在土壤及底泥重金属测定中不同前处理和分析方法的比较

采用硝酸-高氯酸-氢氟酸、硝酸-双氧水和王水3种酸消解体系,电热板和全自动石墨消解仪两种方式对样品进行前处理,原子吸收和ICP-MS两种测定方法对土壤和底泥国家标准样品以及实际样品中重金属进行测定.结果表明,硝酸-高氯酸-氢氟酸体系可以使样品完全分解,王水浸提土壤和底泥样品的效率在60.6%—87.7%之间,是硝酸-双氧水浸提率的1.3倍.全自动石墨消解仪和电热板相比受热均匀、操作简单,原子吸收和ICP-MS均可对前处理后的土壤和底泥样品进行准确测定,不同实验室可根据硬件条件选用不同的分析方法.     

脂肪酶对餐厨垃圾厌氧产气的影响

在序批式厌氧反应器中探究了脂肪酶对餐厨垃圾厌氧消化的影响,结果表明脂肪酶能强化甲烷的积累量,且最佳的脂肪酶投加量为0.4 g·L-1,相应的甲烷积累量为356 mL·g-1 VSS,该数值是空白对照组的1.3倍。进一步机理研究表明脂肪酶能够促进溶解性COD的释放,提高生物脱氢酶的活性而减少长链挥发性脂肪酸的积累,进而提高甲烷的积累量。     

高温/中温两相厌氧消化反应中有机酸的变化

为了深入考察高温／中温两相厌氧消化的反应器系统用以处理混合基质时有机酸的变化特性,采用蒸馏－滴 测定挥发有机酸总量,并在系统达到相对稳定时用色质联机确定有机酸的组成及各自含量。研究结果表明,混合基质经高温消化后挥发有机酸含量有所增加,平均在３４６－５５２９ｍｌ／Ｌ,进一步经中国消化且系统达到稳定后其含量平均为４３－４３３ｍｇ／Ｌ,乙酸,丙酸,丁酸和戊酸是进料混合基质和高温消化后基质中主要有机酸种类     

Fate of ah receptor agonists during biological treatment of an industrial sludge containing explosives and pharmaceutical residues

GOAL, SCOPE AND BACKGROUND: Sweden is meeting prohibition for deposition of organic waste from 2005. Since 1 million tons of sludge is produced every year in Sweden and the capacity for incineration does not fill the demands, other methods of sludge management have to be introduced to a higher degree. Two biological treatment alternatives are anaerobic digestion and composting. Different oxygen concentrations result in different microbial degradation pathways and, consequently, in a different quality of the digestion or composting residue, It is therefore necessary to study sludge treatment during different oxygen regimes in order to follow both degradation of compounds and change in toxicity. In this study, an industrial sludge containing explosives and pharmaceutical residues was treated with anaerobic digestion or composting, and the change in toxicity was studied. Nitroaromatic compounds, which are the main ingredients of both pharmaceutical and explosives, are well known to cause cytotoxicity and genotoxicity. However, little data are available concerning sludge with nitroaromatics and any associated dioxin-like activity. Therefore, we studied the sludge before and after the treatments in order to detect any changes in levels of Ah receptor (AhR) agonists using two bioassays for dioxin-like compounds. METHODS: An industrial sludge was treated with anaerobic digestion or composting in small reactors in a semi-continuous manner. The same volume as the feeding volume was taken out daily and stored at -20 degrees C. Sample preparation for the bioassays was done by extraction using organic solvents, followed by clean up with silica gel or sulphuric acid, yielding two fractions. The fractions were dissolved in DMSO and tested in the bioassays. The dioxin-like activity was measured using the DR-CALUX assay with transfected H4IIE rat hepatoma pGudluc cells and an EROD induction assay with RTL-W1 rainbow trout liver cells. RESULTS AND DISCUSSION: The bioassays showed that the sludge contained AhR agonists at levels of TCDD equivalents (TEQs) higher than other sludge types in Sweden. In addition, the TEQ values for the acid resistant fractions increased considerably after anaerobic digestion, resulting in an apparent formation of acid resistant TEQs in the anaerobic reactors. Similar results have been reported from studies of fermented household waste. There was a large difference in effects between the two bioassays, with higher TEQ levels in the RTL-W1 EROD assay than in the DR-CALUX assay. This is possibly due to a more rapid metabolism in rat hepatocytes than in trout hepatocytes or to differences in sensitivities for the AhR agonists in the sludge. It was also demonstrated by GC/FID analysis that the sludge contained high concentrations of nitroaromatics. It is suggested that nitroaromatic metabolites, such as aromatic amines and nitroanilines, are possible candidates for the observed bioassay effects. It was also found that the AhR agonists in the sludge samples were volatile. CONCLUSIONS: The sludge contained fairly high concentrations of volatile AhR agonists. The increase of acid resistant AhR agonist after anaerobic digestion warrants further investigations of the chemical and toxic properties of these compounds and of the mechanisms behind this observation. RECOMMENDATION AND OUTLOOK: This study has pointed out the benefits of using different types of mechanism-specific bioassays when evaluating the change in toxicity by sludge treatment, in which measurement of dioxin-like activity can be a valuable tool. In order to study the recalcitrant properties of the compounds in the sludge using the DR-CALUX assay, the exposure time can be varied between 6 and 24 hours. The properties of the acid-resistant AhR agonists formed in the anaerobic treatment have to be investigated in order to choose the most appropriate method for sludge management.     

