微生物管式膜污水处理工艺试验与应用

某油田污水处理站设计处理规模1500 m³/d,实际处理量630 m³/d,处理工艺为“微生物接触氧化+加药絮凝沉淀+二级过滤”,在运行过程中投加的混凝剂等药剂成本高,且二级过滤器使用年限过长,其处理后出水无法达到Q/SYTH 0082—2020《油田注水水质规定》中油小于5 mg/L、悬浮物含量小于3 mg/L、粒径中值小于2μm的注水水质要求。该油田污水处理站开展了“特种微生物+低能耗管式膜”污水处理技术研究,并完成现场中试试验,处理后膜出水的悬浮物含量基本稳定在1 mg/L,出水水质达标,表明此工艺处理油田污水是可行和可靠的,为该油田污水处理工艺优化提供了可靠依据。     

超声波处理三元驱采油废水的实验

利用超声技术对油田三元驱采油废水的处理进行了实验研究。通过实验确定了超声波的最佳反应频率、功率、反应时间以及絮凝剂的筛选复配。实验结果表明:在最佳的反应条件下(超声频率为28kHz,超声频率为95 W,超声时间40min,沉降分离之后添加絮凝剂PAC 25mg/L,PAM 5mg/L),测得处理后的含油污水中悬浮物含量为1.5mg/L和含油率为4.9%,达到SY/T 5329—2012《碎屑岩油藏注水水质指标及分析方法》中低渗透油层注水水质要求。在不改变以重力沉降为主的传统采油污水处理工艺的前提下,为三元驱采油废水的处理提供一种经济高效的方法。     

一体式膜生物反应器(SMBR)处理抗生素废水研究

采用一体式膜生物反应器处理抗生素废水,用配水在水温30℃,体积负荷分别为0.5COD/m3*d,1.0COD/m3*d,1.5kgCOD/m3*d,出水COD、NH3-N均小于21.7mg/L、14.1mg/L,原水实验中在水温30℃时,体积负荷为0.957kgCOD/m3*d时,出水平均值分别为26.53mg/L,2.84mg/L、有较好的处理效果.     

化学氧化—混凝沉淀法处理油田作业废液

采用化学氧化—混凝沉淀法对油田作业废液进行处理,筛选出最佳的混凝条件及氧化条件。实验结果表明,与产出水混合处理后可使原水的悬浮物从500～1000 mg/L降至<3 mg/L、总铁<0.5 mg/L。处理后的污水由处理前的黑浆状变为清澈透明,淡黄色,基本达到了注水水质标准。该方法具有投资小、净化效果好、设备简单、占地面积小、操作方便、不产生二次污染等优点。     

油田压裂废液处理及回注实验

油田压裂废液具有高COD、高悬浮物等特点,处理达标难度大。以悬浮固体含量、悬浮固体颗粒粒径中值和含油量为指标,实验研究了混凝、微滤膜过滤技术参数,最佳条件为:絮凝剂投加量800～1 000mg/L,助凝剂投加量9～10mg/L,快速搅拌G值250～300s--1,慢速搅拌G值约50s--1,经50、10μm两级微滤膜过滤后悬浮固体含量、粒径中值、含油量满足SY/T 5329-2012《碎屑岩油藏注水水质指标及分析方法》标准要求。该方法工艺简单,成本低,在一定程度上解决了压裂废液难处理的问题。     

新疆油田压力式连续流过滤器工业性试验

介绍了压力式连续流过滤器用于油田采出水的工业性试验,试验结果表明:采用0.8～1.2 mm石英砂滤料处理水质悬浮物,73.7%情况下出水悬浮物可降至2 mg/L以下,26.3%情况下出水悬浮物可降至2～5 mg/L,水质介于一级与二级过滤指标要求之间,处理水质较双滤料过滤器出水水质好;采用0.5～0.8 mm金刚砂滤料,处理水质悬浮物在5～6 mg/L,含油在1 mg/L以下。     

油田高盐浓度废水对其生化处理的影响

根据油田压裂液废水中的盐浓度对生化处理系统的影响,对生化处理系统中活性污泥的生物学变化规律进行了实验研究。结果表明:当废水中盐浓度低于2.5×104mg/L时,废水生化处理系统对COD的去除率可稳定在92%左右,污泥活性良好;当废水中盐浓度达到2.5×104mg/L时,污泥活性开始受到抑制,COD去除率急剧下降(稳定在80%左右);当盐浓度达到3.5×104mg/L时,COD去除率下降到60%左右;当废水中盐浓度达到6.0×104mg/L时,污泥活性系统趋于崩溃。     

