改性锯末吸附含Cr（Ⅵ）废水的实验研究

初步探讨了以改性后的锯末作为吸附剂去除废水中的Cr（Ⅵ）,实验表明改性锯末对于不同浓度的含Cr（Ⅵ）废水都具有较高的去除率。同时通过实验研究了pH值、吸附时间、吸附剂量、初始浓度等因素对吸附去除率的影响。     

两种木材生物炭对铜离子的吸附特性及其机制

为探索高效利用废弃生物质资源制备生物炭去除水体和土壤中Cu~(2+)污染的可行性,本文以常见的农林废弃物苹果树枝和梧桐木锯末为原料,采用450℃限氧热裂解法制备生物炭,通过两种生物炭对Cu~(2+)的批量吸附试验,利用4种等温吸附模型(Langmuir、Freundlich模型、Temkim、D-R模型)和4种吸附动力学模型(准一级动力学、准二级动力学、Elovich模型、颗粒内扩散模型)研究了苹果枝和锯末生物炭对Cu~(2+)的吸附行为.同时,使用FTIR红外、SEM和BET比表面积及孔径分析等技术表征了生物炭的理化性质,研究了两种生物炭对Cu~(2+)吸附机制,分析了两种生物炭之间的吸附特性差异及其影响因素.结果表明:(1)苹果枝生物炭在3 h达到吸附平衡,理论最大吸附量为15.85 mg·g~(-1),锯末生物炭在6h达到吸附平衡,理论最大吸附量为17.44 mg·g~(-1),与其他研究相比,这两种生物炭体现了较高的Cu~(2+)吸附性能;(2)两种生物炭对Cu~(2+)的热力学吸附均较好地符合Langmuir模型,表明吸附过程主要是近似单分子层的有益吸附;动力学吸附均符合准二级吸附动力学模型,表明其对Cu~(2+)的吸附包括表面吸附、颗粒内扩散和液膜扩散等多种过程;(3)吸附机制主要包括静电吸附,配体(酚羟基)/离子(H+)交换和阳离子—π键作用.     

木屑处置漏油事故的室内模拟

用锯木屑作为吸附材料，0#柴油为吸附对象进行室内模拟实验，研究了木屑对纯油、水中浮油的吸附以及吸油后的木屑在水中的漂浮性能；并以木屑粒径、木屑投加量、振荡频率、油膜厚度为研究指标，设计了5因素4水平的正交实验，考察了各因素对0#柴油的吸附量、去除率以及木屑漂浮率的影响并对优化条件进行了讨论。结果表明，在实验研究范围内，木屑对水中柴油的吸附速度极快，1min即可达到饱和，饱和吸附量为8．08g／g；木屑在水中漂浮性能良好，静态时经72h漂浮，漂浮率维持在92％左右；振荡频率为150r／min时，72h内漂浮率维持在68％以上；最佳吸油条件组合为吸附剂粒径10～20目，振荡频率120r／min，木屑投加量0．7g，油膜厚度1．65mm。     

松树锯末对亚甲基蓝（MB）的吸附研究

采用松树锯末以及改性松树锯末对模拟废水中的亚甲基蓝进行吸附实验研究。研究结果表明，当亚甲基蓝的初始浓度为50 mg/L、pH为6、锯末投加量为1 g/L时，改性前后的锯末对亚甲基蓝的吸附量最大，分别为29.9 mg/g和60.6 mg/g。同时，对改性前后的锯末做了吸附等温线拟合及动力学研究。结果表明，吸附等温线均能很好地符合Langmuir吸附模式，吸附过程符合拟二级动力学方程。     

Biomethanation of plant materials and agricultural residues using dung samples as wild population of microbes and also with isolated methanogens

Recycling of plant materials and agricultural residues for biomethanation was attempted in vials. The methanogenic activities of certain sewage samples have also been tested. Both sterilized and non-sterilized biomasses were used. Biomethanation was carried out with dung samples (cow, goat, buffalo, piggery wastes and poultry wash) as wild populations of microbes and in combination with other microbial isolates (isolated in the laboratory).Biomethanation had been observed to be good in most cases and particularly with the sterilized biomass. Mixed inoculum (dung samples and poultry wash) was found to be best for biomethanation. Of the microbe isolates, isolates from buffalo, pig and paper mill wastes appear to be most effective. Pretreated sawdust and rice straw were found to be good subtrates for biomethanation. Of the different plant biomass used Spirogyra (algae), Ipomea and water hyacinth were most effective whereas Jatropa gossypifolia and Parthenium sp. were the least effective. Biomethanation of Spirogyra was carried out both in anoxic and oxic conditions. Though methane production decreased enormously under oxic conditions, definite methane production continued indicating that the biomethanation process is not exclusively anoxic. Similarly, biomethanation of sewage samples from different sewage treatment plants were carried out with and without isolated methanogens and methane production was found to be moderate.     

