Treatment of anthraquinone dye wastewater by hydrolytic acidification-aerobic process

Experiment on microbial degradation with two kinds of biological process, hydrolytic acidification-aerobic process and aerobic process was conducted to treat the anthraquinone dye wastewater with CODc, concentration of 400 mg/L and chroma 800. The experimental result demonstrated that the hydrolytic-aerobic process could raise the biodegradability of anthraquinone dye wastewater effectively. The effluent CODc, can reach 120-170 mg/L and chroma 150 which is superior to that from simple aerobic process.     

Photodegradation mechanism of two dyes: the influence of adsorption behavior on the novel TiO2 particles

The relationship between adsorption behavior and photocatalytic mechanism of the two dyes was investigated. Adsorption isotherms showed that the adsorption of cationic pink FG was Langmuir type behavior, while the reactive brilliant red k-2G was Freundlich type behavior. The increasing pH favored the adsorption of FG but have little effect on the photodegradation. The increasing pH favored the adsorption and the photodegradation of k-2G. The presence of scavenger of hvb^ and OH. radical potassium iodide inhibited the degradation of k-2G, free radicals scavenger tetranitromethane inhibited the photodegradation of FG. These results indicated that the photodegradation of FG mainly via free radicals in solution, and the photodegradation of k-2G was mainly on the catalysts surface or near the interface of solid and solution by react with hvb^ and surface-bound OH.. The different effect of SO4^2- , HCO3^- on the adsorption and photodegradation of two dyes confirmed these results.     

基因工程菌在厌氧膜生物反应器中对偶氮染料废水的脱色

印染和染料废水色度大,COD高,可生化性差.采用基因工程菌Escherichia coli JM109(pGEX-AZR)在厌氧膜生物反应器中,对模拟偶氮染料废水进行脱色研究.结果表明,系统对酸性红B有很好的脱色能力,且启动期短,脱色效率高,脱色率稳定在95%以上,对COD的去除率能达到68%.系统运行过程中,反应器内生物量稳定在0.4 g/L.EPS与生物量变化趋势一致,先升高后降低;pH值在运行初期由6.5降至6.2,后维持在6.6左右.系统运行27 d后进行第一次膜清洗,膜通量恢复为初始值的92%,系统运行周期约为26 d.     

铁阳极电凝聚处理活性黑KN-B染料废水

对铁阳极电凝聚处理活性黑KN-B染料废水过程进行了实验研究.考察了电流密度、染料溶液初始pH值、电介质浓度及种类、温度、染料浓度等因素对脱色效率的影响.结果表明,在一定实验条件下,活性黑KN-B模拟废水的脱色效率达93%;电流强度、染料浓度、电解液初始pH值及电解质的种类对染料溶液脱色效率影响显著,电解液温度、电解质的浓度对脱色效率的影响不明显;以铁为阳极的原位电凝聚处理活性黑KN-B模拟废水混凝过程中主要作用机理以吸附电性中和为主;电凝聚过程中活性黑KN-B在阴极上发生了还原反应.     

Indian dye yielding plants: Efforts and opportunities

The present review article deals with the information on the dye‐yielding plants of India. Dyes are intensively coloured compounds that are applied to a substrate such as fibre, paper, cosmetics, hair, etc. to give colours and can be extracted from the roots, fruits/berries, bark, leaves, flowers, and stem/wood, fungi, and lichens by various processes of extractions. In addition to their dye‐yielding characteristics, many of these plants possess medicinal values and can be used for multiple other purposes. Plant derived‐colours have an important role in human life because of their safe and eco‐friendly nature. But due to the availability of economically cheaper synthetic dyes, the indigenous knowledge of extraction, processing, and proper utilisation has been diminished. Nowadays, the demand for natural dyes has been increased worldwide due to awareness about their beneficial properties. It has been essential that proper documentation and measure of conservation should be undertaken to preserve these natural dye‐yielding plants. This review article is an aid to a collective inquiry into Indian dye plants.     

过硫酸钠氧化脱色罗丹明B——影响因素和机理

采用过硫酸钠(PDS)直接氧化和催化活化氧化脱色罗丹明B(RhB),分别考察了PDS剂量、pH、催化剂、Cl-浓度对RhB脱色的影响.结果表明,PDS在无外加催化剂下能够有效脱色RhB,pH越低,脱色率越高;当pH 2.4,PDS用量为3.5 g·L^-1,在120 min内RhB的脱色率可达92%;自由基淬灭实验表明,酸性条件下主要为PDS直接氧化脱色RhB,并存在小部分硫酸根自由基(SO₄4·-)作用.在pH 5.6、pH 8.0条件下,外加活性炭纤维(ACF)、四氧化三铁(Fe₃O₄4)、Fe₃O₄4负载型催化剂(ACF/Fe3O₄4)可促进PDS对RhB脱色;在pH 2.4条件下,外加ACF对RhB脱色的促进作用较小,Fe₃O₄4、ACF/Fe₃O₄4对RhB脱色有一定抑制作用.不同pH和催化剂处理下,低浓度Cl-(0.01、0.04 mO₄l·L^-1)对RhB脱色速率都呈现抑制作用,高浓度Cl-(0.08 mO₄l·L^-1)相对于低浓度Cl-处理都呈促进作用.不同浓度Cl-处理在反应前60 min RhB脱色速率差异较大,而反应120 min后脱色率差异较小.提出Cl-通过调控SO₄4·-脱色RhB途径来影响RhB脱色速率的机理,Cl-竞争消耗SO₄4·-降低RhB脱色速率,但经一系列反应生成的Cl2·-能与RhB快速反应而提高RhB脱色速率;Cl-对RhB的脱色反应速率的影响存在抑制-促进双重机制,且与Cl-浓度相关.研究结果为基于PDS直接氧化和催化氧化处理含盐染料废水的研究和应用提供了一定的理论依据.     

