臭氧氧化—湿式钙法吸收工艺对烟气的同时脱硫脱硝

采用臭氧氧化—湿式钙法吸收工艺对模拟烟气进行同时脱硫脱硝处理。O₃于150 ℃下具有较高的热稳定性,可将NO氧化为高价态氮氧化物,且NO氧化率随n（O₃）∶n（NO）的增大而逐渐提高。烟气中SO₂和H₂O的存在对NO氧化率的影响不大。O₃对SO₂的氧化率较低,约为5%。3%（w）石灰石浆液对SO₂的吸收率接近100%,NO_x吸收率随n（O₃）∶n（NO）的增大而逐渐提高,当n（O₃）∶n（NO）为1.6时NO_x吸收率可达约65%。SO₂能促进吸收液对NO_x的脱除。石灰石浆液中加入0.2%（w）的（NH₄）₂SO₃或Na₂SO₃后NO_x吸收率可达约85%或82%,且吸收率随添加剂加入量的增加而提高,添加（NH₄）₂SO₃的NO_x吸收率略高于添加Na₂SO₃。     

密相塔半干法烟气脱硫塔内加湿降温及其对脱硫效率的影响

为了实现密相塔半干法脱硫工艺的精确加湿进一步提高系统脱硫效率,利用推导出的传热传质计算方法,得到烟气温度降低和加水量的关系.结合3组密相塔半干法工程实际数据,发现理论计算值和实测值误差区间仅为2.9％ ～5.4％.通过选取河北某钢厂210 m2烧结烟气密相塔半干法脱硫项目实际在线检测数据,发现循环脱硫灰含湿量为3％的系统脱硫效率整体高于含湿量为5％和4％的样品,最大值达93.56％.通过粒度分析、扫描电镜、X射线衍射及差热-热重对2种不同含湿量的循环脱硫灰进行表征,结果表明,含湿量为3％的循环脱硫灰较含湿量为5％的样品粒径小、比表面积大,无团聚现象,物相分析还证实相对于含湿量为5％样品,其Ca(OH)2和结晶水含量少,几乎都是CaSO4和CaS03干态物质,因此脱硫反应进行彻底,脱硫效率较高.     

某电厂600MW火电机组脱硫增容改造方案探讨

按照国家环保部文件要求，大唐集团河北某电厂600 MW机组湿法脱硫系统需进行增容改造。该电厂根据实际情况，归纳了3种可行的脱硫增容改造方案，即原吸收塔增加喷淋层和高度、双吸收塔串联、双吸收塔双循环，阐述了各自的技术特点，结合性能保证、工程投资、施工周期等影响因素，比较了各方案的优缺点。经过对比和论证，双吸收塔方案比单吸收塔方案更适合于本次工程改造。     

Determination of the residue dynamics and dietary risk of thiamethoxam and its metabolite clothianidin in citrus and soil by LC-MS/MS

A modified quick, easy, cheap, effective, rugged and safe (QuEChERS) method was developed for the determination of thiamethoxam and its metabolite clothianidin in citrus (including the whole citrus, peel and pulp) and soil samples by liquid chromatography-tandem mass spectrometry. The sample was extracted with acetonitrile and purified with octadecylsilane. The detection limits of both compounds were 0.0001–0.0002?mg kg^–1, while the limit of quantification of thiamethoxam was 0.002?mg kg^–1 and the limit of quantitation of metabolites was 0.001?mg kg^–1. The recovery was 70.37%–109.76%, with inter-day relative standard deviations (RSD) (n?=?15) values ≤9.46% for the two compounds in the four matrices. The degradation curve of thiamethoxam in whole citrus and soil was plotted using the first-order kinetic model. The half-life of the whole citrus was 1.9–6.2?days, and the half-life of the soil was 3.9–4.2?days. The terminal residue of thiamethoxam (the sum of thiamethoxam and clothianidin, expressed as thiamethoxam) was found to be concentrated on the peel. The final residual amount of thiamethoxam in the edible portion (pulp) was less than 0.061?mg kg^–1. The risk quotient values were all below 1, indicating that thiamethoxam as a citrus insecticide does not pose a health risk to humans at the recommended dosage.     

