废弃SCR脱硝催化剂的再生及其脱硝性能研究

对废弃脱硝催化剂处理后重新加工再生,研究了添加剂对其粉体成型和再生催化剂脱硝活性的影响,探讨了反应温度、空速、n(NH3)∶n(NO)摩尔比、氧含量、H2O和SO2对再生催化剂NH3选择性催化还原(SCR)NO的影响。结果表明:最佳再生条件是使用5%羧甲基纤维素和10%无机粘结剂辅助成型;废弃催化剂再生利用率高达90%;再生催化剂抗压强度为4.73 MPa,优于商用催化剂;空速5 000 h-1、氨氮摩尔比1、氧含量6%时,脱硝活性温度窗口为310⁴50℃,350℃时活性最高为94%;350℃时,单独通入1 000×10-6SO2或10%H2O对再生催化剂活性均有一定抑制作用,最低活性分别为70%和81%,停止通入SO2或H2O后其活性逐渐恢复;同时通入1 000×10-6SO2和10%H2O,再生催化剂活性下降至63%并于1 h内保持相对稳定,停止通入SO2和H2O 2 h后,活性逐渐恢复到73%。     

三槽氧化沟内底推位置与积泥厚度的分析研究

氧化沟工艺由于进水中含有大量的无机颗粒,无机颗粒的沉淀导致沟内积泥较厚。为了不影响正常生产,依据经验数据,依次对1号、2号氧化沟安装底推。对沟内积泥情况及影响因素进行分析比较,得出氧化沟的积泥主要由进水中密度较大的无机颗粒造成,且积泥规律与底推安装位置和运行情况相关。     

明胶厂剩余高钙污泥作为燃煤固硫剂的应用研究

明胶生产产业在废水处理工艺中产生大量剩余高钙污泥,采用该剩余污泥作为燃煤固硫剂,在高温管式电阻炉内进行燃烧实验,通过测定燃烧前和燃烧后样品中的硫含量确定该剩余污泥的固硫效果。通过单因素研究煤粉粒径、剩余污泥粒径和剩余污泥/煤样%等影响因素对固硫率的影响。在单因素试验的基础上通过正交设计法优选达到较高固硫率的实验条件。实验结果表明:影响固硫率的因素从大到小依次为燃烧温度>剩余污泥/煤样%>煤粉粒径>剩余污泥粒径。以剩余污泥作为固硫剂,固硫率最高的实验条件为:燃烧温度800℃,剩余污泥/煤样为3%,煤粉粒径60⁹0目,剩余污泥粒径9090目,剩余污泥粒径90¹20目。并且,当温度达到1150℃,煤粉粒径90120目。并且,当温度达到1150℃,煤粉粒径90¹20目,剩余污泥粒径为60120目,剩余污泥粒径为60⁹0目,污泥/煤样(质量比)为3%时,固硫率可达62.78%,说明在高温下该剩余污泥保持较高的固硫率。将明胶厂剩余污泥作为固硫剂是较为合适的再利用方法,可有效缓解当前该污泥大量堆积污染环境的状况。     

Formation of THMs and HANs during bromination of Microcystis aeruginosa

Bromine-contained disinfectants and biocides are widely used in swimming pools, recreational waters and cooling towers. The objective of this study was to evaluate the formation of thrihalomethanes (THMs) and haloacetonitriles (HANs) and their cytotoxicity in algae solutions during free bromine disinfection. Disinfection by-products formation potential experiments were conducted using model solutions containing 7 mg/L (as total organic carbon) Microcystis aeruginosa cells. Effects of free bromine dosage, pH and ammonia were investigated. The results showed that brominated disinfection by-products were the major products when free bromine was applied. The total THMs formed during bromination was much as that formed during chlorination, whereas HANs were elevated by using bromination instead of chlorination. Dibromoacetonitrice (C2H2NBr2 ) and bromoform (CHBr3 ) were the only detected species during free bromine disinfection. The production of C2H2NBr2 and CHBr 3 increased with disinfectant dosage but decreased with dosing ammonia. CHBr3 increased with the pH changing from 5 to 9. However, C2H2NBr2 achieved the highest production at neutral pH, which was due to a joint effect of variation in hydrolysis rate and free bromine reactivity. The hydrolysis of C2H2NBr2 was base-catalytic and nearly unaffected by disinfectant. Finally, estimation of cytotoxicity of the disinfected algae solutions showed that HANs formation was responsible for the majority of toxicity. Considering its highest toxicity among the measured disinfection by-products, the elevated C2H2NBr2 should be considered when using bromine-related algaecide.     

锦州市近十年降水现状调查分析

根据锦州市环境监测中心站的大气资料,通过对其3个采样点,从2001年到2010年共10年的监测数据进行综合分析,结果表明锦州地区酸雨多出现在5、6、7月,以SO42-、NO3-和NH4+、Ca2+为主要污染离子,体现了大气降水煤烟型污染的特点。通过对数据的综合分析,研究锦州市降水现状及发展变化趋势,分析了酸雨的成因并提出了酸雨控制的对策。     

哈尔滨大气中PAHs的污染源解析

通过将比值法、主成分分析和正定矩阵分析法相结合对大气中PAHs的污染源进行了解析,结果表明,煤的燃烧和汽车尾气的排放是PAHs的主要污染源,冬季,煤的燃烧是主要污染源,其贡献率为60.6%,其次为汽车尾气排放(34.4%),其他季节,汽车尾气的排放和燃煤污染是主要的污染源,其贡献率分别为59.3%和17.1%。通过等效毒性当量因子计算得到,哈尔滨大气中BaP当量浓度冬季为7.751 9 ng/m3,其他季节为0.688 6 ng/m3,均符合中国规定的10 ng/m3。     

