金山湖底泥重金属稳定化处理效果及机制研究

采用氧化钙和过氧化钙及二者混合物对底泥中的重金属进行稳定化试验,研究了稳定化后底泥中重金属迁移情况,并对底泥重金属稳定化技术的机制进行初步探讨.酸雨淋溶试验结果表明,底泥经CaO、CaO CaO2、CaO2稳定化后, pH=2.9时, Zn迁移到第3层,其首层迁移量分别为96、97和93mg/kg,而空白试验中Zn迁移至第6层,首层迁移量为128mg/kg; pH:5.0时, Zn迁移到第3层,其首层迁移量分别为87、90和89mg/kg,而空白试验中Zn迁移至第5层,首层迁移量为112mg/kg,这说明稳定化底泥中Zn的迁移速度和首层迁移量均有降低,3种稳定化药剂能够降低其在土壤中的迁移能力;淋溶液pH值对Zn的迁移能力有影响, pH较高能够减缓Zn在土壤中的迁移速度,降低其首层迁移量; Ni和Cd的酸雨淋溶试验也可得出同样结论.重金属稳定化机制试验结果表明,经上述3种药剂稳定化处理后,底泥pH值由6.76分别上升到8.33、8.15和8.21, TOC含量分别降低5%、10.9%和13.1%; Zn、Ni和Cd的稳定态含量分别增加10.6%、1.7%和4.5%,这是导致重金属迁移能力下降的主要原因;由此可见,3种药剂对同一金属的稳定化作用无明显差异;从不稳定态向稳定态转化的比例来看,稳定化药剂对不稳定态金属的稳定能力次序为: Zn>Cd>Ni.     

含砷飞灰固化处理研究

通过试验确定了胶凝材料的组成体系,探讨了影响胶凝材料性能的主要工艺参数,确立的最佳固化工艺条件为:水泥∶砂子∶飞灰= 57.6∶40∶2.4,水灰比为0.28,水泥采用标号为42.5的快硬硫铝酸盐特种水泥,以硫化钠作为添加剂,其用量为飞灰/硫化钠= 1.5.在最佳配比和最佳养护条件下,固化体在实验室条件下抗压强度可达2.5 MPa,砷的浸出浓度为0.83 mg/L,达到了相关的填埋标准.     

新标准下垃圾焚烧飞灰化学稳定技术的比选和研究

研究了新的生活垃圾填埋场污染控制标准(GB168892008)实施后,飞灰要进入生活垃圾卫生填埋场时传统的重金属稳定方法可行性,并在此基础上提出了新的复合药剂稳定法.研究结果表明,已经报道的化学药剂稳定法均有必要重新检验其对重金属的稳定效果是否满足新的填埋标准的要求.绿矾与TMT-18配合使用、绿矾用量为25%（质量分数）以下、TMT-18的用量为8‰左右时完全可以使飞灰中所有重金属浸出浓度满足新的填埋标准要求,是处理二噁英含量不高于3 ng·g-1(以TEQ计)飞灰的一种经济处理技术.对二噁英含量高于3 ng·g-1 (TEQ)的飞灰,采用绿矾辅助水热处理的方法可以稳定包括Pb、Cd在内的所有重金属和降解二噁英使之符合新填埋标准对飞灰填埋的要求.     

不同修复材料对铅锌尾砂中DTPA浸提态Pb、Zn、Cu、Cd含量的影响

采矿业产生的大量尾砂作为典型的污染源,其含有的重金属等有害成分在雨水浸淋下会直接或间接对周边环境造成污染。为研究尾砂中重金属的污染修复技术,以湖南郴州某废弃矿区的尾砂为研究对象,通过添加质量分数为2.0%的生石灰、还原铁粉、过磷酸钙等廉价修复材料,对尾砂中DTPA浸提态Pb、Zn、Cu、Cd的含量变化进行研究,并就其含量变化所体现的时间效应及机理进行探讨。研究发现,还原铁粉对尾砂的修复作用最好,其次是过磷酸钙。还原铁粉使得尾砂中DTPA浸提态Pb、Zn、Cu、Cd的含量分别降低了59.91%,56.53%,75.81%,35.78%;过磷酸钙使得尾砂DTPA浸提态Pb、Zn、Cu、Cd的含量分别降低了48.85%,44.27%,44.27%,39.23%,可为尾砂中重金属稳定化工程实施提供参考。     

富营养化水体内源磷释放和稳定化研究进展

水体富营养化是当今世界面临的一个严峻的环境问题,很多研究表明:水体沉积物中磷的释放是引起富营养化的主要因素,因此国内外很多学者对水体沉积物中磷形态,磷释放的影响因素和控制技术进行了研究。研究发现:pH、温度、溶解氧、氧化还原电位和扰动等环境因子对沉积物中磷的释放均有影响,但其影响程度不同。国外关于水体沉积物中磷的控制技术的研究比较多,其中包括供氧技术、原位控制技术和覆盖技术等,还有近几年发现的水生植物控制技术,但国内对沉积物污染控制技术的研究还停留在实验探索阶段,应用的很少。     

