采油污水中化学药剂对COD的影响及可生化性研究

油田采油污水中含有多种源于石油生产的化学药剂,会对污水中的COD及处理效果产生影响。文章以目前某油田使用的几种主要化学药剂为研究对象,分析了药剂浓度对COD的影响,并通过SBR反应器考察了其生物降解性能。结果表明,油田使用的化学药剂对COD有明显的影响,药剂浓度与COD呈线性关系,药剂的种类与结构不同,其对COD影响的显著程度也各异。生物降解性能差是现有油田化学药剂的共同特点,这可能是油田含油污水难处理,特别是采用生物技术处理效果欠佳的重要原因。     

油田抗氧缓蚀剂的复配及研究

以油酸基咪唑啉与除氧剂联氨进行复配形成新的复配缓蚀体系。使用静态挂片法及电化学分析法评价其对P110钢的缓蚀性能,实验结果表明,当缓蚀剂与除氧剂用量比为11,浓度为300mg/L时缓蚀率可达到87.24%。同时通过预膜处理的方法对该缓蚀体系的缓蚀性能进行评价,预膜油溶助剂以5倍常规加注量为宜,缓蚀剂以10倍常规加注量为最好,缓蚀率可达到87.77%。     

低温环境下电子电气缓蚀剂对飞机电子元器件电性能的影响

为提高海洋环境下飞机电子元器件的耐腐蚀性能,使用电子电气缓蚀剂进行防护。采用温度试验箱模拟电子电气缓蚀剂的使用温度,通过测量不同试验温度下试样的接触电阻,计算试样接触电阻的变化率,评定低温环境下电子电气缓蚀剂对试样电性能的影响。结果表明95%的接触点接触电阻变化率不超过7%,温度越低,缓蚀剂对试样接触电阻的影响越大。     

季铵盐复合型缓蚀剂的研制

以烷基卤化物与喹啉等原料合成的喹啉季铵盐，当其与有机胺、适当溶剂、表面活性剂复配后，可作为油井酸化作业的酸化缓蚀剂。该缓蚀剂对金属腐蚀的阴、阳极过程起抑制作用，因此使用的温度范围宽（60～150℃），盐酸浓度高（15％～34％），该产品生产工艺简单，成本低，是油田较理想的酸化缓蚀剂。     

一种硫化氢抑制剂的研发与现场应用

针对镇X区原油开发过程中硫化氢浓度较高的现状,通过室内实验,研发出硫化氢抑制剂LY-05。分析了LY-05的主剂、助剂的主要成分及性能,测定了其脱硫率、杀菌性能、与其他助剂的配伍性。实验表明:当LY-05的投加浓度≥800 mg/L时,脱硫率90%,杀菌率为100%,该硫化氢抑制剂与清蜡剂、破乳剂、杀菌剂、阻垢剂、缓蚀剂等助剂配伍性良好,不影响其他助剂的性能。在镇X区5口油井现场应用表明:该硫化氢抑制剂具有较好的硫化氢治理效果,投加后油井硫化氢浓度全部降至10 mg/m~3以下,脱硫率≥96.0%。     

环境友好缓蚀剂聚天冬氨酸在自来水中对碳钢的缓蚀性能研究

通过电化学极化测试与交流阻抗实验,研究了聚天冬氨酸(PASP)在自来水中对碳钢的缓蚀性能.结果表明:在20℃时,随着PASP浓度的增大,其缓蚀性能增强;PASP是以抑制阳极腐蚀为主的缓蚀剂.缓蚀率随PASP浓度的增加而迅速增加,当PASP(单一组分)质量浓度达到1.0g/L时,缓蚀率增加趋缓,当PASP质量浓度达到5.0g/L时,缓蚀率达到93.1％.PASP在碳钢表面的吸附基本服从Freundlich吸附等温式.     

