--N等指标随时间的变化特征.结果表明:采用序批式进料、温度反馈通气量控制的静态好氧堆肥技术进行蔬菜和花卉废物联合堆肥可以有效控制堆肥过程,实现有机物料的快速稳定和去除水分,解决了滇池流域蔬菜废物量远大于花卉废物量时堆肥难以有效进行的技术难题.     

城市污水厂污泥堆肥中试实验研究

城市污水厂污泥由于产生量大且成分复杂,如何对它进行稳定化、无害化处理已越来越受到人们的关注.本研究基于好氧发酵仓式堆肥系统,研究了城市污泥处理过程中温度、含水率、pH、有机质、水溶性有机碳、总氮和发芽指数等指标参数的变化规律.研究结果表明:当物料初始含水率控制在65%左右时,在强制通风量112.5m3/12hr,搅拌频率30min/24hr的工艺条件下,堆肥过程可以实现顺利升温并在55℃以上维持3天,满足杀灭致病菌要求的条件;14天反应周期结束时,物料含水率、水溶性有机碳和有机质含量显著降低,堆肥产品腐熟,卫生学指标达到了美国EPA污泥产品A类标准;得到的污泥产品成为性质优良的土壤质量调节剂.     

屠宰场污泥堆肥效果及其影响因素实验研究

对宜宾县城周边屠宰场污泥进行堆肥实验,以种子发芽指数作为参考指标,重点考察了温度、添加菌剂、填充料、堆体尺寸、初始p H值、碳氮比以及初始含水率对堆肥腐熟程度的影响。结果表明:堆肥温度随时间呈现先升后降的趋势,约在第13天达到最大值,且高温区达到60~70℃堆肥效果最佳;添加活性菌剂,能大大提升有机物降解能力,缩短堆肥时间并提高肥效;以锯末作为填充料对堆肥的促进作用最为明显;为促使污泥快速腐熟,应控制初始p H值在7.5左右、碳氮比(C/N)为25左右、初始含水率为55%。该研究为实现屠宰场污泥无害化利用提供了参考。     

通风控制方式对动物粪便堆肥过程的影响

考察了2种不同通风控制方式(时间控制、时间-温度联合控制)对动物粪便堆肥过程的影响.研究结果表明,在高温阶段,2种通风控制方式堆肥试验的堆体温度均达到了在50℃～55℃以上维持5～7 d的无害化要求(GB7959-87).在高温持续时间和温度分布均匀性方面,采用时间控制通风的堆肥方式优于采用时间-温度联合控制通风的堆肥方式,但过高的温度(60～70℃)不利于堆体中水分的去除和有机质的生物降解在高温堆肥阶段,通过改变通风时间,2种控制方式的堆肥过程均出现了2次高温期,这更利于堆肥的无害化.     

酵母生产剩余污泥和糖渣混合堆肥试验研究

堆肥是世界范围内处理有机固体废弃物的一种普遍工艺,本试验以酵母生产副产物糖渣和污泥为原料,以谷糠为填充料,以RW促腐剂为发酵菌剂,按一定比例混合后堆肥,研究了污泥和糖渣混合堆肥的可行性以及处理过程中温度、含水率、pH、有机质、重金属、卫生学等指标的变化规律。试验结果表明,污泥和糖渣混合堆肥具有可行性,初始含水率控制在60%左右,添加一定量的发酵菌种和填充料,并控制合适的翻堆频率,可以顺利实现堆体升温发酵腐熟,并最终满足污泥糖渣无害化、减量化要求。     

