Treatment of 2-phenylamino-3-methyl-6-di-n-butylaminofluoran production effluent by combination of biological treatments and Fenton＇s oxidation

High strength refractory organic stream is produced during the production of 2-phenylamino-3-methyl-6-di-n-butylaminofluoran （One Dye Black 2, abbr. ODB 2）, a novel heat-sensitive material with a promising market. In this study, a combination of acidificationprecipitation, primary biological treatment, Fenton＇s oxidation and another biological treatment was successfully used for the removal of COD from 18000-25000 mg/L to below 200 mg/L from the ODB 2 production wastewater in a pilot experiment. A COD removal of 70%-80% was achieved by acidification-precipitation under a pH of 2.5-3.0. The first step biodegradafion permitted an average COD removal of 70% under an hydraulic residence time （HRT） of 30 h. By batch tests, the optimum conditions of Fenton＇s oxidation were acquired as： Fe^2＋ dose 6.0 mmol/L; H2O2 dose 3000 mg/L; and reaction time 6 h. The second step biological treatment could ensure an effluent COD below 200 mg/L under an HRT of 10 h following the Fenton＇s treatment.     

不同基质垂直流人工湿地对猪场污水季节性处理效果的研究

研究了3套不同基质垂直流人工湿地小试装置在不同季节处理猪场污水的运行效果.结果表明,垂直流人工湿地对有机污染物的去除效果随季节变化差异不明显,对有机物降解情况可用一级降解模型模拟;传统型湿地系统NH4 -N去除率在各季节稳定在52%,而沸石和沸石-煤渣型系统冬季NH4 -N去除效率分别从秋季的89.8%和93.4%下降至冬季的64.2%和73.5%,春、夏季回升至80%左右.冬季湿地系统中生物硝化与反硝化作用的减弱影响了垂直流人工湿地系统TN的去除;3套不同基质系统中,沸石-煤渣型系统各高度层硝化强度均为最高,沸石型和沸石-煤渣型系统的反硝化强度明显高于传统型系统,与实际运行过程TN去除率变化相吻合.采用沸石作为基质有利于系统的反硝化进程和TN的去除.垂直流系统对TP去除率随季节性变化波动不显著,但随着垂直流人工湿地系统的运行,基质层对TP的吸附逐渐饱和,去除效率明显下降.     

含半无限长裂纹压电材料的Ⅲ型强度因子

研究了含半无限长裂纹压电材料在平面内电场和反平面荷载作用下的问题 ,得到了满足拉普拉斯方程、裂纹面边界条件的位移函数解和电势函数解及电弹场的基本解 ,并得到了应力、应变、电位移强度因子和能量释放率。研究结果表明 ,在裂尖 ,电场强度没有奇异性 ,而应变、应力、电位移具有奇异性。     

煤矿轴流式局部通风机的降噪试验研究

煤矿局部通风机（简称“局扇”）的噪声是煤矿掘进中的主要噪声源，分析了局扇噪声的产生机理，提出了减少局扇的动叶叶顶与机壳间隙，在局扇入口加阻性消声器和在机壳涂上一层阻尼材料等方法来控制局扇的噪声方法，方法在JBT52－2型局扇的试验研究表明，实施上海降噪措施，局扇的噪声有大幅度降低，可使局扇的噪声达到工矿企业噪声卫生标准要求。     

循环流化床锅炉床温控制方法

就目前电厂循环流化床锅炉运行中存在的床温波动问题，讨论了导致床温波动的因素，并针对性地提出了控制床温的一些措施。     

现代化工分离技术在环境保护中的应用

介绍了高效导向筛板、新型高效填料、超临界流体萃取等现代化工分离技术及其在清洁生产和废物处理方面的应用。     

Oil/Suspended Particulate Material Interactions and Sedimentation

The interactions of physically dispersed oil droplets with suspended particulate material (SPM) can be important for the transport of bulk quantities of spilled crude oil and polycyclic aromatic hydrocarbons (PAH) to subtidal sediments. The literature regarding oil/SPM interactions is reviewed, and results from whole-oil droplet/SPM interaction kinetics and pure-component (Prudhoe Bay crude oil distillate cut) equilibrium partitioning experiments are presented. The effects of oil type, SPM characteristics, and salinity on the interaction rates are examined, and the importance of whole-oil droplet/SPM interactions on particle agglomeration and settling behavior are discussed. Whole-oil droplet/SPM interactions are retarded as oil droplet dispersion into the water column is inhibited by oil viscosity increases due to evaporation weathering and water-in-oil emulsification. Compared to whole oil droplet/SPM interactions, dissolved-component/SPM adsorption is not as significant for transport of individual components to sediments. The information presented in this paper can be used to augment computer-based models designed to predict oil-spill trajectories, oil-weathering behavior, and spilled oil impacts to the marine environment.     

磁分离技术在我国废水处理中的研究进展

本文介绍了磁分离技术的基本原理、分离方法和设备，综述了该技术在某些特定废水处理中的应用现状。磁分离技术的实际应用具有分离效率高、分离速度快、选择性好、处理对象广、成本低廉、分离物系的粒度可达到很小，并且不受处理体系的温度、密度、酸碱度限制等优点，可以使某些采用传统分离方法较难或不能分离的物系得以顺利地分离，有较为广泛的应用前景。     

焦化黄血盐吸收塔填料自燃原因分析

焦化黄血盐系统内的吸收塔在停产检修补充填料——铁刨花期间，经常发生铁刨花自燃现象，这是严重的事故隐患。结合武钢焦化公司黄血盐工艺特点，对其自燃原因作了详细分析，提出了避免此类事故发生的措施。     

活性炭膜处理工业废水的试验研究

将活性炭膜与常规弹性材料同时作为生物接触氧化处理工艺的填料,分别加装在相同条件的两套接触氧化池中,采用生物接触氧化处理工艺,在同样的条件下处理工业废水,经过对试验数据的对比分析得出:以活性炭膜为填料,处理废水的能力更强,净化效果更好。