钻屑法测定煤层H_2S含量

为了测定煤层硫化氢(H2S)含量,防治矿井H2S涌出,提出一种通过钻屑法测定煤层H2S含量的方法。在未受采动影响的新鲜煤壁,采用钻屑法取样,通过测定煤样H2S解吸量、取样过程损失量和H2S残存量确定煤层H2S含量。根据溶于水中H2S的p H值和色谱分析解吸气体中H2S体积分数,确定H2S解吸量;根据煤样解吸规律和气样H2S体积分数,确定H2S损失量;根据色谱分析残存气体中H2S体积分数,确定其残存量。用此方法,对山西某矿H2S涌出煤层进行现场和实验室测定。研究表明,该矿H2S含量为(4.465~6.701)×10-3m3/t。钻屑法测定煤层H2S含量是可行的,可以为矿井H2S治理提供基础数据。     

模拟油田采出水中硫化氢的脱除研究

硫化氢是油气田伴生气中的有害组分。在含硫油气田的采出水中,硫化氢的存在对于安全生产和和油田环境均会产生危害。采出水经处理后通常需作为地层回注水使用,由于油气生产的特殊性,常用的硫化氢脱除方法在使用中受到限制,探索适合于油气田生产的水处理方法十分必要。本文探讨了通常可用于油田水中硫化氢脱除的各种方法,对比了各类方法的优缺点,提出以次氯酸钠为主要脱硫剂的水处理方法,通过对模拟采出水的室内试验,证明次氯酸法可以快速有效地去除采出水中的硫化氢,并提出了消除过量氧化剂的后续处理方法。实验表明经处理后的水质可以达到油气田回注水质要求,处理成本较低。     

Research on different venting performance between flat and curved bursting panels

There is a noticeable discrepancy in the ability to control reduced explosion overpressure between flat bursting panels and curved bursting panels with the same static activation overpressure. Flat bursting plates were observed to leak at approximately 80% of the static activation overpressure lower than curved bursting plates. A new experimental technique is proposed in our paper. Three different vent areas of flat and curved bursting panels were tested, there was significant difference in structural stiffness between flat bursting panels and curved bursting panels, which is the reason the discrepancy in the ability to control reduced explosion overpressure. The structural stiffness of the flat bursting panels is poorer than that of the other, and a greater deformation of the flat bursting panels occurs under the same load. The membrane stress caused by the explosion overpressure therefore produces a larger value in the flat bursting panels which causes it to open prematurely. Moreover, the smaller the vent area that is, the more significant discrepancy in controlling the reduced explosion overpressure between both bursting panels is. This experimental and theoretical result in our paper provides some useful experience for the method of explosion venting.     

TiO2气溶胶快速去除空气中的芥子气模拟剂

在自制反应器内,通过喷射法将纳米TiO_2分散成气溶胶形式,用以降解空气中的芥子气模拟剂二乙基硫醚(DES)。利用自行设计的一套气溶胶沉降行为评价装置,对TiO_2气溶胶的释放条件进行了优化。系统研究了相对湿度、反应温度、光强、催化剂加入量、反应物浓度等因素对DES降解速率和彻底矿化速率的影响。结果表明:TiO_2气溶胶对2.80 mg/L(近似芥子气快速致死浓度)DES降解的半衰期由涂覆型TiO_2的34.5 min缩短至8.5 min;TiO_2气溶胶光催化降解DES的最佳相对湿度为35%,此时CO_2最快生成速率可达34.64μg/(L·min),150 min内彻底矿化比例达66.1%;对于1.5 L反应器,催化剂加入量为30 mg时降解DES的量效比达到最佳状态;TiO_2气溶胶光催化适用于含低浓度DES空气的快速净化。     

普光气田含硫污水尾气处理工艺应用与优化

针对中国石化普光气田产出水属于典型的含硫污水,密闭处理系统中产生大量高含硫尾气,论述了尾气处理工艺中存在的问题,优化了单一的生物除硫、活性炭吸附工艺,增加了一级碱洗、氧化除硫工艺,实现尾气达标排放。     

亚甲基蓝分光光度法测定废水硫化物的不确定度评定研究

分析了应用亚甲基蓝分光光度(GB/T16489-1996)测定废水硫化物测试过程中不确定度影响因素,主要来源为硫化物标准溶液、标准曲线拟合、随机效应、分光光度计和取样体积这五部分。本测量合成相对标准不确定度0.025 9;其中由测定样品质量引入的不确定度为0.024 7;由样品体积引入的不确定度为0.007 7。本次废水中硫化物测量结果为:0.110±0.006 mg/L,k=2(包含概率约为95%)。     