新型生物质活性炭烟气脱硫研究

以农业废弃物核桃壳为原料,天然软锰矿为添加剂共混制备得到的新型生物质柱状活性炭进行烟气脱硫的性能研究.采用固定床反应器进行脱硫实验,装填活性炭质量为16 g,考察了进口SO2含量、空速、床层温度、水蒸气和氧气含量等工艺参数对活性炭脱硫性能的影响.结果表明,进口SO2含量在0.1%～0.3%(体积含量)范围内时,活性炭的穿透硫容和穿透时间随着进口SO2含量的升高而降低;空速越大,活性炭越容易穿透,较佳的空速为600 h-1;最适的床层温度为80℃,过高会降低脱硫效率;水蒸气和氧气的存在大大促进了活性炭对SO2的吸附性能,最佳水蒸气含量为10%,最佳氧气含量为10%～13%.在最佳工艺操作条件下,当进口SO2含量为0.2%时,活性炭穿透硫容为252 mg.g-1,穿透时间可达26 h.     

活性焦联合脱硫脱硝技术及发展方向

本文介绍了活性焦特点、活性焦联合脱硫脱硝技术的反应机理及工艺流程、活性焦联合脱硫脱硝技术的优缺点及发展方向。指出了活性焦联合脱硫脱硝工艺具有可以实现同时脱除S02、NOx和粉尘,脱除效率高,投资小等优点,通过加热再生活性焦,可获得高浓度的SO2气体,用于生产硫酸、液体二氧化硫或硫磺,有效回收硫资源。该技术具有流程简单、占地面积小、无二次污染、费用低、应用范围广等特点。     

Validation of QuEChERS-based method for determination of flusilazole residues in grape by high-performance liquid chromatography with photodiode array detector

A high-performance liquid chromatography with photodiode array detector analytical method was developed to determine the residue levels of flusilazole in grape and investigate the dissipation pattern and safety. The results showed that the mean recoveries were in the range of 86%–90%. Limits of detection and quantification were 0.008 and 0.02 mg/kg, respectively. The residue levels of flusilazole were best described by first-order rate kinetics and with half-lives ranging from 4.2 days (recommended dose) to 4.6 days (double the recommended dose). In conclusion, flusilazole at the recommended or even at double the recommended doses does not pose any apparent hazards to consumers.     

Experimental investigation of the efficiency of triple rinsing of agricultural containers regarding their characterization as non-hazardous wastes

The efficiency of water rinsing for removing fenthion from non-combustible used pesticide containers was investigated. Four hundred empty containers from four olive oil producing areas in Greece were studied. Following triple rinsing cleaning procedures, the amount of fenthion retained in the container ranged from 0.01% to 0.1% w/w of its initial concentration. Extraction was accomplished with acetone, and the extracts were analyzed with a capillary gas chromatographic system coupled with flame ionization detector. The results obtained showed that triple rinsing is an effective procedure for removing fenthion from used pesticide containers, since the remaining pesticide concentration was below the legislated threshold value. Consequently, the containers can be handled as non-hazardous solid wastes.     

化学沉淀组合电催化氧化处理脱硫废液技术研究

真空碳酸钾脱硫工艺碱洗段废液因含有高浓度硫化物、COD等有毒成分而影响焦化废水后续生物处理。以焦化企业实际碱洗段废液为研究对象,选用化学沉淀和电催化氧化的组合方式对其进行预处理。结果表明,室温下当氧化铜的投加量为65 g/L、反应时间60 min时废液中S2-去除率可达93%,且经过高温灼烧可实现Cu O沉淀剂的再生使用。沉淀后出水经电催化氧化处理,在电流10 A、电压4.9 V、电解时间120 min的条件下,出水COD可降至2 400 mg/L,满足常规生化系统进水的要求。     

自动电位滴定法测定烟气氨法脱硫模拟浆液中氯离子的研究

氯离子含量是氨法脱硫工艺中的一个重要监控指标,用自动电位滴定法测定氨法脱硫浆液中的氯离子。结果表明,实验加入乙醇有利于增大电位突跃幅度;pH值为3~5时实验结果准确;加标回收率为90%~110%;与莫尔法相比,测定结果准确度、精密度更高,且不受灰分颜色干扰;与离子色谱法测定结果准确度、精密度相近,但测定高浓度氯离子电位滴定法更有优势。