注空气低温氧化辅助热采废水处理

对注空气低温氧化辅助热采废水的处理进行实验研究,先进行混凝处理,再分别采用Fenton氧化法和二氧化氯氧化法对废水氧化处理。结果表明后者效果较好,二氧化氯最佳投加量为300 mg/L,催化剂活性炭-Ni投加量为2.5 g/L,反应2 h,COD_(Cr)降低至129.14 mg/L,去除率达到95.29%,出水无色透明。二氧化氯氧化法适合于海上油田注空气低温氧化辅助热采废水的处理。     

油田污水膜法处理工艺优化及膜污染分析

利用扫描电镜、原子力显微镜、能谱分析等对油田采出水膜污染的机理进行研究,确定了污水中的有机污染物是导致膜污染的主要因素.通过优化预处理,控制膜污染,形成以生物接触氧化为核心的预处理与膜过滤相集成的油田污水资源化处理工艺.现场试验结果表明：预处理后污水COD67.3～92.6mg/L,浊度〈0.5NTU,悬浮物〈1.0mg/L,含油〈1.0mg/L,保障了膜过滤系统的稳定运行.膜过滤产水达到油田锅炉用水和配制聚合物用水标准.     

垂直流人工湿地处理稠油废水的实验研究

采用垂直流人工湿地模拟装置对新疆油田外排含盐稠油废水进行了处理。实验表明:对于进水CODCr为402～406mg/L,盐度5701～5712mg/L,石油类40.62mg/L的含盐稠油废水,该系统的出水指标为CODCr35～38mg/L,盐度1535～1542mg/L,湿地系统对CODCr和盐分的去除率达到91%和73%;当水力停留时间为11d以上,出水石油类<5mg/L,处理后出水CODCr、石油类达到《污水综合排放标准》(GB8978-1996)的一级标准。     

含硫低浊度采油污水絮凝处理技术的研究

中原油田明二污属含硫低浊度污水,处理后水主要用于回注。文章通过pH调节剂的优选、除硫剂优选并与絮凝药剂联合,对明二污含硫低浊度污水进行了絮凝处理。结果表明:当pH值为7.5、2#絮凝剂加量为50mg/L、有机絮凝剂加量为0.5mg/L、除硫剂加量为20mg/L时,处理后水中的悬浮物、总铁和含油量分别达到1.9mg/L、0.43mg/L和0mg/L;SRB、TGB均为102个/mL;腐蚀速率及结垢量分别降到0.062mm/a和1.9mg/L;污泥产生量降低到0.23～0.26mg/L;在90℃时的结垢量由地层水的23.3mg/L降低到1.9mg/L,处理后的水达到中原油田回注水的水质标准,并且水质稳定。     

Treatment of wastewater phosphate by reductive dissolution of iron: use of ferric oxyhydroxide media

In smaller wastewater treatment systems such as septic systems, there is an interest in the development of passive phosphorus (P) removal methods. This study tested fixed-bed filters containing ferric oxyhydroxide media for wastewater P removal in a laboratory column test and in a full-scale domestic septic system. In the column test, during 30 mo of dosing with domestic wastewater, reductive iron dissolution reactions delivered consistent moderate concentrations of Fe into solution (2.9 ± 1.6 mg L), and influent PO-P of 3.7 ± 1.0 mg L was attenuated to 0.09 + 0.04 mg L in the column effluent (98% removal). Phosphorus breakthrough at successive locations along the column indicated that in addition to sorption, mineral precipitation reactions probably also played an important role in the observed P attenuation. This was supported by electron microprobe analyses, which showed the presence of thick (20 μm) secondary Fe-rich coatings containing P on the primary ferric media grains. Assays of NaHCO-leachable and acid-extractable P on the column solids showed accumulation of up to 5.4 mg g acid-extractable P near the column inlet, but <5% of this amount was easily desorbable, further indicating P attenuation from processes other than sorption. Over 19 mo of operation, the domestic septic system also showed generally consistent increased Fe in the filter effluent (2.6 ± 1.7 mg L) and achieved 99% P removal to 0.03 ± 0.02 mg L when the effluent was subsequently oxidized in a sand filter. Ferric iron filters could be attractive options for P removal in smaller wastewater systems because of their passive nature.     

