纳米SiO2在含阴离子表面活性剂低浊水处理中的应用

在含有阴离子表面活性剂-十二烷基硫酸钠(SDS)的6 NTU高岭土悬浊液中,改变SDS的浓度,投加纳米SiO2与聚合铝PAC进行动态混凝实验与静沉实验,借助图像分析技术与分形理论,探讨了纳米SiO2与PAC处理含SDS低浊水的作用机理、絮凝效果与形态学特征.结果表明:①纳米SiO2与SDS使高岭土粒子表面负电性增强.纳米SiO2的絮凝机理以吸附架桥为主.②纳米SiO2对SDS的去除效果优于PAC.SDS浓度越高,去除效果越显著.但纳米SiO2对无机高岭土粒子的处理能力不如PAC,PAC絮凝后的上清液浊度低.当SDS浓度增至10 mg/L时,纳米SiO2对SDS的去除率高,而PAC对SDS的絮凝能力弱,PAC对无机颗粒的去除效果也下降.③助凝剂纳米SiO2较强的吸附活性能加快PAC絮体成长为结构密实的RLCA构型,分维值高,絮凝效果好.     

锌离子印迹聚合物的合成及固相萃取特性研究

为了达到对溶液中目标痕量金属离子的分离和分析,采用了硅胶表面金属离子印迹聚合技术,活化硅胶表面羟基后,在硅烷偶联剂(APS)存在条件下合成了Zn(Ⅱ)离子印迹聚合硅胶。对其进行表征和吸附、再生等性能及合成机理研究,并将所得Zn(Ⅱ)离子印迹聚合物填充于市售空白小柱制成Zn(Ⅱ)离子印迹聚合物固相萃取小柱,并对其固相萃取性能进行了初步研究表征结果表明,Zn(Ⅱ)成功印迹于活化硅胶表面。与非离子印迹硅胶相比,Zn(Ⅱ)离子印迹聚合硅胶具有更高的选择性,其最大静态吸附容量可达12.87 mg/g,并可反复利用10次以上保持吸附率不低于95%。所得Zn(Ⅱ)离子印迹聚合物固相萃取小柱在不同初始条件下对Hg的相对选择因子可达15.5和13.8。Zn(Ⅱ)离子印迹聚合硅胶是一种新型高效低成本的聚合物,可将其用于水溶液中Zn(Ⅱ)的分离和分析。     

硅铝比和NiO对ZSM-5协同低温等离子体降解甲苯的影响

研究了不同硅铝比的ZSM-5与Ni/ZSM-5分子筛协同低温等离子体技术对甲苯降解性能的影响.以Ni O(Nickel Oxide)为活性组分,采用浸渍法对ZSM-5分子筛进行改性,利用氮气吸附脱附(BET)、X射线衍射仪(XRD)、X射线光电子能谱分析(XPS)、H_2程序升温还原(H_2-TPR)、NH_3程序升温脱附(NH_3-TPD)、Toluene程序升温脱附(Toluene-TPD)等技术表征样品的物理化学性质.考察了硅铝比对ZSM-5与Ni/ZSM-5分子筛体系中甲苯的吸附性能,研究了不同放电电压下硅铝比对甲苯降解率、碳平衡及二氧化碳选择性的影响,并采用气相色谱-质谱联用仪(GC-MS)分析了催化剂表面的有机产物.结果表明:硅铝比不但影响分子筛本身的物理化学特性(比表面积、氧化还原性能、表面酸性、疏水性等),还会影响Ni的负载形态和方式,更高的硅铝比与Ni O的负载能促进甲苯深度氧化,减少副产物,提高碳平衡和二氧化碳选择性.     

夏季黄海和渤海微表层和次表层海水中营养盐的分布特征

基于2011年6月黄海和渤海微表层和次表层中营养盐(DIN、PO34--P、SiO23--Si)的调查数据,分析讨论了营养盐的平面分布特征,并选取黄海冷水团断面和长江口断面对营养盐的垂直分布特征进行了分析.结果表明,不论是微表层还是次表层,营养盐的分布都是从近岸向远海递减,在河口地区有明显的高浓度分布;由于夏季长江冲淡水左转北上,营养盐在黄海南部长江口区呈现出水舌状分布特征;受黄海冷水团的影响,北黄海冷水团断面的垂直分布出现表层层化和底层垂直混合均匀的现象;受长江径流输入的影响,长江口断面DIN和SiO23--Si的垂直分布呈现表层浓度大于底层浓度的特征.另外,研究了微表层对NH4+-N、NO2--N、NO3--N、PO34--P、SiO23--Si和DIN的富集情况,结果表明除NO3--N外,微表层对次表层中的其它营养盐都产生了明显的富集作用,平均富集因子介于1.37～2.21之间.     

Simultaneous preconcentration of cadmium and lead in water samples with silica gel and determination by flame atomic absorption spectrometry

A new method that utilizes pretreated silica gel as an adsorbent has been developed for simultaneous preconcentration of trace Cd(Ⅱ) and Pb(Ⅱ) prior to the measurement by flame atomic absorption spectrometry. The effects of pH, the shaking time, the elution condition and the coexisting ions on the separation/preconcentration conditions of analytes were investigated. Under optimized conditions, the static adsorption capacity of Cd(Ⅱ) and Pb(Ⅱ) were 45.5 and 27.1mg/g, the relative standard deviations were 3.2% and 1.7% (for n = 11), and the limits of detection obtained were 4.25 and 0.60 ng/mL, respectively. The method was validated by analyzing the certified reference materials GBW 07304a (stream sediment) and successfully applied to the analysis of various treated wastewater samples with satisfactory results.     