沼液回流对秸秆与污泥混合中温厌氧消化的影响

为了提高秸秆与市政污泥混合厌氧消化的消化产率,以秸秆污泥混合物作为底物,在批次实验中研究不同沼液回流对中温（35 ℃）混合厌氧消化过程的影响。实验采用0% 、20%、30%、40%、50%和60%等6种不同的沼液回流量,分析不同沼液回流量下产气量、甲烷含量、发酵过程氨氮含量、sCOD、总挥发酸（VFAs）的变化情况。结果表明：50%的沼液回流产气量和甲烷产量均最大,分别是1 645 mL和797.5 mL,TS和VS去除率达到17.5%和47.8%,单位VS甲烷产量为613.45 mL·g-1,较未加沼液的发酵瓶提高了37.7%,且无VFAs积累。过高的沼液回流量提升了厌氧反应的氨氮浓度,对厌氧产气过程产生了抑制。50%沼液回流量可以作为秸秆污泥混合厌氧消化最佳回流量。     

利用白云石石灰去除与回收污泥厌氧消化液中氮和磷

以白云石石灰为实验材料去除与回收污泥厌氧消化液中的氮磷,通过小试实验研究不同投药固液比S/L、初始pH值、反应温度、搅拌速度及反应时间对去除与回收氮磷效果的影响。实验结果表明,在最佳投药固液比S/L为300mg/L,最佳初始pH值范围为8.5~9.5,反应温度为25.0℃,搅拌速度为150 r/min,反应时间为24 h条件下,氨氮(NH+4-N)和磷(PO3-4-P)的去除率分别为37.26%和89.60%。利用X射线衍射仪(XRD)、扫描电镜(SEM)对沉淀产物进行了表征,通过分析可知沉淀产物中含有磷酸铵镁(MAP),可实现废水中氮磷经济有效的回收。     

中试条件下稻秸干法厌氧发酵搅拌方式的优化

针对秸秆类农业废弃物干法厌氧发酵过程中易产生物料分层、表面结垢以及存在“死角”等问题,通过改进横卧推流式中试厌氧反应器搅拌工艺,探索了连续运行条件下机械搅拌、前端气动搅拌和全程气动搅拌等3种单一搅拌方式对稻秸干法厌氧发酵产气规律、底物降解特性及系统稳定性的影响,并通过进一步设置不同的搅拌频次优化了机械搅拌和前端气动搅拌组合工艺,综合考察了发酵效率和能源消耗情况。结果表明,在单一搅拌工艺条件下,稻秸干法厌氧发酵40 d总产气量呈现出“机械搅拌>前端气动搅拌>全程气动搅拌”的规律,分别为75.5、66.5和61.9 m³,对应的单位VS产气量分别为441.9、389.3和362.3 L·kg⁻¹,这说明采用改进型框型叶片的机械搅拌可有效翻动物料,以促进其与发酵液的充分接触。在进一步优化“机械+前端气动”的组合搅拌工艺后发现,稻秸40 d产气量与单一机械搅拌模式较为接近,尤其是“机械搅拌(每天4次)+前端气动搅拌(每天4次)”的组合搅拌方式,单位VS产气量高达447.2 L·kg ⁻¹,纤维素和半纤维素降解率分别可达14.9%和15.1%;但从能源损耗角度来看,“机械搅拌(每天2次)+前端气动搅拌(每天4次)”的组合搅拌方式中能耗最低,仅为单一机械搅拌方式能耗的约40%。在稻秸干法厌氧发酵工程实际运行过程中,可根据厌氧发酵效率和能耗节省需求,因地制宜地选择合适的组合搅拌工艺。本研究结果可为木质纤维素类废弃物干法厌氧发酵工程中的搅拌方式改进提供参考。     

