微生物絮凝剂的絮凝性及抗氧化性研究

考察了一株产絮凝剂细菌BK-4所产絮凝剂的絮凝能力、组成及抗氧化性.结果表明,接种量2％、培养24 h后BK-4菌发酵液的最大絮凝率可达96.9％.发酵液的主要组成为多糖,提取方法对粗提物的絮凝率有明显影响,水溶醇沉法粗提物的最大絮凝率可达95.6％,粗提物多糖含量为1.65g/L时对DPPH自由基的捕获率可达最大值3...     

Turbosorp湍流吸收循环流化床烟气脱硫技术在改造工程中的应用

循环流化床半干法烟气脱硫技术是目前世界上主流脱硫工艺技术之一,主要适用于大中型燃煤电厂的烟气脱硫,在国内外拥有大量成功运行的工程案例。本文章基于本公司实践论述Turbosorp湍流吸收循环流化床脱硫技术的技术特点、关键工艺控制要点以及在机组改造工程中的技术优势,为同类型机组改造工程中的方案选择提供参考。     

Enhanced struvite recovery from wastewater using a novel cone-inserted fluidized bed reactor

The feasibility of struvite recovery at low （12.5 mg/L） and high （120 mg[L） phosphorus concentrations was studied by constructing a novel fluidized bed reactor with cones （FBRwc） and without cones （FBRwoc）. The crystallization process was continuously operated for 133 days under different hydraulic retention times （HRT = 1-10 hr）, pH （7.5-10）, and molar ratios of Mg/P （0.75-1.75）, N/P （1-10） and Ca/Mg （0-2）. The optimum operating conditions of HRT, pH, Mg/P and N/P molar ratios were found to be 2 hr, 9, 1.25, and 7.5, respectively. Under these optimum conditions, the phosphorus precipitation efficiencies of FBRwc were 93% for low and 98% for high phosphorus influent; however, the efficiencies were 78% and 81% for FBRwoc, respectively. Due to crystal losses at each junction （17%-31%）, the crystal recovery efficiency of FBRwoc was relatively low （47%-65%） for both influent concentrations. However, the losses were minimal in FBRwc, which showed 75% and 92% crystal recovery for low and high phosphorus concentrations, respectively. At low calcium concentration, crystal chemical analysis showed the product to be pure struvite （〉 99%）. The scanning electron microscope and X-ray diffraction results further confirmed that the crystal recovered from FBRwc contained pure struvite, which could be considered a high quality fertilizer. Except HRT, all parameters （pH, Mg/P, N/P and Ca/Mg） were found to be influencing factors for FBRwc performance. Overall, inserting cones in each part of the reactor played a significant role in enhancing struvite recovery from a wide range of phosphorus-containing wastewater.     

A restoration-promoting integrated floating bed and its experimental performance in eutrophication remediation

Numerous studies on eutrophication remediation have mainly focused on purifying water first, then restoring submerged macrophytes. A restoration-promoting integrated floating bed （RPIFB） was designed to combine the processes of water purification and macrophyte restoration simultaneously. Two outdoor experiments were conducted to evaluate the ecological functions of the RP1FB. Trial 1 was conducted to compare the eutrophication purification among floating bed, gradual-submerging bed （GSB） and RPIFB technologies. The results illustrated that RPIFB has the best purification capacity. Removal efficiencies of RPIFB for TN, TP,NH4＋-N, NO3-N, CODcr, Chlorophyll-a and turbidity were 74.45%, 98.31%, 74.71%, 88.81%, 71.42%, 90.17% and 85%, respectively. In trial 2, influences of depth of GSB and photic area in RPIFB on biota were investigated. When the depth of GSB decreased and the photic area of RPIFB grew, the height of Potamogeton crispus Linn. increased, but the biomass of Canna indica Linn. was reduced. The mortalities of Misgurnus anguillicaudatus and Bellamya aeruginosa in each group were all less than 7%. All results indicated that when the RPIFB was embedded into the eutrophic water, the regime shift from phytoplankton-dominated to macrophyte-dominated state could be promoted. Thus, the RPIFB is a promising remediation technology for eutrophication and submerged macrophyte restoration.     