Effect of nutrient conditions on the toxicity of naphthalene to Chlorella pyrenoidosa

The toxicity of naphthalene to a freshwater microalga, Chlorella pyrenoidosa, and the subsequent recovery of algae from the damage were investigated under two nutrient conditions, either enriched with nitrogen (N) and phosphorus (P), or starved of N and P. Results showed that C. pyrenoidosa was more sensitive to naphthalene under N,P-enriched condition, and the inhibitory rate generally increased at first and then decreased gradually with the evaporation of naphthalene under both nutrient conditions. Enriched N, P reduced the inhibitory rate at initial naphthalene concentration of 5 and 10 mg/L, but enhanced it at 100 mg/L, at which more severe ultrastructure damages were found than those under N,P-starved condition. Observed damages included partly or totally disappearance of nucleolus, nuclear, and plasma membranes. According to the chlorophyll content and cell density measurements, C. pyrenoidosa could recover from naphthalene damage with initial concentrations 6 50 mg/L in 7 days under both nutrient conditions, while they could not recover if the initial concentration of naphthalene was at 100 mg/L. Under the N,P-starved condition, the inability of C. pyrenoidosa to recover from the naphthalene damage was consistent with the results of high inhibitory rate, low value of specific growth rate (SGR, 0.05 day??1), and the severe destruction of cell structure. However, under the N,P-enriched conditions, the observed lower inhibitory rate, higher value of SGR (0.55 day??1), and the intact cell structure of most cells suggested that algae could potentially recover from the naphthalene damage.     

南京某城市污水二级处理系统中酞酸酯类的分布及去除特征

以南京某城市污水厂污水和污泥中的酞酸酯类（PAEs）为研究对象，分别采用固相萃取-气相色谱-质谱联用（SPE—Gc．Ms）和超声提取．气相色谱．质谱联用（USE—GC—Ms）检测其中的优先控制污染物邻苯二甲酸二甲酯（DMP）、邻苯二甲酸二乙酯（DEP）、邻苯二甲酸二丁酯（DBP）和邻苯二甲酸单（2-乙基己基）酯（MEHP），研究其在厌氧／好氧（A／O）污泥处理过程中的分布特征及降解规律。研究结果表明，各类PAEs在该污水厂的污水和污泥中均有检出，二级处理出水中4种酞酸酯类物质的浓度在0．151—2．419μg／L。污水中4种酞酸酯的分布规律为MEHP〉DBP〉DMP〉DEP，污泥中4种酞酸酯的分布规律为MEHP〉DBP〉DEP〉DMP。该污水厂二级处理工艺对4种PAEs的去除效果较明显，去除效率DBP〉DEP〉DMP〉MEHP．     

南京某城市污水二级处理系统中酞酸酯类的分布及去除特征简

以南京某城市污水厂污水和污泥中的酞酸酯类（PAEs）为研究对象，分别采用固相萃取-气相色谱-质谱联用（SPE-GC-MS）和超声提取-气相色谱-质谱联用（USE-GC-MS）检测其中的优先控制污染物邻苯二甲酸二甲酯（DMP）、邻苯二甲酸二乙酯（DEP）、邻苯二甲酸二丁酯（DBP）和邻苯二甲酸单（2-乙基己基）酯（MEHP），研究其在厌氧/好氧（A/O）污泥处理过程中的分布特征及降解规律。研究结果表明，各类PAEs在该污水厂的污水和污泥中均有检出，二级处理出水中4种酞酸酯类物质的浓度在0.151~2.419 μg/L。污水中4种酞酸酯的分布规律为MEHP>DBP>DMP>DEP，污泥中4种酞酸酯的分布规律为MEHP>DBP>DEP>DMP。该污水厂二级处理工艺对4种PAEs的去除效果较明显，去除效率DBP>DEP>DMP>MEHP。     

Role of membrane and compound properties in affecting the rejection of pharmaceuticals by different RO/NF membranes

This study was conducted to assess the merits and limitations of various high-pressure membranes, tight nanofiltration (NF) membranes in particular, for the removal of trace organic compounds (TrOCs). The performance of a low-pressure reverse osmosis (LPRO) membrane (ESPA1), a tight NF membrane (NF90) and two loose NF membranes (HL and NF270) was compared for the rejection of 23 different pharmaceuticals (PhACs). Efforts were also devoted to understand the effect of adsorption on the rejection performance of each membrane. Difference in hydrogen bond formation potential (HFP) was taken into consideration. Results showed that NF90 performed similarly to ESPA1 with mean rejection higher than 95%. NF270 outperformed HL in terms of both water permeability and PhAC rejection higher than 90%. Electrostatic effects were more significant in PhAC rejection by loose NF membranes than tight NF and LPRO membranes. The adverse effect of adsorption on rejection by HL and ESPA1 was more substantial than NF270 and NF90, which could not be simply explained by the difference in membrane surface hydrophobicity, selective layer thickness or pore size. The HL membrane had a lower rejection of PhACs of higher hydrophobicity (log D>0) and higher HFP (>0.02). Nevertheless, the effects of PhAC hydrophobicity and HFP on rejection by ESPA1 could not be discerned. Poor rejection of certain PhACs could generally be explained by aspects of steric hindrance, electrostatic interactions and adsorption. High-pressure membranes like NF90 and NF270 have a high promise in TrOC removal from contaminated water.

Open image in new window