活性污泥中超氧化物歧化酶(SOD)活性测定影响因素

研究以污水生物处理中的活性污泥为对象,采用氮蓝四唑光还原法测定超氧化物歧化酶(SOD)活性,从样品制备和保存方面探讨了是否添加溶菌酶液、细胞破碎时间、酶液保存时间与保存温度等因素对SOD活性测定的影响。研究表明,溶菌酶液的加入提高了细胞破碎效果;细胞破碎的条件为99次(工作3 s,停3 s),时间为40 min时破碎效果最好;酶液保存时间在4 h内最佳;-20℃保存比4℃保存对酶活性影响小。最佳检测条件为:取样量为1 mL时,反应温度为30℃,反应时间为20 min时,SOD酶活性最大。     

基于超声空化原理的废旧线缆回收方法

废旧线缆是一种可以回收利用的资源。目前普遍使用机械破碎方法回收废旧线缆,具体工艺是采用机械磨削的方法分离铜和绝缘皮,然后用筛分法获得。由于此工艺中包含有磨削过程,因此会损失很大一部分铜,从而造成资源浪费。为此,研究使用超声波工艺回收电线,并探讨一些因素对分离率的影响。研究结果表明:利用超声波的空化效应分离电线中的金属和塑料,能有效避免铜的大量损失。当水温为60℃,分离率达到最高值;电线长度与分离率之间基本成反比关系;电线总量的大小对分离率也有一定的影响。     

超声辅助氨解预处理对纤维素酶酶解餐厨垃圾的影响研究

为了提高餐厨垃圾酶解产糖能力,从而能得到更多的燃料乙醇,就纤维素预处理对餐厨垃圾酶解产糖能力的影响进行了试验研究,考察了餐厨垃圾氨解、超声预处理对酶解产糖的影响规律。结果表明：在纤维素酶加酶量为12 g/100g实验垃圾样品、pH4.8、酶解糖化温度为42℃～58℃、反应时间为60 min的条件下,餐厨垃圾经过氨水-超声（10%氨水,固液比1∶20,超声30min）预处理的酶解产糖率比没进行预处理的产糖率有较大提高。     

光助Fenton反应催化剂Fe/Al2O3的制备及其对六氯苯的催化活性研究

采用超声促进浸渍法制备了光助Fenton催化剂Fe/Al2O3,利用该催化剂对六氯苯（HCB）进行光助Fenton氧化降解,考察了浸渍液浓度、浸渍温度、灼烧温度和灼烧时间等制备条件对其催化降解六氯苯的活性的影响,确定了制备Fe/Al2O3的工艺条件,并对制得的催化剂进行表征。结果表明,超声促进浸渍法制备非均相光助Fenton反应催化剂Fe/Al2O3的最佳工艺条件为：浸渍液浓度25mmol/L,浸渍温度40℃,焙烧温度500℃,焙烧时间3h。在此条件下制备的催化剂对六氯苯的降解具有较高的催化活性。     

Combined alkaline and ultrasonic pretreatment of sludge before aerobic digestion

Alkaline and ultrasonic sludge disintegration can both be used as pretreatments of waste activated sludge (WAS) for improving the subsequent anaerobic or aerobic digestion. The pretreatment has been carried out using different combination of these two methods in this study. The effect was evaluated based on the quantity of soluble chemical oxygen demand (SCOD) in the pretreated sludge as well as the degradation of organic matter in the following aerobic digestion. For WAS samples with combined pretreatment, the released COD was in high level than those with ultrasonic or alkaline treatment. When combined with the same ultrasonic treatment, NaOH treatment resulted in more solubilization of WAS than Ca(OH)2. For combined NaOH and ultrasonic treatments with different sequences, the released COD were in the order: simultaneous treatment > ultrasonic treatment following NaOH treatment > NaOH treatment following ultrasonic treatment. For simultaneous treatment, low NaOH dosage (100 g/kg dry solid), short duration (30 min) of NaOH treatment, and low ultrasonic specific energy (7 500 kJ/kg dry solid) were beneficial for sludge disintegration. Using combined NaOH and ultrasonic pretreatment with the optimium parameters, the degradation efficiency of organic matter was increased from 38.0% to 50.7%, which is much higher than with ultrasonic (42.5%) or with NaOH pretreatment (43.5%) in the subsequent aerobic digestion at the same retention time.     

超声辅助纳米铁降解酸性红G的实验研究

通过硼氢化纳还原法制备了铁纳米颗粒,并用十二烷基硫酸钠对其进行保护。所得铁纳米颗粒大小在13nm左右,体心立方相。对比了在机械搅拌和超声辅助条件下纳米铁对酸性红G的降解率,超声条件下纳米铁和微米铁对酸性红G的降解率,以及纳米铁投加量、pH值对酸性红G降解率的影响。结果表明,超声辅助下,pH=6～7时,4min内纳米铁对酸性红G有较高的降解率。机理分析表明超声辅助条件下纳米铁对酸性红G的降解主要是超声分散下纳米铁的还原作用得到提高以及纳米铁氧化产物的絮凝作用。