SGA对垃圾焚烧飞灰中重金属的固化性能研究

根据EPA1311、HJ／T299—2007、HJ／T300—2007和HJ557—2009等国内外不同标准，研究了深圳某垃圾焚烧发电厂垃圾焚烧飞灰的浸出毒性，探讨了六硫代胍基甲酸（sixthioguanidineacid，SGA）、二甲基二硫代氨基甲酸盐（sodiumdimethyldithiocarbamate，SDD）和Ca（OH）2浓度对垃圾焚烧飞灰中重金属的固定性能的影响。研究结果表明，随着浸提液pH的降低，该厂焚烧飞灰中大部分金属元素的浸出量增大，焚烧飞灰浸出液中的cd、Ni、Ph和zn浓度分别超过国家危险废物鉴别标准（GB5085．3—2007）规定值的4．75倍、1．47倍、6．72倍和2．20倍，属于危险废弃物，必须进行稳定化处理。当固化剂SGA加入量为0．1mol／kg时，稳定化后的重金属浸出浓度已经低于危险废物鉴别标准，且对Cd、Cr、Cu和Pb的固化性能优于SDD和Ca（OH）2；当固化剂SGA、SDD和Ca（OH）2加入量为0．5mol／kg时，稳定化后的焚烧飞灰重金属浸出浓度均低于国家危险废物鉴别标准（GB5085．3-2007）中的规定值。与SDD和Ca（OH）：相比，SGA对垃圾焚烧飞灰中重金属的固化处理更具有优势。     

Oxygen demand for the stabilization of the organic fraction of municipal solid waste in passively aerated bioreactors

Conventional aerobic waste treatment technologies require the use of aeration devices that actively transport air through the stabilized waste mass, which greatly increases operating costs. In addition, improperly operated active aeration systems, may have the adverse effect of cooling the stabilized biomass. Because active aeration can be a limiting factor for the stabilization process, passive aeration can be equally effective and less expensive. Unfortunately, there are few reports documenting the use of passive aeration systems in municipal waste stabilization. There have been doubts raised as to whether a passive aeration system provides enough oxygen to the organic matter mineralization processes. In this paper, the effectiveness of aeration during aerobic stabilization of four different organic fractions of municipal waste in a reactor with an integrated passive ventilation system and leachate recirculation was analyzed. For the study, four fractions separated by a rotary screen were chosen. Despite the high temperatures in the reactor, the air flow rate was below 0.016 m³/h. Using Darcy’s equation, theoretical values of the air flow rate were estimated, depending on the intensity of microbial metabolism and the amount of oxygen required for the oxidation of organic compounds. Calculations showed that the volume of supplied air exceeded the microorganisms demand for oxidation and endogenous activity by 1.7–2.88-fold.     

有机负荷条件对间歇式气提内循环反应器中好氧颗粒污泥形成的影响

在R1、R2和R3共3组气提式内循环序批式反应器中启动好氧颗粒污泥工艺,探讨在无选择压作用下有机负荷对好氧颗粒污泥的形成及稳定性的影响.其中,R1、R2分别以7 kg.(m3.d)-1和3 kg.(m3.d)-1的目标COD负荷直接启动,R3以1.5kg.(m3.d)-1逐步增加至3 kg.(m3.d)-1的递增COD负荷方式启动.结果表明,3组反应器在启动期中均能快速形成好氧颗粒污泥,但以目标负荷启动方式易使好氧颗粒污泥反应器产生丝状菌污泥膨胀.通过对颗粒形成过程、粒径、性质以及胞外多聚物等指标分析,认为递增负荷的启动方式可有效抑制启动初期丝状菌污泥膨胀,且形成的颗粒更为稳定,生物降解效率更高.     

