稠油废水及油性废渣处理技术

克拉玛依油田的稠油废水及油性废渣的有效治理,一直是困扰油田的技术难题。为了解决这一难题,利用专效化学药剂使废水内含的油性杂质产生中和、破乳、架桥、絮凝等反应形成絮凝胶体,通过机组的加压、加气、混匀、旋流、释放、气浮、分离、阻截等物理作用,加速药剂与杂质的反应过程,将其从水体中分离出来,达到净化水质的目的。对油性废渣,加入还原剂在室温以上进行充分搅拌,产生还原反应,分离成原油和铝（铁）离子水溶液。该项技术经过三年多的实践与探索,在机组性能、运行费用、作业条件等方面,取得了满意的效果,特别是油渣回收处理不仅消除了二次污染,填补了国内技术空白,而且具有明显的环境效益与经济效益。     

不停产检修曝气系统在污水处理中的应用

本文介绍了在污水处理中好氧阶段的可不停产检修的曝气系统，重点阐述了实现不停产检修的曝气系统的曝气器选用及下垂式曝气系统、上浮式曝气平台、漂浮式曝气悬链三种布气装置。该技术能够实现污水处理厂的不停产检修，保证污水处理设施的连续运行，具有很高的推广价值。     

曝气生物滤池在石化污水处理工程中的应用

曝气生物滤池可以用于石化污水的二段生化处理,是一种运行可靠、自动化程度高、出水水质好和抗冲击能力强的好氧生物处理新工艺。它与活性污泥法工艺相比,对于低基质污水二段生化工况,其有机物容积负荷高,污水停留时间短,其后不须设置二次沉淀池。与普通生物滤池相比,其占地面积小,不宜堵塞。与生物接触氧化方法相比,生物活性较高,处理效果好。曝气生物滤池集曝气池、二次沉淀池和滤池的功能于一身,其出水水质指标可以完全达到《污水综合排放标准》(GB8978-1996)一级标准。     

污水处理中影响微孔曝气充氧性能因素的研究

对污水处理中微孔曝气充氧性能影响因素的研究是一个复杂而又重要的问题。本文对污水水质、曝气器通气量、曝气池运行负荷和方式等几个主要因素对微孔曝气充氧性能的影响进行了研究探讨。鉴于曝气系统能耗在污水处理厂中所占比重较大，加强对该问题的研究，以降低处理厂能耗，有较好的经济意义。     

啤酒废水治理技术研究现状

啤酒废水具有水量大、污染物浓度高、易生物降解的特点。介绍了当前厌氧一好氧的组合工艺中UASB—SBR工艺、UASB—CASS工艺、EGSB一接触氧化工艺、USFB—AODT工艺、水解酸化-UASB—A／O工艺等主流工艺的原理和研究现状,以及射流曝气MBR5-艺、双极室联合工艺、光合细菌治理工艺等将来啤酒废水治理热点技术,并对啤酒废水治理技术的未来发展趋势进行了展望。     

Closed wastewater cycle in a meat producing and processing industry

Creta Farm Plc, owns the largest meat producing (pigs rearing), processing and packaging unit in the island of Crete, in Greece, placed outside the city of Rethymnon in the north coast of the island. From the farm, where more than 20 000 pigs of various ages and sizes live, 300–320 m³ of wastewater are collected in a daily basis. From the slaughterhouse and the processing unit another 100–125 m³/d are produced. The wastewater treatment system is a combination of settling and aeration tanks, with decanters operating in different phases of the process, mainly for the removal of the solids from the wastewater. The average biochemical oxygen demand and total suspend solids values of the treated effluent are 40 and 80 mg/l, respectively. From this almost secondary treated effluent about 100 m³ are used for cleaning the sewage pipes of the rearing unit (animals houses). The remaining 300 m³ are disinfected with a weak chlorine solution before used for irrigating trees, grass and various other plants. More than 2000 eucalyptus trees, 1500 tamarix trees and a large number of olive trees are growing in the site creating a pleasant view and at the same time help minimising the odour problem.     

