氨废水资源化利用的折流式超重力床集成技术

利用折流式超重力床将氨废水处理的精馏和吸收过程集成在一台设备中,开发出一种设备小型化、流程紧凑的氨废水资源化利用集成技术。与传统技术相比,该技术在大幅节省占地面积和空间的同时,还可大幅节约设备建设所用钢材。工业规模试验结果表明,不同浓度的氨废水经该技术处理后可转化为氨质量分数大于22%的氨水资源,处理出水中氨氮质量浓度低于8.2 mg/L,尾气中未检测到氨,处理结果优于GB 31573—2015《无机化学工业污染物排放标准》。     

基于超低电容特性的微尘在线监测技术研究

为了更有效地测量工业烟尘排放浓度,研究了一种电容特性的微尘在线监测技术,利用电容传感器输出电压来反映粉尘质量。介绍了电容法测量粉尘量的原理、测量系统组成等,研究了粉尘质量与电容传感器输出电压的关系。对5种不同粉尘的测量结果进行分析表明,粉尘质量与电容传感器输出电压之间存在着一定的比例关系,其相关系数高达0.99。同时进行了微尘在线测量的研究,并采用电容特性曲线对测量系统进行了标定,从而验证了电容法在线微尘监测的可行性。     

Cycle Aware: Piloting a module for novice drivers

Introduction: In low-cycling countries, motor-vehicle traffic and driver behavior are well known barriers to the uptake of bicycles, particularly for utility cycling. Lack of separation between cyclists and faster-moving traffic is one key issue, while attitudes of drivers toward and/or harassment of cyclists is another. Cyclist-related driver education has been recommended as a means to improve driver-cyclist interactions. Methods: The driver licensing process provides an opportunity for such education. The Cycle Aware module was developed to test and enhance novice drivers’ knowledge of interacting safely with cyclists. It was piloted across three Australian jurisdictions targeting both novice and experienced drivers. Participants were asked to complete the Cycle Aware module and an accompanying survey. A total of 134 novice and 97 experienced drivers completed the survey with 42 novice and 50 experienced drivers going on to complete the module. Results: Both groups of drivers scored equally well in the module but the very youngest and very oldest participants were more likely to have some incorrect responses. We did not find any relationship between correct module scores and attitudes toward cyclists. Survey results showed both novice and experienced drivers had somewhat positive attitudes toward cyclists. The two cohorts differed on several attitude questions. Sixty percent (60%) of novices compared to 30% of experienced drivers reported feeling concerned when sharing the road with cyclists, and novices were less likely to agree that cyclists had a right to use the roads. Conclusions and practical applications: The analysis suggests novices need to be better equipped to share roads confidently with cyclists and to recognize cyclists as legitimate traffic participants.     

SCADA系统在污染物治污工况在线监控系统中的应用

本文介绍了SCADA系统在内蒙古自治区重点污染源治污工况在线监控系统中的应用,系统以西门子成熟S7—200系列可编程序控制器为在线监测设备,基于OPC（OLE for Process Control）技术,以WINCC为监控平台,实现了自治区内重点污染源企业治污工况的远程监测、污染物排放的有效管理。     

酸碱度对生活垃圾焚烧厂沥滤液蒸发处理效果的影响

采用蒸发法处理城市生活垃圾焚烧厂垃圾沥滤液,着重考察了不同沥滤液初始pH值对蒸发去除COD和氨氮效果的影响,并采用GC-MS对蒸发冷凝液中有机物成分进行了分析鉴定.结果表明,生活垃圾沥滤液的初始pH对冷凝液中COD、氨氮含量及有机污染物分布产生了决定性的影响.沥滤液在酸性条件下(pH≤6)蒸发,随着pH的增加,冷凝液中COD的含量线性降低,而氨氮的含量线性增加.当沥滤液的初始pH值从6增加到11,冷凝液中COD的含量呈对数函数降低,而氨氮的含量表现出显著增加趋势.从冷凝液中鉴定出38种有机污染物,多为沸点较低的醇、酸、酚和酯类.在酸性条件下(pH=3),冷凝液中挥发性有机酸和低碳醇的相对丰度接近90％.在近中性条件下(pH=6.2),冷凝液中的有机污染物以酚、酸和杂环类化合物为主.在碱性条件下(pH =11),冷凝液中酚和杂环类化合物占比较高,而酸的含量极少.     