采油用油田化学剂对鱼类的急性毒性实验研究

以白鲢鱼为实验生物,采用半静态实验方法,研究了几种油田化学剂的半致死浓度和安全浓度。研究表明:防膨剂、杀菌剂K、杀菌剂L、清蜡剂、四氟硼酸、酸化缓蚀剂、阻垢剂、阻垢缓蚀剂、缓蚀阻垢剂和破乳剂的96h半致死浓度LC50值分别为0.68、1.6、9.3、25、123、510、620、3240、4570、7410mg/L。根据化学物质对鱼类毒性物质分级标准,防膨剂属于剧毒物质;杀菌剂K、杀菌剂L和清蜡剂属于高毒物质;四氟硼酸、酸化缓蚀剂和阻垢剂属于中毒物质;阻垢缓蚀剂、缓蚀阻垢剂和破乳剂属于低毒物质。这几种油田化学剂的安全浓度为0.068～741mg/L。此研究可为评价油田化学剂对水生生物的影响,制定废水排放浓度标准提供依据。     

油井酸化缓蚀剂述评

本文扼要介绍了国内外近年来在研究和应用油井酸化缓蚀剂方面的现状和发展，并列出了美国几家公司研制的缓蚀剂的性能试验数据。对目前我国的研究工作提出了看法和建议。     

咪唑啉硫酸酯盐的缓蚀性能及协同增效作用研究

参照SY/T 5405-1996《酸化用缓蚀剂性能试验方法及评价指标》,采用静态失重法评价咪唑啉硫酸酯盐缓蚀剂1-羟乙基-2-油酸基咪唑啉硫酸酯盐(ISES)与丙炔醇(BCC)、非离子表面活性剂OP-10组成的二元和三元复配缓蚀剂体系对N80钢的缓蚀性能,考察二元和三元复配缓蚀剂体系的协同增效作用。通过动电位极化扫描和电化学阻抗分析对ISES及其复配体系的电化学行为进行研究。     

一种油田注水缓蚀剂的合成与性能评价

以不同长链脂肪酸、四乙烯五胺为原料合成油田注水缓蚀剂,通过正交试验筛选了最优合成条件。采用静态挂片法评价了产品的缓蚀性能,并考察了用量、温度对其缓蚀性能的影响。结果表明,试验条件下此类缓释剂在用量800mg/L、相对低温的条件下缓蚀效果较好。     

3种腐熟剂促进玉米秸秆快速腐解特征

为筛选出适宜东北寒冷区快速腐解秸秆的腐熟剂,通过网袋腐解试验明确施入3种秸秆腐熟剂对玉米秸秆生物量及养分释放的影响。结果显示：经过100 d的腐解,玉米秸秆生物量失重率随着时间的延长逐渐增加,玉米秸秆失重率为57.1%-64.1%,其中以施用3号秸秆腐熟剂的玉米秸秆生物量失重率最高,为64.1%。施入不同秸秆腐熟剂后玉米秸秆氮、磷、钾释放率分别为35.1%-57.2%、44.2%-59.6%、77.4%-89.7%,其中以3号腐熟剂的秸秆磷、钾素释放率最高。各处理有机碳矿化率呈相同的趋势,均随时间的延长逐渐增加,取样末期有机碳矿化率在65.3%-69.1%之间,且各处理间差异不明显。综上,以3号秸秆腐熟剂腐解秸秆的效果最好。     

复合絮凝剂Al2(SO4)3+PAM处理生活污水中CODCr和浊度的实验研究

研究絮凝剂硫酸铝Al2(SO4)3与助凝剂聚丙烯酰胺(PAM)联合处理生活污水的效果。研究表明:Al2(SO4)3与PAM联用比单独用Al2(SO4)3处理生活污水效果更好;Al2(SO4)3 PAM对生活污水CODCr和浊度具有良好的去除能力;当投加1:1的50mg/L的Al2(SO4)3 0.5mg/L的PAM,调节水体pH=7时,处理效果最理想,CODCr去除率可达95.8%,浊度去除率可达97.5%。为复合絮凝剂Al2(SO4)3 PAM处理生活污水的应用提供了有价值的参考依据。     

利用高效复合菌净化城市微污染水的静态试验研究

EM经三种培养基富集培养后，用其培养液对微污染水进行净化处理。结果表明：三种培养液在曝气或静置的运行条件下，对微污染水中的COD和氨氮有稳定良好的去除效果，其去除率分别为50％和85％；对磷酸盐的去除随运行条件的不同而不同，曝气条件下比静置条件要好，其去除率也都在60％以上。试验证明：EM培养液对微污染水有良好的净化能力。     

