厌氧生物滴滤法脱除冷煤气中硫化氢的研究

水煤气中硫化氢在燃烧时会转变成二氧化硫,对环境产生污染。文章采用厌氧生物滴滤塔法对冷煤气进行脱硫处理。因煤气对氧的严格限制,通过设计生物滴滤塔,经挂膜驯化后在厌氧条件下对浓度在1~5 g/m3左右的硫化氢进行脱除处理,考察滴滤塔运行条件对脱除效果的影响。结果表明,生物挂膜25 d后,生物滴滤塔达到稳定,喷淋液pH值为2.23,ORP值为283 mV,溶解氧为0.4 mg/L,对溶液中硫离子氧化效率达到94%。滴滤塔在液气比0.15,空塔气速0.088 m/s,pH值5.0~7.0,填料高度为82 cm,塔温为25~30℃左右时,达到较优的运行条件,此时该滴滤塔对以CO、CO2、H2和1 940 mg/m3H2S组成的模拟水煤气的脱硫效率达91.2%。     

Characteristics of sewage sludge and distribution of heavy metal in plants with amendment of sewage sludge

In order to better understand land application of sewage sludge, the characterization of heavy metals and organic pollutants were investigated in three different sewage sludges in Shanghai City, China. It was found that the total concentrations of Cd in all of sewage sludge and total concentrations of Zn in Jinshan sewage sludge, as well as those ofZn, Cu, and Ni in Taopu sludge are higher than Chinese regulation limit of pollutants for sludge to be used in agriculture. Leachability of rig in all of studied samples and that of Cd in Taopu sewage sludge exceed the limit values of waste solid extraction standard in China legislation. Based on the characteristics for three kinds of sewage sludge, a pot experiment was conducted to investigate the effect of soil amended with Quyang sewage sludge on the accumulation of heavy metalo.by Begonia semperfloreas-hybr; Ophiopogon japonicas （L.F.） Ker-Gaw; Loropetalum chindense-var, rubrum; Dendranthema morifolium; Viola tricolor; A ntirrhinum majas; Buxas radicans Sieb; Viburnum macrocephalum; Osmanthas fragrans Lour; Cinnamomum camphora siebold and Ligustrum lucidum ait. Results showed that 8 species of plant survived in the amended soil, and moreover they flourished as well as those cultivated in the control soil. The heavy metal concentration in plants varied with species, As, Pb, Cd and Cr concentration being the highest in the four herbaceous species studied, particularly in the roots of D. morifolium. These plants, however, did not show accumulator of As, Pb, Cd and Cr. The highest concentration of Ni and Hg was found in the roots ofD. morifolium, followed by the leaves ofB. semperflorens-hybr. Levels of Zn and Cu were much higher in D. morifolium than in the other plant species. D. morifolium accumulated Ni, Hg, Cu and Zn, which may contribute to the decrease of heavy metal contents in the amended soil. Treatment with sewage sludge did not significantly affect the uptake of heavy metals by the L. chindense-var, rubrum, however, it significantly affected the uptake of heavy metals by D. morifolium.     

新型聚乙烯填料生物滴滤床净化硫化氢气体的启动研究

研究了新型高密度聚乙烯改良型拉西环填料生物滴滤床净化硫化氢气体的启动过程,重点比较了启动过程中不同的挂膜方式对启动时间及效能的影响.结果表明,采用液相连续流强化挂膜法成膜时间短,在环境温度20～28℃时7 d可以挂膜成功.在启动过程中,随着工艺参数的突然改变(GRT缩短)和入口浓度波动,液相连续流强化挂膜后反应器的硫化氢去除率更稳定.在进气浓度最高为343 mg/m³时硫化氢去除率稳定在95%以上.试验过程中还发现,将SO₄^2-浓度作为活性污泥驯化完成的监测指标、液相S^2-去除率作为挂膜完成的监测指标更合理.启动结束后,通过2种途径减去喷淋液中的碳源并未影响硫化氢的去除率,这进一步表明生物滴滤床中硫化氢的净化主要由自养菌完成.     

生物滴滤塔脱除污泥干化尾气中的SO2

以市政污泥干化尾气中的主要含硫物质二氧化硫(SO2)为处理对象,从市政污泥中筛选出高效脱硫菌——嗜酸性氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,A.f),搭建了实验室规模的生物滴滤塔,考察了进气质量浓度、气体停留时间、营养液喷淋密度和营养液中Fe2+浓度对生物滴滤塔脱除SO2的影响....     

关于1#滤毒罐防护范围的进一步探讨

本文通过实验的方法,对1#滤毒罐防护范围进行了探讨,说明1#罐不仅能防护CNCL、HCN,对苯、SO2等毒剂也能起到有效的防护作用,同时提出了如何选择滤毒罐的建议。     

不同煤矿自救器的正确选择

我国是以煤炭为主要能源的国家,由于防护技术和监管力度以及煤矿地质特有因素等原因,煤矿开采中生产安全事故频发,造成大量人员伤亡.经过对矿难现场和伤亡人员的大量数据分析,发现井下工作现场死亡人数的90％以上是因为瓦斯爆炸后吸入了一氧化碳气体.因此,自救器是入井作业人员的必备安全防护装置.那么我国煤矿井下配备的一氧化碳过滤式自救器、隔绝式化学氧自救器、隔绝式压缩氧自救器等的性能如何呢?     

旋转切向流聚丙烯管式膜微滤能耗分析

设计了一种新型旋转切向流聚丙烯管式膜器,实验研究了聚丙烯PA管式膜器的能耗通过建立的旋转切向流强化微滤实验装置系统,测定了聚丙烯PA管式膜器在旋转切向流和轴向流下的膜通量与能量有效利用率.实验结果表明,旋转切向流管式膜微滤比一般轴向流膜微滤的有效利用率要高得多,是一种非常有效的强化膜分离技术在实验条件下,直线切向流膜微滤和圆弧切向流膜微滤的稳态能量有效利用率比轴向流稳态能量有效利用率分别高11.185倍和14.591倍.     

地下渗滤处理村镇生活污水的中试

以红壤土作为填充土壤,在2cm/d的水力负荷下,进行了地下渗滤系统处理村镇生活污水的现场中试.结果表明,地下渗滤系统对COD、氨氮、总磷和总氮有着良好的去除效果,去除率分别达到84.7%、70.0%、98.0%和77.7%,出水COD、氨氮、总磷和总氮的平均浓度分别为11.7mg/L、4.0mg/L、0.04mg/L、4.7mg/L,达到建设部颁发的生活杂用水水质标准对总氮去除机理的分析表明,由硝化/反硝化实现生物脱氮是地下渗滤系统去除总氮的主要途径.在本中试系统中,反硝化效果良好但硝化效果不够理想,改善土壤环境以促进硝化作用是提高总氮去除率的关键.对土壤中氧化还原电位的测定结果表明,土壤内部的还原性质是阻碍硝化反应进行的主要原因.     

2,4-滴、灭草松和多种酚类的快速检测方法探讨

采用Waters Oasis HLB柱分离富集水样,用超高效液相色谱法同时测定水中2,4-滴、灭草松和7种酚类。通过优化试验条件,使方法在0. 03 mg/L～10. 0 mg/L范围内线性良好,方法检出限为0. 03μg/L～0. 12μg/L,自来水水样的回收率为84. 4%～109%,RSD为0. 8%～3. 7%。