Some properties of a sequencing batch reactor for treatment of wastewater containing thiocyanate compounds

Thiocyanate (SCN) compounds in photo-processing wastewater (PPWW) could be treated by an SBR system without any release of thiocyanate to the atmosphere during the aeration step. An SCN loading greater than 84 g m(-3)d(-1) showed negative effects on the growth of bio-sludge and removal efficiencies of the system. The acclimatization period of the system was increased with an increase in SCN concentration or loading. The COD, BOD(5), TKN, and SCN removal efficiencies were 96.0 +/- 1.6%, 72 +/- 2%, 49 +/- 5%, and 82 +/- 3%, respectively, under an SCN loading of up to 84 g m(-3)d(-1). The removal efficiency of the system was repressed by SCN due to the repressed growth rate of nitrification bacteria. However, the removal efficiency could be increased with an increase in HRT or a decrease in SCN loading. Also, increases in HRT or decreases in SCN loading led to increased sludge age or solid retention time (SRT) and decreased the sludge volume index (SVI) value. The SRT and SVI of the system with synthetic wastewater containing 840 mg l(-1) SCN under an HRT of 3 days (SCN loading of 280 g m(-3)d(-1)) were 3.9 +/- 0.7 days and 65 +/- 4 ml g(-1), respectively, while they were 11.2+/-0.8 days and 55 +/- 6 ml g(-1), respectively under an HRT of 10 days (SCN loading of 84 g m(-3)d(-1)).     

城市污水条件下ASBR厌氧氨氧化的启动与脱氮性能

采用ASBR在城市污水条件下进行厌氧氨氧化的启动与脱氮性能研究。实验接种好氧硝化污泥,在温度为(35±1)℃、HRT为24 h、pH为7.3～8.5的条件下经过130 d的培养,成功启动了厌氧氨氧化反应。实验结果表明,厌氧氨氧化反应稳定运行时,TN容积负荷平均为0.179 kg/(m3.d),NH4+-N、NO2--N和TN去除率分别达到了95.30%、91.30%和76.28%。启动期和稳定运行期NH4+-N、NO2--N去除量和NO3--N生成量的比值分别达到1∶1.54∶0.25和1∶1.27∶0.27;稳定运行期进出水pH差值由启动时的0.85下降到0.24。启动期反硝化和厌氧氨氧化反应同时存在而在稳定运行期厌氧氨氧化发展成为主导反应。MLSS和MLVSS/MLSS先减少后增加,反映了启动过程中硝化细菌、反硝化细菌的衰亡和厌氧氨氧化菌逐渐富集的过程,这与反应器的宏观运行效果相一致。     

厌氧序批式反应器预处理垃圾渗滤液的碳平衡研究

为初步了解垃圾渗滤液中有机物降解过程的物质和能量转化,对渗滤液实际处理工程提供借鉴,在最优工艺参数条件下,分别用处于中温(35±1)℃和常温状态的厌氧序批式反应器(ASBR)对垃圾渗滤液进行预处理。通过对反应器内的液相、气相和固相碳素进行全面的分析测定,结果表明:中温(常温)条件下,整个反应周期内约有86.4%(77.6%)的碳进入气相,约有1.7%(1.4%)的碳进入固相,其余约11.7%(22.3%)的碳仍存于液相中;其中,进入气相部分的碳有77.6%(71.3%)以甲烷形式存在,8.8%(4.7%)以二氧化碳形式存在,这说明ASBR预处理垃圾渗滤液过程中产生的甲烷资源化利用潜力较大。另外,反应器在中温状态下较常温状态处理效果更佳。     

好氧颗粒污泥培养及不同阶段除污性能的研究

以某味精污水处理厂厌氧池的厌氧颗粒污泥作为接种污泥,采用人工模拟配水,通过控制运行条件在序批式反应器(SBR)中成功培养出了好氧颗粒污泥。研究表明,该好氧颗粒污泥具有良好的沉降性能及除污性能。好氧颗粒污泥的形成阶段的粒径为0.1～0.5 mm,成熟后的平均粒径为2 mm。形成阶段SBR中MLSS为5 000～6 000 mg/L,对COD和NH3-N的去除率分别达到了88.1%和87.6%。成熟后SBR中MLSS为10 000 mg/L左右,对COD和NH3-N的去除率分别达到了94%和97.5%。通过电镜分析可知,好氧颗粒污泥表面主要聚集了球状菌,中部主要以丝状菌和杆状菌为主,内部为无机核心。这种明显的分层现象,充分说明了好氧颗粒污泥沿半径方向由于溶解氧的梯度分布,微生物呈层状分布,这种层状分布的结构为好氧颗粒污泥同步硝化反硝化提供了可能。     

序批式生物反应器填埋场脱氮微生物多样性分析

为探究序批式生物反应器填埋场脱氮过程中的微生物作用机制,本研究采用建立脱氮功能基因(amoA、nosZ)克隆文库及PCR-RFLP技术对序批式生物反应器填埋场垃圾稳定化后期的主要脱氮功能微生物多样性进行分析.结果表明,矿化垃圾反应器中检测到的氨氧化细菌存在高度多样性,大部分为未知类群,且均为不可培养菌或未经分离获得的细菌,经系统发育树分析系统内氨氧化细菌以β-变形菌门中的亚硝化单胞菌属(Nitrosomonas)为主;新鲜垃圾反应器中反硝化细菌种群丰富,主要有β-变形菌纲中的陶厄氏菌属(Thauera)和硫杆菌属(Thiobacillus).Thauera属在好氧条件下具有反硝化特性,Thiobacillus属中的脱氮硫杆菌(Thiobacillus denitrificans)是一种硫自养反硝化菌,可见新鲜垃圾单元稳定化后期以好氧反硝化和自养反硝化的脱氮途径为主.此外文库中检测到的一部分反硝化细菌可能归属于α-变形菌纲的慢生根瘤菌科(Bradyrhizobiaceae).     