针铁矿对重金属Pb^2＋、Cd^2＋的吸附特征

本文采用平衡振荡法，主要探讨了重金属铅和镉在针铁矿上的环境行为。研究结果表明针铁矿对重金属有较强的吸附作用。在pH一定时，针铁矿对Pb^2＋和Cd^2＋的吸附率随着初始浓度的增加而增大。随着介质pH升高，针铁矿对Pb^2＋和Cd^2＋的吸附量与吸附率均增大，最大吸附率可达到99．71％和99．46％，而解吸量则随之降低。在高pH条件下，针铁矿对Pb^2＋和Cd^2＋的结合牢固，且与Pb^2＋的稳定度大于Cd^2＋。研究表明，环境中针铁矿对铅、镉等重金属的环境化学行为具有重要的影响。利用针铁矿处理含Pb^2＋和Cd^2＋的污水具有良好的应用潜力。     

车载巡回式UV／Fenton装置处理小城镇垃圾渗滤液

为了研究车载巡回处理装置对小城镇垃圾渗滤液的处理效果,采用自制的UV-Fenton试验装置研究了pH值、FeSO_4剂量、反应时间等因素对处理效果的影响,结果表明:最佳pH值为4.0,进水中COD为825 mg/L时,FeSO_4和H_2O_2的投加量分别为0.008 mol/L和0.08 mol/L,此时COD去除率72.22%,出水COD为216 mg/L;随着FeSO_4投加量缓慢增加到一定程度后转而下降,FeSO_4最佳投加量为0.008 mol/L;不同H_2O_2和Fe~(2+)配比对COD去除效果具有影响,(10:1)时为最佳配比。经过氨吹脱和混凝沉淀预处理的渗滤液采用UV/Fenton处理工艺,出水中COD可以达到《生活垃圾填埋场污染控制标准》(GB 16889-1997)中二级标准。     

Mineralization of soil-aged isoproturon and isoproturon metabolites by Sphingomonas sp. strain SRS2

The aim of the study was to determine the effect of aging of the herbicide isoproturon and its metabolites monodesmethyl-isoproturon and 4-isopropyl-aniline in agricultural soil on their availability to the degrading bacterium Sphingomonas sp. strain SRS2. The 14C-ring-labeled isoproturon, monodesmethyl-isoproturon, and 4-isopropyl-aniline were added to sterilized soil and stored for 1, 49, 71, or 131 d before inoculation with strain SRS2. The availability of the compounds was estimated from the initial mineralization and the amount of 14CO2 recovered after 120 d of incubation. Aging in soil for 131 d reduced the initial mineralization of isoproturon and monodesmethyl-isoproturon and, in the case of isoproturon, also reduced the recovery of 14CO2. Initial mineralization and recovery of 14CO2 from aged 4-isopropyl-aniline were slightly reduced, but less 14CO2 was generally produced than with isoproturon or monodesmethyl-isoproturon. Thus, recovery of 14CO2 from 14C-isoproturon and 14C-monodesmethyl-isoproturon was 50.7 to 64.4% of the initially added 14C, while recovery from 14C-4-isopropyl-aniline was only 11.7 to 17.0%. Sorption measurements revealed similar Freundlich constants (K(f)) for isoproturon and monodesmethyl-isoproturon, whereas K(f) for 4-isopropyl-aniline was more than fivefold greater. The findings imply that in soil, partial degradation of isoproturon to 4-isopropyl-aniline may lead to reduced mineralization of the herbicide due to sorption of the aniline moiety.     