冬季动态槽式堆肥温度的空间变异

以鲜鸡粪、蘑菇渣和污泥按照体积比3∶1∶1混合进行动态堆肥模拟试验.堆肥槽沿物料前进方向分为7个部分,对每个部分按等间距分别做5个水平方向上切分和5个垂直方向上切分,在形成的125个交叉点上进行温度监测.研究结果表明,第1天的混合物料温度在同一层中变异很小,不同层之间略有差异.随着动态过程的进行,同一层温度变异逐渐增大,从第一天相差1～3℃,增加到相差30～40℃,靠近墙体的堆料温度较低,远离墙体的温度较高.随着堆肥时间延长,差异增大.机械翻堆能起到通风的作用,同时使每一个堆方的堆料在纵向方向上上下混合,但达不到横向混匀,因此,靠近墙体两侧的堆料始终处于较低的温度,只有中部能达到较高的温度,以堆肥温度50℃作为无害化指标,自墙体向中心方向的1m为没有达到无害化厚度,无害化体积占堆肥总体积50%.整个动态堆肥过程符合二级动力学方程.     

调理剂在鸡粪锯末堆肥中的保氮效果

在自动高温堆肥装置中,进行了4种调理剂对鸡粪锯末高温堆肥中的保氮效果实验,分析了堆肥化不同时期各处理中的堆温、pH值、水溶性氨氮、水溶性有机氮、全氮和有机碳的变化.结果表明,几种调理剂的加人对高温堆肥的堆温、pH值、水溶性氨氮、水溶性有机氮、TN和OC指标都有影响.都可降低堆肥过程氮素的损失;对OC的分解都有一定的促进作用.特别是同时添加草炭和过磷酸钙使堆肥高温期延长了5d,使堆制初期和高温期的pH值分别降低了0.89pH单位和0.44pH单位,使OC的降解率增加了60.7%,且使堆制过程中氮素的损失率下降了65.1%,有明显的保氮效果;而单加草炭或过磷酸钙效果次之;加沸石效果不明显.     

秸秆与污泥混合好氧堆肥研究

将污泥与秸秆进行混合好氧堆肥研究,对堆肥过程中堆料的温度、pH值、含水率及堆肥前后重金属各形态的变化进行了分析．结果表明堆肥处理可以实现顺利升温并在50-55℃维持5d以上,达到杀灭致病菌要求的条件;pH值稳定在7．5-9．0之间,含水率不断减小,堆肥过程可以顺利进行;重金属有效态有一定程度的降低,减小了污泥土地利用时重金属的环境危害。     

Distribution and ecological effect of mercury in Laogang landfill, Shanghai, China

Laogang landfill near Shanghai is the largest landfill in China, and receives about 10000 t of daily garbage per day, Samples of topsoil and plants were analyzed to evaluate mercury pollution from the landfill. For topsoil samples, there were significant correlations among total mercury （HgT）, combinative mercury （Hgc） and gaseous mercury （HgG）, and content of total organic carbon （TOC）, but, no significantly relationship was found between Hg content and filling time. Hg content changes in vertical profiles with time showed that the average Hgv of profiles 1992, 1996, and 2000 was similar, but their average HgG was quite different. HgT was significantly correlated with Hgc in profile 1992 and 2000, and Hgv was significantly correlated with Hg6 in profile 1996. HgG/Hgv ratio in profile samples decreased in the order of （HgG,/HgT）1992〉（HgG/HgT）1996〉〉（HgG/HgT）2000. A simple outline of Hg release in landfill could be drawn： with increasing of filling time, degradation undergoes different biodegradation, accordingly, gaseous mercury goes through small, more, and small proportion to total mercury. Distribution of Hg in plants was inhomogeneous, following the order of leaf〉root〉stem. The highest value of leaf may be associated with higher atmospheric Hg from landfill. Ligneous plants （e.g. Phyllostachys glanca, Prunus salicina and Ligustrum lucidum） are capable of enriching more Hg than herbaceous plants.     