流化床O2/CO2气氛燃煤痕量元素的排放特性及控制

通过平顶山烟煤在小型流化床中的燃烧实验,采用X-射线荧光光谱仪(XRF)对低压撞击器(LPI)收集到的细颗粒物元素组成进行定量测定,研究了O2/CO2气氛下硅藻土对煤粉燃烧痕量元素的排放控制.结果表明,Zn、Mn和Ni的含量随粒径呈双峰分布,峰值分别在0.1μm和2μm附近,Hg和Co的含量在0.1μm附近有一峰值;Hg和Zn在亚微米颗粒上有一定程度的富集,Mn、Ni和Co在亚微米和超微米颗粒上的含量基本相当;当颗粒物粒径一定时,随着硅藻土含量的增加,5种元素的富集因子呈减小的趋势;随着添加剂粒径的减小,颗粒物中Hg、Mn、Zn、Ni和Co的含量呈减少的趋势;当颗粒物粒径一定时,5种元素含量顺序为MnZnNiCoHg.     

畜牧业清洁生产关键技术实例研究——生态发酵床在规模化养猪场的应用研究

畜牧养殖业最大的污染物就是畜禽粪便,在畜禽养殖也实施清洁生产技术十分必要,将粪便在产生的环节上降低污染物的产生和排放,结合具体实例,按照企业清洁生产审核程序要求,对一家生猪养殖场进行清洁生产审核,对生态发酵床技术在规模化养猪场的应用进行深入研究,从技术、环境、经济三个方面阐述这项清洁生产技术的示范作用。     

波流式生态滤床氨氮去除效果及其微生物群落结构分析

利用波流式生态滤床处理受污染的河水,考察了其对氨氮的去除效果和沿程污染物转化情况,并采用扫描电镜、高通量测序手段解析了波流式生态滤床不同时间和位置基质上生物膜的细菌群落组成,分析了波流式生态滤床小试反应器中硝化细菌和反硝化细菌的分布特点,以探讨其去除氨氮的机理.结果表明,反应器稳定运行以后,对氨氮平均去除率为74.83%,基质表面可以观察到大量微生物,不同时期优势细菌有较大不同.反应器前部主要发挥硝化作用,中部发挥反硝化作用,硝化菌的分布呈现上多下少、前多后少的特点,使得氨氮在前端被快速去除;中部以黄杆菌属(Flavobacterium)为代表的反硝化菌丰度较高,促进了反硝化作用的发挥,降低了出水中总氮浓度;不同部位样品中细菌多样性差别不大,微生物种群多样性随着水流方向呈现先增加,到后段减少的趋势.     

粉状活性焦在双层滤料颗粒床中的脱硫试验研究

在双层滤料颗粒床模型试验台上对粒径为300～400目的粉状活性焦进行了脱硫试验,研究了温度、O2和水蒸气体积分数、气体流速、再生次数对脱硫效果的影响.试验结果表明.温度为120℃、O2体积分数为8%、水蒸气体积分数为10%条件下,脱硫效果最好;粉状活性焦在双层滤料颗粒床中经过7次重复吸附.达到硫饱和吸附量为66.2 mg/g.粉状活性焦再生试验表明,随着再生次数的增加.粉状活性焦的脱硫性能呈下降趋势.     

移动式颗粒床除尘器最佳入口风速下的阻力计算

分析论述了ＹＸＫＣ型除尘器在最佳入口风速下的阻力计算方法及其影响，指出了进一步研究和改进设计的方向与途径。     

Catalytic decomposition of hydrocarbon into hydrogen and carbon in a spouted-bed reactor as the second-stage reactor of a plastic recycling process

A two-stage process for the chemical recycling of plastics is proposed. In this process, which consists of two reactors, plastics are converted into hydrogen and carbon. In the first reactor, plastic chips are thermally decomposed into hydrocarbons. In the second reactor, the hydrocarbons formed in the first reactor are catalytically decomposed into carbon and hydrogen. In this study, in order to obtain basic data for the second reactor, propene was catalytically decomposed in a laboratory-scale spouted-bed reactor (600mm high, 21.6mm internal diameter, made of SUS304). The effect of the type of spouting medium used on the decomposition behavior of propene was investigated using four types of spouting medium (nickel-plated -alumina, palladium-plated -alumina, nickel-impregnated -alumina, and -alumina). The nickel-impregnated -alumina gave the best propene conversion and hydrogen yield.