硫磺回收装置脱硫废液处理的试验研究

采用将脱硫废液与炼油废水按比例混合之后对其进行处理的方法,通过批式试验,考查混合废液的BOD5/COD指标及其COD、NH3-N、S2-的去除率。筛选合适的混合液配比,分别对500︰1和800︰1的混合废液进行了模型试验,分析了COD去除效果。结果表明:800︰1的混合废液在10d之后,出水COD为134mg/L,达到了《污水综合排放标准》(GB8978—1996)二级标准要求。最终确定炼油废水与脱硫废液混合的合适比例应不低于800︰1。     

Allocation of supplementary aeration stations in the Chicago waterway system for dissolved oxygen improvement

The Chicago Waterway System (CWS), used mainly for commercial and recreational navigation and for urban drainage, is a 122.8 km branching network of navigable waterways controlled by hydraulic structures. The CWS receives pollutant loads from 3 of the largest wastewater treatment plants in the world, nearly 240 gravity Combined Sewer Overflows (CSO), 3 CSO pumping stations, direct diversions from Lake Michigan, and eleven tributary streams or drainage areas. Even though treatment plant effluent concentrations meet the applicable standards and most reaches of the CWS meet the applicable water quality standards, Dissolved Oxygen (DO) standards are not met in the CWS during some periods. A Use Attainability Analysis was initiated to evaluate what water quality standards can be achieved in the CWS. The UAA team identified several DO improvement alternatives including new supplementary aeration stations. Because of the dynamic nature of the CWS, the DUFLOW model that is capable of simulating hydraulics and water quality processes under unsteady-flow conditions was used to evaluate the effectiveness of new supplementary aeration stations. This paper details the use of the DUFLOW model to size and locate supplementary aeration stations. In order to determine the size and location of supplemental aeration stations, 90% compliance with a 5 mg/l DO standard was used as a planning target. The simulations showed that a total of four new supplementary aeration stations with oxygen supply capacities ranging from 30 to 80 g/s would be sufficient to meet the proposed target DO concentration for the North Branch and South Branch of the Chicago River. There are several aeration technologies, two of which are already being used in the CWS, available and the UAA team determined that the total capital costs of the alternatives range from $35.5 to $89.9 million with annual operations and maintenance costs ranging from $554,000 to $2.14 million. Supplemental aeration stations have been shown to be a potentially effective means to improve DO concentrations in the CWS and will be included in developing an integrated strategy for improving water quality in the CWS.     

间歇式活性污泥法处理1-4丁二醇废水的研究

用间歇式活性污泥法(SBR法)对高浓度1-4丁二醇废水进行了处理研究。实验测定了污泥沉降性能,测试了最佳曝气时间、最佳pH值范围以及SBR处理系统耐污染的负荷。实验结果表明:SBR法的污泥沉降比为15%～30%,完全符合活性污泥正常运行时的沉降标准。处理污水的最佳曝气时间为5h,最佳pH值范围为7～8。该处理系统耐冲击,能承受较高的污染负荷,对水质的波动有较强的承受能力。利用SBR法可以处理1-4丁二醇、聚丙烯酰胺和顺丁烯二酸酐三套装置排放的混合污水。     

Cost analysis of alternative methods for wastewater handling in small communities

Wastewater collection and treatment is quite important for sustainable management. It would be uneconomical and impractical to provide sewer systems and separate wastewater treatment plants (WWTP) for small communities. The decision process in wastewater planning is rather important in terms of comparing the alternatives considered. The two important points in the management of wastewater at rural areas not connected to a sewer system are to develop an optimized operation strategy and to make sure that the complete system is environmentally and economically sustainable. In some regions, package treatment could be an alternative solution. However, in cases where there is an existing large WWTP, a cluster system, where sewage generated by small communities could be transported via conveyors to a centralized WWTP, could be employed. In this study, the wastewater treatment and disposal problems in small communities were addressed and an alternative wastewater handling scenario was proposed. Additionally, three wastewater handling scenarios were compared. As a case study, Gebze villages were selected.     

Operation strategy of a sequencing batch reactor for simultaneous removal of wastewater organic matter and nutrients

The Sequencing Batch Reactor (SBR) system employing activated sludge process is an alternative wastewater treatment technology. A cycle of the conventional SBR system generally consists of five periods, with complete aeration during the React period to oxidize the organic matter and nitrify the ammonium-nitrogen of wastewater. Laboratory-scale reactors were used to evaluate the feasibility of incorporating alternative aerobic-anoxic-aerobic stages within the React period for simultaneous removal of organic matter, N and P. Two cycles of SBR process per day were maintained.Under the operation strategy of 0.75-h fill, 8-h react (with continuous aeration), 3.25-h settle, draw and idle periods, the treatment performance became consistent after running the system for two to four cycles (1–2 days). The percentages of both BOD₅ and COD removal were around 94% from Cycle 2 onwards, the BOD₅ content dropped from initial 251 mg L⁻¹ to less than 14 mg L⁻¹ in the final effluent. A steady nitrification (about 97%) was obtained from Cycle 4 onwards, with 1 mg NH₄⁺-N L⁻¹ and 25 mg NO₃⁻-N L⁻¹ present in the final effluent. This suggested that the time required for SBR system to acclimate and reach an equilibrium state was relatively short when compared with the time needed for continuous flow activated sludge system. The findings also show that 4-h aeration during the react period was long enough to achieve more than 90% nitrification. With the incorporation of a 3-h anoxic stage after the initial 4-h aeration of the react period, a satisfactory denitrification process was observed, with nitrate level dropped from 27 to around 8 mg L⁻¹ within 3 h. The second aeration stage did not cause significant change in wastewater nitrogen content. The wastewater phosphate content declined rapidly during the initial 4-h aeration and P-release was not observed during the anoxic stage. A slight reduction of P was found in the second aeration stage suggesting that more P-uptake occurred in this stage. A 12-h cyclic SBR system with the incorporation of 4-h aerobic, 3-h anoxic and final 1-h aerobic stages into the 8-h react period was demonstrated to be able to remove C, N and P simultaneously.     

