废弃红砖微粉填料制备环保乳胶漆及其性能研究

研究了利用废弃红砖生产环保乳胶漆的制备方法,通过正交试验分析了乳液种类、乳液含量、醇酯十二含量、丙二醇含量和增稠剂含量对环保乳胶漆性能的影响.结果表明,废弃红砖微粉与苯丙乳液有较好的相容性,当乳液含量为25%~30%,醇酯十二0.4%~1.2%,丙二醇3.00%~3.75%,增稠剂1‰~1.5‰时,砖质环保乳胶漆产品低温稳定性良好,可成完全悬浮状态,表干时间小于30min,摆杆阻尼次数可达103次,附着力等级大于5,这为建筑废物资源化提供新的途径.     

家具企业喷涂过程呼吸防护技术应用研究

随着家具行业持续高速发展和从业人数的不断增加,家具企业职业危害的严峻性也日益突显,职业危害预防、控制也越来越受重视。喷涂作为家具表面处理的重要工艺,其作业过程产生的漆雾和挥发性有机化合物更是直接威胁到职工的健康安全。基于对家具企业喷漆作业场所的有毒、有害因素分析研究的基础上,从个体职业危害防护的角度,提出适用于家具企业喷漆过程的固定式长管呼吸装置防护技术,加强对家具企业职工喷漆作业的劳动保护,实现职业危害的预防控制。     

油漆废水处理技术的试验研究——混凝沉淀和氧化絮凝复合床法的应用

利用混凝沉淀法和所研制的氧化絮凝复合床法联合处理了高浓度的油漆废水。实验了多种化学混凝剂及多种催化剂对废水中有机污染物去除率的影响,选取了最佳催化剂和最佳化学混凝剂。对油漆厂原有废水处理工艺进行了大的改造。结果表明:采用化学混凝沉淀法及氧化絮凝复合床法与后续生化法串联处理该废水后,出水水质符合排放标准。     

BEHAVIORAL RESPONSES TO TWO ESTUARINE FISH SPECIES SUBJECTED TO BIS (tri-n-butyltin) OXIDE1

ABSTRACT: The objective of this investigation was to evaluate the avoidance responses of juvenile striped bass, Morone saxatilis and Atlantic menhaden, Brevoortia tyrannus to bis (tri-n-butyltin) oxide. An avoidance responses was exhibited by striped bass at a total organic tin concentration of 24.9 μg/L. Atlantic menhaden exhibited avoidance to total organic tin concentrations of 5.5 μg/L and greater. Atlantic menhaden are generally more sensitive to toxicants than striped bass; therefore, avoidance responses reported in this study are not surprising. It is highly likely that the concentrations of total organic tin that were avoided by the test species in this study were much higher than expected environmental concentrations. Ecologically significant hazards may occur due to potential effects that unperceived or non-avoided organotin concentrations may have on behavioral responses mediated by chemosensory systems.     

Adsorption behaviors of activated carbons for the exhaust from spray painting booths in vehicle surface coating

Adsorption performance of activated carbon adsorbers in the downstream duct of vehicle spray painting booths has been studied to understand whether fine paint particles in the off-gas would deteriorate the adsorption capacity of volatile organic compounds (VOCs) on activated carbons. Three forms of activated carbons were selected and their properties were determined using nitrogen adsorption analysis, the measurement of pH value and total ash content, energy dispersion spectrometer, field-emission scanning electron microscopy, and thermogravimetric analysis. Results show that the adsorption capacity of activated carbon strongly depends upon its available specific surface area. When the total uptake on activated carbon approaches saturation, the vapors adsorbed would commence to get displaced by the paint particles gradually as time elapses and finally the uptake of vapors and paint particles reach equilibrium. Microporous carbons, in particular, were much more susceptible to paint particles. A Langmuir-type model for the uptake on activated carbons was suggested, which successfully described the adsorption behaviors of the off-gas released from vehicle spray painting booth.     

