A Watershed-based Cumulative Risk Impact Analysis: Environmental Vulnerability and Impact Criteria

Swine Concentrated Animal Feeding Operations (CAFOs) have received much attention in recent years. As a result, a watershed-based screening tool, the Cumulative Risk Index Analysis (CRIA), was developed to assess the cumulative impacts of multiple CAFO facilities in a watershedsubunit. The CRIA formula calculates an index number based on: 1) the area of one or more facilities compared to the area of the watershed subunit, 2) the average of the environmental vulnerability criteria, and 3) the average of the industry-specific impact criteria. Each vulnerability or impact criterion is ranked on a 1 to 5 scale, with a low rank indicating low environmental vulnerability or impact and a high rank indicating high environmental vulnerability or impact. The individual criterion ranks, as well as the total CRIA score, can be used to focus the environmental analysis and facilitate discussions with industry, public, and other stakeholders in the Agency decision-making process.     

高效酶促进剂Accell在养猪废水处理工艺中的应用研究

为了考察高效酶促进剂在养猪废水处理工艺中的功能,在养猪废水治理工艺的生化段SBR反应器进水中投加高效酶促进剂Accell.两套相同的装置平行运行的效果对比表明:投加Accell可减少剩余污泥的排放量,增加溶氧效率,强化污染物的去除效果;投加高效酶的装置对COD的去除可在SBR反应器基础上再减少40%以上,对NH3-N的去除可进一步再减少25%以上,对P的去除也有一定的促进作用.     

生态高负荷土地快速渗滤系统处理猪场废水的效能及微生态

以经过厌氧反应器处理后的猪场废水为研究对象,探讨了新型生态高负荷土地快速渗滤系统对废水中COD、氨氮及总氮的去除情况;同时分析了该系统中的微生物群落结构以及过氧化氢酶、脲酶、硝酸盐还原酶的含量.结果表明,在水力负荷为11 cm·d~(-1)、进水COD为700 mg·L~(-1)左右的条件下,一级土地渗滤柱与二级土地渗滤柱对COD的去除率分别为78.8%与63.0%,总去除率达到了92.6%;而当水力负荷增大到22 cm·d~(-1)时,总的COD去除率仍在90.0%以上;该系统对于氨氮的去除更为显著,去除率可达99%左右.一级土地快速渗滤系统中上、中、下部的过氧化氢酶含量分别为1.899、0.990、0.323 m L·g~(-1),表明猪场废水中的有机物主要在该系统的上部与中部得以去除;二级土地快速渗滤系统上、中、下部的硝酸盐还原酶含量分别是3.453、3.831、1.971 m L·g~(-1),表明脱氮作用主要发生二级土地快速渗滤系统的上部与中部.该土地快速渗滤系统中微生物以Gram Negative与Gram Positive为主,特别是在二级土地快速渗滤系统中,AM Fungi与Actinomycetes占有一定比例,为猪场废水中难降解有机物的去除提供了保障.     

四环素抗性基因在人工湿地中的去除及累积

以垂直潜流人工湿地系统为试验装置,考察了猪场养殖废水中四环素类抗生素抗性基因(tetW、tetM和tetO)在人工湿地中的去除及累积情况.结果表明,养猪废水中的3种抗性基因均有检出且含量较高,tetW、tetM和tetO的平均绝对含量分别为1.07×1010、4.03×1010和4.92×1010copies.L-1.通过湿地系统处理后,水体中抗生素抗性基因绝对拷贝数和相对表达量均明显降低,tetW、tetM和tetO的平均去除率分别为95.73%、92.21%和95.05%.在系统运行末期,湿地表层土壤和底层土壤中tetW、tetM和tetO的绝对拷贝数和相对表达量均有明显的升高,并且抗性基因在表层土壤中的累积水平高于底层土壤.因此,人工湿地系统可有效降低养猪废水中抗生素抗性基因的绝对及相对含量水平,系统的运行条件可对抗生素抗性基因在湿地系统中的积累产生影响.     

高径比对猪场废水脱氮与沼气脱硫耦联反应器的影响

采用填料鼓泡塔反应器研究其高径比对猪场废水脱氮与沼气脱硫耦联过程的影响,比较了3种不同高径比(8∶1、3∶1、2∶1)反应器的废水脱氮与沼气脱硫效能.在温度30～32℃、空塔停留时间6.70 min、水力停留时间3.35 d、沼气中H2 S浓度1 414～1 838 mg.m-3、进水NO x--N浓度114～243 mg.L-1的条件下,高径比2∶1反应器的运行较稳定,且处理效果较好,硫化氢去除率平均值为96.7%,NO x--N去除率平均值达到88.7%;而高径比8∶1和3∶1反应器的运行不太稳定,硫化氢去除率的平均值分别为68.0%、80.4%,NO x--N的去除率平均值分别为89.7%、90.2%.主要是因为高径比2∶1反应器的实际气速(3.12×10-2 m.s-1)比高径比3∶1、8∶1反应器的实际气速(分别为3.62×10-2 m.s-1和6.64×10-2 m.s-1)更慢,其气液传质系数(1.79×10-5 s-1)比高径比3∶1、8∶1反应器的气液传质系数(分别为1.64×10-5 s-1和1.55×10-5 s-1)更大,传质效果更好.处理效能试验结果以及反应器流体力学特征参数均表明,高径比2∶1反应器为最适合的反应器.     