剩余污泥中木质纤维素稳定并转化能源可行性分析

剩余污泥中往往含有大量木质纤维素物质,在厌氧消化过程中难以降解,最终被浓缩于熟污泥中,这就是导致污泥有机物稳定并转化能源效率低下的主要原因之一.本文分析了剩余污泥中木质纤维素的含量与来源;阐述了木质纤维素的结构特点以及对其生物降解的关键技术所在;揭示了污泥常规预处理与木质纤维素预处理存在工艺条件不同的相似技术.文章结合两种预处理技术的特点和工艺条件,从原理、技术等角度分析了通过强化剩余污泥预处理而同时达到破解木质纤维素的技术思路.为此,提出了将污泥细胞破碎与木质纤维素破解耦合的观点,以期将污泥中木质纤维素的稳定与能源转化合二为一,从而构建木质纤维素稳定化、能源化与碳减排三位一体的技术策略     

以膨润土为辅助添加剂固化/稳定化污泥的试验研究

针对传统以水泥固化污泥,带来的水泥用量大与固化体的浸出液pH过高等问题,提出了以膨润土为添加剂辅助水泥固化/稳定化污泥的思路.通过开展无侧限抗压强度试验、毒性浸出试验,测量掺入膨润土后污泥固化体的强度、重金属浸出率、浸出液COD及pH值,研究该固化/稳定化方法的效果.结果表明,膨润土的掺入极大地提高了固化体的抗压强度,将掺入量为0.4(相对污泥的质量比)的水泥一半用膨润土替代时,固化体的强度提高了6左右.体积安定性也能够满足要求.随膨润土掺入量增加,固化体中锌、铅的浸出率与浸出液的pH值呈现不断减小的趋势,锌与铅的浸出率分别由6.9%下降至0.25%,9.6%下降至5%,pH值由12.3下降至12.1.在强碱条件下及烘干或风干条件下,铜会随着有机物的分解而析出,从而增加铜的浸出率,而膨润土的加入能弥补水泥造成的强碱环境及风干或烘干过程对固化污泥中铜的稳定产生的不利影响.     

采用巯基捕收剂稳定化处理垃圾焚烧飞灰中的重金属

研究了3种巯基捕收剂,二乙基二硫代氨基甲酸钠（乙硫氮）、乙基黄原酸钾（乙基黄药）和二丁基二硫代磷酰铵（丁铵黑药）,对垃圾焚烧飞灰中重金属的稳定化效果。3种巯基捕收剂的用量均为62.5μmol?g-1飞灰。扫描电镜观察发现,飞灰经稳定化处理后,巯基捕收剂均匀地覆盖于飞灰晶体表面,使矿物晶体棱角变得模糊。利用酸浸提程序（TCLP法）和水浸提程序（水平振荡法）评价飞灰中重金属Cu、Pb、Cd、Cr和Zn的浸出毒性。在0.1mol?L-1醋酸浸提条件下,与Na2S相比,巯基捕收剂对Cu和Pb的稳定化效果较好,其中乙硫氮对Cu的稳定化比率接近100%,丁铵黑药对Pb的稳定化比率达到69.2%;在水浸提条件下,乙硫氮、乙基黄药和丁铵黑药对5种重金属的稳定化比率分别为72.6%、73.5%和76.8%,显著高于Na2S处理（52.4%）。三种巯基捕收剂对5种重金属亲和力的强弱顺序大致为Cu＞Pb＞Cr＞Cd＞Zn,并且超过60%的巯基捕收剂与酸可浸提重金属离子发生了螯合沉淀反应。重金属-巯基捕收剂絮凝物在中性和碱性条件下（pH>6）比较稳定,在酸性条件下（pH<6）可发生部分溶解。为获得较好的重金属稳定化效果,维持稳定化飞灰的高酸缓冲容量十分重要。     

Topsoil organic carbon mineralization and CO2 evolution of three paddy soils from South China and the temperature dependence