Enterobacter sp. CV-v对甲基橙的脱色特性与条件优化

从浙江温州分离筛选到1株甲基橙高效脱色菌株CV-v,经16S rRNA基因序列分析表明,该菌株属于Enterobacter sp.属.单因素实验结果表明:当pH值在5.0~9.0之间时,培养48h以后,该菌株对甲基橙的脱色率均在80%以上;脱色的最适温度范围为30~40℃之间;所测碳源中的葡萄糖和麦芽糖、氮源中的牛肉膏和酵母粉对脱色的促进效果最为显著,且Ca2+和Mg2+也对脱色有显著的促进效应;此外,当接种量达到7%(V:V)以后,48h的脱色率即可达近100%.响应面设计实验结果显示,该菌株对甲基橙脱色的最优操作条件为:pH 8.0,葡萄糖1.7g/L,酵母粉3.0g/L,氯化镁3.0mmol/L及培养温度35.9℃.验证实验结果表明在最优条件下,该菌株在10h内对甲基橙的脱色率可达88.0%.总体而言,该菌株在偶氮染料脱色中的应用潜能较大.     

Decolorization and degradation of acid dyes mediated by salt fractionated turnip ( Brassica rapa ) peroxidases

Peroxidases from turnip roots (524?U?g^?1 of vegetable) were highly effective in decolorizing acid dyes having wide spectrum chemical groups. Dye solutions, containing 40–170?mg?dye?L^?1, were treated by turnip peroxidases (TP) (specific activity of 122.0?U?mg^?1 proteins). These enzymes were able to decolorize most of the acid dyes in the presence of 2.0?mM 1-hydroxybenzotriazole (HOBT). Increasing concentration of enzyme and time in the absence of HOBT did not influence dye decolorization. The rate of decolorization was significantly enhanced when HOBT was added to the decolorizing solutions. The decolorization of all the used dyes was maximum at pH 5.0 and 40°C. Complex mixtures of dyes were significantly decolorized when treated with enzyme in the presence of HOBT (2.0?mM). Phytotoxicity test based on Allium cepa root growth inhibition has shown that majority of the TP-treated dye product were not more toxic than their parent dye. Kinetic parameters of the TP with various dyes showed that this enzyme has highest affinity for Acid Yellow 42. This study demonstrates that the peroxidase/mediator system was an effective biocatalyst for the treatment of industrial effluents from textile, dye manufacturing, dyeing and printing industries or complex mixtures of dyes.     

Removal of Remazol Brilliant Violet-5R dye using periwinkle shells

The purpose of this research is to obtain optimal processing conditions for the adsorption of Remazol Brilliant Violet-5R (RBV-5R) dye onto activated carbon prepared from periwinkle shells (PSAC) by chemical activation with KOH using response surface methodology. Central composite design (CCD) was used to determine the effects of three preparation variables; CO₂ activation temperature, CO₂ activation time and KOH:char impregnation ratio (IR) on two responses; percentage RBV-5R dye removal and PSAC yield. Based on the CCD, two quadratic models were developed for percentage RBV-5R dye removal and PSAC yield, respectively. The most influential factor on each experimental design response was identified from the analysis of variance (ANOVA). The optimum conditions for the adsorption of RBV-5R dye onto PSAC were CO₂ activation temperature of 811 °C, CO₂ activation time of 1.70 h and IR of 3.0, resulting in 81.28% RBV-5R dye removal and 28.18% PSAC yield. PSAC prepared under optimum conditions was mesoporous with a Brunauer–Emmett–Teller surface area of 1894 m²·g^?1, total pore volume of 1.107 cm³·g^?1 and average pore diameter of 2.32 nm. The surface morphology and functional groups of the activated carbon were respectively determined from the scanning electron microscopy and Fourier transform infrared analysis.     

Fe-C-H_2O_2协同催化氧化处理印染废水

用Fe-C-H2O2协同催化氧化体系对印染工业废水的降解脱色处理进行了研究。对影响印染废水降解的几种因素如铁屑/碳粒质量比、双氧水的质量分数、废水pH等进行考察。试验结果表明,对于色度为650度和ρ（COD）为468mg·L-1的印染废水,在废水pH=4.8的情况下,当铁屑/碳粒质量比为25∶1、H2O2用量为150mg·L-1、催化反应30min时,印染废水的脱色率达98%以上,CODCr去除率可达78%。与Fe-C微电解法相比,Fe-C-H2O2协同催化氧化方法对印染废水的脱色能力和去除COD,表现出了更好的处理效果。