Pyrolysis of rice husk and sawdust for liquid fuel

The paper is focused on studying how to convert rice husk and sawdust into liquid fuel. Rice husk, sawdust and their mixture were pyrolyzed at the temperature between 420℃ and 540℃, and the main product of liquid fuel was obtained. The experimental result showed that the yield of liquid fuel heavily depended on the kind of feedstock and pyrolysis temperature. In the experiments, the maximum liquid yields for rice husk, sawdust and their mixture were 56% at 465 ℃, 61% at 490℃ and 60% at 475℃ respectively. Analysis with GC-MS and other apparatus indicated that the liquid fuel is a complicated organic compound with low caloric value and can be directly used as fuel oil without any up-grading. As a crude oil, the liquid fuel can be refined to be vehicle oil.     

水分调节材料对牛粪堆肥氨气挥发的影响

利用通风式堆肥发酵方式研究了牛粪堆制过程中氨气的挥发特征和锯末、稻壳、稻草等不同水分调节材料对氨气挥发的影响。结果表明,牛粪堆制过程中主要在前期,尤其是在最初的2周内释放氨气;堆肥期间挥发的氨态氮约为牛粪总含氮量的17%～50%。不同水分调节材料都可以在一定程度上抑制氨气的挥发,但锯末抑制氨气挥发效果最好,其次是稻壳,稻草抑制氨气挥发的效果较小。因此,为了减少氮素损失,应采取适当措施抑制氨挥发或回收挥发的氨气。     

人粪便好氧堆肥过程中典型抗生素的消减特性

以人粪便和锯末为试验材料,进行3种不同温度(55℃、35℃和无温控)控制条件下的好氧堆肥试验,对比温度对堆肥过程中4种人们大量应用的抗生素(四环素、金霉素、磺胺嘧啶和环丙沙星)消减特性的影响.同时分别对抗生素在水环境、锯末载体和人粪便加锯末堆肥中的降解进行针对性试验,分析人粪便好氧堆肥中影响抗生素降解的主要因素或作用,并对其贡献进行了评价.结果表明,4种抗生素在高温堆肥中的去除效果最好,其去除率都在90%以上.相比磺胺嘧啶和环丙沙星,金霉素和四环素的降解对堆肥温度依赖更强.四环素和金霉素在堆肥中的去除主要为水解作用导致的去除,而磺胺嘧啶和环丙沙星的去除则主要归因于锯末有机质对其吸附的影响.与其它3种抗生素不同,微生物作用对堆肥中环丙沙星降解的影响是重要的,贡献率接近20%.     

Removal of congo red and basic violet 1 by chir pine (Pinus roxburghii) sawdust,a saw mill waste: batch and column studies

The efficiency of chir pine sawdust (CPS) for adsorptive removal of the dyes, congo red (CR) and basic violet 1 (BV), from aqueous solution was evaluated using batch and column studies. The equilibrium was attained in 60 min for CR and 45 min for BV. The adsorption of BV obeyed the Langmuir isotherm model while the Freundlich isotherm fitted the equilibrium data of CR adsorption. The Langmuir monolayer adsorption capacities (Q_o) of CPS for BV and CR were 11.3 and 5.8 g kg^?1, respectively. The kinetic data for CR were best fitted to the Lagergren pseudo-first-order model and for BV to the pseudo-second-order model. The intra-particle diffusion was found to be the rate-controlling step for CR adsorption, while the adsorption kinetics of BV were controlled by both intra-particle and liquid-film diffusion. The thermodynamic parameters indicated that the adsorption process was spontaneous and endothermic in nature. The adsorption activation energy (E_a) for CR (124 kJ mol^?1) implied chemical adsorption while that for BV (5.4 kJ mol^?1) indicated physical adsorption. An increase in the Thomas model constant (K_Th) with increasing flow indicated that for both dyes the mass transport resistance decreased during adsorption. Thus, CPS may be an efficient low-cost adsorbent for decolorization of dye-containing wastewaters.     

Acid Blue 25 adsorption on base treated Shorea dasyphylla sawdust: Kinetic, isotherm, thermodynamic and spectroscopic analysis

The potential of base treated Shorea dasyphylla (BTSD) sawdust for Acid Blue 25 (AB 25) adsorption was investigated in a batch adsorption process. Various physiochemical parameters such as pH, stirring rate, dosage, concentration, contact time and temperature were studied. The adsorbent was characterized with Fourier transform infrared spectrophotometer, scanning electron microscope and Brunauer, Emmett and Teller analysis. The optimum conditions for AB 25 adsorption were pH 2, stirring rate 500 r/min, adsorbent dosage 0.10 g and contact time 60 min. The pseudo second-order model showed the best conformity to the kinetic data. The equilibrium adsorption of AB 25 was described by Freundlich and Langmuir, with the latter found to agree well with the isotherm model. The maximum monolayer adsorption capacity of BTSD was 24.39 mg/g at 300 K, estimated from the Langmuir model. Thermodynamic parameters such as Gibbs free energy, enthalpy and entropy were determined. It was found that AB 25 adsorption was spontaneous and exothermic.