Industrial experience of process identification and set-point decision algorithm in a full-scale treatment plant

This paper presents industrial experience of process identification, monitoring, and control in a full-scale wastewater treatment plant. The objectives of this study were (1) to apply and compare different process-identification methods of proportional-integral-derivative (PID) autotuning for stable dissolved oxygen (DO) control, (2) to implement a process monitoring method that estimates the respiration rate simultaneously during the process-identification step, and (3) to propose a simple set-point decision algorithm for determining the appropriate set point of the DO controller for optimal operation of the aeration basin. The proposed method was evaluated in the industrial wastewater treatment facility of an iron- and steel-making plant. Among the process-identification methods, the control signal of the controller's set-point change was best for identifying low-frequency information and enhancing the robustness to low-frequency disturbances. Combined automatic control and set-point decision method reduced the total electricity consumption by 5% and the electricity cost by 15% compared to the fixed gain PID controller, when considering only the surface aerators. Moreover, as a result of improved control performance, the fluctuation of effluent quality decreased and overall effluent water quality was better.     

溶解氧对好氧颗粒污泥影响的研究进展

好氧颗粒污泥技术是一种新颖废水处理技术。溶解氧(DO)是好氧颗粒污泥形成和稳定运行的一个重要参数。好氧颗粒污泥需要的曝气量大,能耗高。高曝气量带来的高DO浓度不利于氨氮通过SND去除。当DO扩散在颗粒内部受到限制时,颗粒中心形成的厌氧层不利于颗粒污泥的长期稳定运行。本文系统分析了DO浓度对好氧颗粒污泥影响的国内外研究现状,对好氧颗粒污泥中DO浓度这一重要参数的研究进行了总结。研究在低DO浓度下保持好氧颗粒污泥的稳定性有利于降低运行成本,采取合适的方法降低颗粒内部的扩散限制有利于增强颗粒的稳定性能。     

Evaluation of municipal wastewater treatment plants with different technologies at Las Rozas, Madrid (Spain)

Eight small-scale municipal wastewater treatment plants were evaluated over a period of 19 months in the suburb of Las Rozas in Madrid (Spain). Four plants used compact extended aeration, two used conventional activated sludge, two used conventional extended aeration, one used a rotary biodisc reactor and the other used a peat bed reactor. The best results were obtained from the plants that used conventional technologies and the biodisc. Conventional activated sludge and extended aeration had higher removal efficiencies for ammonia, TSS, COD and BOD(5) and produced good quality final effluents for final disposal in accordance with the discharge standard. Empirical equations that correlated the concentration of dissolved oxygen in the effluents with the efficiencies of TSS, ammonia, COD and BOD(5) removals for all plants evaluated were obtained. The performance of the plants using compact extended aeration was affected more than those using conventional technologies or rotary biodisc when the capacity exceeded that of its initial design.     

Experimental study on microalgae cultivation in novel photobioreactor of concentric double tubes with aeration pores along tube length direction

Microalgae have been identified as a superior feedstock for biodiesel production and varied tubular photobioreactors are developed for high efficient and scale-up microalgae cultivation. This article presented a novel concentric double tubes using aeration through radial pores along the length direction of inner tube. Experiments on microalgae cultivation were carried out in the novel photobioreactor, and two control groups including concentric double tubes with axial aeration at both ends and common tubular. The biomass productivity of novel photobioreactor increased by 43.6% and 107.4%, respectively, compared with concentric double tubes with axial aeration at both ends and common tubular without aeration. The values of pH shifted from 7.5 to 9.0 for novel photobioreactor, but 7.5 to 8.8 for common tubular, and 7.5 to 9.6 for concentric double tubes with axial aeration. The dissolved oxygen concentration fluctuated between 6.0 and 7.0 mg·L^?1 for novel photobioreactor, but rose from 6.6 to 10.2 mg·L^?1 for the common tubular, and 6.9 to 8.1 mg·L^?1 for the concentric with axial aeration. Results show that the aeration style of novel photobioreactor can make efficient local mixing and maintain smaller range of pH and lower level of dissolved oxygen in case of higher biomass concentration. Moreover, compared with the two control groups, the novel concentric double tubes have advantages on the light/dark cycle frequency, which may be benefit for microalgae cultivation. The novel concentric double tubes presented in this work can give some inspiration for high efficiency microalgae cultivation.     