The performance of constructed wetlands treating primary, secondary and dairy soiled water in Ireland (a review)

In Ireland, no database detailing the design, influent loading rates or performance of constructed wetlands (CWs) exists. On account of this, they are designed without any protocol based on empirical data. The aim of this paper was to provide the first published data on the performance of free-water surface flow (FWSF) CWs treating primary and secondary-treated municipal wastewater, and agricultural dairy soiled water (DSW) in Ireland. In total, the performance of thirty-four FWSF CWs, comprising fourteen CWs treating primary-treated municipal wastewater, thirteen CWs treating secondary-treated municipal wastewater, and seven CWs treating DSW, were examined. In most CWs, good organic, suspended solids (SS) and nutrient removal was measured. At an average organic loading rate (OLR) of 10 and 9 g biochemical oxygen demand (BOD) m(-2) d(-1), CWs treating primary and secondary wastewater removed 95 and 84% of influent BOD. Constructed wetlands treating DSW had an average BOD removal of 98%. At average SS loading rates of 6 and 14 g m(-2) d(-1), CWs treating primary and secondary wastewater had a 96 and an 82% reduction, and produced a final effluent with a concentration of 14 and 13 mg L(-1). Constructed wetlands treating DSW produced a final effluent of 34 mg L(-1) (94% reduction). Similar to other studies, all CWs examined had variable performance in ammonium-N (NH(4)(+)-N) removal, with average removals varying between 37% (for CWs treating secondary wastewater) and 88% (for CWs treating DSW). Variable ortho-phosphorus (PO(4)(3-)-P) removal was attributable to different durations of operation, media types and loading rates.     

中空纤维膜生物反应器处理炼厂浮选池出水试验研究

研究设计的膜生物反应器处理炼厂浮选池出水,在每天进水容积负荷1.0 kg COD/m3,进水COD浓度600 mg/L,MLSS为900～5500 mg/L的条件下,无论活性污泥表现正常还是膨胀,过滤出水中COD均稳定地小于90 mg/L,处理效果好于目前炼油厂的合建式曝气池(容积负荷为0.5 kg COD/m3左右,出水COD100 mg/L左右)。试验运行期间,膜通量最高可达到42 L/m2·h。该工艺的技术关键是采用特殊流态来降低膜堵塞的膜生物反应器和优良质量的膜。     

三步法处理大港油田12井综合废水的实验研究

根据大港油田12井综合废水的污染特征,提出了"混凝-内电解-H2O2氧化"三步处理的方法。实验结果表明:三步法处理后可以使原水的CODcr从4930mg/L降低到128mg/L,去除率达到97%。处理后水质达到国家《污水综合排放标准》(GB8978-1996)二级标准要求。     

ABR+活性污泥法在番茄废水中的应用

以奇台太极华力食品有限公司番茄废水处理工程实例为依据,介绍了采用ABR厌氧+完全混合活性污泥法工艺在处理番茄加工废水的设计、调试及运行情况。经过2年运行,其进水COD在700~1 500mg/L之间,最大处理水量达到4 000m3/d;出水COD在40~70mg/L之间,COD去除率达到97%。处理出水可以稳定达到污水综合排放二级标准。ABR+完全混合活性污泥法工艺具有启动快,调试时间短,工程造价低的优点,尤其适宜处理番茄等间歇时间长工作时间短的季节性生产污水。     

CONTROL OF SUSPENDED SOLIDS AND PHYTOPLANKTON WITH FISHES AND A MUSSEL1

ABSTRACT: Filtering efficiency of the fathead minnow (Pimephales promelas), gizzard shad (Dorosoma cepedianum), carp (Cyprinus carpio), and a freshwater mussel (Elliptio coinpianata) was measured in field and laboratory trials to assess the ability of each species to control phytoplankton and suspended solid densities. All fish species tested were ineffective filterers and generally increased, rather than suppressed, algal and suspended solid concentrations. Filtering efficiencies of fish varied between -354 and 84 percent, depending on the size, shape, abundance, palatability, composition, and resistance to digestion of the particles. Because of poor filtering abilities, unpredictable feeding habits, and sensitivity to stress, the fish species examined are not effective biological controls in waste lagoons. In contrast, the freshwater mussel Elliptio was a highly effective control organism, averaging 66 percent filtering efficiency over a wide size range of algal and suspended particles. Filtration efficiency was positively correlated with mussel density. Elliptio was efficient at filtering small particles, which are particularly difficult to remove. Mean filtration rates ranged from 53 to 134 ml/mussel/h depending on the algal species consumed and algal densities (range 50–180,000 cells/ml) and 3 mg/L/mussel/h on suspended solids (range 14 to 112 mg/L). Water clarification was facilitated by both direct consumption and pseudofeces deposition. Elliptio and probably other mussel species can effectively control algae and suspended solids in wastewater lagoons and eutrophic lakes, if environmental conditions, especially dissolved oxygen levels, are suitable (>5 mg/L) for their survival.