猪粪秸秆高温堆肥过程中碳氮转化特征与堆肥周期探讨

将猪粪与秸秆以7：1（质量比,以鲜重计）的比例,在自制的强制通风静态堆肥反应箱中进行高温堆肥试验,研究了堆肥过程中碳氮转化特征及其腐熟时间.同时,在堆制的23d中,根据堆温变化采样6次,分析了堆肥样品中各种氮素和碳素含量及其它性质的变化情况.结果表明：堆肥结束时,硝态氮含量增加了103.0%,铵态氮、有机氮、总氮含量分...     

Comparative study of heavy metal and pathogenic bacterial contamination in sludge and manure in biogas and non-biogas swine farms

The objective of this study is to determine and compare the heavy metal (Zn, Cu, Cd, Pb) and bacterial (E. coli, coliform and Salmonella spp.) contamination between swine farms utilizing biogas and non-biogas systems in the central part of Thailand. Results showed that average levels of E. coli, coliform, BOD, COD, Zn, Cu and Pb in sludge from the post-biogas pond were higher than the standard limits. Moreover, the levels of E. coli, coliform, Cd and Pb were also higher than the standard limits for dry manure. The levels of E. coli, coliform and BOD on biogas farms were lower than on non-biogas farms. Following isolation of Salmonella spp:; it was found that Salmonella serovars Rissen was the most abundant at 18.46% (12/65), followed by Anatum 12.31% (8/65), and Kedougou 9.23% (6/65). The pathogenic strains of Salmonella serovars Paratyphi B var. java and Typhimurium were present in equal amounts at 4.62% (3/65) in samples from all swine farms. This study revealed that significant reduction in E. coli and coliform levels in sludge from covered lagoon biogas systems on swine farms. The presence of Salmonella as well as Cd and Pb, in significant amount in dry manure, suggests that there is a high probability of environmental contamination if it is used for agricultural purposes. Thus, careful waste and manure disposal from swine farms and the regular monitoring of wastewater is strongly recommended to ensure the safety of humans, other animals and the environment.     

猪粪干发酵物料流动性指标研究

干式沼气发酵工艺的研究中,影响干发酵工艺的最大问题是出料困难.出料的方法及设备的研究开发都涉及物料流动性.目前,还没有表征干发酵物料流动性的指标.针对该问题,本研究考察了塌落度、休止角和静摩擦系数3种参数表征猪粪干发酵物料流动性的可行性.通过3种指标对流速的曲线拟合,发现塌落度与流速的关联性最好,灵敏度系数曲线显示塌落度的灵敏度较休止角和静摩擦系数高.塌落度的测定上限和测定下限分别为253和279 mm,对应的流速分别为0.01和0.29 m/s;休止角和静摩擦系数的准确度均超出了要求的范围,所以无测定限.塌落度的最大相对误差、相对平均偏差和相对标准偏差分别为12.79％、23.62％和30.68％,远低于休止角和静摩擦系数,因此,塌落度测量结果的准确度和精密度高于休止角和静摩擦系数.从参数的准确度和精密度以及测量方法的灵敏性和测定限几方面综合考虑,塌落度适合作为表征猪粪干发酵物料流动性的指标.     

基于碱度平衡与反硝化动力学的厌氧-加原水-间歇曝气工艺配水比例模型

采用批式反硝化试验,研究了BOD5和NOx-N(NO3--N与NO2--N之和)浓度对反硝化速率的影响.结果表明,在碳源充足的条件下,猪场废水厌氧消化液反硝化过程中NOx-N转化为零级反应,与NOx-N浓度无关;在碳源限制的条件下,猪场废水厌氧消化液反硝化过程中NOx-N转化速率与BOD5的关系遵从Monod方程.以Monod方程和碱度平衡为基础,推导出配水比例的数学模型.通过模型分析表明,进水碱度与进水氨氮浓度之比小于3.82时,仅靠配水措施不能平衡整个处理系统的碱度,还需要外加碱度;进水碱度与进水氨氮浓度之比大于6.90时,序批式反应器(SBR)可以直接处理厌氧消化液,不需要配水,厌氧-加原水-间歇曝气工艺不适用.猪场废水厌氧消化液的碱度与氨氮浓度之比大多为3.82～6.90,因此,猪场废水厌氧消化液好氧后处理适宜采用厌氧-加原水-间歇曝气工艺.通过数学模型作图显示,配水比例随着水力停留时间、SBR反应器数量、反应器中微生物浓度、滗水器工作能力以及亚硝化率的增加而减少,随着反应器运行周期的增加而增加.     

猪粪堆肥发酵菌种的分离筛选及特性研究

从多种样品材料中分离筛选出8株能以猪粪为基质生长的菌种,对其中4株菌(8B、8C、8E、2B)进行了初步分类鉴定,并对它们发酵猪粪培养基的特性作了研究.结果表明,这4株菌均属于芽孢杆菌属,其中8C、2B菌种生长最好,8B次之,而8E菌种则不适合作为发酵菌种;对培养基采取完全灭菌对菌种生长繁殖是有利的,间歇灭菌和不灭菌效果相对较差,甚至会对菌种产生不利影响;pH值的变化在一定程度上反映出微生物生长繁殖能力的强弱;较低的pH值不利于微生物菌种生长.