Carbon mineralization and its response to climatic warming have been receiving global attention for the last decade. Although the virtual influence of temperature effect is still in great debate, little is known on the mineralization of organic carbon （SOC） of paddy soils of China under warming. SOC mineralization of three major types of China＇s paddy soils is studied through laboratory incubation for 114 d under soil moisture regime of 70% water holding capacity at 20℃ and 25℃ respectively. The carbon that mineralized as CO2 evolved was measured every day in the first 32 d and every two days in the following days. Carbon mineralized during the 114 d incubation ranged from 3.51 to 9.22 mg CO2-C/gC at 20℃ and from 4.24 to 11.35 mg CO2-C/gC at 25℃ respectively; and a mineralizable C pool in the range of 0.24 to 0.59 gC/kg, varying with different soils. The whole course of C mineralization in the 114 d incubation could be divided into three stages of varying rates, representing the three subpools of the total mineralizable C： very actively mineralized C at 1-23 d, actively tnineralized C at 24--74 d and a slowly mineralized pool with low and more or less stabilized C mineralization rate at 75-114 d. The calculated Q10 values ranged from 1.0 to 2.4, varying with the soil types and N status. Neither the total SOC pool nor the labile C pool could account for the total mineralization potential of the soils studied, despite a well correlation of labile C with the shortly and actively mineralized C, which were shown in sensitive response to soil warming. However, the portion of microbial C pool and the soil C/N ratio controlled the C mineralization and the temperature dependence. Therefore, C sequestration may not result in an increase of C mineralization proportionally. The relative control of C bioavailability and microbial metabolic activity on C mineralization with respect to stabilization of sequestered C in the paddy soils of China is to be further studied.     

猪粪秸秆高温堆肥过程中碳氮转化特征与堆肥周期探讨

将猪粪与秸秆以7：1（质量比,以鲜重计）的比例,在自制的强制通风静态堆肥反应箱中进行高温堆肥试验,研究了堆肥过程中碳氮转化特征及其腐熟时间.同时,在堆制的23d中,根据堆温变化采样6次,分析了堆肥样品中各种氮素和碳素含量及其它性质的变化情况.结果表明：堆肥结束时,硝态氮含量增加了103.0%,铵态氮、有机氮、总氮含量分...     

石灰干化污泥稳定后土壤中Pb、Cd和Zn浸出行为的研究

以人工制备Zn、Pb、Cd污染土壤为研究对象,采用城市污水处理石灰干化污泥作为稳定剂,对污染土壤进行稳定化处理,并采用TCLP、SPLP、去离子水浸提和优化的BCR连续提取法对稳定化效果进行分析和评价.结果表明,单独使用石灰干化污泥,TCLP浸出浓度随着干化污泥质量分数的增加而显著减少,干化污泥的质量分数为40%时,稳定化率最大为Zn-99.54%、Pb-99.60%、Cd-99.85%.SPLP和去离子水浸出评价稳定效果时,Pb和Zn在加入质量分数10%和20%的干化污泥时浸出明显降低,但在加入30%和40%时由于在强碱条件Pb和Zn会再溶出,导致稳定效果变差.为了恢复植物生长功能,经过FeSO4和H3PO4调节pH后,石灰干化污泥稳定过的土壤pH有效降低,同时FeSO4和H3PO4有利于促进Pb和Zn的稳定效果.经稳定化后,土壤中的重金属可交换态降低,限制了土壤重金属的迁移.该研究结果表明石灰干化污泥可以再利用,应用于重金属污染土壤的稳定化修复中,并能改善稳定后土壤适宜植物生长的理化性质.     

不同含磷物质对重金属污染土壤-水稻系统中重金属迁移的影响

通过水稻盆栽试验研究磷酸氢二钠(DSP)和羟基磷灰石(HAP)对污染土壤中重金属(Pb、Cd、Zn)向水稻迁移的影响.结果表明,①DSP和HAP都显著提高了土壤pH值和有效磷含量(p0.05),降低了土壤中Pb、Cd、Zn交换态含量,且HAP降低重金属交换态的效果较DSP好.水稻地上部分重金属含量与土壤中重金属交换态含量呈明显正相关关系,说明DSP和HAP通过降低土壤中重金属交换态含量从而达到减少重金属向水稻中迁移的目的.②DSP和HAP明显降低了水稻各器官Pb、Cd的含量,同时使水稻根、壳、糙米中Zn含量降低,但增加了茎叶中Zn的含量.与对照相比,DSP和HAP分别使糙米中Pb、Cd、Zn最大降低了48.72%、22.22%、25.35%和62.82%、66.67%、39.88%,但是糙米中Pb、Cd含量仍未达到食品卫生标准限值(GB2762—2012).③DSP和HAP处理都使水稻根干重逐渐减少,使茎叶、壳、糙米干重先增加后降低,在0.12 g·kg-1时使水稻糙米产量最大.综上,DSP和HAP都能有效控制土壤中Pb、Cd、Zn向水稻中迁移,且HAP效果比DSP好,但磷添加量不宜过高.