水解池-稳定塘工艺对难降解有机污染物的去除

色谱－质谱联机测定结果表明,水解池能将大分子难降解有机物转化为小分子物质,从而加速了污水在后续稳定塘中的降解。这使得新工艺比对照的传统初沉池－稳定塘工艺减少停留５０％,占地面积５０％以上。本文还研究了三氯甲烷,二氯乙烯,二氯乙烷和四氯乙烷和四氯化碳在新工艺中的去除情况,实验表明,水解池中存在还原脱卤过程,而挥发是稳定塘去除卤代烃的主要途径。     

Stabilization effects of surplus soft clay with cement and GBF slag

Utilization of industrial waste and surplus construction soft clay as construction material was recommended, and many attempts at geotechnical waste utilization were undertaken. This study aimed at the application of cement and a kind of industrial wastes, i.e. granulated blast furnace slag, on stabilization of surplus soft clay. The results showed that the cement and slag can successfully stabilize Ariake clays even though this high organic clay fails to be stabilized by lime and cement. Addition of slag in cement for stabilization induces higher strength than cement alone for longer curing time. The application of the cement with slag is more suitable than cement alone for stabilization because of economical consideration.     

上海城市污水厂污泥处理与利用系统分析

上海市城市污水处理规划的实施，将在2020年前使该市的城市污水厂污泥产生量从现状的85tDS/d增长至1300－1500tDS/d，将形成可观的污泥消纳压力。预期了该市的污水污泥产生状况，以现有污水污泥处置与利用技术为基础，测算了可行的污泥处置与利用方向及相应的容量，以及满足容量利用的前处理要求。以此为基础，推荐了适宜的容量利用方案，并建议以生物稳定化干化处理为污泥处置与利用前的改性处理步骤，且可在适当的条件下增加厌氧消化环节，提高处理体系的水平与容量宽余度。此污泥处理与利用体系可达到污泥消纳运行的柔性化和可靠性，兼具环境安全性与经济合理性。     

An integrated method for the rapid dewatering and solidification/stabilization of dredged contaminated sediment with a high water content

• An integrated method, called PHDVPSS, was proposed for treating DCS. • The PHDVPSS method showed superior performance compared to conventional method. • Using the method, water content (%) of DCS decreased from 300 to<150 in 3 days. • The 56-day UCS from this method is 12‒17 times higher than conventional method. • Relative to PC, GGBS-MgO binder yielded greater reduction in the leachability. To more efficiently treat the dredged contaminated sediment (DCS) with a high water content, this study proposes an integrated method (called PHDVPSS) that uses the solidifying/stabilizing (S/S) agents and prefabricated horizontal drain (PHD) assisted by vacuum pressure (VP). Using this method, dewatering and solidification/stabilization can be carried out simultaneously such that the treatment time can be significantly shortened and the treatment efficacy can be significantly improved. A series of model tests was conducted to investigate the effectiveness of the proposed method. Experimental results indicated that the proposed PHDVPSS method showed superior performance compared to the conventional S/S method that uses Portland cement (PC) directly without prior dewatering. The 56-day unconfined compressive strength of DCS treated by the proposed method with GGBS-MgO as the binder is 12‒17 times higher than that by the conventional S/S method. DCS treated by the PHDVPSS method exhibited continuous decrease in leaching concentration of Zn with increasing curing age. The reduction of Zn leachability is more obvious when using GGBS-MgO as the binder than when using PC, because GGBS-MgO increased the residual fraction and decreased the acid soluble fraction of Zn. The microstructure analysis reveals the formation of hydrotalcite in GGBS-MgO binder, which resulted in higher mechanical strength and higher Zn stabilization efficiency.     

Effects of sepiolite on stabilization remediation of heavy metal-contaminated soil and its ecological evaluation

Stabilization in the remediation of heavy metal contaminated soils has been gaining prominence because of its cost-effectiveness and rapid implementation. In this study, microbial properties such as microbial community and enzyme activities, chemical properties such as soil pH and metal fraction, and heavy metal accumulation in spinach (Spinacia oleracea) were considered in assessing stabilization remediation effectiveness using sepiolite. Results showed that soil pH values increased with rising sepiolite concentration. Sequential extraction results indicated that the addition of sepiolite converted significant amounts of exchangeable fraction of Cd and Pb into residual form. Treatments of sepiolite were observed to reduce Cd and Pb translocation from the soil to the roots and shoots of spinach. Concentrations of Cd and Pb exhibited 12.6%–51.0% and 11.5%–46.0% reduction for the roots, respectively, and 0.9%–46.2% and 43.0%–65.8% reduction for the shoots, respectively, compared with the control group. Increase in fungi and actinomycete counts, as well as in catalase activities, indicated that soil metabolic recovery occurred after sepiolite treatments.