改性累托石复合絮凝剂处理油漆废水

采用改性累托石-天然高分子多糖复合絮凝剂处理油漆废水。在改性累托石质量浓度为80mg／L、天然高分于多糖质造浓度为4mg／L的条件下,COD、悬浮固体和色度的去除率分别较传统絮凝剂三氯化铝和聚丙烯酰胺提高了43．1％,6．4％,22．6％和19．1％,3．4％,21．8％;吨废水药剂成本分别下降了16．9％和30．7％,处理后的油漆废水均达到国家二级污水排放标准。     

湿热盐雾大气环境印制电路板防护棚下试验研究

目的 试验研究不同防护工艺的印制电路板在湿热盐雾大气环境下的适应性。方法 结合无防护试件,在严苛的濒海棚下环境开展4种印制电路板防护工艺的暴露试验,通过观察电路板外观,测量计算绝缘电阻、介质耐压、品质因数,以及扫描电镜、能谱分析等技术手段评价印制电路板防护工艺的性能。结果 濒海棚下环境中,无防护印制电路板腐蚀严重,电气性能显著下降。改性硅、有机硅三防漆防护的印制电路板在整个试验周期内腐蚀程度轻微,电气性能较好,表面涂层仅存在轻微起泡现象。丙烯酸三防漆防护印制电路板防护性能不稳定,印制电路板出现腐蚀现象,品质因数总体低于改性硅、有机硅三防漆防护。聚氨酯三防漆防护印制电路板在电气测试性能中表现良好,但涂层出现太多破损、起泡等缺陷,铜导线出现异常生锈现象。在介质耐压测试中,多周期呈现击穿状态。结论 在濒海区域棚下湿热盐雾环境中,涂覆有机硅、改性硅三防漆的印制电路板防护状态最好,可优先选择作为防护手段。     

循序间歇式活性污泥法处理造漆工业废水

循序间歇式废水生物处理工艺(SBR工艺)集进水、厌氧、好氧、沉淀于一池,改变其运行程序不仅可去除有机物,还能达到脱氮除磷效果。 试验结果表明,工艺的运行周期为22h(其中进水1h,进水和厌氧搅拌6h,好氧14h,沉淀及排水各2h),进水COD浓度在1000—4000mg/L时,COD去除率为84％以上,最高达96％。另外,水文还分析了有机物的去除特点。     

光催化与生物技术联用工艺处理油漆废气中试研究

光催化与生物技术联用工艺用于油漆生产、加工过程有机废气的现场处理,中试实验结果表明:油漆生产、加工过程现场的主要污染物是甲苯、乙苯、间/对二甲苯和邻二甲苯等苯系物,浓度在27～55 mg/m3之间。单独使用光催化和微生物技术现场处理这些苯系物,其去除效率都不很高。虽然在中试开始阶段光催化对苯系物的平均去除效率达到了86.2%,在中试稳定期,光催化技术对苯系物的平均去除效率却只有67.6%,而生物滴滤床在成功挂膜之后对现场有机废气的平均去除效率也仅为67.5%。但是将这两种工艺联合使用之后,在中试稳定期该组合工艺对苯系物的平均去除效率可以达到99.2%。     

Inputs of antifouling paint-derived dichlorodiphenyltrichloroethanes (DDTs) to a typical mariculture zone (South China): potential impact on aquafarming environment

Existing evidence indicated that dichlorodiphenyltrichloroethane (DDT)-containing antifouling paints were an important source of DDT residues to mariculture zones. However, the magnitude of the impact on aquafarming environment has remained largely unknown. In the present study, the concentrations of DDT and its metabolites (designated as DDXs) were determined in harbor sediment and antifouling paint samples collected from a typical mariculture zone in South China. Compositional and concentration correlation analyses implicated the DDT-containing antifouling paints for fishing boat maintenance as an important source of DDT in the mariculture zone. The annual emission of DDXs to the study region was estimated at 0.58 tons/yr. Furthermore, a comparison of the expected DDT loadings in pelagic fish and field measurements indicated that fish feed especially trash fish was a major source of DDTs in the fish body. Nevertheless, the use of DDT-containing antifouling paints should be limited to prevent further deterioration in aquafarming environment.