混凝沉淀过程中铝系混凝剂的形态转化规律

 研究了模拟配水中硫酸铝和氯化铝2种传统铝凝聚剂和2种聚合氯化铝(PAC)絮凝剂在混凝过程中的形态转化规律以及原水浊度和溶解性有机碳(DOC)对残余铝形态分布的影响.结果表明,在低浊体系中,投加铝系混凝剂是导致出水余铝升高的主要原因;但在高浊体系中,铝系混凝剂,尤其是聚合铝具有一定的除铝功能;混凝沉淀过程中传统铝凝聚剂的残余铝总量明显高于聚合铝混凝剂的残余铝总量;聚合铝混凝剂的残余铝全部为悬浮态铝,传统铝混凝剂的残余铝中还存在着胶体态铝和溶解态铝.原水浊度和DOC浓度增加,会提高残余铝中胶体态铝和溶解态铝的含量.     

Comparison of the effects of aluminum and iron(III) salts on ultrafiltration membrane biofouling in drinking water treatment

Coagulation plays an important role in alleviating membrane fouling, and a noticeable problem is the development of microorganisms after long-time operation, which gradually secrete extracellular polymeric substances (EPS). To date, few studies have paid attention to the behavior of microorganisms in drinking water treatment with ultrafiltration (UF) membranes. Herein, the membrane biofouling was investigated with different aluminum and iron salts. We found that Al₂(SO₄)₃·18H₂O performed better in reducing membrane fouling due to the slower growth rate of microorganisms. In comparison to Al₂(SO₄)₃·18H₂O, more EPS were induced with Fe₂(SO₄)₃·xH₂O, both in the membrane tank and the sludge on the cake layer. We also found that bacteria were the major microorganisms, of which the concentration was much higher than those of fungi and archaea. Further analyses showed that Proteobacteria was dominant in bacterial communities, which caused severe membrane fouling by forming a biofilm, especially for Fe₂(SO₄)₃·xH₂O. Additionally, the abundances of Bacteroidetes and Verrucomicrobia were relatively higher in the presence of Al₂(SO₄)₃·18H₂O, resulting in less severe biofouling by effectively degrading the protein and polysaccharide in EPS. As a result, in terms of microorganism behaviors, Al-based salts should be given preference as coagulants during actual operations.     

铝盐混凝剂的混凝效果与残留铝含量和组分之间的关系研究

研究了氯化铝、硫酸铝、聚合氯化铝(poly-aluminum chloride, PAC)3种铝盐混凝剂在腐殖酸-高岭土模拟水样中的应用,以比较3种混凝剂在该水样中的混凝效果与残留铝含量和组分之间的关系.结果表明, 3种铝盐混凝剂在试验选取的投加量下对浊度和UV254的去除率最高可达90%左右,PAC能在较高的投加量下达到较好的混凝效果;较高投加量下PAC混凝沉淀出水中残留总铝含量为0.9 mg/L左右,余铝率为-3.0%左右,均明显低于传统的铝盐混凝剂;3种混凝剂混凝处理腐殖酸-高岭土模拟水样时,残留铝均大部分以溶解性总铝的形式存在,且溶解性有机铝在总溶解性铝中所占比例较大;PAC在腐殖酸-高岭土混凝沉淀出水中残留总铝的含量下降最快,且能够有效降低出水中毒性较大的溶解性铝的含量,其混凝沉淀出水中残留总溶解性铝含量为0.6 mg/L左右.     

一体式铝盐絮体-超滤膜净水效能与机制

一体式膜工艺以其占地面积小、污染物去除效率高等优点在水处理工艺中逐渐应用.然而,长期运行后,传统颗粒性吸附剂存在加剧膜表面损伤的风险,同时大多数研究所用吸附剂价格较高,如纳米铁、碳纳米管等.针对上述问题,本文将铝盐混凝剂水解后形成的松散絮体直接注入膜池,基于腐殖酸(HA)和密云水库原水,考察了一体式絮体-超滤膜工艺运行效能及膜污染行为.结果表明,仅HA过膜时,第12 d跨膜压差(transmembrane pressure,TMP)急剧增至76. 4 k Pa,将膜组件取出经自来水清洗膜表面后TMP降为10. 1 k Pa (13 d),表明滤饼层是膜污染的主要形式,并且运行期间HA平均去除率仅为23. 3%.絮体注入频率、曝气强度及溶液pH能显著影响该工艺运行效能,尤其溶液pH.当采用连续投加方式将43. 2mmol·L-1铝盐絮体注入到pH为6. 0、曝气速率为0. 3 L·min-1膜池内时,膜污染程度显著降低,第12 d时TMP仅增长到19. 5 k Pa,清洗之后TMP降为5. 6 k Pa (13 d),此时HA平均去除率提高至61. 2%.此外,密云水库原水实验表明,当原水直接过膜时,TMP也急剧增加,运行12 d时TMP达到38. 0 k Pa,而清洗膜表面后TMP降低至3. 8 k Pa (13 d),滤饼层仍然为主要污染方式,同时有机质平均去除率为7. 5%.在上述最佳工艺条件下(曝气0. 3 L·min-1、溶液pH 6. 0)投加43. 2mmol·L-1铝盐絮体时,TMP增长也极其缓慢,12 d时仅增至6. 1 k Pa,膜表面清洗后TMP降至2. 3 k Pa (13 d),有机质平均去除率高达58. 6%.本研究表明一体式铝盐絮体-超滤膜在水处理中具有潜在的应用价值.