纳米铝粉对烟火药剂热安全性影响研究

为研究铝粉纳米化后对烟火药剂性能的影响，本文将普通铝粉和纳米铝粉分别与氯酸钾、硫粉按照零氧平衡的同一配比（17％AL＋63％KClO3＋20％S）配成的烟火药剂进行ARC热分析对比试验发现，含纳米铝粉的烟火药剂热分解的初始反应温度降低，反应到达最大温升速率所需的时间延长，反应所能达到的最高压力降低。这说明纳米铝粉的加入在加速其反应进程的同时，可有效地降低其反应的激烈程度和危险性，即铝粉纳米化后可以有效的改善烟火药剂的性能，提高其安全性。     

水泥厂煤粉制备系统袋除尘器的选型及应用

本文介绍了煤粉制备系统含尘废气的特性及治理技术的发展与应用，并从袋除尘器类型的确定、处理风量的确定、过滤风速的选取、过滤面积的计算和除尘器规格的选取等方面介绍了煤磨袋除尘器的选型，以及FGM（M）型气箱脉冲防爆袋除尘器、MMC型脉冲喷吹防爆袋除尘器和LPMC型低阻高效防爆袋除尘器在煤粉制备系统除尘中的应用推广情况。     

江苏省不锈钢产业集聚区土壤重金属污染评价与分析

随着不锈钢产业的发展,其生产加工过程中产生的含重金属的废水、废气及固体废弃物对周围土壤及地表水环境的影响也日益显现。选择江苏省不锈钢产业集聚区内溱东镇土壤为研究对象,对区域内63个采样点进行分析,发现区域内土壤中Cr、Zn、Cd、Pb质量分数平均值均未超过国家土壤环境质量标准的二级标准要求,重金属污染程度由大到小的顺序为:CdNiCrMnZnPb,并且通过SPSS13.0统计软件对分析数据进行相关性分析,数据表明,土壤中重金属Cr、Fe、Cd、Ni、Mn来自不锈钢产业的可能性较大。     

超声波-铁粉协同降解五氯酚

通过超声波-铁粉联合体系协同降解废水中的五氯酚(PCP).实验结果表明:降解120 min后,PCP去除率可达90.4％；在该体系中铁粉被逐渐腐蚀成Fe2+,随降解时间的延长,Fe2+浓度逐渐增加；体系中的Fe2+可以促进·OH的产生,并且可以与超声空化作用下产生的H2O2发生Fenton试剂氧化反应降解PCP；超声波...     

Treatment of coking wastewater by an advanced Fenton oxidation process using iron powder and hydrogen peroxide

In this study the treatment of coking wastewater was investigated by an advanced Fenton oxidation process using iron powder and hydrogen peroxide. Particular attention was paid to the effect of initial pH, dosage of H₂O₂ and to improvement in biodegradation. The results showed that higher COD and total phenol removal rates were achieved with a decrease in initial pH and an increase in H₂O₂ dosage. At an initial pH of less than 6.5 and H₂O₂ concentration of 0.3 M, COD removal reached 44-50% and approximately 95% of total phenol removal was achieved at a reaction time of 1 h. The oxygen uptake rate of the effluent measured at a reaction time of 1 h increased by approximately 65% compared to that of the raw coking wastewater. This indicated that biodegradation of the coking wastewater was significantly improved. Several organic compounds, including bifuran, quinoline, resorcinol and benzofuranol were removed completely as determined by GC-MS analysis. The advanced Fenton oxidation process is an effective pretreatment method for the removal of organic pollutants from coking wastewater. This process increases biodegradation, and may be combined with a classical biological process to achieve effluent of high quality.     

Mitigation of hydrogen fluoride aerosols by dry powders

Fluid bed tests were used to determine overall reaction rates for eight different dry powders of low hazard and toxicity before and after reaction with HF. In flow chamber tests, a representative oxide, hydroxide and carbonate were used to measure the efficiency of mitigation of an HF aerosol cloud. The results show that dry powders provide a valid alternative to water spray mitigation. Powder efficiencies are higher than water efficiencies at constant weight ratio.

At present, no attempt has been made to provide any technical designs or layouts for powder mitigation systems. However, the technology for smaller systems is available through manufacturers of dry powder chemical fire extinguisher equipment. When these powders are kept dry and under nitrogen atmosphere, a shelf life of several years can be expected.     

Synthesis of hydrogarnet from molten slag and its hydrogen chloride fixation performance at high temperature

Hydrogarnet was synthesized hydrothermally below 200°C using molten slag obtained from municipal solid waste. For comparison, it was also synthesized using pure-phase CaO–Al₂O₃–SiO₂–H₂O, as reported previously. The structural and textural properties of this material were investigated using various analytical and spectroscopic techniques such as X-ray diffraction, X-ray fluorescence spectrometry, atomic absorption spectrometry (AAS), thermogravimetry/differential thermal analysis, Fourier transform infrared spectroscopy, and scanning electron microscopy. The Cl⁻ fixation ability of hydrogarnet was investigated in the temperature range 500–800°C in a fixed-bed flow reactor using a HCl concentration (1000 p.p.m.v.) similar to that of incinerator exhaust gas. Under these experimental conditions, the hydrogarnet was capable of reducing the HCl gas level to less than 1 p.p.m.v. Analysis of the spent catalyst revealed that the hydrogarnet was being transformed into wadalite and CaCl₂ at high temperatures. The elution test for chromium ions in hydrogarnet obtained from slag was also used, and it was found that chromium ions were not eluted from hydrogarnet. Received: January 27, 2001 / Accepted: October 11, 2001     

天然黏土材料附着纳米TiO2对 电解锰渣中锰的吸附固定

采用机械球磨法对膨润土、硅藻土、高岭土3种天然黏土材料进行预处理,通过超声法将纳米TiO_2附着于其上制得复合材料,考察了不同复合材料加入量及养护时间条件下复合材料对电解锰渣中Mn的吸附固定效果。3种天然黏土材料中,硅藻土的平均粒径最小,比表面积和总孔隙度最大,对水中Mn的吸附量也最大。黏土材料附着纳米TiO_2后对电解锰渣中Mn的吸附固定效果较单纯黏土材料有明显改善。在养护时间为12 d、硅藻土附着纳米Ti O_2复合材料加入量为10%(w)的最佳条件下,Mn的TCLP浸出量较原电解锰渣下降了83.04%。     

粉料无尘装车机工作原理及其在冶金厂矿的应用

介绍集装车与防尘统一于一体的无尘装车技术及具有设备本质安全化特点的无尘装车机在解决粉状物料装车作业时的扬尘问题,保护作业工人健康,维护厂区环境方面的重要优越性。     

利用粉煤灰处理含碱污水的试验研究

为了探讨火电厂除灰水中的粉煤灰（含炉渣）对炼油厂含碱污水中石油类、ＣＯＤ(ｃｒ)等污染物的吸附处理效果,根据某单位现场情况,将炼油厂含碱污水送入火电厂除灰沟→经充分混合排入储灰场→并经长时间沉降分离的流程进行模拟试验,结果表明：由于粉煤灰的吸附作用,显著降低了炼油厂含碱污水中的石油类、ＣＯＤ(ｃｒ)、挥发酚、碳化匕物等污染物。