Response surface method for modeling the removal of carbon dioxide from a simulated gas using water absorption enhanced with a liquid-film-forming device

This paper presents the results from using a physical absorption process to absorb gaseous CO_2mixed with N_2using water by producing tiny bubbles via a liquid-film-forming device(LFFD)that improves the solubility of CO_2in water.The influence of various parameters—pressure,initial CO_2concentration,gas-to-liquid ratios,and temperature—on the CO_2removal efficiency and its absorption rate in water were investigated and estimated thoroughly by statistical polynomial models obtained by the utilization of the response surface method(RSM)with a central composite design(CCD).Based on the analysis,a high efficiency of CO_2capture can be reached in conditions such as low pressure,high CO_2concentration at the inlet,low gas/liquid ratio,and low temperature.For instance,the highest removal efficiency in the RSM–CCD experimental matrix of nearly 80%occurred for run number 20,which was conducted at 0.30 MPa,CO_2concentration of 35%,gas/liquid ratio of 0.71,and temperature of 15°C.Furthermore,the coefficients of determination,R~2,were 0.996 for the removal rate and 0.982 for the absorption rate,implying that the predicted values computed by the constructed models correlate strongly and fit well with the experimental values.The results obtained provide essential information for implementing this method properly and effectively and contribute a promising approach to the problem of CO_2capture in air pollution treatment.     

Contamination of butyltin and phenyltin compounds in the marine environment of Otsuchi Bay, Japan

Butyltin (BT) and phenyltin (PT) compounds were measured in seawater, sediment, and biological samples collected from coastal areas of Otsuchi Bay, Japan. Tributyltin (TBT) compounds in seawater, sediment, plankton, mussels, scallops and fish were in the range of 0.008-0.074 microg liter(-1), 0.01-0.64 mg (kg dry wt)(-1), 0.24-9.8 mg (kg dry wt)(-1), 0.04-0.18 mg (kg wet wt)(-1), 0.10-0.13 mg (kg wet wt)(-1) and 0.01-0.02 mg (kg wet wt)(-1), respectively. Trace amount of PTs were found in seawater. The highest concentrations of TBT and triphenyltin (TPT) were found near a shipyard. Triorganotin compounds were more dominant than their metabolites. A positive correlation was observed between the concentrations of TBT and TPT in the mussels. Concentrations of TBT and TPT in mussels were high in the upper intertidal zone, and decreased toward the water.     

Transportation of organic matter to the sea floor by carrion falls of the giant jellyfish <Emphasis Type="Italic">Nemopilema nomurai</Emphasis> in the Sea of Japan

The fate of the giant jellyfish Nemopilema nomurai after death was examined in the southwest Sea of Japan. The density of dead jellyfish was greater than that of live animals. The dead animals are heavier than the Japan Sea Proper Water which occurs deeper than 200 m, suggesting that dead jellyfish sink to the sea floor. The sea floor survey, conducted with a towed video tape recorder (VTR) monitoring system between mid September and mid October, observed a total of 138 jellyfish during 28 of 29 operations. The density of carrion ranged between 0.2 and 5.1 individuals/1,000 m² (mean ± SE = 1.1 ± 0.2). Ophiuroids occurred abundantly at 23 jellyfish carcasses and a sea anemone was observed attached to five carcasses. The VTR surveys confirmed that carrion sinks to the sea floor not only during the winter, the normal end of life for medusae, but also during the fall. A trap survey baited with medusae was also employed, and four different species were sampled with the traps: the snow crab (Chionoecetes opilio), a shrimp (Pandalopsis japonica), the ivory shell (Buccinum striatissimum) and an ophiuroid (Ophiura sarsii). Much of the trap bait remained (49–68% weight-mean = 60.3%) during the 23 h soak-time, and the reduction in weight was greater than that observed by bacterial decomposition, suggesting benthic animals consume dead organisms. The present study indicates that dead N. nomurai sink to the sea floor continuously and were subsequently consumed by benthic scavengers.     

