活性污泥丝状膨胀早期预警的研究进展

活性污泥法是目前处理污水的一种有效方法,在应用过程中,频频发生的污泥膨胀现象成为影响污水处理效率的难题,对污泥膨胀进行早期预警调控研究,已成为该领域关注的热点问题.本文阐述了丝状菌引起的污泥膨胀预警研究的进展情况,从污泥常规指标测定、形态观察和分子生态学3个方面对丝状污泥膨胀的预警方法进行了综述,对各种方法的优点与不足展开讨论,并在此基础上归纳出一些改进的措施,展望了丝状污泥膨胀预警的应用前景.     

Continuous nitrifying granular sludge bioreactor: Influence of aeration and ammonium loading rate

Granulation of nitrifying bacteria was investigated in a continuous bubble column bioreactor. Then, the combined effect of aeration and ammonium loading rates on dissolved oxygen (DO) concentration as well as nitrification process was evaluated in the system using an experimental design technique. After 120 days, stable nitrifying granules with average diameter of 1.4 mm and settling velocities of 55 m/h were obtained. The influence of increasing ammonium loading rate (ALR) was found to be more significant than decreasing aeration rate on the reduction of DO concentration inside the nitrifying bioreactor. The system could handle the ALR values of 0.48–1.92 gNH₄⁺-N/L d with the ammonium removal efficiency from 65% to nearly 100% at the tested airflow rates of 2.5 and 4.5 L/min. At the low aeration, the complete ammonium conversion to nitrate was replaced with nitrite when the ALR increased to 1.44 gNH₄⁺-N/L d. At the high aeration, however, almost complete nitrification was achieved except the high ALR in which the nitrite accumulation was observed up to 38%. The study demonstrated that the continuous bioreactor had a considerable performance for obtaining stable nitrifying granules to have nitrite accumulation under control with changing the ratio of aeration rate and ALR.     

处理含酚废水曝气生物流化床中丝状菌种群结构的解析

应用曝气生物流化床反应器(ABFT)处理含酚废水,随着进水ρ(苯酚)由100 mg/L提高到400 mg/L,苯酚的去除率稳定在100%左右,且苯酚的去除主要发生在4个反应池中的第一池. 利用扫描电镜(SEM)、荧光原位杂交(FISH)和变性梯度凝胶电泳(DGGE)技术对反应器内微生物种群进行分析. 扫描电镜结果表明,随着反应器进水ρ(苯酚)的提高,填料生物膜微生物逐渐演变为以丝状菌为主. 针对SSU rRNA的荧光原位杂交结果表明,反应器内丝状微生物主要为真菌. 分别对细菌和真菌的16S rDNA和18S rDNA 进行PCR-DGGE分析,结果表明,反应器内主要的苯酚降解菌为克氏地霉(Geotrichum klebahnii),同时存在发硫菌等丝状细菌. 聚类及多样性分析表明,苯酚对微生物种群表现出很强的选择性.      

好氧颗粒污泥中丝状微生物生长研究

通过在序批式摇床反应器(SSBR)中分别接种絮状活性污泥与厌氧颗粒污泥来处理含盐及淡水2种废水并培养好氧颗粒污泥,研究好氧颗粒污泥中丝状微生物的过度生长及可行的控制措施.结果表明,进水水质与接种污泥类型都会影响颗粒污泥中丝状微生物的生长.同是接种好氧絮状污泥的R1、R3,由于R1进水为含盐废水而R3为淡水,R1中颗粒污泥丝状化程度低于R3,而接种厌氧颗粒污泥并处理含盐废水的R2颗粒污泥丝状化程度最低.当好氧颗粒污泥外部出现明显丝状微生物过度生长时,各反应器中颗粒污泥平均丝状化程度△分别达到△R1=1.4、△R2=1.2及△R3=2.0.对各反应器颗粒污泥中丝状微生物进行鉴定,R1颗粒中丝状微生物主要为Eikelboom 0092及Nocardia spp.,R2中主要为.Fungi spp.及Nocardia spp.,R3中主要为S.natans 及H.hydrossis,这几种类型丝状微生物一般出现在污泥龄长、溶解氧浓度低及基质易降解的环境中,但由于好氧颗粒污泥结构不同于传统活性污泥,试验通过控制污泥负荷、污泥龄及曝气量等并不能有效控制颗粒中丝状微生物的过度生长.试验将各反应器进水基质由易降解的葡萄糖配水换为难生物降解废水时,能快速有效地控制颗粒污泥中丝状微生物的过度生长.     

好氧颗粒污泥用于膜污染的控制

膜生物反应器在运行过程中容易引起严重的膜污染,从而限制了膜生物反应器在实际废水处理工程中的应用.从污泥特性角度分析了好氧颗粒污泥的特点和减缓膜污染的原因,并且与活性污泥比较,提出好氧颗粒污泥减缓膜污染的优势,为膜污染的控制提出了新的思路和方法.     