Experimental investigation of a solar water distillation-cum-drying unit

In this communication, a new design of solar-energy-based water distillation cum drying unit with parabolic reflector has been designed, fabricated, and tested. Bitter gourd and potato slices are chosen as a drying commodity. Thermal performance of the developed system has been evaluated based on the experimental results and using linear regression analysis. Heat transfer coefficients (convective, evaporative, and radiative) for solar distillation system have been observed to be 2.48–4.09, 13.25–52.38, and 8.75–9.66 W/m²°C, respectively. Overall thermal efficiency and exergy efficiency for the distillation system has been found to be 18.77% and 1.2%, respectively. The convective heat transfer coefficient for potato slices are observed higher for initial hours and decreases as the day progresses. The average convective heat transfer coefficients for bitter gourd and potato slices have been observed as 2.18 and 5.04 W/m²°C, respectively. Experimental error in terms of percent uncertainty for bitter gourd and potato slices are found to be 42.93% and 37.06%, respectively. The present design of solar distillation and drying in a single unit could be beneficial for the development of remote, arid, and rural areas.     

Clam shell catalyst for continuous production of biodiesel

Continuous flow transesterification of waste frying oil (WFO) with methanol for the biodiesel production was tested in a laboratory scale jacketed reactive distillation (RD) unit packed with clam shell based CaO as solid catalyst. The physiochemical properties of the clam shell catalysts were characterized by X-ray Diffraction (XRD), Brunauer–Emmett–Teller (BET), Scanning Electron Microscopy (SEM), and Energy Dispersive Atomic X-ray Spectrometry (EDAX). The effects of the reactant flow rate, methanol-to-oil ratio, and catalyst bed height were studied to obtain the maximum methyl ester conversion. Reboiler temperature of 65°C was maintained throughout the process for product purification and the system reached the steady state at 7 hr. The experimental results revealed that the jacketed RD system packed with clam shell based CaO showed high catalytic activity for continuous production of biodiesel and a maximum methyl ester conversion of 94.41% was obtained at a reactant flow rate of 0.2 mL/min, methanol/oil ratio of 6:1, and catalyst bed height of 180 mm.     

减压塔规整填料腐蚀现状与防护

介绍了减压塔规整填料腐蚀的现状,阐述了介质温度、流速、腐蚀介质种类和填料尺寸等因素对规整填料腐蚀的影响,提出了改变工艺、加注缓蚀剂、改变材质和加强腐蚀检测等防护措施。     

分馏塔腐蚀原因分析及预防措施

针对目前炼厂原油性质越来越差,同时装置的生产周期越来越长的状况,结合生产实际对分馏塔顶部腐蚀漏液现象及原因进行了详细对比分析。提出选用合适的耐腐蚀材料、注缓蚀剂等措施,提高了设备的抗腐蚀能力,缓解了分馏塔顶部的腐蚀现象。     

物化-生物组合工艺处理TNT红水

采用酸析+微电解+混凝沉淀+减压蒸馏+固定化微生物滤池+活性焦吸附组合工艺处理兵器八○五厂(襄樊分部)的TNT红水,出水中的硝基化合物浓度多小于0.8 mg/L,且多次未检出;COD最高值为76 mg/L,平均值为51.6 mg/L;色度为20°;苯胺浓度全部小于1 mg/L,达到了中试方案提出的要求,出水水质指标符合《兵器工业水污染物排放标准火炸药》(GB14470.1-2002)的要求.中试期间设备没有发生堵塞、燃烧等事故,减压蒸馏装置正常稳定运行,证实了减压蒸馏法处理TNT红水的安全可靠性.