Thermal destruction of wastes containing polychlorinated naphthalenes in an industrial waste incinerator

A series of verification tests were carried out in order to confirm that polychlorinated naphthalenes (PCNs) contained in synthetic rubber products (Neoprene FB products) and aerosol adhesives, which were accidentally imported into Japan, could be thermally destroyed using an industrial waste incinerator. In the verification tests, Neoprene FB products containing PCNs at a concentration of 2800 mg/kg were added to industrial wastes at a ratio of 600 mg Neoprene FB product/kg-waste, and then incinerated at an average temperature of 985 °C. Total PCN concentrations were 14 ng/m³N in stack gas, 5.7 ng/g in bottom ash, 0.98 ng/g in boiler dust, and 1.2 ng/g in fly ash. Destruction efficiency (DE) and destruction removal efficiency (DRE) of congener No. 38/40, which is considered an input marker congener, were 99.9974 and 99.9995 %, respectively. The following dioxin concentrations were found: 0.11 ng-TEQ/m³N for the stack gas, 0.096 ng-TEQ/g for the bottom ash, 0.010 ng-TEQ/g for the boiler dust, and 0.072 ng-TEQ/g for the fly ash. Since the PCN levels in the PCN destruction test were even at slightly lower concentrations than in the baseline test without PCN addition, the detected PCNs are to a large degree unintentionally produced PCNs and does not mainly stem from input material. Also, the dioxin levels did not change. From these results, we confirmed that PCNs contained in Neoprene FB products and aerosol adhesives could be destroyed to a high degree by high-temperature incineration. Therefore, all recalled Neoprene FB products and aerosol adhesives containing PCNs were successfully treated under the same conditions as the verification tests.     

Humification index of composts originating from three types of woody biomass

Composting is a good method for recycling surplus manure and stabilizing organic matter from biowastes. Compost is used as a soil amendment and recently, for restoration of vegetation in barren areas. We investigated the relationship between the type of woody biomass (using Robinia pseudoacacia, Japanese larch and apple) and the humification index (HI) of the resulting compost. This study evaluated the difference in HI between the three compost types, and the structural features of composts and extracted humic acids (HAs). The HIs for R. pseudoacacia and apple were larger than that for Japanese larch after composting for 11 months. The structural features of the Japanese larch compost were also different from the apple and R. pseudoacacia, with a very high carbon/nitrogen ratio. The average molecular weights and ultraviolet–visible spectra (A600/C) of HAs extracted from composting samples at 0 and 11 months indicate that the humification rate of Japanese larch was slower than that of R. pseudoacacia and apple. During composting, the average molecular weights of apple and R. pseudoacacia decreased, while their A600/C values increased, but the reverse was observed for Japanese larch. The humification rate was found to depend on the type of woody biomass being composted.     

Postembryonic development of the bone-eating worm Osedax japonicus

Bone-eating worms of the genus Osedax exclusively inhabit sunken vertebrate bones on the seafloor. The unique lifestyle and morphology of Osedax spp. have received much scientific attention, but the whole process of their development has not been observed. We herein report the postembryonic development and settlement of Osedax japonicus Fujikura et al. (Zool Sci 23:733–740, 2006). Fertilised eggs were spawned into the mucus of a female, and the larvae swam out from the mucus at the trochophore stage. Larvae survived for 10 days under laboratory conditions. The larvae settled on bones, elongated their bodies and crawled around on the bones. Then they secreted mucus to create a tube and the palps started to develop. The palps of O. japonicus arose from the prostomium, whereas the anterior appendages of other siboglinids arose from the peristomium. The recruitment of dwarf males was induced by rearing larvae with adult females. Females started to spawn eggs 6 weeks after settlement.     

Inactivation effect of pressurized carbon dioxide on bacteriophage Qβ and ΦX174 as a novel disinfectant for water treatment

The inactivation effects of pressurized CO2 against bacteriophage Qβ and ΦX174 were investigated under the pressure of 0.3–0.9 MPa, initial concentration of 107–109PFU/mL, and temperature of17.8°C–27.2°C. The optimum conditions were found to be 0.7 MPa and an exposure time of 25 min. Under identical treatment conditions, a greater than 3.3-log reduction in bacteriophage Qβ was achieved by CO2, while a nearly 3.0 log reduction was observed for phage ΦX174. The viricidal effects of N2O(an inactivation gas with similar characteristics to CO2), normal acid(HCl), and CO2 treatment with phosphate buffered saline affirmed the chemical nature of CO2 treatment. The pumping cycle, depressurization rate, and release of intracellular substances caused by CO2 were its viricidal mechanisms. The results indicate that CO2 has the potential for use as a disinfectant without forming disinfection by-products.