EDTA-enhanced phytoremediation of lead contaminated soil by Bidens maximowicziana

Phytoremediation is a potential cleanup technology for the removal of heavy metals from contaminated soils.Bidens maximowicziana is a new Pb hyperaccumulator,which not only has remarkable tolerance to Pb but also extraordinary accumulation capacity for Pb.The maximum Pb concentration was 1509.3 mg/kg in roots and 2164.7 mg/kg in overground tissues.The Pb distribution order in the B. maximowicziana was:leaf>stem>root.The effect of amendments on phytoremediation was also studied.The mobility of soil Pb and the Pb concentrations in plants were both increased by EDTA application.Compared with CK(control check),EDTA application promoted translocation of Pb to overground parts of the plant.The Pb concentrations in overground parts of plants was increased from 24.23-680.56 mg/kg to 29.07-1905.57 mg/kg.This research demonstrated that B.maximowicziana appeared to be suitable for phytoremediation of Pb contaminated soil,especially,combination with EDTA.     

Decomposition of alachlor by ozonation and its mechanism

Decomposition and corresponding mechanism of alachlor, an endocrine disruptor in water by ozonation were investigated. Results showed that alachlor could not be completely mineralized by ozone alone. Many intermediates and final products were formed during the process, including aromatic compounds, aliphatic carboxylic acids, and inorganic ions. In evoluting these products, some of them with weak polarity were qualitatively identified by GC-MS. The information of inorganic ions suggested that the dechlorination was the first and the fastest step in the ozonation of alachlor.     

Enzymatic oxidation of aqueous pentachlorophenol

The influence of the nonionic surfactant Tween 80 on pentachlorophenol （PCP） oxidation catalyzed by horseradish peroxidase was studied. The surfactant was tested at concentrations below and above its critical micelle concentration （CMC）. Enhancement of PCP removal was observed at sub-CMCs. The presence of Tween 80 in the reaction mixture reduced enzyme inactivation which occurred through a combination of free radical attack and sorption by precipitated products. A simple first-order model was able to simulate time profiles for enzyme inactivation in the presence or absence of Tween 80. At supra-CMCs, the surfactant caused noticeable reductions in PCP removal, presumably through micelle partitioning of PCP which precluded the hydrophobic PCP molecule from interacting with the enzyme.     

基于综合水质标识指数和对应分析法的校园河道水质评价

以三峡大学的校园河道求索溪为研究对象,利用综合水质标识指数法确定求索溪水质类别,分析其水质时空变化规律,并利用对应分析法得出求索溪中不同监测点的主要污染因子.研究结果表明:求索溪整体的综合水质标识指数为7.423,整体水质为劣V类(地表水环境质量标准GB 3838-2002)且黑臭.从时间变化来看,求索溪4月份的水质最差,5月份次之,4、5月份所有监测点的水质都劣于V类且黑臭;8月份水质最好,水质为Ⅳ类;从空间分布来看,8个监测点综合水质标识指数均超过6.0,水质为劣V类,其中6号监测点的水质相对最好,监测点3号的水质相对最差;对应分析法得出求索溪的整体水体污染程度受总氮因子的影响最大,其次为总磷.该研究拟为求索溪及类似校园河道的水环境治理研究提供基础依据和参考.     

Effects of chitosan on growth of an aquatic plant (Hydrilla verticillata) in polluted waters with different chemical oxygen demands

Effects of chitosan on a submersed plant, Hydrilla verticillata, were investigated. Results indicated that H. venicillata could prevent ultrastructure phytotoxicities and oxidativereaction from polluted water with high chemical oxygen demand (COD). Superoxide dismutase (SOD) activity and malondialdehyde (MDA) contents in H. verticillata treated with 0.1% chitosan in wastewater increased with high COD (980 mg/L) and decreased with low COD (63 mg/L), respectively. Ultrastructural analysis showed that the stroma and grana of chloroplast basically remained normal. However, plant cells from the control experiment (untreated with chitosan) were vacuolated and the cell interval increased. The relict of protoplast moved to the center, with cells tending to disjoint. Our findings indicate that wastewater with high COD concentration can cause a substantial damage to submersed plant, nevertheless, chitosan probably could alleviate the membrane lipid peroxidization and ultrastructure phytotoxicities, and protect plant cells from stress of high COD concentration polluted water.     