Shewanella oneidensis MR-1对硫化汞的生物利用性研究

在实验室模拟条件下,研究了铁还原菌奥奈达希瓦式菌Shewanella oneidensis MR-1对固态硫化汞的生物溶解、生物甲基化作用及其影响因素.结果表明,铁还原菌S.oneidensis MR-1在含硫培养基中生长良好,低浓度硫素能够促进其生长,高浓度时细菌生长则受到抑制,这种抑制主要表现在菌株生长曲线迟缓期的延长;铁还原菌S.oneidensis MR-1能够利用固态硫化汞,促进其溶解并迅速进行汞甲基化;在S.oneidensis MR-1的耐硫化物范围内,菌株对硫化汞的生物溶解作用随着硫化钠浓度的增大而增强,但生物甲基化作用只在低浓度硫化钠时受到促进,硫化钠浓度过高时则会受到抑制;此外,弱酸性环境比酸性及中碱性的环境更有利于S.oneidensis MR-1对硫化汞的生物溶解及甲基化.     

连续流动法测定沉积物中的酸挥发性硫化物

优化沉积物中酸挥发性硫化物(Acid Volatile Sulfide,AVS)的提取方法并采用连续流动分析法检测提取液中的硫化物.研究了吸收液的种类、氮气流量与吹气的时间和反应温度对AVS提取效果的影响以优化提取方法.结果表明,与传统的氢氧化钠或硫酸镉-氢氧化钠吸收液相比,以氯化锌-羧甲基纤维素钠溶液为吸收液吸附效率好,稳定性高且无毒.用连续流动分析法检测提取液中的AVS快速、准确、稳定性好.     

Dynamic behaviour of direct spring loaded pressure relief valves in gas service: II reduced order modelling

A previous study of gas-service direct-spring pressure relief valves connected to a tank via a straight pipe is continued by deriving a reduced-order model for predicting oscillatory instabilities such as valve flutter and chatter. The reduction process uses collocation to take into account a finite number N of acoustic pressure waves within the pipe, resulting in a set of 2N+3 ordinary differential equations. Following a novel non-dimensionalization, it is shown analytically that the model can exhibit, at experimentally realistic parameter values, instabilities associated with coupling between the valve and acoustic waves in the pipe. The thresholds for each instability are such that for a given flow rate, the first mode to go unstable as the inlet pipe length increases is the quarter-wave mode, then a three-quarter wave, a 5/4-wave etc. Thus the primary mode of instability should always be due to the quarter wave. In the limit of low flow rates, a simple approximate expression is found for the quarter-wave instability threshold in the form of inlet pipe length against mass flow rate. This threshold curve is found to agree well with simulation of the full model. For higher flow rates there is a need to include fluid convection, inlet pressure loss and pipe friction in order to get good agreement. The reduced model enables the dependence of the stability curve on key dimensionless physical parameters to be readily computed.     

Biogenic volatile organic compound analyses by PTR-TOF-MS: Calibration, humidity effect and reduced electric field dependency

Green leaf volatiles(GLVs) emitted by plants after stress or damage induction are a major part of biogenic volatile organic compounds(BVOCs). Proton transfer reaction time-of-flight mass spectrometry(PTR-TOF-MS) is a high-resolution and sensitive technique for in situ GLV analyses, while its performance is dramatically influenced by humidity, electric field,etc. In this study the influence of gas humidity and the effect of reduced field(E/N) were examined in addition to measuring calibration curves for the GLVs. Calibration curves measured for seven of the GLVs in dry air were linear, with sensitivities ranging from 5 to10 ncps/ppbv(normalized counts per second/parts per billion by volume). The sensitivities for most GLV analyses were found to increase by between 20% and 35% when the humidity of the sample gas was raised from 0% to 70% relative humidity(RH) at 21°C, with the exception of(E)-2-hexenol. Product ion branching ratios were also affected by humidity,with the relative abundance of the protonated molecular ions and higher mass fragment ions increasing with humidity. The effect of reduced field(E/N) on the fragmentation of GLVs was examined in the drift tube of the PTR-TOF-MS. The structurally similar GLVs are acutely susceptible to fragmentation following ionization and the fragmentation patterns are highly dependent on E/N. Overall the measured fragmentation patterns contain sufficient information to permit at least partial separation and identification of the isomeric GLVs by looking at differences in their fragmentation patterns at high and low E/N.