生活垃圾焚烧飞灰固化体力学及重金属浸出特性

以苏州七子山生活垃圾焚烧厂产生的飞灰为研究对象,采用水泥作为固化剂,研究水泥飞灰固化体的应力应变特征及重金属浸出特性,并探讨了水泥飞灰配合比、养护时间等关键性因素对这些特性的影响。实验结果表明:较养护3 d的样品,其余养护时间的样品强度平均增长了约96.2%,而其破坏应变平均减小了56%。随着水泥含量和养护时间的增加,飞灰固化体的强度上升,而其破坏应变减小,该趋势主要归因于钙矾石(AFt)的形成促进了飞灰固化体强度的发展。较飞灰原样,飞灰固化体的重金属浸出浓度随着水泥含量、养护时间的增加而降低了38%~99%,重金属的迁移被限制,主要归因于水化硅酸钙(C—S—H)和钙矾石(AFt)的形成,以及飞灰和水泥水化反应创造的强碱性环境。     

酱糟与醋糟混合发酵产沼气研究

酱糟、醋糟是我国食品酿造行业产生的废弃物,通过厌氧发酵不仅可以解决废糟处理问题又可获取能源.因此本研究在中温(35±1)℃的条件下,根据C/N比的不同,进行了酱糟/醋糟干物质(TS)比分别为1∶0(N1)、1∶1.5(N2)、1∶3(N3)、1∶7(N4)、1∶18(N5)和0∶1(N6)的混合发酵实验.结果表明,单一酱渣的延滞期为17.46 d,混合发酵明显缩短了延滞期,为3.00-3.83 d;混合发酵组(N2～N5)累计产甲烷量的实验结果比计算结果分别提高了1％、16％、14％和10％,其中,N3组C/N比为25.7∶1,提高最为明显;各组发酵产生的沼气的甲烷体积分数在65％～ 70％之间;Gompertz模型拟合可以用于酱糟和醋糟混合发酵产甲烷的过程;酱、醋糟发酵的产酸类型以乙酸型发酵为主.     

畜禽养殖场污染防治对策研究

通过对萧县某种猪养殖场污染状况进行调查,研究制定污染防治对策,采用USR升流式厌氧发酵工艺对其产生的粪便、污水进行处理,产生沼气并附产沼液、沼渣还田利用等,不仅可以实现污染减排,减轻环境污染,而且产生的清洁能源可供周边居民使用,有着较好的环境效益、社会效益和经济效益.     

家禽养殖项目的环境影响评价相关问题探讨——以某公司扩建10万只蛋种鸡养殖为例

本文针对家禽养殖项目的环境影响特点,根据在环境影响评价工作中的实践经验,以XX公司扩建10万只蛋种鸡养殖为例,就养殖场施工期、运营期对大气环境、水环境、声环境的影响评价,并结合产生的影响提出具体的防治措施.     

沼气高值化利用与净化提纯技术

基于户用沼气池以及传统工业沼气锅炉的低附加值沼气利用方式已经不适合沼气产业规模化和商业化的发展方向,在分析我国沼气资源潜力的基础上,重点介绍了沼气制备车用压缩天然气、管道天然气、热电联产等高值化利用方式及相关标准;针对高值化利用方式,分析比较了现有的高压水洗、物理吸收、化学吸收、变压吸附、膜分离和深冷分离等几种沼气净化提纯工艺的技术及应用情况,介绍了高效沼气脱硫技术,并指出氧、氮含量源头控制的重要性。     

高径比对猪场废水脱氮与沼气脱硫耦联反应器的影响

采用填料鼓泡塔反应器研究其高径比对猪场废水脱氮与沼气脱硫耦联过程的影响,比较了3种不同高径比(8∶1、3∶1、2∶1)反应器的废水脱氮与沼气脱硫效能.在温度30～32℃、空塔停留时间6.70 min、水力停留时间3.35 d、沼气中H2 S浓度1 414～1 838 mg.m-3、进水NO x--N浓度114～243 mg.L-1的条件下,高径比2∶1反应器的运行较稳定,且处理效果较好,硫化氢去除率平均值为96.7%,NO x--N去除率平均值达到88.7%;而高径比8∶1和3∶1反应器的运行不太稳定,硫化氢去除率的平均值分别为68.0%、80.4%,NO x--N的去除率平均值分别为89.7%、90.2%.主要是因为高径比2∶1反应器的实际气速(3.12×10-2 m.s-1)比高径比3∶1、8∶1反应器的实际气速(分别为3.62×10-2 m.s-1和6.64×10-2 m.s-1)更慢,其气液传质系数(1.79×10-5 s-1)比高径比3∶1、8∶1反应器的气液传质系数(分别为1.64×10-5 s-1和1.55×10-5 s-1)更大,传质效果更好.处理效能试验结果以及反应器流体力学特征参数均表明,高径比2∶1反应器为最适合的反应器.     