零价铁对污泥高温厌氧消化过程中四环素抗性基因及第一类整合子的消减影响

为研究污泥高温厌氧消化过程中零价铁(Fe0)对抗生素抗性基因的消减影响,采用荧光定量PCR方法定量检测了7种四环素抗性基因(TC-ARGs,包括tetA、tetC、tetG、tetM、tetO、tetW和tetX)及第一类整合子int I1基因在厌氧消化过程中的丰度变化,同时检测分析了挥发性脂肪酸(VFAs)的质量浓度变化,并探讨了目标基因与VFAs之间的相关关系.结果表明,适量Fe0(如0.10 g·g~(-1),以Fe0/VSS计)不仅可以强化污泥厌氧消化进程,显著提高总VFAs和乙酸的产生量,而且能够增强TCARGs和int I1基因的消减效果.尽管如此,过量Fe0(如1.17 g·g~(-1),以Fe0/VSS计)对污泥高温厌氧消化过程中TC-ARGs和int I1基因消减的增强效果并不显著,推测可能是由于基因水平转移的发生所导致的.通过相关性分析可知,TC-ARGs(除tetO基因外)和int I1基因与乙酸之间存在显著负相关性,表明乙酸可能对TC-ARGs和int I1基因的消减具有促进作用.     

城市污泥中温厌氧消化过程中厌氧耐药菌的分布与去除研究

城市污泥中含有大量的耐药菌,具有向环境传播耐药菌与抗性基因的潜在危险,但目前缺乏对城市污泥厌氧消化过程中耐药菌的研究.为此对某城市污水处理厂卵形消化池污泥进行了为期1 a的调查研究,考察了中温厌氧消化过程中四环素类与β-内酰胺类抗生素厌氧耐药菌的污染特征与去除效果,并分析了耐药菌的季节性变化规律.结果表明,厌氧进泥中四环素类耐药菌浓度与耐药率均低于β-内酰胺类.中温厌氧消化过程可以去除1.48~1.64 log单位的耐药菌(P<0.05),但经过厌氧消化后氨苄西林与头孢噻吩耐药率有显著增长(分别增加了12.0%与14.3%,P<0.05).厌氧进泥中耐药菌分布有明显的季节特征,除金霉素耐药菌外,其它耐药菌的浓度均为寒冷季显著高于温暖季(P<0.05).     

A novel use of anaerobically digested liquid swine manure to potentially control soybean cyst nematode

Experiments were carried out in two steps to determine the effect of anaerobically digested swine manure on soybean cyst nematode (SCN) egg control. In the first step, liquid swine manure underwent anaerobic digestion to search for the best digestion time for both volatile fatty acids (VFA) and ammonium nitrogen (NH₄ ⁺) enrichment. The results showed that about 17 and 28 days of incubation were needed, respectively, to reach the maximal levels of VFA and NH₄ ⁺ in the manure. In the second step, raw, VFA-enriched, and NH₄ ⁺-enriched manure were applied separately, at four different rates (25, 50, 100, and 200 mL/pot), to soil pots inoculated with nematode eggs in a greenhouse environment. Soil samples were collected 35 and 61 days after inoculation to determine the effect of such treated manure on SCN egg productivity. The data indicated that the SCN egg counts were inversely related to the manure application rates in a linear manner with correlation coefficients of 0.998, 0.967, and 0.900 for raw, NH₄ ⁺-enriched, and VFA-enriched manure for the 35-day samples. While no such relationships were found for the 61-day samples, implying that none of the treatments were still effective 61 days after application. At the four application rates, the VFA-enriched manure performed best in reducing SCN egg counts (by 18.1, 19.5, 34.3, and 18.6%) as compared to the raw manure treatment. In contrast, the NH₄ ⁺-enriched manure achieved mostly negative reductions. To achieve the best control of SCN egg growth, the VFA-enriched manure should be used and applied to soybean fields every 35 days.