Performance of the hybrid growth sequencing batch reactor (HG-SBR) for biodegradation of phenol under various toxicity conditions

Hybrid growth microorganisms in sequencing batch reactors have proven effective for treating the toxic compound phenol, but the toxicity effect under different toxicity conditions has rarely been discussed. Therefore, the performance of the HG-SBR under toxic, acute and chronic organic loading can provide the overall operating conditions of the system. Toxic organic loading(TOL) was monitored during the first 7 hr while introducing50 mg/L phenol to the system. The system was adversely affected with the sudden introduction of phenol to the virgin activated sludge, which caused a low degradation rate and high dissolved oxygen consumption during TOL. Acute organic loading(AOL) had significant effects at high phenol concentrations(600, 800 1000 mg/L). The specific oxygen uptake rate(SOUR) gradually decreased to 4.9 mg O_2/(g MLVSS·hr) at 1000 mg/L of phenol compared to 12.74 mg O_2/(g MLVSS·hr) for 200 mg/L of phenol. The HG-SBR was further monitored during chronic organic loading(COL) over 67 days. The effects of organic loading were more apparent at 800 mg/L and 1000 mg/L phenol concentrations, as the removal range was between 22%–30% and 18%–46% respectively, which indicated the severe effects of COL.     

潜流湿地处理生活污水时的强化策略

研究在潜流湿地处理生活污水时通过预处理强化、介质优化和工艺改进克服现有技术缺陷的可行性.改进方法包括化学强化预处理、预曝气、添加氮吸附介质、添加磷吸附介质、湿地高浸润线、中浸润线、低浸润线和动态浸润线运行.结果表明,化学强化预处理不仅可以除磷,而且削减湿地污染负荷可使后续湿地面积减小63%,但是不能有效脱氮.预曝气仅使氨氮去除率提高了1%.添加氮吸附介质的有效时间短,运行前3个月对NH₄⁺-N去除率为84%,5个月后下降到64%.添加磷吸附介质的有效时间较长,可维持数年.因此,脱氮过程只有通过基质微生物实现.稳态浸润线下对COD、NH₄⁺-N、TN、TP的去除率,高浸润线湿地为50%、21%、32%、-26%;中浸润线湿地为53%、48%、48%、-14%;低浸润线湿地为74%、96%、35%、22%.提出动态浸润线及序批式潜流人工湿地工艺(CBSW),其对COD、NH₄⁺-N、TN、TP去除率为67%、62%、53%、33%.CBSW实现了单级湿地内好氧/缺氧环境的交替出现,提高了脱氮能力,除污综合表现最佳.     

EGSB出水回流对EGSB—SBR工艺处理果汁废水的影响

采用EGSB—SBR工艺处理实际果汁废水(COD 2 608~6 500 mg/L,p H 5.0~7.0)。在EGSB反应器成功启动及驯化完成的情况下,连续运行49 d。实验结果表明:第25天起,控制EGSB回流比为3.00∶1,EGSB反应器可在无须添加Na HCO3的条件下稳定运行,从而降低了废水处理成本;第25天起,平均进水COD,BOD5,SS分别为5 968,2 130,1 020 mg/L,平均出水COD,BOD5,SS分别降至131,11,50 mg/L,平均COD,BOD5,SS去除率分别为98%,99%,95%;组合工艺对该实际果汁废水具有良好的处理效果。     

Treatment of azo dye Orange II in a sequential anaerobic and aerobic-sequencing batch ractor system

We studied the biodegradation of Orange II in a sequential anaerobic and aerobic-sequencing batch reactor system. Granular activated carbon was used either packed into a column or added directly into the anaerobic reactor to investigate the treatment performance between the two operation conditions. We found that the circulation of mixed liquor between the anaerobic reactor and the carbon-packed column enhanced the chemical oxygen demand from 28 to 52% and Orange II removal efficiencies from 88 to 96%, under simultaneous adsorption and biodegradation process. The morphology of microbes was observed under an electron-scanning microscope.     

芽孢杆菌发酵产碱性果胶酶温度控制策略

采用自行筛选获得一株产碱性果胶酶芽孢杆菌WSH03-09,在小型发酵罐中研究了不同温度对碱性果胶酶分批发酵的影响,结果表明,在恒定39℃条件下,可获得最高酶活5．39u／mL,各温度条件下的菌体干重相差不多,最终均能达11．5g／L左右;在发酵前期,控制温度41℃时最有利于菌体的生长,而在产物合成期,控制37℃有利于获得较高的产物合成比速,在此基础上,提出分阶段温度控制策略,采用此温度控制策略进行碱性果胶酶的发酵,碱性果胶酶酶活达5．99u／mL,比采用单一温度下的最大值提高了11％,其它各项指标也有较大提高．图6表1参6