Removal of cadmium using MnO2 loaded D301 resin

MnO2 loaded weak basic anion exchange resin D301 （Anion exchange resin, macroreticular weak basic styrene） as adsorbent has been prepared and applied to the removal of cadmium. The adsorption characteristics have been investigated with respect to effect of pH, equilibrium isotherms, removal kinetic data, and interference of the coexisting ions. The results indicated that the Cd^2＋ could be efficiently removed using MnO2 loaded D301 resin in the pH range of 3-8 from aqueous solutions with the co-existence of high concentration of alkali and alkaline-earth metals ions. The saturate adsorption capacity of the Cd^2＋ was 77.88 mg/g. The adsorption process followed the pseudo first-order kinetics. The equilibrium data obtained in this study accorded excellently with the Langmuir adsorption isotherm.     

Evaluation of phytoextracting cadmium and lead by sunflower, ricinus, alfalfa and mustard in hydroponic culture

Soil contaminated with heavy metals cadmium(Cd)and lead(Pb)is hard to be remediated.Phytoremediation may be a feasible method to remove toxic metals from soil,but there are few suitable plants which can hyperaccumulate metals.In this study,Cd and Pb accumulation by four plants including sunflower(Helianthus annuus L.),mustard(Brassica juncea L.),alfalfa(Medicago sativa L.), ricinus(Ricinus communis L.)in hydroponic cultures was compared.Results showed that these plants could phytocxtract heavy metals, the ability of accumulation differed with species,concentrations and categories of heavy metals.Values of BCF(bioconcentration factor)and TF(translocation factor)indicated that four species had dissimilar abilities of phytoextraction and transportation of heavy metals.Changes on the biomass of plants,pH and Eh at different treatments revealed that these four plants had distinct responses to Cd and Pb in cultures.Measurements should be taken to improve the phytoremediation of sites contaminated with heavy metals,such as pH and Eh regulations,and so forth.     

Effect of coagulation pretreatment on the fouling of ultrafiltration membrane

The purpose of this study is to understand the effect and mechanism of preventing membrane fouling, by coagulation pretreatment, in terms of fractional component and molecular weight of natural organic matter （NOM）. A relatively higher molecular weight （MW） of hydrophobic compounds was responsible for a rapid decline in the ultrafiltration flux. Coagulation could effectively remove the hydrophobic organics, resulting in the increase of flux. It was found that a lower MW of neutral hydrophilic compounds, which could remove inadequately by coagulation, was responsible for the slow declining flux. The fluxes in the filtration of coagulated water and supernatant water were compared and the results showed that a lower MW of neutral hydrophilic compounds remained in the supernatant water after coagulation could be rejected by a membrane, resulting in fouling. It was also found that the coagulated flocs could absorb neutral hydrophilic compounds effectively. Therefore, with the coagulated flocs formed on the membrane surface, the flux decline could be improved.     

Penetration analysis of elements and bioleaching treatment of spent refractory for recycling

Acidithiobacillus ferrooxidans ATCC23270 and Acidithiobacillus thiooxidans TM-32 were used for bioleaching of spent refractories of aluminium and copper melting furnaces for their recycling.Firstly,penetration of elements into aluminium melting furnace refractory was investigated and it was found that up to 7 cm from surface was contaminated.Comparison on leaching efficiency by the strains ATCC23270 and TM-32 found that the strain ATCC23270 could treat larger amount of the refractories than the strain TM-32 could do.In the experiment of bioleaching of spent refractory aluminium melting furnace by the strain ATCC23270,high leaching efficiency were obtained on Al,Si,and Ca,and extremely low leaching performance was,however,shown on the rest of elements i.e.,Na,Mn,and Zn.Under the strain TM-32 use,relatively high leaching performance was recognized on Al,Si,Ca,Na,Mn,and Zn.In the experiment of bioleaching for spent refractory copper melting furnace,almost the same leaching trends were shown on Cu,Zn,Al,and Si under the strains ACTT23270 and TM-32 uses.