浅析XLDM型脉冲袋式除尘器在CFB锅炉上的应用

介绍了兖矿国宏化工公司2台160 t/h CFB锅炉配套XLDM-5700型袋式除尘器的实际运行情况,从除尘效率、喷吹方式、运行能耗等方面分析了袋式除尘器的性能,并总结出XLDM型袋式除尘器最佳运行方式。     

“电改袋”技术在130t／h煤粉炉烟气除尘系统改造中的应用

介绍了“电改袋”除尘系统的工艺特征，分析了130t／h煤粉炉烟气除尘器系统改造为长袋低压脉冲袋式除尘器的技术方案。改造后，除尘器已经稳定运行1年多，各项技术指标均达到设计要求，环境效益与经济效益显著。     

铁炭微电解工艺处理采油废水的研究

随着采油废水产生量的逐渐增大以及排放标准的日益严格,寻找一种经济、高效的处理方法显得十分必要。采用铁炭微电解技术对冀东油田采油废水进行了处理。考察了铁屑粒径、pH值、Fe/C质量比和反应时间对COD去除率的影响并设计了正交实验,结果表明,影响微电解工艺的因素主次关系为:pH>Fe/C质量比>反应时间,在最佳条件pH=5,Fe/C质量比为7∶1,反应时间50 min下,原水COD由170 mg/L降至95.6 mg/L,去除率达43.85%,出水满足国家二级排放标准。     

Simultaneous determination of three herbicides by differential pulse voltammetry and chemometrics

A novel differential pulse voltammetry method (DPV) was researched and developed for the simultaneous determination of Pendimethalin, Dinoseb and sodium 5-nitroguaiacolate (5NG) with the aid of chemometrics. The voltammograms of these three compounds overlapped significantly, and to facilitate the simultaneous determination of the three analytes, chemometrics methods were applied. These included classical least squares (CLS), principal component regression (PCR), partial least squares (PLS) and radial basis function-artificial neural networks (RBF-ANN). A separately prepared verification data set was used to confirm the calibrations, which were built from the original and first derivative data matrices of the voltammograms. On the basis relative prediction errors and recoveries of the analytes, the RBF-ANN and the DPLS (D – first derivative spectra) models performed best and are particularly recommended for application. The DPLS calibration model was applied satisfactorily for the prediction of the three analytes from market vegetables and lake water samples.     

电解法处理含镍废水及纯镍的回收

采用电解回收法处理Ni2+含量为2g/L的废水,在阴极回收纯镍。研究了电解电流、极距、NH4Cl浓度、pH值等因素对Ni2+去除率、槽压、阴极能耗的影响,得出最优工艺参数为:温度20℃,电解时间20min时、电解电流300mA,极距15mm,NH4Cl浓度5g/L,pH值8.0,该条件下Ni2+去除率为96.926%,槽压16.21V,阴极能耗22.418kW.h/kg,在阴极可得到沉积6.45μm厚的镍板。     

电解法处理高含硫气田水

本文详细介绍了川南矿区含硫气田水电解法处理的试验情况，用自己研制的电解反应器对电解时间、pH值、电流密度等工艺条件进行了考察，提出了电解法处理含S~(2-)200mg／L的气田水的最佳工艺条件。试验结果表明：该方法是成功的，它可以使气田水中硫化物的脱除率达99％以上，达到国家排放标准（GB8978—88：S~(2-)＜5mg／L）。该方法的主要特点是投加处理药剂少，操作简便，设备小型，占地面积小，特别适用于产水量不大的井站使用。     

近断层强震速度脉冲效应及连续梁桥减隔震特性分析

应用非线性时程分析的方法 ,对于减、隔震连续桥梁在近场地震作用下的有效性和响应特性 ,作了深入的研究。通过有代表性的脉冲型近场强震记录时程分析 ,提出了用速度脉冲峰值及其周期之积来表示速度脉冲能量的方法 ,计算表明近场地震速度脉冲波能近似表征地震动破坏能力的大小 ,它和桥梁结构承受的地震响应大体成正比例关系。铅芯橡胶隔震支座在近场地震作用下仍然适用 ,但对于个别脉冲型强震记录效果不够明显 ,支座参数有必要进行优化。     

Electrochemical Monitoring of Methylparathion Degradation in an Acid Aqueous Medium in Presence of Cu(II)

Abstract

A study was undertaken to determine the effect of Cu(II) in degradation of methylparathion (o,o-dimethyl o, 4-nitrophenyl phosphoriotioate) in acid medium. Initial electrochemical characterization of Cu(II) and methylparathion was done in an aqueous medium at a pH range of 2–7. Cu(II) was studied in the presence of different anions and it was observed that its electroactivity depends on pH and is independent of the anion used. Methylparathion had two reduction signals at pH ≤ 6 and only one at pH > 6. The pesticide's transformation kinetic was then studied in the presence of Cu(II) in acid buffered aqueous medium at pH values of 2, 4, and 7. Paranitrophenol appeared as the only electroactive product at all three pH values. The reaction was first order and had k values of 5.2 × 10^?3 s^?1 at pH 2, 5.5 × 10^?3 s^?1 at pH 4 and 9.0 × 10^?3 s^?1 at pH 7. It is concluded that the principal degradation pathway of methylparathion in acid medium is a Cu(II) catalyzed hydrolysis reaction.     

陶瓷膜污染过程分析与膜清洗方法优化

采用膜孔径为50 nm的陶瓷膜错流过滤方式,对碱性高浓度有机洗涤废水进行9个周期的膜通量衰减及反向脉冲清洗再生实验研究.通过设计膜污染阻力构成实验,测算膜污染总阻力及其构成比例.实验结果表明,膜固有阻力比例较低,浓差极化污染较弱,Rt和Rc+Rirt污染阻力稳定性较高,膜堵塞形式兼有孔内堵塞和滤饼过滤；选择质量分数0.1％的稀盐酸和0.2％的草酸溶液膜清洗效果均较好,清洗时间为3 min,脉冲时间和频率为3 s/5 s.     

燃煤锅炉机组电改袋工程成功案例分析

以宝钢电厂3#机组电改全袋工程为例，论述了该成功工程的特点，介绍了袋式除尘器及滤料的比选过程、结构型式和设计参数，总结了除尘系统所具有的技术特色和投运后所取得的效果，该案例对袋式除尘器在电站锅炉的推广应用具有参考意义。