序批式活性污泥法在炼油化工废水处理中的应用

炼油化工废水处理的传统处理工艺中存在一定的弊端。为此,玉门炼油化工总厂对其废水处理设施进行了改建和扩建,其生物处理系统采用了序批式活性污泥法处理工艺。经过 3年运行的结果表明:该系统运行效果良好,处理后的水质可达到《GB8978-1996》(石化)一级排放标准的要求;化学需氧量(COD)和生化需氧量(BOD)分别降低78.6%和91.2%,硫化物去除率为98.2%,挥发酚去除率为99.6%。而且该反应器具有较强的耐冲击负荷能力,进水中COD在600 mg/L以下且有大幅度波动时,该系统仍可稳定地运行,处理后的水可达标排放。     

苯罐安全储存技术措施

液态苯极易燃烧爆炸,苯类化学事故造成的后果及影响极大,其安全储存涉及多方面技术措施.通过危险预知分析等方法,较详细地介绍了苯罐的安全储存温度和安全储存的技术措施.     

原油油气职业卫生标准研究

我国目前尚未制订原油油气卫生标准,多数引用溶剂汽油卫生标准,研究表明原油油气毒性较溶剂汽油大,为保障油运装卸作业人员的健康,科学地监测与控制油气污染,确定合理的作业环境,制订原油油气卫生标准是十分必要的。该研究通过色-质联用分析,表明原油蒸气成份大多为C9以下烷烃、环烷烃及少量的芳香烃。采用大、小鼠为对象的急性毒性实验研究,获得大庆、胜利、渤海3种原油油气的LC50分别为49.54g/m3、77.54g/m3、417.50g/m3;亚慢性毒性实验研究表明,原油油气对动物神经系统的影响较为突出。现场劳动卫生学调查统计表明油轮、油码头作业人员,除了在装船、装罐作业状态下受到较大油气浓度危害外,大部分时间处于100mg/m3以下油气浓度环境,但长期从事油运装卸作业,表现出一定的健康异常,其主要症状是神衰症候群发生率明显增高,植物神经功能障碍,血象异常,其次为心率、心电图的改变等。根据上述研究结果,该研究认为原油装卸贮运作业场所原油油气时间加权平均容许浓度确定为100mg/m3(以总烃计)较为适宜。     

油罐清洗作业火灾预防措施

油罐清洗是石油化工行业一项基本的业务活动.目前大型原油储罐、成品油储罐正在逐步推广应用自动机械清洗系统进行清罐作业,而对于容量小、沉积物较少的油罐国内仍然采用人工清洗方式进行.本文分析了油罐人工清洗作业过程中容易引发火灾的原因的基础上,从严格执行规章制度、处理好清洗废物,控制和消除引火源等几方面相应提出了预防火灾措施.     

ClO2去除废水中石油类污染物的研究

就如何使用ClO2和O3对水中石油类污染物氧化去除进行了研究，确定了最佳反应时间、pH和氧化剂用量对去除率的影响。ClO2的最佳投加量应为有机物总量的1．5倍，反应时间可控制在20min上。ClO2处理pH5．0～6．5溶液时的去除效果最好。同时进行了O3的对照实验。分析了ClO2和O3在水处理应用中的优缺点。     

我国废铅蓄电池产生量与再生铅产能的讨论

废铅蓄电池是再生铅主要原料，铅蓄电池产量、进出口量、社会消费保有量，以及铅蓄电池消费使用领域与废铅蓄电池产生量有关。预测2015年废铅蓄电池产生量，并讨论我国再生铅产能规模，供再生铅产业结构调整与区域布局调整作参考。     

Stand-alone wind power system with battery/supercapacitor hybrid energy storage

This paper presents a stand-alone wind power system with battery/supercapacitor hybrid energy storage. A stand-alone wind power system mainly consists of a wind turbine, a permanent magnet synchronous generator, hybrid energy storage devices based on a vanadium redox flow battery and a supercapacitor, an AC/DC converter, two bidirectional DC/DC converters, a DC/AC converter and a variable load. Several control strategies for the stand-alone wind power system are involved such as a maximum power point tracking (MPPT) control, a vanadium redox flow battery charge/discharge control and a supercapacitor charge/discharge control. The proposed MPPT control combines a sliding mode control with an extreme search control to capture maximum wind energy. This strategy avoids the necessity of measuring wind velocity, obtaining models or parameters of the wind turbine and calculating the differentials of the power generated from the wind power system and from the speed of the generator. The battery charge/discharge control maintains a constant DC bus voltage. When the battery charging/discharging current reaches the setting threshold, the charge/discharge control of the supercapacitor is triggered to limit the charging/discharging current of the battery. The simulation results show that the proposed method can rapidly respond to variations in wind velocity and load power.     

