Application of Defined Co-Immobilized Microbial Consortium as a Ready-to-Use Seed Inoculum in Bod Analysis

A number of microorganisms were isolated from sewage. Biochemical Oxygen Demand (BOD-5 day) analysis was carried out by individual pure cultures. The cultures giving higher or equal BOD values as compared to reference GGA solution were selected for the formulation of a defined mixed microbial consortium. This microbial consortium was co-immobilized on calcium-alginate beads. Four synthetic and six industrial samples were tested for BOD by using immobilized beads as well as sewage as source of seeding materials. BOD values obtained with beads for all the synthetic as well as industrial samples were fairly comparable with those obtained with sewage. Reusability of prepared microbial beads was also checked with different synthetic and industrial samples and was compared with reference GGA solution. The same microbial beads can be reused three times for different BOD-5 day estimations. It is recommended that immobilized microbial beads can be used as a ready-to-use seeding material for BOD analysis.     

石油污染土壤的生物修复室内模拟实验研究

在实验室模拟的条件下,利用从克拉玛依的石油污染土壤中筛选出的4株高效降解菌,以石油烃降解率、脱氢酶活性、呼吸强度、微生物量碳氮和土壤毒性作为评价指标,研究不加生物菌剂不翻耕、不加生物菌剂翻耕、加生物菌剂不翻耕、加生物菌剂翻耕、加固定化菌剂不翻耕和加固定化菌剂翻耕6种不同实验条件对石油污染土壤修复的效果。结果表明,在63 d的修复过程中,加固定化菌剂翻耕实验F组的石油去除率达到了78.7%,比不加生物菌剂不翻耕实验A组的石油去除率提高了49.5%。随着土壤毒性逐渐降低,玉米(Zea mays L.)和赤子爱胜蚓(Eisenia fetida)可以在F组土壤中良好的生长,达到了修复的效果。     

固定化解脂耶氏酵母处理油脂废水研究

利用海藻酸钙包埋固定的解脂耶氏酵母(Yarrowia lipolytica)分别降解以色拉油为惟一碳源和以葡萄糖为惟一碳源的污水，结果表明，在最佳处理条件下，固定化细胞在50 h内，能较好地降解废水中浓度为2 000 mg/L的色拉油和浓度为2 000 mg/L 的COD，降解率都在80%以上；固定化细胞对色拉油、COD降解效率随着时间的延长而增加、随着底物浓度的增加而下降；与未固定菌株相比，固定化细胞有着更好的储存稳定性和可重复使用性，结果进一步提示固定化解脂耶氏酵母适于含油废水以及高COD含量的生活污水处理。     

氧化硫硫杆菌固定化菌球制备及其耦合填料去除H2S

以海藻酸钠(SA)为包埋载体,对氧化硫硫杆菌(Acidithiobacillus thiooxidans)进行固定化制备菌球,优化菌球制备条件,在生物滤塔内验证其对H₂S的去除能力.以前期驯化获得的富含硫系恶臭降解微生物菌群的污泥为菌源进行生物滤塔填料筛选,耦合A.thiooxidans菌球和填料进行生物除臭.结果表明,优选的固定化条件为:SA浓度3.0%､吸附剂CNT､A.thiooxidans菌悬液与混合液比例20%､CaCl₂浓度4.0%､改性剂己二胺溶液,获得的菌球机械强度､传质性能､硫氧化能力最好.将A.thiooxidans菌球填装于生物滤塔,H₂S最大去除率和去除能力为70%和1.06g H₂S/m³·h.以混合挂膜方式进行填料挂膜后,在聚氨酯泡沫､活性碳布和陶粒中优选出最佳填料活性碳布,获得H₂S最大去除率和去除能力为88%和0.84g H₂S/m³·h.以混合填装方式将A.thiooxidans菌球与活性碳布填装于生物滤塔,获得H₂S最大去除率和去除能力为86%和1.00g H₂S/m³·h.     

磷基材料对土壤铅稳定化效果及影响因素的Meta分析

磷基材料对土壤Pb有良好的稳定化效果.利用Meta分析法筛选汇总了1997~2022年磷基材料稳定土壤Pb的90篇文献,从土壤性质、稳定化工艺条件和磷基材料类型这3个方面量化分析了磷基材料对土壤Pb的稳定化率、赋存形态转化和对土壤pH的影响.结果表明,从土壤性质来看,土壤碱性越强（pH≥7.5）、土壤ω（Pb）越低（≤500 mg ·kg^-1）和土壤ω（有机质）越高（>0.5%）时,越有利于磷基材料对土壤Pb的稳定化,稳定化率分别为75.21%、34.97%和93.12%.从稳定化工艺条件来看,磷基材料添加量较高（≥10%）、含水率较高（>50%）、养护时间较长（≥30d）和养护温度较高（≥40℃）时,更有利于土壤Pb的稳定化,稳定化率可分别达到80.65%、84.98%、79.39%和41.44%.从磷基材料类型来看,可溶性磷基材料对土壤Pb有很高稳定化率（96.24%）;其使土壤可交换态Pb和碳酸盐结合态Pb向残渣态Pb转化的转化率达到95.93%;可溶性磷基材料多呈酸性,对土壤pH的降低率为7.27%,难溶性磷基材料多呈碱性,对土壤pH的增加率为3.63%.综上,在土壤pH≥7.5、土壤ω（Pb）≤500 mg ·kg^-1、土壤ω（有机质）>0.5%、可溶性磷基材料添加量≥10%、含水率>50%、养护时间≥30 d和养护温度≥40℃时,磷基材料对土壤Pb的稳定化效果较好.可见在实际Pb污染土壤修复过程中,为提高Pb稳定化率,需综合考虑土壤性质、稳定化工艺条件和磷基材料类型等因素的影响.     