Emergy analysis of municipal wastewater treatment and generation of electricity by digestion of sewage sludge

This study examines and evaluates, by using emergy analysis, the use of environmental resources for wastewater treatment in a Swedish town. Emergy analysis was applied, while it facilitates the comparison of resource use of substantially different kind. In the emergy analysis, all resources are assessed on the basis of the amount of direct and indirect solar energy required in their generation. The study also includes an evaluation of the amount of emergy associated with the production of wastewater. On the basis of our analysis, we suggest that the large amount of emergy that wastewater contains are in proportion to the amount of resources employed for wastewater treatment and the extensive effects on surrounding ecosystems of discharge of untreated wastewater. The use of local renewable natural resources in Swedish municipal wastewater treatment systems is negligible compared with the use of purchased inputs, processed largely with the support of fossil energy. A drastic shift of this order would demand that extensive land areas surrounding human settlements be (indirectly or directly) devoted to wastewater treatment. These areas are not accessible today. Our analysis also indicates that resource requirements from the economy in the production of electricity by the digestion of sewage sludge is about two times the total resource use for generation of the average mix of electricity used in the town. We, therefore, conclude that if the only reason to digest the sludge were to produce electricity, it would be more resource-efficient to purchase the electricity on the Swedish distribution net. Accordingly, there is no resource economy in producing biomass to digest just to increase the energy production at the wastewater treatment plant.     

含铜废水处理技术现状

含铜废水主要来源于工业生产过程，如不经过适当处理排入环境，将给环境带来极大危害。含铜废水的主要处理方法有化学沉淀法、离子交换法、电解法等。由于各生产过程不同，废水中铜的存在状态与价态都各有差异，对于不同类型含铜废水的处理应依据废水性质，选用不同工艺或工艺组合对废水进行处理，以满足排放标准的要求。同时在处理含铜废水时，应考虑处理后出水的回用和废水中铜的资源化问题。     

Point- and nonpoint-source pesticide contamination in the Zwester Ohm catchment, Germany

Reducing pesticide loads in surface waters implies identifying the pathways responsible for the pollution. The current study documents the pesticide contamination of the river Zwester Ohm, a 4917-ha catchment in Germany with 41% of the land used for crop production. Discharges and concentrations of 19 pesticides were measured continuously at three locations for 15 mo. The load detected at the outlet of the catchment amounted to 9048 g a.i. The losses represent 0.22% of the pesticides applied by the farmers. The contamination showed a seasonal pattern following the pesticide application times. The wastewater treatment plant system (WWTPS) in the catchment (two wastewater treatment plants [WWTP], 14 combined sewer overflows (CSO), four CSO tanks) emits during dry weather periods purified sewage and during storm events sewage mixed with stormwater runoff into the river. The contribution by the WWTPS to the pesticide load was defined as point-source pollution (PSP). The load was dominated by PSP with at least 77% of the total pollution. No significant interdependencies between intrinsic properties of the pesticides, hydrometeorological factors, and the loads occurring in the stream could be found. Therefore, it is not possible to predict PSP for other catchments based on the results from this study. Whereas 65% of the total load entered the river via the WWTP, a portion of 12% was attributed to the CSO. The study points out that the influence of CSO on PSP should be taken into account in future catchment studies in areas with comparable agricultural structure.     

膜曝气生物膜反应器生物膜影响因素分析

膜曝气生物膜反应器（MABR）是一种利用透气膜进行曝气，可以实现同步硝化反硝化的污水生物处理新工艺。本文阐述了膜曝气生物反应器生物膜的原理和特点，总结了国内外在该领域的研究成果，重点介绍了C／N、氧气压力、流速、生物膜厚度、温度和pH对生物膜性能的影响。     

水质改性工艺原理和现场管理探讨

中原油田的注入水是一种由CO2-HCO-3构成的弱酸性缓冲体系,具有很强的腐蚀倾向,增加了水处理的难度。通过加入一种以OH-为主要成份的调整剂,对水中离子进行重新调整,除掉水中的CO2和HCO-3离子,使水中离子形成热力学或动力学的稳定分布,从而抑制使水质变劣的化学反应,使水质沿注水流程达标。通过几年的实践,表明该工艺在处理油田污水方面具有可行性和实效性。采用该工艺的污水处理站水质全面达标。