降水中甲酸、乙酸和草酸的离子色谱法测定及样品保存研究

甲酸、乙酸和草酸是降水中有机酸的主要成分。研究选用离子色谱法同时测定降水中的甲酸、乙酸和草酸,并对降水样品中3种有机酸的保存条件进行了研究。优化后的色谱条件为4. 0 mmol/L Na_2CO_3和1. 2 mmol/L NaHCO_3混合淋洗液,淋洗液流速为1. 0 m L/min,进样体积为200μL,电导池温度为30℃,柱温为室温。甲酸、乙酸和草酸的检出限分别为0. 002、0. 005、0. 005 mg/L,实际降水样品测定时平行样的相对标准偏差为1. 4%～12%,加标回收率为95%～118%。样品采集后需尽快用0. 45μm聚醚砜微孔滤膜过滤,4℃以下冷藏密封保存,2 d内测定。若用氢氧化钠溶液调节p H至8～10,样品可保存7 d。     

Comparative evaluation of sizing of metal hydride (MH) hydrogen storage tank filled with different alloys

This study presents a comparative analysis of sizing of metal hydride tank filled with different alloys. Alloys include solid solutions and intermetallic compounds of the generic families AB₅, AB₂, AB, A₂B. The effects of the different alloys on the sizing of metal hydride hydrogen storage tanks are complicated and depend on many factors. In this paper, a thermoeconomic optimization analysis with a simple algebraic formula was presented for the estimation of optimum metal hydride tank surface area for heat transfer enhancement. The optimum area of the metal hydride tank filled with commercially available different alloys (LaN₅, Ti_0,98Zr_0,02V_0,43Fe_0,09Cr_0,05Mn_1,5, TiFe, Mg₂NiH₄) was evaluated and compared by the developed method. The optimum net savings and the value of payback were determined for four alloys. It is found that mathematical model can be employed for the determination of optimum metal hydride tank design and increasing net savings according to alloy types. The optimum areas of the tanks filled with four alloys (LaN₅, Ti_0,98Zr_0,02V_0,43Fe_0,09Cr_0,05Mn_1,5, TiFe, Mg₂NiH₄) were calculated as 0.136, 0.130, 0.133, and 0.173 m², respectively. The optimum net savings for tanks filled with four alloys (LaN₅, Ti_0,98Zr_0,02V_0,43Fe_0,09Cr_0,05Mn_1,5, TiFe, Mg₂NiH₄) are about 461.0, 409.3, 419.6, and 979.6 $ and the values of payback are about 1.98, 2.1, 2.17, and 1.37 years, respectively. Excessive area of the metal hydride tank would not be as economical as the optimum tank area. Thermal management of metal hydride tank must be designed for optimum points calculated at which maximum savings occur.     

陕西省油松混交林木质残体储量与腐烂特征

木质残体是油松针阔混交林的重要组成部分,具有多种的生态功能,对生态系统的稳定和发展有着不可忽视的作用。以陕西省黄龙山林区为研究区域,设置1 hm2(100 m×100 m)的固定样地,研究典型油松针阔混交林木质残体的储量组成、优势树种的空间关系、腐烂特征及密度与含水量,研究结果表明:(1)研究区油松针阔混交林内木质残体的总储量为10.73 t·hm–2,倒木是林分内木质残体的主要来源。在径级组成结构上,径级20 cm以上的木质残体储量占总储量的绝大部分。腐烂等级中,以腐烂等级Ⅱ与腐烂等级Ⅲ的木质残体贮量最多;(2)利用线性模型模拟该林分木质残体的分解密度与含水量,其拟合结果显示木质残体的密度随着腐烂等级的增加而呈现下降趋势,而含水量则随着腐烂等级的增加而呈现升高的趋势;(3)林分内主要研究树种(油松、白桦和山杨)之间在小空间尺度上呈负关联,大尺度下呈正关联,顶级树种与先锋树种间达到互利共生,群落具有较大稳定性。林分内种间竞争的结果将为地带性顶级树种油松代替白桦与山杨等先锋树种。天然油松针阔混交林木质残体的贮量组成及腐烂特征反映了该区森林群落演替后期阶段木质残体的结构特征,本文的研究结果为我国黄土高原针阔混交林生态系统的管理和保护以及可持续经营提供科学依据。