Sorption of MS2 bacteriophage to layered double hydroxides: effects of reaction time, pH, and competing anions

Batch sorption and column breakthrough studies were conducted to investigate the potential of layered double hydroxides (LDHs) to remove bacteriophage MS2 from contaminated waters. All four of the LDHs evaluated in this study had very high retention capacities for MS2. Sorption results showed that MS2 could be completely removed from 5.2 x 10(2) plaque-forming units (pfu)/mL solution by Mg-Al LDH 2 (i.e., 2:1 Mg to Al ratio LDH), with the highest sorption capacity observed in this study of 1.51 x 10(10) pfu/g. Attachment of MS2 to LDHs was a rapid process and reached quasi-equilibrium after a 1-h reaction time. Within the pH range studied (pH 4-9), Mg-Al LDH 2 showed high sorption potential for MS2 at all pH values but sorption decreased slightly with increasing solution pH. Background solution anions influenced virus sorption, with SO4(2-) and HPO4(2-) decreasing sorption significantly whereas the presence of NO3- had little effect on the attachment of MS2 to Mg-Al LDH 2. The addition of another virus (phiX174) only caused a slight decrease in the retention of MS2 by Mg-Al LDH 2, suggesting that there was insignificant competitive sorption between MS2 and phiX174 on LDH surfaces. Results from column experiments indicate that there was no MS2 breakthrough from columns packed with Mg-Al LDH 2-coated sand, suggesting complete MS2 retention at the virus concentration tested. The high mass recovery by beef extract solution revealed that the removal of viruses by the LDH was due to sorption of MS2 to LDH surfaces, rather than inactivation.     

不同因素对黄山贡菊叶中过氧化氢酶活性的影响

以黄山贡菊离体叶片中过氧化氢酶为研究对象，采用室内模拟方法，研究不同因素处理对黄山贡菊离体叶片中过氧化氢酶活力的影响。结果表明，在30℃时酶活力较高，高温或低温时酶活力均减小；低浓度的K^＋和Ca^2＋对过氧化氢酶有激活作用，高浓度的K^＋和Ca^2＋对过氧化氢酶有抑制作用；Mg^2＋、Pb^2＋、Cu^2＋对过氧化氢酶均具有抑制作用，生长素和赤霉素对过氧化氢酶活性的影响不明显。     

广西桂林市全州县测土配方施肥水稻“3414”肥料效应田间试验结果分析

在广西桂林市全州县中等肥力土壤上的5年试验结果表明：水稻栽培增施N、P、K三要素肥料均具有增产效果,增产增幅N〉K〉P;全州县水稻栽培推荐的最大施肥量分别为N12.7 kg·666.7 m^-2,P 4.0 kg·666.7 m^-2,K 9.5 kg·666.7 m^-2;最佳施肥量分别为N11.7 kg·666.7 m^-2,P 3.5 kg·666.7 m^-2,K7.5 kg·666.7 m^-2。本研究结果为全州县测土配方施肥成果应用提供了依据。     

Effects of TiO2 based photocatalytic paint on concentrations and emissions of pollutants and on animal performance in a swine weaning unit

The beneficial effect of a TiO2-based photocatalytic treatment on the indoor air purification of a swine farm has been evaluated in a trial performed in two identical mechanically ventilated traditional weaning units, with 391 animals lodged in each of them. One unit was used as reference, whereas the walls of the second unit (260 m2) were coated with ca. 70 g m(-2) of TiO2 and irradiated with ten UV-A lamps. The environmental parameters (i.e. the ventilation rate, the internal and external temperature and relative humidity), together with NH3, CH4, CO2 and N2O concentrations in the exhaust ducts and PM10 emissions, were monitored in the two units throughout all of the production cycle (75 days). Significant decreases in CH4 concentration (ca. 27%, P < 0.05) and PM10 emission (ca. 17%, P < 0.01) were observed, together with an increase of the piglets' productive performance in the treated unit with respect to the reference one. Indeed, the ADG (Average Daily Gain of piglets) was 424 g vs. 414 g for the piglets lodged in the two units, respectively, with a significantly better feed conversion ratio (FCR, ratio between the food ingested by the animals and their weight gain) of 2.18 vs. 2.44 (P < 0.001). Therefore, the photocatalytic treatment with TiO2 coating had positive effects not only on methane concentration and particulate matter concentration and emission, but also significantly improved the feed conversion ratio of growing piglets, very likely due to the increased quality of indoor air, with positive economic repercussions for the farmer. Internal photocatalytic treatment in swine husbandry could thus be considered as a potential Best Available Technology (BAT).