Experimental study on filtration and continuous regeneration of a particulate filter system for heavy-duty diesel engines

This study investigated the filtration and continuous regeneration of a particulate filter system on an engine test bench, consisting of a diesel oxidation catalyst（DOC） and a catalyzed diesel particulate filter（CDPF）. Both the DOC and the CDPF led to a high conversion of NO to NO2 for continuous regeneration. The filtration efficiency on solid particle number（SPN） was close to100%. The post-CDPF particles were mainly in accumulation mode. The downstream SPN was sensitively influenced by the variation of the soot loading. This phenomenon provides a method for determining the balance point temperature by measuring the trend of SPN concentration.     

Carbonyl emissions from heavy-duty diesel vehicle exhaust in China and the contribution to ozone formation potential

Fifteen heavy-duty diesel vehicles were tested on chassis dynamometer by using typical heavy duty driving cycle and fuel economy cycle. The air from the exhaust was sampled by 2,4- dinitrophenyhydrazine cartridge and 23 carbonyl compounds were analyzed by high performance liquid chromatography. The average emission factor of carbonyls was 97.2 mg/km, higher than that of light-duty diesel vehicles and gasoline-powered vehicles. Formaldehyde, acetaldehyde, acetone and propionaidehyde were the species with the highest emission factors. Main influencing factors for carbonyl emissions were vehicle type, average speed and regulated emission standard, and the impact of vehicle loading was not evident in this study. National emission of carbonyls from diesel vehicles exhaust was calculated for China, 2011, based on both vehicle miles traveled and fuel consumption. Carbonyl emission of diesel vehicle was estimated to be 45.8 Gg, and was comparable to gasolinepowered vehicles （58.4 Gg）. The emissions of formaldehyde, acetaldehyde and acetone were 12.6, 6.9, 3.8 Gg, respectively. The ozone formation potential of carbonyls from diesel vehicles exhaust was 537 mg O3/km, higher than 497 mg O3/km of none-methane hydrocarbons emitted from diesel vehicles.     

河南生物柴油产业技术优势与发展方向

生物柴油是以生物质为原料,通过物理、化学和生物的方法转化为长链烃类或脂肪酸甲酯为主的液体燃料。与燃料乙醇不同,生物柴油能量密度高,不会腐蚀发动机,可以完全替代石油。根据原料来源和生产工艺的不同,生物柴油分为两大类：一是以生物油脂为原料经转酯反应生成的脂肪酸（C12-C18）甲酯,即传统的生物柴油。根据生物油脂的来源不同,传统的生物柴油又可以分为动、植物生物柴油（第一代生物柴油）和微生物生物柴油（第二代生物柴油）     

UASB处理生物柴油废水的效果研究

采用升流式厌氧污泥床(UASB)工艺处理地沟油回收制备生物柴油废水,通过试验研究了UASB反应器各个阶段对该类废水的处理效果,并考察了甲基磺酸、对甲基苯磺酸两种预酯化催化剂对该类废水处理效果的影响。结果表明:当进水COD为15g/L、容积负荷为15kg/(m3·d)时,UASB反应器COD的去除率稳定在87%左右,出水VFA为4~6mmol/L,沼气产量为16.8L/d;当容积负荷稳定在5kg/(m3·d),进水甲基磺酸浓度为5500mg/L时,UASB反应器COD的去除率达83%以上,进水对甲基苯磺酸浓度为1 000mg/L时,UASB反应器COD的去除率为58.3%,从废水处理的难易程度角度考虑,建议采用甲基磺酸为预酯化催化剂。     

低温柴油吸收工艺在高温油品储罐罐顶废气净化中的应用

采用罐区减排措施和低温馏分油吸收-脱硫工艺处理高温油品罐罐顶废气,在处理气量43.0~384.5 m3/h,柴油流量10~20 m3/h,吸收柴油温度10~15℃条件下,废气经过净化后,硫化氢和有机硫化物去除率大于97.2%,净化气体非甲烷总烃浓度小于8.35 g/m3,均低于GB20950-2007《储油库大气污染物排放标准》和GB 16297-1996《大气污染物综合排放标准》中相关污染物的限值。     

柴油加氢装置余热回收利用节能技术改造

柴油加氢装置分馏塔底精制柴油产品经塔底循环泵增压后,与低分油换热至100℃左右,余热进入新增高压换热器E-3020与柴油原料换热进行余热回收,最后进入柴油空冷器A3002A/B利用百叶窗冷却至50℃送至产品罐区。通过改造后的工艺流程,使空冷器A3002停运,达到节约空冷器电费,提高进料温度节约反应加热炉瓦斯用量的节能降耗目的。     

喷射时刻对柴油甲醇组合燃烧发动机颗粒物排放的影响

为了进一步减少甲醇掺烧后的柴油机颗粒物排放,在一台由增压中冷的高压共轨柴油机改造成的柴油甲醇组合燃烧(DMCC—diesel/methanol compound combustion)发动机上详细研究了柴油喷射时刻对两种燃料共燃时的颗粒物生成及其排放的影响.试验工况选择重型柴油机常用的A50工况.试验结果表明,当柴油在上止点后喷射时,颗粒物排放的数量浓度随着甲醇替代率的增加而减少,当上止点前喷射时,颗粒物的数量浓度先减少后增加.随着喷射时刻的提前,颗粒中超细颗粒所占比例增大.随着喷射时刻的推迟,甲醇替代率降低颗粒物质量浓度的作用增强,同时甲醇替代率降低颗粒物几何平均直径的作用减弱.     

纳米TiO2添加剂对DMDF发动机大负荷燃烧及PM排放影响的试验研究

在一台电控增压中冷四缸柴油机的进气道上加装一套电控喷射装置,使其运行柴油/甲醇双燃料(DMDF)模式.研究了甲醇中Ti O_2添加剂的添加量及同一添加剂添加量在不同甲醇分散系喷射量时对发动机大负荷工况的燃烧和颗粒物(PM)排放的影响.结果表明,在甲醇中添加适量(30和100 mg·kg~(-1))的纳米Ti O_2能够使爆发压力升高,对燃烧有一定的促进作用,但添加过量(100 mg·kg~(-1))会对燃烧产生不利影响.加入纳米Ti O_2后,干炭烟烟度排放和积聚态颗粒数明显降低,在添加剂添加量为1000 mg·kg~(-1)时,最大降幅分别达到26.8%和29.4%,而核态颗粒物排放变化不大.在相同添加剂添加量下,增加甲醇分散系替代率R_m会使放热始点后移,放热更加集中,爆发压力增大,干炭烟烟度和颗粒物排放均大幅度降低.在添加剂添加量为100 mg·kg~(-1)时,与R_m=10%相比,R_m=40%时爆发压力增加0.94 MPa,放热率峰值增加53.5%,烟度、核态颗粒数、积聚态颗粒数和颗粒物总数的降幅分别达66.9%、42.3%、67.0%和58.0%.     

货车侧翻差点埋了摩的司机

4月16日上午,一辆运石子的大货车在泉州市泉港区通港公路侧翻,满车的石子倾泻而出,差点把摩的司机林师傅"埋"了。     

农村危桥改造要加速——项城塌桥引发的思考

河南省项城市水新公路的汾河板桥发生坍塌事故,造成一辆满载沙子的重型卡车和一辆微型面包车落水,一辆出租车和中型货车坠落桥下,两人轻微伤。据悉,坍塌桥梁于1977年建设,2001年河南省交通厅检查时将