利用磷渣制白炭黑

研究了采用沉淀法由磷渣制白炭黑的工艺条件。在最佳工艺条件下，白炭黑的收率为８３．３％，二氧化硅的质量分数达９４．５％，产品质量符合ＧＢ１０５１７－８９要求。     

Pickering乳化强化地下水三氯乙烯NAPL修复

合成了4种不同长径比的SiO₂颗粒调控水/NAPL界面,考察所形成的Pickering乳化效果和稳定性,结果表明：长径比（L/D）为2.3的SiO₂颗粒分散的Pickering乳液液滴尺寸均匀,直径约10 μm,且10d内保持稳定,乳化指数高达63%.流变测试进一步证实所形成的Pickering乳化具有低剪切应变下乳液稳定的特性,利于地下水的原位修复技术的实施.同时考察胶体颗粒浓度,水中离子强度以及水/NAPL比例对Pickering乳化效果和稳定性的影响,为Pickering乳化技术在实际地下水修复应用提供理论基础.通过对比Pickering乳化和未乳化条件下NAPL溶解和氧化降解动力学过程,发现Pickering乳化通过增大两相间界面积显著提高NAPL的溶解速率,进而实现NAPL相污染物降解速率的提高.     

Vertical and spatial distribution of biogenic silica in the sediment of the gulf of Riga,Baltic Sea

The vertical and spatial concentration trends of biogenic silica (BSi) were investigated in a variety of sediment types from the Gulf of Riga. These trends were compared with the concentration of organic carbon to examine how variations in the mass sedimentation and the dissolution rate of BSi versus bacterially mediated oxidation of organic matter affect the distribution of BSi in different environments. The effects of important physical and biogeochemical factors on the distribution of BSi have also been examined.

The concentration of BSi in the surface sediment at accumulation bottoms ranges between 0.8–1.5 mmol/g with an average concentration of 1.1 mmol/g. This is about two times the concentration that has been reported in similar sediments in the open Baltic proper. Much lower concentrations were measured in erosion and transitional areas; on average around 0.2 and 0.6 mmol/g, respectively.

A comparison between recent sedimentation rate measurements (²¹⁰Pb) and concentrations of BSi within different accumulation bottoms suggests an approximate inverse relationship with each other. The importance of variation in the sedimentation rate on the surface BSi concentration is supported by the fact that higher C_org/BSi ratios are found in periphery accumulation zones close to transition areas (larger supply of carbon rich allochthonous material that dilutes settled amounts of BSi) than at accumulation bottoms in the central part of the Gulf. The C_org/BSi ratio in the sediment is always lower than in living siliceous algae which shows that the microbial degradation of organic carbon is always greater than the inorganic dissolution of BSi, irrespective of the assemblage of silica and non‐silica species.

The general vertical concentration pattern at accumulation sites showed a decreased concentration with increased depth down to 2–6 cm below seafloor where the concentration gradually equalizes. The concentration in the equalizing zone is on average about 20% lower than in the uppermost centimeter. This implies that the main part of the BSi entering the accumulation bottoms is permanently buried and that a great amount of silica already has been released during halmyrolysis. The spatial and vertical BSi trends at sites in transitional and erosional areas reflects prevailing sedimentation conditions with a low concentration in sections with a dominance of sand and gravel (no deposition of fine material) and a higher concentration in the sections containing stiff glacial clay (former accumulation area).

The average annual burial amount of BSi in the Gulf has been estimated to be around 50 000 tons of which most is buried in accumulation bottoms outside the central muddy part of the Gulf. The buried amount is about 60% of the annual river load of silica.     

氯氧化锆生产排放废硅渣中锆资源的回收

开展了氯氧化锆生产排放废硅渣中锆资源的回收工艺研究,结果表明,当废硅渣在50℃条件下溶解废碱液时,硅渣中夹带的未熔锆英砂可以沉积,回收率可达到98.5%以上。继续加热溶硅碱液,可溶锆可与硅产生凝聚,形成锆富集物沉淀,锆富集物中湿基的ZrO2含量最高可达6.5%,可溶锆的回收率在97%以上。回收得到的未熔砂和锆富集物可直接返回氯氧化锆主流程中再利用,从而实现硅渣中锆的资源化利用。     

石材加工行业尘肺病危害风险评估研究

应用国际采矿与金属委员会风险评估模型（ICMM）评估石材加工行业尘肺病风险。 以20家石材加工企业为研究对象,运用ICMM模型的定量法和矩阵法分别评估4个重点岗位的尘肺病风险,并与粉尘作业分级和文献报道进行结果验证。 结果显示打磨、雕刻、切割和破碎4个重点岗位的总粉尘和呼吸性粉尘浓度均超过职业接触限值,超限倍数范围分别为4.3~85倍和3.1~63.3倍。ICMM定量法判定该4个重点岗位的Ⅲ期矽肺风险均为最高级风险水平（不可容忍）,矩阵法判定该4个重点岗位Ⅲ期矽肺风险也均为最高级水平（高风险）。这些风险评估结果得到生产性粉尘作业分级和文献报道的支持。结论为石材加工行业尘肺病发病风险非常高,ICMM风险评估模型可应用于石材加工行业职业健康风险评估。