Influence of different substrates on the formation and characteristics of aerobic granules in sequencing batch reactors

The effects of different substrates on the aerobic granulation process were studied using laboratory-scale sequencing batch reactors （SBRs）. Four parallel granules sequencing batch reactors （GSBR）： R1, R2, R3, and R4 were fed with acetate, glucose, peptone and fecula, respectively. Stable aerobic granules were successfully cultivated in R1, R2, R4, and smaller granules less than 500 μm were formed in R3. Morphology and the physic-chemical characteristics of aerobic granules fed with different carbon substrates were investigated by the four reactors operated under the same pressure. The aerobic granules in the four reactors were observed and found that peptone was the most stable one due to its good settleability even after a sludge age as short as 10 d. A strong correlation was testified between the characteristics of aerobic granules and the properties of carbon substrates. The stability of aerobic granules was affected by extracellular polymer substances （EPS） derived from microorganism growth during feast time fed with different carbon substrates, and the influence of the property of storage substance was greater than that of its quantity. Optimal carbon substrates, which are helpful in the cultivation and retention of well-settling granules and in the enhancement of the overall ability of the aerobic granules reactors, were found.     

竹丝生物膜反应器修复校园景观水体的实验研究

以竹丝作为填料而组建的接触氧化生物膜工艺对校园景观水体进行易位修复,通过设置5个不同工况以探明竹丝载体在修复轻度污染水体的特性,研究表明:当进水CODMn、氨氮和浊度分别为7.79~24.32 mg/L、1.36~11 mg/L和0.63~33.11 NTU的情况下,其去除率分别为10.57%~74.34%、-83.33%~57.55%和20.01%~100%,不同的运行工况对修复效果的影响不显著;系统在启动后的8 d内即可形成丰富成熟的生物相,而且竹丝上的细菌主要以短杆菌为主;竹丝生物膜反应器修复后的景观水体中的活细菌数量可减少1个数量级。竹丝上的亲水性基团和良好的生物亲和性以及从竹丝上脱落下来的零散竹丝纤维是竹丝填料生物膜快速形成的基础,宏观和微观"网捕"结构是该系统能在极短时间实现高效去除浊度、有机物和细菌等高分子物质的主要原因。     

丝状菌对生物淋滤去除底泥中重金属的促进作用

利用氧化亚铁硫杆菌(Acidithiobacillus ferrooxidans,A.f)对采自株洲霞湾港底泥中的Cu、Cd、Pb和Zn 4种重金属进行生物淋滤实验,在实验中加入丝状菌考察其对重金属去除效果的影响。结果表明,丝状菌可以有效抑制低分子量有机酸对A.f的毒害作用,促进各种重金属的去除。当加入10%(体积比)的丝状菌后,生物淋滤过程中系统pH值在5 d内降低到2以下,Fe2+在4 d内完全氧化。经过10 d的处理,Cu、Cd、Pb和Zn 4种重金属的最高去除率分别达到76.3%、92.5%、52.6%和88.5%,与不加入丝状菌的处理相比,达到最大去除率所需的时间缩短1~2 d,4种重金属中,丝状菌的加入对Pb的去除促进作用最为明显,其去除率增加1倍左右。因此,在生物淋滤处理重金属-有机物复合污染底泥工艺中接入丝状菌对处理效果有很好的促进作用。     

Roles of ATP-dependent N-acylhomoserine lactones (AHLs) and extracellular polymeric substances (EPSs) in aerobic granulation

Aerobic granules which form through a cell-to-cell self-immobilization process have been intensively studied and developed for wastewater biotreatment. However, the microbiological origin of this phenomenon is still largely unknown. This study investigated the possible role of metabolic energy in the development of aerobic granules. Results showed that aerobic granulation was positively related to ATP-dependent N-acylhomoserine lactones (AHLs) and extracellular polymeric substances (EPSs) production. Inhibited ATP synthesis by a chemical uncoupler, 3,3′,4′,5-tetrachlorosalicylanilide, led to significant reduction of AHLs and EPSs production, which in turn prevented aerobic granulation. This study for the first time demonstrated the involvement of ATP-dependent AHLs in aerobic granulation.     

ABR-好氧颗粒污泥处理黄连素废水的启动研究

实验研究了ABR-好氧颗粒污泥组合工艺处理黄连素制药废水的启动运行,通过分析发现,ABR装置在HRT为4 d,黄连素浓度为50 mg/L的运行方式下成功启动,反应器运行稳定后每个格室MLSS平均值分别为25 840、21 560、27 500和11 200 mg/L。以ABR出水为营养物,成功培养出粒径在2～10 mm,沉降速率为104～137 m/h,沉降性能优良的好氧颗粒污泥。该组合工艺在启动实验的末期,进水COD浓度为3 000～4 000 mg/L左右,出水COD浓度到达168.4～271mg/L,系统总的去除率保持在90%～95%之间,表明ABR-好氧颗粒污泥组合工艺能够有效地处理黄连素制药废水。