TiO2-PTFE光催化膜的制备及性能

以聚四氟乙烯（PTFE）乳液和纳米TiO2粉末为原料，采用无水乙醇为溶剂，经辊压后与不锈钢网结合，制备了多孔固定化TiO2-PTFE光催化膜。膜性能研究结果表明，m（TiO2）：m（PTFE）=4时，光催化反应处理质量浓度为20mg／L的苯甲酸溶液，2h内TOC去除率高达81．3％。通过扫描电子显微镜观察，TiO2-PTFE光催化膜表面平整，且孔隙分布均匀。TiO2最佳负载量为15mg／cm2。在优化反应条件下同悬浮态TiO2光催化反应体系相比，TiO2-PTFE光催化膜对光源有更高的利用率，表现出更佳的催化活性。     

Effect of Cell-to-matrix Ratio in Polyvinyl Alcohol Immobilized Pure and Mixed Cultures on Atrazine Degradation

Atrazine biodegradation by immobilized pure and mixed cultures was examined. A pure atrazine-degrading culture, Agrobacterium radiobacter J14a (J14a), and a mixed culture (MC), isolated from an atrazine-contaminated crop field, were immobilized using phosphorylated-polyvinyl alcohol (PPVA). An existing cell immobilization procedure was modified to enhance PPVA matrix stability. The results showed that the matrices remained mechanically and chemically stable after shaking with glass beads over 15 days under various salt solutions and pH values. The immobilization process had a slight effect on cell viability. With the aid of scanning electron microscopy, a suitable microstructure of PPVA matrices for cell entrapment was observed. There were two porous layers of spherical gel matrices, the outside having an encapsulation property and the inside containing numerous pores for bacteria to occupy. J14a and MC were immobilized at three cell-to-matrix ratios of 3.5, 6.7, and 20 mg dry cells/mL matrix. The atrazine biodegradation tests were conducted in an aerobic batch system, which was inoculated with cells at 2,000 mg/L. The tests were also conducted using free (non-immobilized) J14a and MC for comparative purpose. The cell-to-matrix ratio of 3.5 mg/mL provided the highest atrazine removal efficiency of 40–50% in 120 h for both J14a and MC. The free cell systems, for both cultures, presented much lower atrazine removal efficiencies compared to the immobilized cell systems at the same level of inoculation.     

固定化硝化菌去除氨氮的研究

选用氯乙烯醇作为包埋载体,添加适量粉末活性炭,包埋固定硝化污泥,处理以（ＮＨ４）２ＳＯ４和葡萄糖为主的合成废水,考察了影响固定化工艺及硝化作用的各种因素。对固定化硝化菌的呼吸活性,细菌活性回收率等生物特性进行了测定。     

聚乙烯醇包埋厌氧活性污泥处理废水的最优化条件研究

研究以聚乙醇为主要包埋材料的混合载体法固定厌氧活性污泥处理有机废水的最优化条件。混合载体由聚乙烯醇（ＰＶＡ）、０．１５％海藻酸钠,２％Ｆｅ粉,０．３％ＣａＣＯ３,４％ＳｉＯ２粉末组成,结果表明,ＰＶＡ８％,初始污泥浓度１５％时最适宜,凝固凝饱和硼ＰＨ对包埋效果有影响,用Ｎａ２ＣＯ３调节硼酸ＰＨ至６．７可使包埋颗粒强度及产ＣＨ４活性提高,混合载体法有效地解决了固定化细胞技术应用于废水处理所面临的成球     

纳米Al_2O_3固定化红平红球菌菌球的制备及其对苯酚的降解

以海藻酸铝为主要包埋材料、纳米Al_2O_3为添加剂,包埋固定红平红球菌,制得纳米Al_2O_3固定化红平红球菌菌球,并将其用于苯酚的降解。表征结果显示:菌球内部包含丰富的菌丝体;内部孔径以中孔居多。实验结果表明:菌球的最优制备方案为0.05 g纳米Al_2O_3加入3 m L海藻酸钠溶液中、海藻酸钠质量分数6%、微生物包埋量0.5 m L/m L(以海藻酸钠溶液计)、Al_2(SO_4)_3质量分数3%;在初始苯酚质量浓度为400 mg/L、反应时间为24h、菌球加入量为8 g/L、反应p H为8.0、反应温度为30℃的条件下,菌球首次使用时可使苯酚完全降解,使用5次后的苯酚降解率仍达93%以上,具有良好的循环使用性。