Anaerobic tapered fluidized bed reactor for starch wastewater treatment and modeling using multilayer perceptron neural network

Anaerobic treatability of synthetic sago wastewater was investigated in a laboratory anaerobic tapered fluidized bed reactor(ATFBR) with a mesoporous granular activated carbon(GAC)as a support material.The experimental protocol was defined to examine the effect of the maximum organic loading rate(OLR),hydraulic retention time(HRT),the efficiency of the reactor and to report on its steady- state performance.The reactor was subjected to a steady-state operation over a range of OLR up to 85.44 kg COD/(m~3.d).The COD removal efficiency was found to be 92% in the reactor while the biogas produced in the digester reached 25.38 m~3/(m~3·d) of the reactor. With the increase of OLR from 83.7 kg COD/(m~3.d),the COD removal efficiency decreased.Also an artificial neural network(ANN) model using multilayer perceptron(MLP)has been developed for a system of two input variable and five output dependent variables. For the training of the input-output data,the experimental values obtained have been used.The output parameters predicted have been found to be much closer to the corresponding experimental ones and the model was validated for 30% of the untrained data.The mean square error(MSE)was found to be only 0.0146.     

Comparative study of heavy metal and pathogenic bacterial contamination in sludge and manure in biogas and non-biogas swine farms

The objective of this study is to determine and compare the heavy metal (Zn, Cu, Cd, Pb) and bacterial (E. coli, coliform and Salmonella spp.) contamination between swine farms utilizing biogas and non-biogas systems in the central part of Thailand. Results showed that average levels of E. coli, coliform, BOD, COD, Zn, Cu and Pb in sludge from the post-biogas pond were higher than the standard limits. Moreover, the levels of E. coli, coliform, Cd and Pb were also higher than the standard limits for dry manure. The levels of E. coli, coliform and BOD on biogas farms were lower than on non-biogas farms. Following isolation of Salmonella spp:; it was found that Salmonella serovars Rissen was the most abundant at 18.46% (12/65), followed by Anatum 12.31% (8/65), and Kedougou 9.23% (6/65). The pathogenic strains of Salmonella serovars Paratyphi B var. java and Typhimurium were present in equal amounts at 4.62% (3/65) in samples from all swine farms. This study revealed that significant reduction in E. coli and coliform levels in sludge from covered lagoon biogas systems on swine farms. The presence of Salmonella as well as Cd and Pb, in significant amount in dry manure, suggests that there is a high probability of environmental contamination if it is used for agricultural purposes. Thus, careful waste and manure disposal from swine farms and the regular monitoring of wastewater is strongly recommended to ensure the safety of humans, other animals and the environment.     

酒精废水处理及资源利用

通过对酒精废水的水质特性、污染情况及治理现状的分析,提出了污水综合治理的工艺流程,包括预处理、二级UASB、好氧活性污泥法.通过一系列的牛物及物理化学方法在酒精废水处理工程中的实际应用,COD、BOD5、SS去除率均＞99%,达到国家<污水综合排放标准>(GB 8978-1996)二级标准,有效地削减了酒精废水的排放量...     

多菌种混合发酵转化秸秆技术的研究及应用进展

农作物秸秆是农业生产的副产品,也是一项重要的生物资源。利用微生物的广泛适应性和多功能性来转化秸秆已日益受到国内外科学研究者重视,特别是多菌种混合发酵是将秸秆纤维素转化为蛋白质、乙醇、乙酸等最具发展前景的方法。文章通过混合菌降解秸秆纤维,转化利用秸秆制蛋白饲料、燃料酒精、农用沼气等方面,对混合菌发酵转化秸秆技术的研究进展进行阐述。混合菌发酵转化秸秆已成为农业综合开发领域的一个亮点,正在朝着多元化,深层次的方向发展。